Ford F-550 Complaints

561 consumer complaints on file.

#11083152April 3, 2018
ENGINE
TL* THE CONTACT OWNS A 2012 FORD F-550. WHILE DRIVING ON AN INCLINE AT 60 MPH, THE ENGINE POWER LOSS INDICATOR ILLUMINATED. SUDDENLY, THE CONTACT HEARD A LOUD POP SOUND AND THE ENGINE STALLED AND LOST POWER. THE VEHICLE WAS TOWED TO WORTHINGTON FORD (2950 N BELLFLOWER BLVD, LONG BEACH, CA 90815, (562) 420-3333) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11076629March 7, 2018
ENGINE
TL* THE CONTACT OWNS A 2008 FORD F-550 SD. WHILE DRIVING 65 MPH, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT AND THE VEHICLE STALLED. THE CHECK ENGINE AND ENGINE OVERHEATING INDICATORS ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS TOWED TO CHAPMAN FORD OF HORSHAM (1100 EASTON RD, HORSHAM, PA 19044) WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE FAILURE MILEAGE WAS 33,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11074813February 26, 2018
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
2007 FORD F-550. CONSUMER WRITES IN REGARDS TO BATTERY CONTROL CENTER SAFETY RECALL. *LD *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11073798February 20, 2018
POWER TRAIN, SUSPENSION
TL* THE CONTACT OWNS A 2017 FORD F-550 SD. WHILE DRIVING 65 MPH, THE REAR PASSENGER SIDE OF THE VEHICLE BEGAN TO SHAKE, FISHTAIL, AND AN ECHOING NOISE WAS HEARD FROM THE REAR END. THE VEHICLE WAS TAKEN TO PASO ROBLES FORD (2401 OAKWOOD ST, PASO ROBLES, CA 93446), BUT THE FAILURE COULD NOT BE DIAGNOSED. THE VEHICLE WAS THEN TAKEN TO ANOTHER DEALER (MULLAHEY FORD, 330 TRAFFIC WAY, ARROYO GRANDE, CA 93420) WHERE IT WAS DIAGNOSED THAT THE BEARINGS FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND COULD NOT PROVIDE A SOLUTION. THE FAILURE MILEAGE WAS 400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11073606February 19, 2018
SERVICE BRAKES, STEERING, UNKNOWN OR OTHER
FROM THE DAY I TOOK IT OFF THE LOT TRUCK PULLS LEFT AND RIGHT BRAKES SQUEAK VIBRATION STARTS AT 55MPH FILLS LIKE REAR ENDED IS LOSS TRUCK SWERVES . I WAS DRIVING DOWN FREEWAY WHEN REAR SLIDING WINDOW BLEW OUT FROM INSIDE OF CAB OUT SOUNDING LIKE A GUN SHOT OR TIRE BLEW UP INSIDE THE CAB AND BLEW GLASS ALL OVER MY 4 YEAR OLD IN BACK SEAT . I HAVE HAD THIS TRUCK INTO FORD FOR A NUMBER OF THINGS BUT WON'T FIX VIBRATION OR THE WAY TRUCK DRIVES DOWN THE ROAD
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11064394January 23, 2018
FUEL/PROPULSION SYSTEM
FUEL TANK IS RUSTING. I UNDERSTAND FORD HAD A RECALL FOR THIS, BUT MY VIN DOES NOT SHOW ONE. MY VEHICLE ONLY HAS 48,000 MILES AND I AM HAVING TO REPLACE MY FUEL FILTER EVERY 1000 MILES!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11061627January 10, 2018
ENGINE, FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2003 FORD F-550 SD. WHILE DRIVING UNKNOWN SPEEDS, THE ENGINE STALLED WITHOUT WARNING AND THE FUEL TANK DISINTEGRATED. THE FLOAT FILTER AND FILTER WERE CLOGGED. THE CONTACT CALLED A LOCAL DEALER (VISION FORD, 1500 S WHITE SANDS BLVD, ALAMOGORDO, NM 88310) AND WAS ADVISED TO SCHEDULE A SERVICE APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 107,550.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10993685June 7, 2017
