Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11719728February 22, 2026
AIR BAGS
NHTSA Complaint Summary Vehicle: 2025 Hyundai Santa Fe Issue: Airbag non‑deployment in a 40‑mph side‑impact collision On January 20, 2026, my 2025 Hyundai Santa Fe was struck by another motorist directly along the driver side awaiting to make a left turn. The other motorist crossed the centerline at an estimated impact speed of approximately 40 mph, according to the police report. The collision caused significant damage along the front and entire driver side of the vehicle. Despite the severity and direct nature of the impact, neither the side curtain airbags nor the front airbags deployed. The impact was so much that the other motorist ended up behind my husband in the left turning lane once he stopped. My husband, who was driving, suffered a head abrasion and a concussion from the force of the impact. Since the crash, he has continued to experience persistent headaches and intermittent dizziness when standing, which began immediately after the collision and have not resolved. The lack of airbag deployment in a high‑energy side‑impact crash raises concerns about a potential malfunction in the airbag sensors or side‑impact detection system. This incident presents a significant safety risk, and I am reporting it so NHTSA can evaluate because as I've researched there have been other incidences of similar non‑deployment issues are with 2025 Hyundai Santa Fe vehicles. I can provide photos, the police report, medical documentation, and repair estimates upon request.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11719714February 22, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
After turning off the radio with the push button control the instrument cluster and navigation display panel went completely dead black. After pushing multiple buttons several times the panel came back to life. This has not yet been reported to the dealer. On 12/12/2025 this same vehicle also experienced faulty engine / power train components which required replacement @1199 miles. Throttle body assembly and torque converter assembly which caused loss of power when accelerating onto a high speed parkway attempting to reach @55mph along with excessive vibration when brakes were off. Took dealer 22 days to fix the problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719636February 21, 2026
ENGINE
HI! Leaking valve cover gasket which damages spark plugs, ignition coils and fuel injector. Defective High Pressure Fuel Pump and fuel injector causing fuel to spray into engine and into engine oil. Large amount of fuel found in oil pan when oil changed. Complaint filed with Hyuandia, no response at this time. Thank you, [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719647February 21, 2026
UNKNOWN OR OTHER
The motor began to making a knocking noise and started smoking like a fire was starting. We immediately turned off the vehicle preventing from a full fledge fire. We had children in the car as well which posed a safety concern for them. We had no prior warning lights or issues. It has yet to be inspected by anyone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719329February 20, 2026
ENGINE
I purchased this vehicle one year ago from a used car dealership with 148,000 miles on it. Within a few months it was throwing crankshaft position, sensor codes, camshaft codes, and burning oil. I cannot bring my RPMs above two without my check engine light coming on and blinking. My car will go into limp mode. Hyundai does not have my car included in the engine recall they only have the sport Santa Fe included. They released an extended warranty for 150,000 miles but by the time that was put into place my car was at 151,000 miles so it was not eligible.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719008February 19, 2026
ENGINE
Engine failed at approximately 95000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719165February 19, 2026
UNKNOWN OR OTHER
Dashboard cracking - not overly parked in sunlight.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719267February 19, 2026
POWER TRAIN
On November 18, 2025, at 24,370 miles, the vehicle suffered a catastrophic powertrain failure, triggering a dashboard warning: "Transmission system error! Check transmission oil immediately." The vehicle suffered a loss of reliable motive power. This sudden failure is a severe safety hazard that presents a high risk of stalling or stranding in active traffic, which is especially dangerous as this vehicle is used for a 40-mile round-trip school commute four days a week on local highways. The dealership replaced the transmission, keeping the vehicle out of service for 27 days. However, the exact same critical failure occurred a second time on December 24, 2025, at 24,878 miles. The vehicle was once again completely incapacitated and required a second transmission replacement as well as a new TCU, resulting in an additional 50 days out of service. Two catastrophic transmission failures within a 500-mile span on a brand new vehicle demonstrate a highly dangerous defect that puts the driver, passengers, and other motorists at unreasonable risk of a crash due to sudden loss of power.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719196February 19, 2026
STEERING
A brand new Santa Fe Hybrid AWD SEL(less than 2500 miles) makes squeaky noises when rotating the steering wheel to the counter clock wise. It is very annoying and frustrating. Due to the noise I can't fully concentrate to driving the car. Brought the vehicle to a local dealer and they would not do anything about it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11719072February 19, 2026
