Jeep Wrangler Complaints (1999)

217 consumer complaints on file.

#11457803March 22, 2022
STRUCTURE
The contact owns a 1999 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the rear subframe fractured near the axle. The vehicle was taken to an independent mechanic who diagnosed that the subframe was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11278657November 7, 2019
STRUCTURE:BODY
I STARTED HEARING A BANGING/CLANGING NOISE UNDER THE REAR OF THIS VEHICLE UPON STARTING/STOPPING OR REVERSING. THE NOISE IS BEST DESCRIBED AS A SHARP METALLIC CLANG. UNDERCAR INSPECTION REVEALED THE FRAME HAS CORRODED TO THE POINT THE UPPER CONTROL ARM MOUNTS HAVE PULLED AWAY FROM THE FRAME AND THE TRACK BAR THAT LOCATES THE AXLE SIDE-TO-SIDE HAS SEPARATED FROM THE REAR AXLE HOUSING ALONG WITH THE UPPER CONTROL ARM MOUNT SEPARATING FROM THE AXLE HOUSING. REPAIR OF THIS VEHICLE REQUIRES REPLACEMENT OF THE FRAME ALONG WITH REPLACEMENT OF THE COMPLETE REAR SUSPENSION AND AXLE HOUSING. THIS SAME VEHICLE WAS REPORTED TO YOU 03 NOVEMBER 2016 FOR THE SAME ISSUE INVOLVING THE CENTER SECTION OF THE FRAME RUSTING THROUGH CAUSING THE TRANSFER CASE MOUNT/SKID PLATE TO DROP. SAFETY CAPS WERE INSTALLED ON THE FRAME AT THIS TIME AND THE VEHICLE WAS PLACED BACK INTO SERVICE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11267334October 9, 2019
STRUCTURE:BODY
FRAME ROTTED FROM RUST WHERE THE REAR SUSPENSION ATTACHES TO THE FRAME. TOO MUCH RUST TO REPAIR. REMAINING VEHICLE IS IN GOOD SHAPE CONSIDERING ONLY 107K MILES. SUSPENSION BROKE FREE FROM THE FRAME DURING NORMAL ROAD OPERATION. I AM TOLD THAT THE PROBLEM IS EPIDEMIC WITH JEEP TJ FRAMES. APPARENTLY SO BECAUSE THERE IS NOTING AVAILABLE ON THE USED PARTS MARKET. LOTS OF TJ BODIES AND PARTS AVAILABLE BUT NO FRAMES TO GO ALONG WITH THEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11192646March 30, 2019
STRUCTURE:BODY
JEEP IS A 5 SPEED TRANSMISSION. COULDN'T SHIFT CORRECTLY, HEARD A RATTLE. ENGINE HAD FALLEN DUE TO RUSTING FRAME. FRAME SO RUSTED, ENGINE FELL. ONLY 90,000 MILES ON VEHICLE. NOT DRIVEN DAILY. WAS IN MOTION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11093813May 14, 2018
SUSPENSION
JEEP FRAME ROTTED ABOVE REAR AXLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11035913October 23, 2017
STRUCTURE:BODY, WHEELS
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE CHANGING THE REAR DRIVER SIDE TIRE, IT WAS DISCOVERED THAT THE SPARE TIRE HUB WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY OPEN RECALLS. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,001.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11016062August 17, 2017
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
FUEL- JEEP HARD TO FILL WITH FUEL OR MUST FILL FUEL AT VERY SLOW RATE. NOZZLE DOES NOT LOCK OR FILL PROPERLY. (STATIONARY) ELECTRICAL- HAZARD LIGHTS(IN REAR) RANDOMLY TURN ON BY THEMSELVES WHILE DRIVING. (ANY MPH, CITY STREETS AND HIGHWAYS)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10935478December 15, 2016
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 50 MPH OVER A BUMP IN THE ROAD, THE BLOWER MOTOR FAILED TO FUNCTION. THE INSTRUMENT PANEL WARNING INDICATORS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924055November 3, 2016
STRUCTURE:BODY
JEEP WRANGLER (TJ BODY) 1999 FRAME RUST I WAS DRIVING THE VEHICLE AT INTERSTATE (68-72MPH) SPEEDS WHEN A SEVERE VIBRATION STARTED SUDDENLY AND THE MANUAL TRANSMISSION SHIFT LEVER DROPPED TO A LOWER THAN NORMAL POSITION. I PULLED OFF IN A SAFE AREA AND INSPECTED FIRST FOR A FLAT TIRE AND THEN LOOKED UNDER THE VEHICLE. I NOTED THE RIGHT FRAME RAIL HAD RUSTED THROUGH FROM THE INSIDE AND THE TRANSMISSION-TRANSFER CASE MOUNT/SKID PLATE ASS'Y HAD SEPARATED FROM THE RIGHT (PASSENGER SIDE FRAME RAIL AND DROPPED APPROX. 2-3 INCHES. THIS CAUSED SEVERE DRIVELINE VIBRATION AND ERRATIC VEHICLE CONTROL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10864340May 11, 2016
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE ODOMETER BACK LIGHT SEIZED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED PREVIOUSLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V117000 (UNKNOWN OR OTHER). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 175,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10853108April 2, 2016
SUSPENSION