ENGINE
ENGINE SHUTTING OFF & WILL NOT RE-START AFTER. WILL RESTART AFTER IT SITS FOR A COUPLE HOURS. HAS BEEN INTO TUTTLECLICK FORD SEVERAL TIMES FOR REPAIR OF THIS ISSUE. STILL NOT FIXED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10978998April 18, 2017
SEAT BELTS
SEAT BELT WILL NOT STAY LATCHED WHILE DRIVING VEHICLE. APPEARS TO BE LATCHED BUT WHEN VEHICLE ENGAGES THE SLIGHTEST BUMP ON THE ROAD THE BUCKLE RELEASES. I KNOW THIS WILL NOT HOLD IN THE EVENT OF A CRASH. RECALL WAS PERFORMED IN 2002, WHICH WAS JUST AN INSPECTION AT THAT TIME BUT REPLACEMENT WAS NOT PERFORMED AT THAT TIME.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10966637March 18, 2017
ELECTRICAL SYSTEM, ENGINE, FUEL/PROPULSION SYSTEM
DIESEL EXHAUST FLUID SYSTEM FAILED SHUTTING DOWN MY VEHICLE WHILE DRIVING AND I HAD TO BE TOWED TO A FORD DEALER. THIS IS A SAFETY ISSUE AND COULD HAVE CAUSED A MAJOR ACCIDENT ON THE HIGHWAY. I NEVER GOT A RECALL NOTICE ABOUT THIS MAJOR PROBLEM. NOW I AM TOLD I WOULD HAVE TO SPEND OVER $5000.00 TO GET THIS PROBLEM FIXED. FORD HAD GOTTEN MANY COMPLAINTS ABOUT THIS ISSUE. THEY SHOULD PAY TO HAVE THIS REPAIR DONE. I ONLY HAD THIS VEHICLE FOR A SHORT TIME AND PAID OVER $59,000 FOR IT. I TRIED TO CONTACT SEVERAL FORD EXECUTIVES OVER TWO WEEKS AGO AND HEARD BACK FROM NONE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10946265January 18, 2017
ENGINE, FUEL/PROPULSION SYSTEM
WATTER SEPERATOR VALVE DUMPED FUEL ON THE TURBO CAUSING A FIRE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10934412December 10, 2016
STRUCTURE:BODY, SUSPENSION, WHEELS
THE VEHICLE IS A MOTOR HOME MANUFACTURED BY THOR MOTOR COACH THAT THEY ADDED TO A MODIFIED 2015 FORD F550 CHASSIS. ALTHOUGH THOR MODIFIED THE CHASSIS, REPLACED THE FRONT BUMPER AND QUARTER PANELS AND ADDED THE COACH BODY TO THE FRAME, THEY FAILED TO DO ANY ALIGNMENT PROCESS TO MAKE SURE THAT THE BODY AND THE FRONT WHEELS WERE PROPERLY ALIGNED. THIS FAILURE HAS LED TO SEVERE WEAR TO THE FRONT RIGHT TIRE CREATING A MAJOR SAFETY HAZARD. ON PAGE 121 OF THE OWNER'S MANUAL IT STATES THAT THE FRONT SUSPENSION AND STEERING SYSTEM WAS FACTORY ALIGNED PRIOR TO DELIVERY TO THE DEALERSHIP. HOWEVER, THE HAVE FAILED TO SUPPLY ANY DOCUMENTATION REGARDING THIS AND THE ANTIDOTAL INFORMATION FROM FORD AND OTHERS IS THAT THOR DOES NOT DO THE NEEDED ALIGNMENT AFTER SUCH A SEVERE MODIFICATION. WHILE THEY TRY TO PASS THIS OFF TO THE CONSUMER, THERE IS ONLY ONE SENTENCE REGARDING THIS IN A 151 PAGE MANUAL. ALTHOUGH I HAVE OWNED OTHER MOTOR HOMES PREVIOUSLY THE PROCESS OF LEARNING EVERYTHING ABOUT A NEW MOTOR HOME IS QUITE OVERWHELMING. SECONDLY I AM NOT AWARE THAT VEHICLE MANUFACTURE PASSES THIS SAFETY CONCERN ON A NEW VEHICLE TO THE CONSUMER. LASTLY MOTOR HOMES ARE THE LARGEST, HEAVY VEHICLES WITH CHALLENGING HANDLING CHARACTERISTICS DRIVEN BY NON-PROFESSIONAL DRIVERS, MANY OF WHOM ARE SENIORS. THE MANUFACTURES SHOULD BE HELD RESPONSIBLE FOR MAKING SURE THAT THE VEHICLES ARE PROPERLY ALIGNED FOR SAFE OPERATION AND TIRE WEAR. THE FAILURE TO PROPERLY ALIGN THE VEHICLE AS A FINAL MANUFACTURING PROCESS HAS LEAD TO SEVERE TIRE WEAR CAUSING A MAJOR SAFETY ISSUE AND SIGNIFICANT EXPENSE FOR THE OWNER TO REPLACE THE FRONT TIRES AND HAVE THE PROPER ALIGNMENT DONE IN ORDER TO MAKE FOR SAFE OPERATION. ALTHOUGH THE VEHICLE WAS NEW WHEN PURCHASED IT HAD 2,598 MILES ON IT. THE DAMAGED TIRE WAS NOTED AFTER A CROSS COUNTRY TRIP OF NEARLY 10,000 MILES.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10923835November 2, 2016
ENGINE
TL* THE CONTACT OWNS A 2012 FORD F-550. WHILE DRIVING 65 MPH WITH THE EXHAUST CLEANING CYCLE OPERATED, THE CYCLE SUDDENLY STOPPED. THE VEHICLE LOST POWER, STALLED, AND THE CHECK OIL WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON TWO SEPARATE OCCASIONS. THE VEHICLE WAS TOWED TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 36,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10915481October 12, 2016
ENGINE
TL* THE CONTACT OWNS A 2007 FORD F-550 SD. THE CONTACT STATED THE VEHICLE WAS LEAKING COMPRESSION FROM THE CYLINDERS INTO THE COOLANT SYSTEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A MALFUNCTIONED HEAD GASKET. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10904734September 8, 2016
ENGINE
TL* THE CONTACT OWNS A 2015 FORD F-550 SD. WHILE DRIVING 60 MPH, THE VEHICLE LOST COMPRESSION TO THE ENGINE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE FAST ENOUGH TO ENTER THE HIGHWAY. IN ADDITION, THE CHECK ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 4,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10897158August 19, 2016
ENGINE
VEHICLE SHUT DOWN COMPLETELY DURING NORMAL HIGHWAY DRIVING AT APPROXIMATELY 65 MPH. LOST ENGINE POWER AND ALL INTERIOR POWER, INCLUDING IGNITION POWER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10882923July 6, 2016
ENGINE
TL* THE CONTACT OWNS A 2015 FORD F-550 SD. WHILE DRIVING APPROXIMATELY 30 MPH IN REVERSE, THE VEHICLE STALLED. THE VEHICLE HAD TO BE PUSHED INTO THE CONTACT'S DRIVEWAY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES, BUT THE FAILURE COULD NOT BE DUPLICATED. THE FAILURE ALSO OCCURRED WHILE IN DRIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10881909June 30, 2016
FUEL/PROPULSION SYSTEM
FORD HAS INSTALLED SIX FUEL TANKS IN THIS TRUCK. ALL HAVE CRACKED DUE DO FAULTY FACTORY INSTALLATION. I HAVE SEVERAL PHOTO'S IF YOU WANT THEM. FORD KNOWS THEY HAVE A PROBLEM BUT WON'T FIX IT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10881404June 29, 2016
ENGINE
SPARK PLUG SPIT OUT, A KNOWN FORD PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10872221June 2, 2016
ENGINE, FUEL/PROPULSION SYSTEM
WHILE DRIVING THE VEHICLE ON THE EXPRESSWAY IN MICHIGAN, IT SUDDENLY BEGAN LOSING POWER. AFTER FREQUENTLY STOPPING AND RESTARTING THE ENGINE, THE TRUCK STOPPED COMPLETELY. WHEN THE DEALERSHIP INVESTIGATED THE CAUSE, THEY FOUND SPECKS OF PAINT IN THE DIESEL FUEL. WHEN THE FACTORY INSTALLED GAS TANK WAS DROPPED, IT WAS DISCOVERED THAT THE COATING INSIDE THE FUEL TANK WAS FLAKING OFF AND HAD PLUGGED THE FUEL FILTERS, CONTAMINATED THE FUEL AS WELL AS DAMAGING 3 INVERTERS.. WHEN INVESTIGATING IF OTHERS HAVE SAME COMPLAINT, WE FOUND MANY OTHERS HAVE HAD THE SAME PROBLEM. LUCKILY WE WERE NOT PULLING OUR RV.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-550