WHEELS
One of the original OEM tires (Pirelli Scorpion MS KS NCS XL - 245/45R21) had the acoustic dampening foam on the inside of the tire fall apart. Dealership indicated that there was 'no impact damage or modifications found with the tire during inspection; meaning this was likely a manufacturing defect due to adhesion issue. Despite the problem and the fact that this tire has less than 12K miles on it at the time of the incident, the local Hyundai dealership, Hyundai corporate and Pirelli all refused to cover the cost to replace the tire. Hyundai dealer said to file a complaint with Hyundai corporate, Hyundai Corporate said that this was a Pirelli tire warranty issue (no paperwork provided about Pirelli tire warranty at time of purchase) and Pirelli indicated that only the local dealer or an authorized dealer of their tires can submit warranty claims, and that it is contingent upon a Pirelli inspection and prorated based on the remaining tread of the tire. This leaves the consumer in a difficult position having to bear the burden of the tire replacement cost upfront, and little chances of recourse as these 3 parties skirt responsibility of the OEM tire. When the acoustic foam fails, the car shakes violently at high speeds, for us this stats at ~50mph. There is no warning light that appears for this, dealer originally thought this was related to ice build up which did not rectify the problem causing us to have to go to the dealer twice for diagnostics. Online forums seem to point that this acoustic foam adhesion issue is especially common in colder climates. Symptoms of problem first appeared in early January, with full diagnosis confirmed early Feb.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718953February 18, 2026
ENGINE, FUEL/PROPULSION SYSTEM
While on the highway my car lost power, gradually slowing down to a stall. I was able to safely park on the side of the road. I got the car to a nearby dealership that kept it for 10 days. The dealership said that the problem was code P2118 (Throttle Actuator Control Motor Current Range/Performance) that the air "flap" was frozen stuck shut and the engine was disabled on the freeway in order to prevent damage. The resolution was "waited for it to thaw and cleared the code". The dealer has a service bulletin and a software update but it did not resolve the safety issue. I've noticed hesitation when accelerating the car from a dead stop as well, which started last year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718964February 18, 2026
VISIBILITY/WIPER, LANE DEPARTURE: BLIND SPOT DETECTION
Side view camera that displays blind spot area in dash screen cluster, screen intermittently shows just a green screen and not the blind spot.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718776February 18, 2026
LANE DEPARTURE: ASSIST, LANE DEPARTURE: WARNING
The vehicle has a feature that puts a message on the dashboard that reads “Consider taking a break “ that is not able to be adjusted by the consumer or the dealer. This message can come up repeatedly and has an audio portion that overrides the audio in the vehicle. Weather conditions, back roads, and unmarked lanes of traffic will trigger this message and without the ability to adjust the sensitivity or the ability to turn it off, it is a very dangerous situation. I have had it go off multiple times in a drive when there is a strong side wind and the vehicle is being pushed around and it can be very, very difficult to safely drive when this is visually and auditory messages keep coming up on the dash without any option to adjust it. On back roads or in situations where there is snow covered roads, this message can be nonstop and go off 50 times or more in a 90 mile drive. It is the worst thing about this vehicle and it’s not reasonable for the vehicle not to have the ability to adjust the feature? I’d ask that an investigation be opened to look into this and demand that Hyundai update the vehicle software to allow the settings for this message to be adjustable. When looking on the internet for this problem, there are 100s of not 1000s of people that have been searching and complaining about this message on the new Kia and Hyundai vehicles. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718459February 17, 2026
ENGINE
Engine valve cover gaskets leaking oil, causing oil drip on pavement. Could cause fire and alternator failure. My mechanic pin-pointed the leak location. The google search indicated that other Hundai vehicle owners also had this problem. Mechanic estimated cost to repair the problem was quoted at $700.00 dollars. Thx, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718516February 17, 2026
ENGINE
My Hyundai Santa Fe has a major oil leak from the oil pressure light. I took the car to a non-Hyundai shop for repair and was told that the problem should be covered under recall campaign 168. Reference Number: 17-01-071, Date of issue: December 01, 2017. A quick check of internet complaints indicates this is a common problem with this type vehicle. My oil pressure light is on at idle after the car is warmed up. Reno Hyundai dealer informs me that it is not covered by recall. I believe that this problem should be covered based on the volume of complaints from other owners. Can your organization help me in getting some kind of an cost adjustment for getting this repaired. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718566February 17, 2026
