FEDERAL MOGUL IS RECALLING 6,903 AFTERMARKET BALL JOINT ASSEMBLIES SHIPPED BETWEEN NOVEMBER 9, 2007 AND MARCH 26, 2008, WHICH MAY HAVE BEEN PACKAGED WITH INCORRECT NUTS. THE PART NUMBERS PACKAGED WITH INCORRECT NUTS ARE: K7147, K7329, K8683, AND 104353. THESE PARTS WERE MADE FOR USE ON THE VARIOUS VEHICLES LISTED ABOVE.
CERTAIN FEDERAL-MOGUL AFTERMARKET FUEL PUMPS SOLD UNDER THE BRAND NAMES OF CARTER, ACCUFLOW, NAPA, TRUFLOW, PARTS DEPO, AND PARTS MASTER, SHIPPED BETWEEN AUGUST 2006 AND JULY 2007 FOR USE ON THE VEHICLES LISTED ABOVE. THE FUEL PUMP DIAPHRAGM IN CERTAIN PRODUCTION RUNS MAY HAVE BEEN IMPROPERLY INSTALLED OR INADEQUATELY TESTED WHICH MAY CAUSE THE FUEL PUMP TO LEAK.
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
ON CERTAIN PASSENGER VEHICLES, CONTAMINATION OF THE FILTER IN THE FUEL DELIVERY MODULE (FDM) CAN REDUCE, AND EVENTUALLY BLOCK, THE FLOW OF FUEL TO THE ENGINE.
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Brake pads constantly keeps running out on front driver, passenger front brakes are still good but rotor keeps running out unevenly, no brake fluid leaks but needs refill every 3rd about 3/4 of a pints bottle, making a left turn it accelerated by itself brakes didn't react, instead of causing in a big accident, pulled the steering wheel, went through a fence and a brick wall stopped my car, checked all fuses replaced fuses if needed, confirmed fuses AMP Ganges with the vehicle own owners manual, dashboard backlights keeps going on and off on it's own, automatic transmission after complete stop it sets it self at neutral , a few taps on the gas pedal then it goes to 1st shift, only has 129,000 miles, 1987 Mercury Cougar LS 5.0l windsor engine, 20th Anniversary Edition
I WAS DRIVING ALONG HWY ABOUT 40 MILES AN HOUR WHEN CAR ENGINE STOPS. THIS STOPS POWER STEERING, BRAKES ETC. TO STOP WORKING AND YOU HAVE A HARD TIME PULLING OFF THE ROAD. WAITED ABOUT 10 MINUTES AND CAR COOLS DOWN A LITTLE. IT WILL THEN START UP AGAIN AND YOU CAN GO AGAIN FOR ABOUT 1/2 MILE OR SO AND ENGINE DIES AGAIN.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1995 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE DROVE DIFFERENTLY AT DIFFERENT TEMPERATURES. THE CONTACT STATED THAT WHILE HER HUSBAND WAS DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SHUT-OFF WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO THE PURVIS FORD INC LOCATED AT 3660 JEFFERSON DAVIS HWY #1, FREDERICKSBURG, VA 22408, WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE TECHNICIAN STATED THAT IT COULD BE THE IGNITION MODULE, DISTRIBUTOR, OR THE POWER CONTROL MODULE. THE MANUFACTURER WAS CONTACTED AND A MESSAGE WAS LEFT ON THE VOICEMAIL RECORDER. THE CONTACT WAS NOT CALLED BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START-UP AFTER MULTIPLE ATTEMPTS. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHUTOFF AS THE OIL WARNING LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE CONTACT HAD TAKEN THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE FUEL SENSOR, RELAY SENSOR, FUEL INJECTION SENOR AND MULTIPLE OTHER PARTS WERE REPLACED. DESPITE MULTIPLE REPAIRS TO THE VEHICLE, THE FAILURE PERSISTED. THE MANUFACTURER HAD BEEN NOTIFIED OF THE FAILURE AND THEY INFORMED HER THAT HER VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V421000 (FUEL SYSTEM, GASOLINE) WHICH WAS LINKED TO HER FAILURE. A DEALER HAD NOT BEEN NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS 116,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2001 MERCURY COUGAR. THE CONTACT STATED THAT ONCE THE FUEL LEVEL REACHED A HALF TANK OF GASOLINE, THE VEHICLE HESITATED AND LOSS MOTIVE POWER WITH THE ACCELERATOR PEDAL DEPRESSED. THE CONTACT STATED THAT THE TRANS AXLE AND CHECK ENGINE WARNING LIGHTS WERE ILLUMINATED. COLUMBIA FORD LINCOLN HYUNDAI (700 7TH AVE, LONGVIEW, WA 98632) WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE MANUFACTURER WAS CONTACTED AND NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
No injuries · No fire · No crash