Ford Focus Complaints

22,326 consumer complaints on file.

#11676729July 28, 2025
POWER TRAIN
My car was purchased in 2015 and currently has ~69,000 miles. All routine maintenance has been completed on schedule. The clutch was repaired under warranty around ~10,000 and the Transmission Control (TCM) was corrected via software update in 2017. The TCM is now failing and requiring replacement. Ford Motor company was offering extended warranty to 150,000 miles or 10 years with one free replacement after that milestone was reached. That program apparently expired 6/30/25. Ford lost litigation on this vehicle as they sold the vehicles knowing the defect in the transmission. I am now responsible for an out of pocket repair due the expiration of the program. I contacted Ford Customer Care Ford Customer Care case number CXH05090063W2F2H4 and they suggested I file a complaint with the NHTSA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676572July 28, 2025
POWER TRAIN
I have had problems with the clutch 3 times and had it repaired and it sounds like it is going again i have only 44,000 miles on my 2018 and this is ridiculous I love my ford but something has to be done. My warranty is over 7/2026.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676654July 28, 2025
POWER TRAIN
I was driving and got a large nail in my tire. I pulled over and fixed my and went to start my car. The battery had died and we jumped it. We let it charge for a little bit and then started it back up. It started just fine and I went to put it in reverse to drive away and it wouldn’t engage but would engage to drive forward. We hooked the scanner to it and it was showing the TCM code. We took it to ford and they’re saying the A and B clutch are stuck and they need to replace both clutches as it’s a dual clutch transmission and the lever and actuator. The focus has 89,000 miles on it and ford is charging $4100 for a known transmission issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11676415July 26, 2025
POWER TRAIN, SERVICE BRAKES
1) power train system- P090C AND P090C-00 clutch b actuator circuit low causing transmission to slip. dangerous when driving 2) anti-lock brake system code U0401-00 and U3003-16
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675864July 24, 2025
POWER TRAIN
The contact owns a 2017 Ford Focus. The contact stated while driving at various speeds, the vehicle shuddered, and the transmission was slipping. There was no warning light illuminated. The vehicle was taken to the dealer, where it was test-driven, but the cause of the failure could not be determined. The contact stated while driving 55-60 MPH, a message indicating that the transmission had overheated, and that the vehicle was overridden and would shut down was displayed. The vehicle stalled. The service warning light was illuminated. The contact was able to pull over to the side of the road. The vehicle was taken to Akron Transmission Inc, where it was diagnosed that the dual clutch assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 6.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675938July 24, 2025
POWER TRAIN
The contact owns a 2017 Ford Focus. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted and the vehicle stalled. There was no warning light illuminated. The vehicle was restarted. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 73,001.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675667July 23, 2025
POWER TRAIN
The contact owns a 2013 Ford Focus. The contact stated that while driving at various speeds, the vehicle failed to accelerate as intended while depressing the accelerator pedal before the vehicle lost automotive power. The vehicle was shifted into park and restarted. The transmission warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with PCM failure. The contact stated that the PCM had been reprogrammed before. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675775July 23, 2025
POWER TRAIN, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
Ford Focus 2017 Hatchback causing traffic jams and backup do to low speed, overheating, stalling, jerky shifting, Failure to move or hesitation in the middle of driving, causing the car to stop or slow down in the middle of traffic and blocking exits and cars from moving around the vehicle. Transmission overheating and car says to pull over when driving after a few minutes. Powertrain is affected car not driving at correct speed. Transmission clutch a disengaged and having a hard time engaging. Constant clutch issues. Causing issues to driver safety and others on the road. Ford knows about these models but are failing to fix at affordable price or provide warranty. Not upholding customer satisfactory.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675607July 23, 2025
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2014 Ford Focus. The contact stated while driving 30-35 MPH, the vehicle shuddered, failed to accelerate, or shift into the intended gear. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the TCM had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to an unknown recall. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675262July 22, 2025
ELECTRICAL SYSTEM, UNKNOWN OR OTHER, EXTERIOR LIGHTING
A major electrical issue has occurred in this car since June 1, 2025. The Traction Control System dashboard indicator (the skidding car) comes on even though I am not using the TCS. When this happens, I get a message saying "Hill start assist not available," and am unable to manipulate my headlights, use turn signals, or lock/unlock my doors (I need to use the physical key to lock/unlock the driver's side door). If this "Hill start assist" issue occurs and I turn off my car (or if it occurs when the car is off), then I am unable to start my car. I get a new message saying "No Key Detected," and the ignition does nothing. I have a physical key, and not a fob. If the TCS light goes away, then I am able to start up my car. However, this is unpredictable; there appears to be no way to force the TCS light to disappear, and sometimes it will stay on for over an hour with my key in the "on" position. As of late, it hasn't gone away at all, making the car unusable. This causes obvious safety issues when on the road, as I cannot use turn signals or change my lights as it gets darker or it begins to rain/snow. When not on the road, I cannot use my car at all. A dealer recently confirmed the problem with the Body Control Module, but was unable to fix it. They managed to turn the car on, but the problems returned after 24 hours. As I was driving home on July 18, 2025, the TCS light came on and suddenly I could not use turn signals or change my lights. I still had over an hour to drive home. I did arrive home safely, but have not been able to use my car since.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675273July 22, 2025
POWER TRAIN
The contact's mother owns a 2012 Ford Focus. The contact stated that while his mother was driving at an undisclosed speed, the transmission was slipping, and the vehicle stalled. The check engine warning light was illuminated. The contact's mother pulled over and had the vehicle towed to an independent mechanic and the dealer, who determined that the Transmission Control Module (TCM) had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14M02 (Transmission Control Module Extended Warranty Coverage); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675325July 22, 2025
ELECTRICAL SYSTEM
The contact owns a 2014 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle lost automotive power. There was no warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that a wiring harness needed to be repaired. The dealer made the contact aware of an unknown recall; however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 62,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675402July 22, 2025
POWER TRAIN
FORD Customer Satisfaction Program 14M02 - Transmission Control Module I purchased a 2015 Ford Focus for my son in 2021. I PAID WITH CASH. In June 2024, he moved from GA to UT for a job after he graduated college. 2 months later, his transmission went out with no notice. I paid to get the Focus towed to the Ed Kenley Ford Inc. Ford had a Customer Satisfaction Program that started in 2015. There are 7 supplements to the original issue. I called Ford to get some kind of reimbursement since they would not fix the module even though it was covered until June 30, 2025 (3 weeks ago). Ford says that there is nothing they can do since the date of June 30, 2025 has passed. I feel that this is FRAUDULENT BEHAVIOR as my son had to buy a newer vehicle to go to work. Thank you for all you do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675431July 22, 2025
POWER TRAIN
I am writing you today because my ford focus with transmission DPS6,7SPDCT has all the same problems the older models have. Ford has stopped there 10 year 150000 mile warranty on there transmission on all models built after November 5 2015. Mine is January 1 2016 with all same transmission components. And all my warranty is ran out and still having transmission problems.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674945July 21, 2025
POWER TRAIN
I recently purchased this car from a private seller. Within weeks, the vehicle began exhibiting serious transmission issues — including sudden loss of power, inability to shift correctly, and entering “limp mode”, which severely restricts speed and performance. I had the codes scanned and received P090C and P090C-00, which point to a transmission control module (TCM) or clutch actuator circuit failure — an issue widely known in these vehicles with the DPS6 PowerShift transmission. Ford previously issued a Customer Satisfaction Program (CSP 14M01) for this exact TCM failure, but they have since ended the program (as of June 30, 2025), and they are refusing to cover the repair — even though my vehicle is within the affected model year range and has not yet had the TCM replaced. The car has already had the clutch replaced, but the shifting problems and check engine light returned, putting me at risk while driving. This is a known, recurring safety issue, and the manufacturer is not standing behind its repair despite the car being part of a program that previously acknowledged this defect. I’m filing this complaint to urge the NHTSA to reopen its investigation or require Ford to reinstate support for affected owners
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675153July 21, 2025
ENGINE
The contact owns a 2015 Ford Focus. The contact stated that while attempting to start the vehicle, the instrument panel illuminated; however, the vehicle failed to start. The contact stated that several unknown warning lights were illuminated. The vehicle was towed to a local dealer and the contact was waiting the diagnostic report. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674457July 18, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Focus. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was not made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674459July 18, 2025
POWER TRAIN
The contact owns a 2015 Ford Focus. The contact stated that while driving from a complete stop, the vehicle experienced transmission shifts. The vehicle was taken to the dealer, where an unknown sensor was replaced; however, the failure recurred. The vehicle was taken back to the dealer, where the contact was informed that the sensor needed time to reset. The contact stated that the failure progressively worsened. The contact stated that the vehicle failed to reverse, experienced hard transmission shifts, and felt as if the vehicle would stall while driving. The vehicle was taken to the dealer, where it was determined that the failure was related to Ford Campaign Number: 14M02 (Transmission control module extended warranty coverage); however, the contact was informed that the Customer Satisfaction Program had expired a week prior to the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 88,300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674595July 18, 2025
POWER TRAIN
The contact owns a 2018 Ford Focus. The contact stated while driving at various speeds, the vehicle jerked abnormally. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a local dealer, where the fuel line was replaced. The contact stated that the vehicle was repaired; however, the failure reoccurred. The vehicle was towed back to the local dealer where it was diagnosed with clutch failure. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 90,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674338July 17, 2025
ENGINE
The contact owns a 2016 Ford Focus. The contact stated that while accelerating from a complete stop or while driving at various speeds, the vehicle jerked, hesitated, experienced difficulty shifting into gears and stalled. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the transmission clutch actuator had failed and needed to be replaced. The vehicle was not repaired. The contact stated that the part was previously replaced under Ford Customer Satisfaction Program Number: 19N08. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Focus