Ford F-550 Complaints (2004)

49 consumer complaints on file.

#10825172February 9, 2016
ELECTRICAL SYSTEM:WIRING
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED; HOWEVER, THE FAILURE RECURRED APPROXIMATELY ONE MILE LATER. THE VEHICLE DID NOT RESTART AND WAS TOWED TO THE CONTACT'S JOB. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS WAS FAULTY, MELTED, AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 155,862.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10781529October 13, 2015
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 FORD F-550 SUPER DUTY. WHILE THE LINK WAS IN THE AIR WITH A WORKER LOCATED IN THE BUCKET, THE LINK FRACTURED WITHOUT WARNING. THE WORKER'S BUCKET CAME DOWN WITH FORCE CAUSING INJURY TO HIS HEAD, BACK, AND PELVIC AREA. THE WORKER RECEIVED MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED. THE CONTACT STATED THAT THE VIN WAS INCLUDED IN AN EQUIPMENT MANUFACTURER RECALL FOR A LINK FAILURE, BUT THE CONTACT DID NOT RECEIVE A NOTIFICATION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND RECALL NUMBER WERE NOT AVAILABLE.
Crash:
Yes
Fire:
No
Injuries:
4
Deaths:
0
#10499917February 25, 2013
ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL
THE TRUCK IN QUESTION IS A 2004 FORD F-550 DIESEL. UPON DEPRESSING GAS PEDAL, TRUCK STALLED AND NO LONGER WORKED PROPERLY. TRUCK WAS TOWED TO LOCAL FORD DEALER WHERE IT WAS DETERMINED THAT THE FUEL TANK WAS SUFFERING FROM RUST INSIDE THE TANK. BASED ON THE WORK DONE, RUST PARTICLES THAT FORMED INSIDE THE TANK WERE FORCED THROUGH THE FUEL PUMP AND FILTER DAMAGING BOTH AND CAUSING AN ISSUE WITH THE FUEL INJECTORS. I CALLED FORD DIRECTLY TO ASK ABOUT ANY RECALLS FOR THIS ISSUE AND THEY TOLD ME THERE WAS NO RECALL CURRENTLY FOR THIS PROBLEM. THEY SAID THE TRUCK WAS OUT OF WARRANTY AND THERE WAS NOTHING THEY COULD DO ABOUT THE $3000 BILL FROM THEIR INDEPENDENT DEALER. I FIND IT HARD TO BELIEVE THAT A TRUCK THAT IS NOT USED FOR PLOWING AND ONLY HAS 36,000 MILES WOULD SUFFER SUCH A CATASTROPHIC FAILURE. THE REPLACEMENT TANK WAS MADE OF SOME TYPE OF PLASTIC NOT THE OEM METAL TANK THAT WAS ORIGINALLY USED ON THE TRUCK WHICH MADE ME QUESTION THE DEALER. THEY SAID THEY HAD SEEN THIS HAPPEN ON TANKS OF THIS MODEL QUITE OFTEN SO THEY REPLACED THEM WITH A PVC MODEL. UPON FURTHER DISCUSSIONS THROUGH BLOGS AND OTHER ONLINE RESOURCES I WAS ABLE TO FIND A FEW OWNERS OF THE SAME TRUCKS THAT HAD SIMILAR PROBLEMS. THESE DISCUSSIONS PROMPTED ME TO FILE THIS CLAIM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10470140August 10, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 45 MPH THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN STATED THAT THE TURBO CHARGER WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER A SECOND TIME WHERE THE FUEL PUMP WAS REPLACED BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE LAMINATION OF THE FUEL TANK WAS PEELING AND ENTERING THE FUEL SYSTEM AND THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10466085July 12, 2012
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
2004 F550 DIESEL. CONSUMER STATES VEHICLE HAS A FAULTY HEAD-GASKET *TGW THE CONSUMER STATED THE TRUCK WOULD ONLY RUN FOR 20 MINUTES BEFORE IT OVERHEATED. THE CONSUMER WAS INFORMED IT COST CLOSE TO 10,000 TO FIX THE TRUCK. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460223June 1, 2012