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
The horn stops working which is a safety hazard in case someone is backing into you, etc. This horn has stop working 4 times and had to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718270February 16, 2026
AIR BAGS
Passenger airbag dash is cracked risking unpredictable deployment of air bag
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718307February 16, 2026
STRUCTURE:BODY
The roof of my car between the sunroof and the windshield (called panoramic sunroof) shattered as I was driving down the highway. It was about 10:00 pm on a weeknight and there were no cars within sight distance in front of me. When it happened it sounded like a gun shot going off at point blank range and I immediately pulled over and checked for bullet holes. Since it was dark I could not see any damage. Today I took the car and had a small chip fixed in my windshield down by the windshield wipers and the service tech pointed out to me that the roof was shattered. He told me that this happens a lot with this vehicle. So I got online and searched and found a lot of vehicles have reported the exact problem. Down to the sounds of gunshots. So I stopped at my local Hyundai dealership and recorded the conversation. He told me that theres no recalls on this car and It probably shattered by a rock or debris. I told him that when this happened it was late night and no cars within sight in front of me. He didn’t even come out and look at the damage. He said to call my insurance company and I said that is a manufacturer defect and I shouldn’t have to pay for their mistake. When I searched for this on the internet people stated that the dealerships will deny this manufacturer defect and that’s exactly what they said to me. My main concern is that this defect is documented by many vehicle owners from their 2020 vehicles and their Is a recall out for this problem but it stops at 2016 models. In this recall the shattered piece is replaced and there is actually compensation given for people getting scared or dealing with stress dealing with thinking they are getting shot at. I don’t care about any of that. I just want the issue fixed because I did not cause the issue, the manufacturer did. Reason being is that the exact thing is happening to numerous people across the Country. Thank you for your time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718320February 16, 2026
FUEL/PROPULSION SYSTEM
In November 2025, my 2022 Hyundai Santa Fe began to hesitate when accelerating and would almost "jerk" when I pressed the gas pedal. Soon after my check engine light came on and I made an appt to take it for the closest Hyundai dealership (as it's still under warranty 33k miles) Upon running a check the dealership notified me that Fuel Injector 1 has misfired and will be replaced. I receive my vehicle back and not even 100 miles later my check engine light in on again and the same issues are arising. Back to the dealership to see now Fuel Injector 3 has misfired and there is an open TSB showing all 4 Fuel Injectors need replaced. My vehicle was finally returned to me in January 2026. It is now February 16, 2026 and my check engine light in on YET AGAIN. I've been given the run around from Hyundai Corp about fixing this vehicle. Why is this acceptable treatment when a vehicle is under warranty ?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718300February 16, 2026
UNKNOWN OR OTHER
1. The factory-supplied scissor-type jack that came with my 2023 Hyundai Santa Fe failed. While changing a flat tire on the side of the road, the jack collapsed three times and could not hold the vehicle. Yes, the jack is still available for inspection. I have it in my possession and have provided photographs of the jack, its capacity label, and the incident location as evidence. 2. My safety was put at serious risk. The vehicle fell off the jack three times while I was attempting to change the tire on the road. The car remained on the ground without a tire until roadside assistance arrived. If I or a family member had been under or near the vehicle when it fell, we could have been seriously injured or killed. My wife and three toddlers travel in this vehicle, making this a major safety concern for our family. 3. No. Rosen Hyundai dismissed my concern. Service Manager Jeff Bravieri claimed the jack is rated for 3 tons (6,000 lbs) and blamed user error. But my photo shows the jack's label states 1,200 kg (2,645 lbs). The road was flat. The dealership dismissed my safety concern and refused to replace the jack unless I paid for it. They have not inspected the jack despite my request until the involvement of Hyundai Motor America. 4. Not sure, that vehicle and jack have been inspected by the manufacturer, police, or insurance representatives. However, manager later agreed to inspect it and instead blamed user error. I am reporting this directly to NHTSA because the dealership and Hyundai have not taken this safety defect seriously. 5. No. No warning lights or signs. The jack looked normal. It failed the first time when I used it in an emergency situation. 6. The jack label says 1,200 kg (2,645 lbs). My vehicle weight is 1,724 kg (3,801 lbs) . The jack is under-rated and unsafe. It failed on a flat road. The dealer ignored the evidence. I fear this could happen to others and cause serious injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe