Ford Maverick Complaints

323 consumer complaints on file.

#11759384August 25, 2026
POWER TRAIN, STEERING
Vibration and shrouding under light and heavy acceleration, the harder the acceleration the stronger the vibration, feels like truck is falling apart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758093August 19, 2026
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
The Ford Maverick is subject to rodent invasions which caused an engine fire. We had to file a State Farm Insurance Claim ($4016.36 of repairs done to repair the engine including electrical, emission system, cowl, fuel system, and insulation.) This was completed XXX. We have been faithfully spraying the engine with Rodent Repellent, using Natural Repeller packs, and rat snap traps. We have regularly checked the engine to see if they have come back. Yesterday, XXX, low and behold there was evidence of rat/mice droppings, insulation, food, nesting, etc. We again have spent time and money to clean the engine and use the above-mentioned products to try to protect the engine. After moving the truck, again on XXX, there was new evidence. We treated again. This is causing us stress. This should be a recall and Ford made to remedy. Sincerely, [XXX] and [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11757941August 19, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
I was driving with some gravel in the back and the trailer sway control came on causing it to brake and almost lose control on the interstate in front of a semi. This. Vehicle has never had a trailer attached and the nothing in the trailer plug and that still came on.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757780August 18, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM
While driving my 2022 Ford Maverick on a public road, the vehicle suddenly lost acceleration and would not respond normally when I pressed the accelerator. I was left in the roadway and could not safely continue driving, creating a risk of being struck by other traffic. The vehicle was later inspected by a Ford dealership and diagnosed with a major internal transmission failure at approximately 62,000 miles. The Ford dealership recommended a rebuilt/replacement transmission. The vehicle remains available for inspection. I did not have advance warning that the transmission was about to fail.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753287July 28, 2026
FORWARD COLLISION AVOIDANCE
The contact's employer owns a 2025 Ford Maverick. The contact stated that while driving approximately 45 MPH, the pre-collision warning light suddenly activated, and the vehicle abruptly stopped. After pulling over and waiting for several minutes, the contact was able to continue driving. The contact also had whiplash from the failure, and medical attention was needed. The contact mentioned completing 12 sessions of physical therapy. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer was unable to duplicate the failure. The failure reoccurred a week later while driving approximately 30 MPH. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,000.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11752946July 26, 2026
POWER TRAIN
I had stopped at an intersection and when I applied the gas, the truck stuttered a bit before going. It ran okay for less than a mile. I stopped at the next intersection and when I applied the gas, the truck shuttered, started to go then just stopped. It stayed running but didn't want to go. I was able to get it through the intersection but that was it. The message i am getting is powertrain malfunction/reduced power. When we put our diagnosis tool on it, we get code P0757.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751291July 18, 2026
STRUCTURE:BODY
The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747684July 1, 2026
STEERING
When I turn left or right my steering-wheel, slowly at intersections, I hear a loud "click" sound inside my truck's cabin, so loud that I cannot realize where the sound comes out from. My steering performance is smooth, and I cannot feel anything wrong or any shaking, with the steering column. Just ONE loud click sound, every time when I turn slowly. This has been happening since October 2024. Thank you!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747507June 30, 2026
ENGINE, FUEL/PROPULSION SYSTEM
2025 Ford Maverick XL EcoBoost AWD with 2,000 lb tow package. Vehicle displays an 'Engine Coolant Over Temperature' warning recurrently at idle and upon initial startup when ambient temperature is 84°F or above. The warning has occurred multiple times under these conditions. Most recently, the warning appeared while the vehicle was stationary at 0 MPH immediately before entering a highway, creating a safety concern. Vehicle currently has 3,911 miles. No prior dealer service visits for this issue. The problem appears to be temperature-dependent and repeatable. Warning is displayed on the instrument cluster with a red coolant temperature icon and the temperature gauge needle visible in the high range
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746600June 26, 2026
POWER TRAIN