ENGINE
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT PRIOR WARNING. THE VEHICLE FAILED TO RESTART AND IT WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THE FAILURE WAS CONTRIBUTED TO THE HIGH PRESSURE OIL PUMP. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 8/8/12 *CN UPDATED 08/15/2012 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454492April 9, 2012
FUEL SYSTEM, GASOLINE
TL-THE CONTACT OWNS 2004 FORD F550 SUPER DUTY. THE CONTACT STATED THAT THE FUEL TANK LINING FAILED AND WAS REPLACED TWICE. THE FAILURE WAS NOT CORRECTED HOWEVER AND THE FUEL TANK LINING REPEATEDLY FAILED, CONTAMINATING THE FUEL SYSTEM UPON EACH RECURRENCE. THE FAILURE WAS NOT REPAIRED. THE MANUFACTURE ADVISED THE CONTACT THAT THE FUEL LINING FAILURE WAS NOT A MANUFACTURING DEFECT. THE FAILURE MILEAGE WAS 47,000 AND THE CURRENT MILEAGE WAS 117,000. KMJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10454588April 9, 2012
FUEL SYSTEM, GASOLINE
2004 F550 TRUCKS HAVE THE INSIDE GAS TANKS PAIN OR LINEN, PEELING OR DELAMINATING. THIS CAUSE THE MOTOR TO STALL. BECAUSE ALL THE LITTLE PIECES OF PAINT GOING TO THE INJECTORS.FOR 3 YEARS (2009-2010 AND 2011) IN A ROW, WE NEED TO FIX THE PROBLEM OURSELVES COSTING US $3,500 EVERY TIME -THIS YEAR IS THE SAME PROBLEM. LAST YEAR I CALL FORD MOTOR CO, AND THEY TOLD ME THAT WERE NOT ENOUGH COMPLAINTS TO MAKE A RECALL. BUT IF YOU CHECK GOGGLE.COM AND GO TO 2004 F550 COMPLAINT'S PAGE YOU WILL SEE HUNDREDS AND HUNDREDS OF COMPLAINTS. WE BOUGHT THE TRUCK ON DEC 2004 AND PAID FOR IT $56,000- DOLLARS, WAS NOT A CHEAP TRUCK. ALSO, I WERE TALKING TO A LOT OF F550'S OWNERS ( MOST OF THEM LANDSCAPERS)AND THEY HAD OR HAVE THE SAME PROBLEM. SO..........FORD CO IS WASHING THE HANDS, AND NOT DOING A RECALL ON THIS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10442595January 5, 2012
FUEL SYSTEM, DIESEL
VEHICLE (2004 DIESEL F550 TRUCK) WAS TRAVELING ON I-405 DURING RUSH HOUR TRAFFIC WHEN THE VEHICLE STALLED. DEALER SAYS THAT THE PAINT/LAMINATE INSIDE THE FUEL TANK IS CORRODING AND PIECES OF DEBRIS ARE BEING FED INTO THE FUEL SYSTEM CAUSING SUDDEN STALLING OF VEHICLE. NO OFF-ROAD DIESEL HAS EVER BEEN USED IN THE TANKS--STANDARD DIESEL FUEL ONLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10420003August 18, 2011
ENGINE AND ENGINE COOLING:ENGINE:DIESEL
TL* THE CONTACT OWNS A 2004 F-550 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED STEAM COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIANS ADVISED THAT THE TURBO HAD OVER BOOSTED AND CAUSED THE ENGINE TO FAIL. THE ENGINE WAS REPLACED AND AFTER THE REPAIRS, THE CONTACT NOTICED WHITE SMOKE FROM THE EXHAUST PIPE AND AN ANTI-FREEZE SMELL EMITTING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE INNER COOLER HAD TO BE REPLACED AND THE HEAD GASKET EXHIBITED A LEAK. THE INNER COOLER WAS REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 6,500. UPDATED 10/05/11
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10419489August 15, 2011
POWER TRAIN:MANUAL TRANSMISSION
PROBLEM 1: IN 2004 I PURCHASED A NEW FORD F-550 WITH THE GASOLINE V10. ABOUT ONE MONTH AFTER OWNING THE TRUCK THE THROUGH-OUT BEARING ON THE CLUTCH STARTED MAKING NOISE AND HAS DONE SO. THIS YEAR WITH ONLY 49,000 MILES ON THE TRUCK NOW IT DOES NOT WANT TO GO INTO GEAR SOMETIMES.BY THE TIME I CONTACTED MY DEALER HE SAID THAT THE TRUCK WAS OFF WARRANTY. DID THEY SELL CHEAP BEARINGS IN THESE TRUCKS, BECAUSE MY LAST F350 I HAD FOR 14 YEARS WITHOUT ANY PROBLEMS. PROBLEM 2: EVER SINCE I HAVE OWNED THIS TRUCK. WHEN YOU ARE SITTING AT A LIGHT AND GET READY TO GO. ALL OF A SUDDEN THE ENGINE SHUTS DOWN FOR ABOUT 2 SECONDS AND THEN GOES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10417113August 4, 2011
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 FORD F-550. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER DIAGNOSED THAT THE FUEL INJECTOR WIRE WAS MELTING ON THE ENGINE. THE VEHICLE WAS REPAIRED AND RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 116,000 AND THE CURRENT MILEAGE WAS 121,164.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10405893June 10, 2011
FUEL SYSTEM, DIESEL
TL*THE CONTACT OWNS A 1997 FORD F-550 SUPER DUTY. THE CONTACT STATED THE VEHICLE WOULD STALL WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THE VEHICLE WAS STALLING DUE TO DELAMINATION OF THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 144,250.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374870January 5, 2011
POWER TRAIN:AUTOMATIC TRANSMISSION, FUEL SYSTEM, DIESEL, ENGINE AND ENGINE COOLING:COOLING SYSTEM, POWER TRAIN:DRIVELINE
04 FORD F550 SD DUMP TRUCK WAS BOUGHT NEW ON 12/04.. IN APRIL 2005 TRANSMISSION LEAKED FLUID WHILE IN PARK AND TRUCK WAS TOWED TO DEALER. THE DEALER CLAIMED CAUSE OF PROBLEM WAS DUE TO LOOSE BOLTS ON TRANS CASE. TRANSMISSION CONTINUED TO SLIP BUT DEALER COULD NOT FIND PROBLEM. FEBRUARY 2006, APPROXIMATELY 16,000 MILES ON TRUCK, TRANSMISSION COMPLETELY FAILS. TRUCK TOWED TO DEALERSHIP AND NEW TRANSMISSION INSTALLED. ON JUNE 2008 (APPROXIMATELY 56,000 MILES) WHILE DRIVING ON MAJOR HIGHWAY, TRUCK BEGINS TO LOSE POWER AND BLACK SMOKE POURS OUT OF MUFFLER. THE TRUCK WAS DRIVEN TO LOCAL DEALERSHIP AND DIAGNOSED WITH A BLOWN TURBO. FORD DID NOT COVER COST OF REPAIR. I PAID $4,500.00 OUT OF POCKET TO REPLACE TURBO. AUGUST 2009 (APPROXIMATELY 68,000 MILES) AGAIN WHILE DRIVING ON MAJOR HIGHWAY, TRUCK LOSES POWER AND STALLS. TRUCK WAS TOWED TO FORD DEALERSHIP AND DIAGNOSED WITH CLOGGED INJECTORS DUE TO DETERIORATING GAS TANK. DEALER ADVISED ME THAT ALL 8 INJECTORS WOULD HAVE TO BE REPLACED AND NEW FUEL PUMP INSTALLED. THE TOTAL COST OF REPAIRS WOULD BE $4,300.00 AND IT WOULD NOT BE COVERED BY FORD. I WAS INCENSED TO SAY THE LEAST...AFTER GETTING A SECOND OPINION, I PAID AN ADDITIONAL $475.00 AND HAD THE TRUCK TOWED TO ANOTHER FORD DEALERSHIP WHICH MADE THE REPAIRS WITHOUT ANY COST TO ME. THE FUEL TANK WAS NOT REPLACED EVEN THOUGH IT WAS THE CAUSE OF THE PROBLEM. I REPLACED THE TANK AND PAID $750.00 OUT OF POCKET...DECEMBER 27, 2010 (96,000 MILES) WITHOUT WARNING, TRANSMISSION BEGINS TO SLIP. I CONTACTED THE FORD DEALERSHIP THAT MADE THE LAST REPAIRS. I WAS TOLD THE TRANSMISSION WAS OUT OF WARRANTY AND WOULD NOT BE COVERED BY FORD. IT WOULD COST $4,200.00 TO REPLACE. I TOOK TRUCK TO A LOCAL TRANSMISSION REPAIR SHOP AND PAID $3,000.00 TO REBUILD TRANSMISSION. ITS OBVIOUS THAT FORD DOES NOT BACK UP THEIR PRODUCT. I WILL NEVER BUY ANOTHER FORD AGAIN!!!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10374731January 5, 2011
