Kia EV6 Complaints (2023)

138 consumer complaints on file.

#11772593October 21, 2026
ELECTRICAL SYSTEM
Vehicle failed to start and a jump is required to start the vehicle for the first time on 10/6/2026. This has now happened numerous times and at times when the vehicle's power train batteries are charged. An small portable charging device has been purchased to jump the vehicle which eliminates the need to call for roadside assistance. Roadside assistance has take over 2 hour to response. An error on the dash indicated the 12 Volt battery has lost charge. There is a red circle message displayed on the dash. The vehicle was taken to Batteries Plus and a battery and alternator test. No problems were noted. The vehicle is scheduled for a dealer inspection on 10/22/2026.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765685September 20, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
The ICCU on the car died in the middle of the street, car would not shift out of park. Car completely died after a few minutes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760996August 31, 2026
LANE DEPARTURE: ASSIST, FORWARD COLLISION AVOIDANCE: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
I was driving in heavy rain on a busy highway (I4) and the lane assist pulled me off the road to the road hand side and then cut across all lanes of traffic to the left hand side. It also engaged emergency braking going forward when there was no reason to do so. Many times when I am backing up, it's engaged emergency breaking when there is no risk of collision. Finally, the front sensors are very inconsistent with when they go off. Today I was not moving and neither was the car ahead of me, first it told me I was too close (yellow) on the left bumper, then it turned off and told me I was too close (red) on the front, turned off again and went back to yellow on the right and then turned off again.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757866August 19, 2026
UNKNOWN OR OTHER
I charged my car at a level 3 fast charger on a road trip. After completing my charge, the AC stopped working. The fan worked but it was only blowing hot air. Normally this would be a nuisance, but the day was about 114 degrees and the car’s interior was probably close to 140 degrees. I was driving on the interstate so it was very hard to keep the windows down. The lack of HVAC made the car difficult to operate and if my family was in there would have been a safety hazard. I took it to the dealer who initially thought it need the coolant to be recharged. It turns out that the inverter for the A/C died. Apparently this has some connection to the known issues with the ICCU, which in my case just blew out and was replaced a month and a half prior to this incident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757865August 19, 2026
ELECTRICAL SYSTEM
ICCU failure. I charged overnight at my home L2 charging as usual. I backed out of my garage and heard a loud pop. Almost immediately an “check electrical” warning came up. The car went to turtle mode and then completely died. The car was towed and I was informed the ICCU needed to be replaced. The car had all previous checks on ICCU performed (per mailed recalls) and was updated and passed each time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756869August 14, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, POWER TRAIN
While driving southbound on the [XXX] in a rented 2023 Kia EV6 from The Hertz Corporation, picked up in [XXX] on XXX, the vehicle entered "Power Limited" mode without warning. The vehicle lost normal propulsion and decelerated from highway speed to a crawl, forcing 4-5 emergency stops onto the highway shoulder over several miles while semi-trucks passed at 70+ mph in live traffic, with two minor children in the vehicle. The vehicle was ultimately abandoned at a highway rest stop on Hertz Roadside Assistance's instruction and towed. This vehicle was subject to three NHTSA recall campaigns for the ICCU defect that produces exactly this failure mode: 24V057000 (SC295, driveshaft, notice mailed XXX), 24V200000 (SC302, ICCU 12V charging failure/Power Limited mode, notice mailed XXX), and 24V867000 (SC327, expanded ICCU remedy superseding SC302, notice mailed XXX) — all mailed well before this vehicle was rented to me on XXX. Under 49 U.S.C. §30120(i), a rental company may not rent a covered rental vehicle subject to an unremedied safety recall. I am requesting NHTSA use its inspection authority under 49 U.S.C. §30166 to determine whether Hertz completed the required SC327 remedy on this vehicle before renting it to me, and to review Hertz's fleet-wide recall compliance for its Kia EV6 inventory. This does not appear to be an isolated incident: NHTSA complaint ODI XXX, filed XXX, describes a near-identical failure — a rented 2023 Kia EV6 (Dollar Rent A Car, a Hertz-owned brand) losing power and shutting down multiple times on the freeway during a single trip, also towed. Two renters, two Hertz-family rentals, same defect signature, five months apart. Hertz has been on written and verbal notice of this incident since XXX, and I sent a formal written demand on XXX with a response deadline of XXX. As of this filing, Hertz has not responded. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753434July 29, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM, POWER TRAIN
While driving a rented 2023 Kia EV6 on the freeway, the vehicle lost power and shut down completely, without warning, on multiple separate occasions during a single trip. This occurred at highway speed in live traffic, creating a serious risk to vehicle occupants and surrounding traffic. The vehicle was a rental (Dollar Rent A Car); no external damage or collision was involved. The vehicle has since been towed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746036June 23, 2026
ELECTRICAL SYSTEM
ICCU failed and replaced under warranty
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744054June 14, 2026
ELECTRICAL SYSTEM, POWER TRAIN, FUEL/PROPULSION SYSTEM
First ICCU the power completely went out on 2/23/26. Power went out again April, 2026. Currently car is immobile and unreliable and not safe for driving due to power failures. Towed car to Kia Cerritos. Car supposedly "fixed" (with other issues I've reported to KIA of America & CA BAR/DMV) Currently 12V battery is not holding charge as of 4/27/26, 4/28/26, and 5/2/26. I received a letter from KIA stating ICCU and inability to charge, Keep this Letter in your Glove Box for a free diagnosis and possible no cost servicing. As an older American this is inherently unsafe, as I travel for work and cannot be stuck on the road. The vehicle suddenly loses power in traffic. It simply stops running. This is my 5th attempt to file this very complaint between April and 6/14/26.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738207May 15, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
