Mitsubishi · Model Report
Showing safety data for the 2004 model year only.
Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2002-2007 Lancer, 2004 Lancer Wagon, 2003-2006 Lancer Evolution, 2003-2006 Outlander and 2007-2013 Outlander V-6 vehicles originally sold in, or ever registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, the front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE. THE ELECTRONIC CONTROL MODULE CAN OVERHEAT.
ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP TIME INTERVAL MAY INCREASE AS MUCH AS 6.8 SECOND BETWEEN WIPER SWEEPS.
The contact owns a 2004 Mitsubishi Outlander. The contact stated that while driving at a slow speed, the front subframe detached. The contact stated that the driver’s side front wheel was pointing outwards. The contact received notification of NHTSA Campaign Number: 16V458000 (Suspension) however, the part to do the recall repair was not yet available. The vehicle was towed to the local dealer. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 180,000. Parts distribution disconnect.
No injuries · No fire · No crash
The entire undercarriage is rusted out, it was taken to Ricart near columbus ohio where they simply sprayed an anti rust coating over the existing rust. There is now rusted holes and the vehicle has spun out driving in straight due to control arm issues and whatever else. The vehicle is not believed to be road safe and needs to be addressed.
No injuries · No fire · No crash
THE FRONT CONTROL ARM WHERE IT BOLTS TO THE K FRAME RUSTED AWAY COMPLETLY RESULTING IN THE FRONT DRIVERS TIRE TO COME OFF. WAS IN A GET IN GO PARKING LOT TURNING WHEN THIS HAPPENED LUCKLY NO ONE WAS HURT.
No injuries · No fire · No crash
REAR SUBFRAME RUSTED THROUGH WHILE MOVING SLOWLY IN DRIVEWAY CAUSING THE DRIVER'S SIDE REAR WHEEL TO MISALIGN, MAKING THE CAR UNABLE TO MOVE. CAR WAS TOWED TO REPAIR SHOP WHERE REAR SUBFRAME WAS REPLACED.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 MITSUBISHI OUTLANDER. THE CONTACT STATED THAT THE VEHICLE'S SUBFRAME FRACTURED DUE TO RUST. THE VEHICLE WAS TAKEN TO DES MOINES MITSUBISHI (4475 MERLE HAY RD, DES MOINES, IA 50310, (515) 270-8100) FOR AN UNKNOWN RECALL REPAIR THAT INVOLVED EITHER REPLACING THE SUBFRAME OR APPLYING AN ANTI-CORROSION FLUID. THE CONTACT STATED THAT THE SUBFRAME WAS ALREADY RUSTED WHEN THE ANTI-CORROSION FLUID WAS APPLIED. THE MANUFACTURER WAS CONTACTED AND PROVIDED A CASE NUMBER. THE DISTRICT MANAGER WAS TO CALL THE CONTACT BACK. THE MANUFACTURER REMOVED THE ORIGINAL RECALL FROM THE CONTACT'S VIN AFTER THE VEHICLE WAS TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 147,087.
No injuries · No fire · No crash