FUEL SYSTEM, DIESEL
SUDDEN POWER LOSS TRAVELING AT HIGHWAY SPEEDS RESULTING IN ENGINE SHUTTING DOWN AND NOT BEING ABLE TO BE RESTARTED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10353775September 3, 2010
FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY
TL*THE CONTACT OWNS A 2004 FORD F-550 SUPERDUTY. WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE STALLED. IT WAS TOWED TO ANOTHER LOCATION WHERE THE DRIVER WAS ABLE TO GET IT RESTARTED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE DRIVER WAS INFORMED THE FUEL TANK WAS DE-LAMINATING DUE TO RUST AND CORROSION. IT WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 80,978.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10347608August 6, 2010
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2004 FORD F-550 SD. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY LOSE POWER WHEN DRIVING AT VARIOUS SPEEDS. ON ONE OCCASION THAT THE FAILURE OCCURRED, THE CONTACT SHUT OFF THE ENGINE AND WHEN RESTARTING, HE WAS ABLE TO DRIVE A VERY SHORT DISTANCE BEFORE THE FAILURE RECURRED. THE VEHICLE WOULD NOT ACCELERATE PAST 5 MPH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FUEL PUMP, FILTERS, FUEL TANK AND EIGHT FUEL INJECTORS WOULD NEED TO BE REPLACED BECAUSE THE FUEL TANK WAS RUSTED. THE MANUFACTURER ADVISED THE FAILURE OCCURRED BECAUSE THE CONTACT FAILED TO KEEP THE FUEL TANK FULL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 27,120 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10329666May 10, 2010
FUEL SYSTEM, DIESEL
WE OWN A FLEET OF FORD DIESEL ENGINE TRUCKS WHICH CONTINUE TO EXPERIENCE FUEL DELIVERY PROBLEMS. THE PROBLEM IS ENGINE CUT-OFF AND SURGING AND HARD STARTING. FORD SAYS NOT THEIR PROBLEM AND CHARGES US. I DON'T THINK WE HAVE THE ONLY ONES. TOYOTA IS NOT THE ONLY COMPANY NOT DEALING WITH THIS PROBLEM. THINK ONLY THE GOVERNMENT WILL MAKE THEM FIX IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10328229April 30, 2010
FUEL SYSTEM, DIESEL, ELECTRICAL SYSTEM:WIRING
WE PURCHASED A FORD F550 6.0L DIESEL TRUCK NEW IN 2004 AND HAVE BEEN THE ONLY ONES TO DRIVE IT AND HAVE DONE PROPER CARE AND MAINTENANCE OF THIS VEHICLE. IT HAS LESS THAN 40,000 MILES ON IT. THE VEHICLE WOULD NOT START FOR NO REASON ON APRIL 29, 2010 NECESSITATING IT BEING TOWED TO THE LOCAL FORD DEALERSHIP. THEY DIAGNOSED A BAD FICM (FUEL INJECTION CONTROL MODULE) AND REPLACED IT. I HAVE FOUND THERE WAS A RECALL ON THIS VEHICLE FOR THIS PROBLEM, CAMPAIGN NUMBER 05V270000 ON 6/10/05. DUE TO THE LOW MILES AND PROPER CARE OF THIS VEHICLE I AM WONDERING IF THIS PROBLEM IS RELATED TO THAT RECALL. WE USE THIS IN OUR WORK AND HAD THE FICM GONE OUT WHILE WE WERE DRIVING IT WITH A LOAD OF CHIPS IT COULD HAVE POTENTIALLY BEEN EXTREMELY HAZARDOUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10327739April 27, 2010
FUEL SYSTEM, DIESEL
FUEL INJECTOR PROBLEMS 3 TIMES, VEHICLE BROKE DOWN,FUEL TANK PROBLEMS, VEHICLE WILL STALL OR START RUNNING SO BADLY THAT U COULDN'T GO, AND OTHER VEHICLES WOULD ALMOST HIT MY VEHICLE, COULD NEVER TELL WHEN IT WAS GOING TO HAPPEN DEFECTIVE FUEL TANK....? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-550