I HAVE OWNED VEHICLE 6 YEARS AND HAVE 118000 MILES AND FOUND FRAME IS ROTTING AWAY MAKE AN UNSAFE VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10748365August 13, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING OVER A BUMP AT 35 MPH, THE INSTRUMENT CLUSTER FAILED TO FUNCTION. THE CONTACT HAD TO HIT THE CONSOLE BEFORE THE CLUSTER ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10743398July 24, 2015
VEHICLE SPEED CONTROL, ENGINE
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 40 MPH, THE SPEEDOMETER FAILED AND THE ENGINE WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THIS WAS A RECURRING FAILURE. THE VEHICLE WAS NOT TAKEN IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 146,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10712189April 22, 2015
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE UNDERCARRIAGE AND FRAME WERE CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10704110April 7, 2015
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
THE FRAME ON MY 1999 JEEP WRANGLER TJ IS ROTTING THROUGH IN SEVERAL PLACES. A VEHICLE ONLY 15 YEARS OLD NORMALLY HAS PROBLEMS, BUT IT SHOULD NOT BE A FRAME RUSTING THOUGH. I AM ASKING YOU TO URGE CHRYSLER TO DO THE RIGHT THING FOR ME AND MANY JEEP OWNERS WHO ARE ALSO EXPERIENCING THIS PROBLEM AND RECALL AND REPLACE THE FRAMES. OTHER AUTOMOBILE MANUFACTURERS HAVE DONE THIS AS IT IS A SAFETY ISSUE AND THE RIGHT THING TO DO. THANK YOU. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10619057August 5, 2014
STRUCTURE
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE TEMPERATURE CONTROL LEVER MELTED WITHOUT WARNING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE CONTACT ATTEMPTED TO REMEDY THE FAILURE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10605175June 23, 2014
STRUCTURE:FRAME AND MEMBERS
TL ' THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE THE VEHICLE WAS BEING SERVICED FOR AN UNRELATED REPAIR, THE MECHANIC NOTICED THAT THE FRONT PASSENGER'S SIDE FRAME WAS SEVERELY RUSTED. THE FRONT DRIVER'S SIDE FRAME CONTAINED A HOLE AND A CRACK. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. JCC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10604427June 19, 2014
STEERING, POWER TRAIN
I HAVE A 1999 JEEP WRANGLER SAHARA V.6. 5 SPEED MANUAL TRANSMISSION. MY JEEP IS IN GREAT SHAPE HOWEVER I STARTED HAVING STEERING PROBLEMS. I NOTICED AROUND THE APEX ON BOTH SIDES THE FRAME HAD RUSTED AWAY. I HAD IT A NEW PIECE WELDED IN PLACE AND IT WAS WORKING GREAT. THEN I NOTICED MY TRANSMISSION WAS HAVING ISSUES. I THOUGHT I WAS GOING TO HAVE TO BUY ANOTHER TRANSMISSION WHEN IT WAS DISCOVERED THE PLATE THAT LIES BELOW THE TRANSMISSION WAS RUSTED FROM THE FRAME AND NOT SUPPORTING THE TRANSMISSION. I HAD THAT WELDED TOO. I LOOKED THE OTHER DAY AND NOTICED A HOLE BETWEEN THE SIZE OF A BASEBALL AND GOLF BALL. I TOOK IT AGAIN TO MY WELDER AND HE SAID THE WHOLE BOTTOM OF MY FRAME IS RUSTED AWAY. I WAS TOLD BY MY BODY SHOP THAT BECAUSE OF JEEPS DESIGN WATER WAS ABLE TO GET AND NOT OUT CAUSING IT TO RUST. THE BODY OF MY JEEP IS IN GREAT CONDITION AS WELL AS MY MOTOR AND TRANSMISSION. IS THERE ANYTHING BEING DONE ABOUT THIS ISSUE. IF NO ONCE CATCHES IT I COULD HAVE LOST MY FRONT WHEELS AND OR TRANSMISSION. I THINK ITS DANGEROUS. I'M LOOKING AT $3000.00 TO REPLACE MY FRAME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10583264April 17, 2014
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT UPON INITIAL START-UP, THE INSTRUMENT PANEL FAILED AND WOULD NOT ILLUMINATE. THE FAILURE WAS RECURRING. THE CONTACT WOULD TURN THE ENGINE OFF AND ONCE RESTARTED, THE FAILURE WOULD SPORADICALLY RESET. ADDITIONALLY, THE VEHICLE STALLED MORE THAN FIVE TIMES WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 99V117000 (INSTRUMENT PANEL SCREWS) BUT HAD EXPERIENCED THE FAILURE MULTIPLE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10575316March 28, 2014
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL AND GAUGE FAILED TO ILLUMINATE DUE TO THE LOOSE SCREWS THAT ARE LOCATED ON THE BOTTOM OF THE INSTRUMENT STRUCTURE. THE CONTACT WAS UNABLE TO READ THE GAUGE ON THE INSTRUMENT PANEL AND THE ELECTRICAL BLOWER MOTOR FAILED. THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 99V117000 (UNKNOWN OR OTHER). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 191,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Jeep Wrangler