Ford · Model Report
Showing safety data for the 1992 model year only.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE REVERSING, THE VEHICLE LOST POWER. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 444,980. UPDATED 5/18/15*CN THE REPAIR SHOP REPLACED THE FUEL VAPOR CANISTER. ALSO, THE VEHICLE WOULD NOT GO IN REVERSE. UPDATED 06/02/15*JB
MY CAR CAUGHT FIRE AT PARKING LOT WHEN I TRIED STARTING IT UP AFTER MY GIRLS AND I GOT BACK IN CAR AFTER BEING AT MALL FOR ABOUT 2 HOURS FLAMES COMING OUT FROM BOTTOM AND TOP OF ENGINE AND FRONT DASH. THANK GOD WE GOT OUT IN TIME. MY CARS ELECTRICAL WIRES FOR EVERYTHING IS MELTED AND IM UNSURE HOW MUCH MORE IS DAMAGED SINCE IM NOT A MECHANIC. *TR
DRIVER'S SIDE SEAT BELT LATCH (FEMALE PIECE) DISENGAGED WHILE DRIVING. LATCH WILL NO LONGER STAY ENGAGED WITH THE MALE PART OF THE SEAT BELT IN A RELIABLE MANNER. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. THE CONTACT STATED THAT HE ATTEMPTED TO STOP THE VEHICLE, BUT THE VEHICLE CONTINUED TO ACCELERATE. THE CONTACT SLAMMED THE GEAR INTO PARK AND TURNED THE ENGINE OFF. UPON RESTART, THE VEHICLE FUNCTIONED AS NORMAL. THE CONTACT STATED THAT HE INSPECTED THE VEHICLE AND NOTICED THAT THERE WAS A PIECE OF PLASTIC IN THE HOSE THAT RAN FROM AIR FILTER TO THE AIR INTAKE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 102,000. UPDATED 08/28/12*LJ THE CONSUMER STATED THAT IT IS ALSO IMPORTANT TO NOTE THAT THE RUBBER RING UNDER THE C-CLAMP- THAT THE PLASTIC HOSE IS ATTACHED TO THE AIR-INTAKE WITH WAS THE REASON FOR THE MALFUNCTION. THE RUBBER CORRODED TO THE POINT THAT A PIECE OF IT BROKE OFF AND WAS SUCKED INTO THE ENGINE. THE ENTIRE HOSE HAD TO BE REPLACED BECAUSE THAT PART ISN'T SOLD SEPARATELY. UPDATED 09/05/2012 *JS
No injuries · No fire · No crash
I WAS TRAVELING DOWN HIGHWAY AND THE SPARE TIRE CABLE BROKE AND THE WHEEL FELL OUT AND GOT JAMMED UNDER THE EXPLORER. LUCKILY I SOME HOW WAS ABLE TO GET PULLED OVER BEFORE THEIR WAS AN ACCIDENT. AFTER THAT HAD HAPPEN I FOUND OUT THAT THEY HAD A RECALL ON THE CABLES DUE TO THEM BREAKING. *TR
No injuries · No fire · No crash