ICCU failure, a well known issue with these cars.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737911May 14, 2026
ELECTRICAL SYSTEM, ENGINE
Iccu failure with Kia ev6. Unreal that this car has not had a recall yet. It is totally unacceptable that this car can at any time fail. Car will not start and shut down while I was driving. Luckily I was beginning to park when it happened
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737319May 12, 2026
FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
The ICCU unit failed. The message "Check Electrical System" appeared on the instrument cluster. Low-voltage battery voltage was 12.0V and vehicle speed was limited to 60 mph. Maximum speed was gradually reduced to 30 mph over a period of 40 minutes (voltage was 11.5 V) with minimal 12V loads. I pulled over and called a tow truck to the nearest service center. Kia confirmed the ICCU was defective and replaced the part under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734074April 27, 2026
ELECTRICAL SYSTEM, POWER TRAIN
ICCU failed despite all prior recall updates being performed. Incident began when home circuit breaker tripped; vehicle subsequently refused Level 1 charging with "Check Electrical System" warning. Per dealer suggestion, tested public chargers. Level 3 (DC) worked, but upon connecting to Level 2 (AC/J1772), a loud "pop" occurred, and the public charging station immediately suffered a mechanical failure/shutdown. Vehicle then displayed "Stop vehicle and check power supply," and was unable to drive above 40mph (with a turtle icon visible on the dash) once I pulled away from the charging station. This created a significant safety hazard while navigating traffic. Within two hours, the 12V battery was completely depleted; vehicle was unresponsive and required a jump-start for towing. Dealer confirmed ICCU failure requiring replacement. The fact that the vehicle's internal failure caused the immediate malfunction of public infrastructure is deeply concerning, as was the loss of motive power on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732973April 22, 2026
ELECTRICAL SYSTEM
My vehicle has been in the possession of Koons Kia of Owings Mills since March 15, 2026, for diagnosis and repair of this issue, with service beginning March 16, 2026. During this time, the dealership has replaced the 12-volt battery and performed a software update; however, the defect has not been corrected. On April 10, 2026, I was notified that the vehicle was ready for pickup. When I arrived on April 11, I found that the battery was completely discharged and the issue had not been resolved. Because the vehicle was not operational at the time of attempted pickup, it was not returned to me and remained in the dealership’s possession. I was contacted again on April 13, 2026, and informed that the vehicle had been repaired. When I returned to the dealership on April 14 to retrieve the vehicle, I again found that the battery was discharged and the defect persisted. As a result, the vehicle was not returned to me and has remained continuously in the dealership’s possession since March 15, 2026. As of today, the vehicle has been out of service for more than 30 consecutive days due to this defect, and multiple repair efforts have failed to resolve the issue. This ongoing condition substantially impairs the use, value, and reliability of the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732210April 19, 2026
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
*ICCU assembly and ICCU fuse fault (a kia recall SC327( NHTSA ID: 24V867000) for ICCU was performed months early but does't help AND iccu crash) *yes - cars stop workind in the midle of nower at 317 mile away from home with 5 persons in) *yes ( kia already performed recall SC327 for our car but doest help and the ICCU crash) *yes *yes-vehicle broke down while driving.Had to be towed to closest Kia dealer(the incidend hapened 317 miles away from our home Dacula GA 30019)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732134April 18, 2026
ELECTRICAL SYSTEM
ICCU on my Kia EV6, this is a known issue, shouldn’t be bound by miles, as it’s not a mileage issue or concern! The warning was Stop Vehicle Check Power Supply!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732104April 18, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
Got in my car to leave a store and heard a loud pop and noticed a smell like an electric motor burning. Backed out of my space to drive home and the car displayed several error messages- Check electric vehicle system, turtle mode, power reduced. I was stranded and had to order a tow truck to be towed to the dealer and get a ride home.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730649April 12, 2026
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
Repeated failed attempts to repair ICCU culminating in ICCU failure. May 15, 2024 – Initial repair attempt (ICCU-related recall/service). September 5, 2024 – VCMS logic recall performed. December 19, 2024 –second repair attempt for ICCU-related issue. October 16, 2025 – Limp-home logic recall performed. March 11, 2026- Vehicle experienced a complete loss of power and was rendered undrivable. Repeated attempts to avoid ICCU failure still resulted in said ICCU failure and a loss of propulsion event while vehicle was on the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11729218April 4, 2026
ELECTRICAL SYSTEM
Vehicle charging. When charging at home or public charging stations. It sometimes automatically shuts off before it gets to limit set.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11728041March 30, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FUEL/PROPULSION SYSTEM
I was driving 40mph and received a yellow error message along the lines of "electrical system issue, please check" and my speed was limited to 25mph. After trying to get the car to a safe location (as I was on a narrow two-lane road), the error changed to a blinking red error and my speed was further limited to 12mph. I was unable to get the car one mile to the dealer for service, so I stopped the car in a parking lot and had it towed to the dealer. The dealer diagnosed the problem and replaced the ICCU (2nd time on this car) and the 12 volt battery.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia EV6