I am filing a formal safety defect complaint regarding a severe catastrophic transmission failure on my 2022 Ford Maverick ( 2.0L EcoBoost 8f35 8 speed transmission ) that poses an immediate safety hazard to occupants and sharing traffic. Upon inspection a heavy volume of metal shavings flakes were discovered also the code PO73D unable to engage in neutral came up. The safety risk of this specific failure is extreme because the vehicle is physically unable to respond to a neutral command the driver cannot clear or cut engine power to the drive wheels during an emergency mechanical malfunction or a potential unintended acceleration event. Furthermore because the metal debris the truck exhibits severe erratic shifting behavior and a persistent risk of sudden high speed wheel lockup drivetrain binding or stalling inactive traffic. Ford motor company is fully aware of this component failure despite my vehicle exhibiting the exact failure mode the exact code PO73D and metal debris found has refused financial responsibility I urge the NHTSA to upgrade this known issue to a mandatory safety recall
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746575June 25, 2026
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
A year ago while driving on the interstate, my Ford Maverick suddenly threw a "Stop Safely Now" alert. I was able to turn the ignition off and back on to safely exit the highway. The alert came back once I made it to a parking lot and stuck around for a while. I was able to get it started and drove to a Ford dealership that told me it was just a software update. The same issue happened 2 more times before I made it to my destination after leaving the dealership, showing that it actually wasn't caused by a missed software update. Returning from my trip it happened 4th time. Afterward, the issue seemed to go away. Now a year later I got in the Maverick to leave work and the alert came back. I was not able to get it started and will attempt to get it over to a Ford dealership tomorrow to be seen for what seems to be the same issue, only worse if it still is not starting in the morning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745687June 22, 2026
STEERING, FORWARD COLLISION AVOIDANCE: WARNINGS, ELECTRICAL SYSTEM
Due to go to dealership to inspect steering wheel
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745659June 22, 2026
VISIBILITY/WIPER
Windshield cracked while parking in the sun.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745656June 22, 2026
VISIBILITY/WIPER
Windshield cracked while parked in the sun.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744344June 15, 2026
ELECTRICAL SYSTEM, SERVICE BRAKES, UNKNOWN OR OTHER
Description On your vehicle, the instrument panel ip upper section may detach from the passenger air bag chute doors during air bag deployment. The airbag is expected to otherwise deploy in position and restrain the occupant as designed. Safety Risk In the event of a crash in which the vehicle deploys the passenger airbag, a part of the ip upper section may detach and strike a vehicle occupant, increasing the risk of injury. Remedy Parts are available to repair your vehicle. Ford Motor Company has authorized your dealer to replace the ip upper section free of charge. Next Steps Contact your dealer for more information to schedule the free service.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743702June 12, 2026
SUSPENSION
The contact owns a 2024 Ford Maverick. The contact received the recall notification letter for NHTSA Campaign Number: 26V340000 (Suspension); however, the part to do the recall repair was not yet available. The contact had no other means of transportation. The local dealer was contacted and confirmed neither the recall remedy nor a loaner vehicle was available. The contact was referred to another dealer. The contact called Crossroads Ford of Sumter (950 N Main St, Sumter, SC 29150), who confirmed no loaner vehicle was available. The manufacturer was contacted but was unable to confirm whether the dealers had loaner vehicles available. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741973June 4, 2026
UNKNOWN OR OTHER, VISIBILITY/WIPER
The info screen, Instrument cluster and backup camera are very dark, it's so dark you can't see the fuel level and engine temperature level, if I switch the headlamp switch to off the screen gets brighter in auto mode its dark, lately it's been flickering and going bright to dark. been to dealer 2x they say," no updates available, no stored codes, lights operating as designed no issues found'. I have checked other vehicles 2026 same year model and their instrument cluster and backup camera and info screen are very bright and clearly visible. I have spoken to service manager at dealer and filed a compilate with ford on 5/26.This is very dangerous there are many children in my neighborhood and have concerns when backing up even using my mirrors and turn around to look I can't see behind the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741076May 30, 2026
POWER TRAIN
Transmission started slipping. Not wanting to pull in drive or reverse
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740980May 30, 2026
SERVICE BRAKES
NHTSA #26V104: I purchased this vehicle to rent it out on Turo (a vehicle sharing platform). It was de-listed from Turo on March 18 due to NHTSA #26V104 recall being unresolved. I have been unable to rent my vehicle since then and Ford has not provided a remedy to this recall. I would like to log a complaint that this software fix remedy has taken too long.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740902May 29, 2026
POWER TRAIN, UNKNOWN OR OTHER
When throttling or under load, significant vibration of the car. Possibly CV axle problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick