Kia Sorento Complaints

10,397 consumer complaints on file.

#11742106June 4, 2026
ENGINE
On Jan 1,2019 under KIA PI-1803 Recall I had a Knock Sensor Detection System(KSDS) installed on my 2013 KIA Sorento. My car broke down and was towed into the Kia Dealership and it indicated a P1326 fault active . It was reset and released to me on 05/12/2026 after conducting a BCT test saying it indicated PASS drove it off the lot went 5 miles, and it broke down, towed back in and they replaced the KSDS. They performed a BCT replaced the KSDS and then said it PASSED. I have requested an actual copy of the test not just a P. They have refused both at the Dealership Level and KIA Customer Service . The Results of both tests are conducted by Techline and that information is available. I believe the vehicle is unsafe to drive as this has happened twice in a 2 day period . I do not trust that it passed the rod bearing tests without the actual test results.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742183June 4, 2026
SERVICE BRAKES, HYDRAULIC
The contact owned a 2014 Kia Sorento. The contact stated that while driving at 10 MPH, smoke emanated from the vehicle's hood. There was no warning light illuminated. The contact coasted to a driveway and attempted to open the hood when the vehicle became engulfed in flames. The vehicle was consumed by the fire. There was no injury sustained. The local Fire Department was contacted and extinguished the fire, and a fire report was filed. The fire report was provided. The vehicle was towed to the tow lot and deemed a total loss. The contact stated that the dealer was not contacted. The contact was provided notification of NHTSA Campaign Number: 23V652000 (SERVICE BRAKES, HYDRAULIC); by the Fire Department. The contact notified the manufacturer about the failure stated in the recall. The contact stated that the manufacturer sent a technician to inspect the vehicle. The failure mileage was approximately 157,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11741862June 3, 2026
ENGINE
My 2019 Sorento 3.3L suffered high oil consumption followed by a severe oil leak at the back of the head/engine block threads. There is an odor of coolant which smells sweet with no visible coolant leak meaning there is likely coolant seeping into the engine mixing with the oil. I believe this an ongoing engine failure caused from Kia not correcting the issues over many years.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741622June 2, 2026
ENGINE
The vehicle's original engine suffered severe oil consumption and a blown head gasket, which contaminated the exhaust system. The Kia dealership replaced the engine under warranty but refused to replace the damaged catalytic converter claiming it wasn’t a part of the warranty even though it was consequently damaged. The dealership explicitly stated the vehicle should not be started or driven due to the blocked exhaust, but then did repair and release after I pushed for the catalytic converter replacement. They said I would have to follow up with Kia corporate. They released the unsafe vehicle anyway and I have been following up with Kia customer service for 2 months to request a CAT replacement. While driving, the blocked exhaust caused a severe rattling noise, immediate engine overheating, and complete mechanical engine seizure. The engine completely cut power and locked up while in motion, creating an immediate crash hazard on the roadway. The vehicle is now completely inoperable and will not turn over. This is a severe safety defect where a known blocked exhaust system directly caused catastrophic engine failure while operating.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741669June 2, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
The vehicle suffered a sudden, severe engine malfunction/misfire while in operation, presenting a serious safety hazard on the road. Following the incident, the vehicle was taken to an authorized dealership service center (Repair Order #XXX), where technicians verbally confirmed that the engine requires a complete replacement due to internal mechanical failure. The catastrophic mechanical failure of the engine directly caused consequential damage to the emissions system, entirely clogging the catalytic converter with unburned fuel/debris. Despite the clear link to the known, systemic defects inherent to the Theta II engine line—which is subject to active federal consent orders, safety recalls, and lifetime warranty extensions—both the dealership and Kia Corporate are refusing to honor the 8-year/80,000-mile Federal Emissions Defect Warranty. The manufacturer is attempting to use the catastrophic failure of their own defective, recalled engine line to evade their legal environmental and safety warranty obligations, leaving the consumer stranded without alternative transportation. This represents a systemic effort by the manufacturer to deflect liability for documented powertrain safety failures onto individual consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741701June 2, 2026
UNKNOWN OR OTHER
Sunroof/Moonroof After a stop light, while driving at less than 30mph, sunroof/moonroof exploded outwards. There were no surrounding cars in front or beside or in other lane direction. It was not hot or cold out. Evening time. No weather issues. If the fabric shade screen had not been closed all the glass would have fallen all over driver. There was no warning of any kind. Glass just exploded outward into a point like a mountain peak. Then glass started falling inwards into car. Took to dealership, had insurance company evaluate for repairs, insurance approved repairs performed by dealership. Dealership service writers said this has happened on other kia's.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741451June 2, 2026
UNKNOWN OR OTHER
Coolant empty, found overheating. Coolant refilled. No noticeable leaks. Mechanic found failure of thermostat. Replaced and car found to be overheating again. Coolant leaking into hood covering engine components.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741308June 1, 2026
ENGINE, POWER TRAIN
Vehicle has a recurring P0018 fault code (Crankshaft Position - Camshaft Position Correlation Bank 2 Sensor A). Dealer diagnosed loose cam pins on Bank 2 requiring major engine repair. This fault creates a safety risk as improper camshaft timing can cause unexpected engine stalling while driving, resulting in sudden loss of power, power steering, and brake assist. The manufacturer has denied warranty coverage despite the vehicle being within the 10-year/100,000-mile powertrain warranty. This appears to be a known widespread issue on the 3.3L V6 engine. Vehicle has 96,000 miles and is still within warranty coverage period.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741434June 1, 2026
ENGINE
While driving on interstate 380 south,with cruise on ,my engine failed with loud knocikng, Ihad two tractor trailors behind me ,i was lucky to get off road onto side of shoulder this was on May 5,2026. this was the second 2.4 liter theta 2 motor in my sorento, first motor failed at 58.000 miles, second motor failed at 138,000miles. auto was taken to kia dealership in Blakely ,Pa. a NEW MOTER HAS BEEN INST.ALLED UNDER WAURENTEE.MY ENGINE HAS THE KNOICK SENSOR AND SOFTWARE INSTALLED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741207June 1, 2026
ELECTRICAL SYSTEM
The Auto Start-Stop System light came on flashing while driving. Vehicle wouldn’t accelerate while in heavy traffic. Pulled over to the shoulder and turned vehicle off. Attempted to start vehicle again and would not start. Had to get the vehicle towed. Positive battery post is loose and screw is tightened as much as possible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741120May 31, 2026
UNKNOWN OR OTHER
The pearl white paint on the 2014 Kia Sorento has delaminated and is coming off in large sections all over the car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741175May 31, 2026
ELECTRICAL SYSTEM
There is a recall for the HAVOC system foe the years 2021-2023, 25V649 recall. My car is a 2019 kia sorento and I m having the same issues, I have already replaced blower motor, resistor, air filter replaced, fuses, air compressor clutch relays, 3 times. Coolant is fine. After reading this recall my car same issues, please add my car to the recall list, I have spent over $600 in mechanic fees and parts, now the problem is recurring. Its a wiring issue, there was melted part on the blower motor when everything was replaced in February, I can't afford more repairs. I can get reciepts from parts i had to buy and a invoice from my mechanic, the issue of AC/heater reoccurring on May 29th. 2026. I had pur in a relay last week, now needs another one. Cost of them $25.00.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741029May 30, 2026
FUEL/PROPULSION SYSTEM, ENGINE, STEERING
Car completely stalled while on the freeway with no warning, no engine lights, nothing….luckily we were going downhill and were able to pull over to the side safely. Still owe 6k to the finance company but mechanic claimed I needed a new waterpump…after being changed and charged the car still wouldn’t turn on despite the new waterpump….and a bunch of new obd codes showed up & now I need a new engine. After a lot of research I’ve learned this car is notoriously known for many recalls and overall complains…..I wish I had done research before buying it, now I’m in debt for a car I can’t even drive
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741030May 30, 2026
ELECTRICAL SYSTEM, UNKNOWN OR OTHER
Fire at the rear bumper of car
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11740994May 30, 2026
VISIBILITY/WIPER
The vehicles windshield may not be sealed properly or have moisture that builds up between the pressed glass causing reduced visibility and higher risk for crash obstructing the view of both passenger and most importantly the driver.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740972May 30, 2026
POWER TRAIN
My vehicle lost power and accelerated quickly yet unpredictably, and the check engine light came on. A local shop told me it was "an old code" for the transmission and that if it does that again to take it to dealer. It occurred again. Kia dealer states this vehicle has a recall and has been repaired twice, but that they will not repair it again. This is such an unsafe issue they will not allow me to drive the vehicle. I will have to pay almost $7,000 to replace the transmission.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740766May 29, 2026
ENGINE, POWER TRAIN
Was in for service on recalls 2 weeks ago may 2026...dealer did not fix shift solenoid recall..stated bcu need replaced...driving may 28 26 without warning no lights anything lost power while driving and engine and or transmission failed..lost oil...metal shavings in dipstick oil.oil on skid plate cover..3.3L V6 2016 kia sorento LX was able to get off road without crashing
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740793May 29, 2026
ENGINE
Engine- car turn off - lights were still on, car restarted - no icons on dashboard
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740792May 29, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
Intermittently, when coming from a stop (stop sign, red light, etc) or recent start of the vehicle, the Sorento will not accelerate past approximately 30 miles per hour and the auto-stop light will flash orange in the panel. Once the vehicle is stopped, turned off, and restarted, it goes back to operating as it should and accelerates like normal. This has happened when driving on small, low speed limit roads and on large, high speed limit roads. My safety and the safety of those driving around me is put at risk when vehicles around me are expecting me to drive a certain speed but I can't and am looking for a safe place to pull over to stop and restart the vehicle. To date, the vehicle acceleration has not suddenly dropped from a high speed to a low speed thankfully, but when the issue presents itself, it will not allow the vehicle to accelerate above the 30mph range. The vehicle is available for inspection upon request. It is currently at a dealership that is working to reproduce and confirm the problem. There are Reddit threads that discuss other Sorento owners experiencing this same issue. To my knowledge, there were not any warning lamps, messages, or other symptoms of the problem prior to this issue presenting itself. It has been happening on and off for the last 1-2 years. My vehicle has not been inspected by the manufacturer, police, insurance representatives, or others but I am happy to have any of them do so. A simple battery replacement has not resolved the issue - it was happening before I had my battery replaced and it has happened since having my battery replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740679May 28, 2026
ENGINE
The contact owns a 2019 Kia Sorento. The contact stated while driving at an undisclosed speed, the low oil and the check engine warning lights were illuminated. The contact stated that a few days later, the contact noticed white smoke coming from the exhaust. The check engine warning light illuminated intermittently. The vehicle was taken to an independent mechanic where it was diagnosed with detached cylinder head bolts and a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 186,016.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento