Ford Explorer Complaints

917 consumer complaints on file.

#11652584April 3, 2025
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652208April 2, 2025
ELECTRICAL SYSTEM, VISIBILITY/WIPER
Sun shade sagging. Causing loss of visibility.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651784March 31, 2025
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact stated while driving at an undisclosed speed, the transmission unexpectedly downshifted. There was no warning light illuminated. The vehicle was able to restart. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11651261March 28, 2025
POWER TRAIN
The contact owns a 2021 Ford Explorer. The contact received notification of NHTSA Campaign Number: 23V675000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 27,000. Parts distribution disconnect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650709March 26, 2025
POWER TRAIN
The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed through a drive-thru, the Auto Hold feature was activated, but the vehicle failed to respond. No warning light was illuminated. The contact opened the front driver's side door, causing the transmission to inadvertently shift to park (P), and the vehicle turned off. The vehicle failed to restart until a tow truck driver had disconnected and reconnected the battery. The vehicle was taken to the dealer, who updated the software for the SYNC module (APIM), gear shift module, powertrain control module (PCM), and Anti-Lock Brake System (ABS) module, as well as an oil change. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 8,967.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650614March 25, 2025
POWER TRAIN, SUSPENSION
the rear axle bolt fractured while driving causing damage to the differential, axles, and mounting bushing. the problem has been confirmed by Baytown Ford Dealership service dept. located at 4110 I-10, Baytown, TX 77521. it has been inspected by the Service Dept at Baytown Ford. located at 4110 I-10, Baytown, TX 77521 no prior symptoms or warnings.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650569March 25, 2025
POWER TRAIN
The contact owns a 2022 Ford Explorer. The contact stated that while attempting to shift into reverse, the vehicle moved forward approximately 2 - 3 feet before reversing as intended. There were no warning lights illuminated. The dealer was contacted and confirmed that the VIN was not included in NHTSA Campaign Number: 25V164000 (Power Train). The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The manufacturer opened a case regarding the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650531March 25, 2025
ENGINE
We were driving the vehicle when we experienced a sudden loss of power and acceleration. We also noticed odors of gas. We took it to a Ford authorized dealership and they said it was due to antifreeze in the oil from what they said was a leaking water pump. They recommended a new engine due to the difficulty of changing the internal water pump and the fact it leaked antifreeze into the engine oil, possibly damaging the engine itself. This was the explanation for the fault codes, random gas odors, and loss of power. It was explained this was normal when the sensors detect something wrong with the oil in the engine. Estimated cost provided by the dealership was $11,000 to replace the engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650265March 24, 2025
UNKNOWN OR OTHER
When vehicle is in reverse, the car still moves forward. Dealership said there is no fix. I was almost hit the other day because I couldn’t reverse quick enough.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11650216March 24, 2025
UNKNOWN OR OTHER
Car has a delay when going into reverse & will move forward while in reverse then jerks into reverse. Also has a delay in going into drive from reverse. Not safe to back out into the road or doing a 3 point turn because of the delays. It happens all the time so the incident happens every day for me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11649774March 21, 2025
ELECTRICAL SYSTEM, ENGINE
The contact owns a 2021 Ford Explorer. The contact stated that while at a stop sign, the vehicle lost automotive power and failed to restart. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was undetermined. The vehicle was not repaired. The contact stated that several unknown warning lights were illuminated. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 74,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648886March 17, 2025
WHEELS, SUSPENSION, STRUCTURE:BODY
Around 20,000 miles, I took my vehicle to the dealer due to rattling and knocking in the front right wheel well and it was discovered the stabilizer arm was cracked. Received the vehicle back, and approximately 1000 miles later, there is rattling at the front driver and passenger wheel well and squeaking going down the road. The sounds coming from vehicle are that of a 40-year-old vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11648382March 14, 2025
POWER TRAIN, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:WHEEL SPEED SENSOR/TONE RING
The contact owns a 2022 Ford Explorer. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that brake pedal was depressed. The vehicle was taken to the dealer where it was diagnosed with a failed valve body. The contact was informed that the valve body needed to be replaced. The vehicle was repaired under warranty. The failure reoccurred. The vehicle was taken to the dealer where it was diagnosed with a failed output speed sensor. The contact was informed that the output speed sensor needed to be replaced and recalibrated. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The manufacturer approved of the buyback; however, the contact stated that the Lemon Law requirement limited the ownership to two years. The failure mileage was approximately 39,793.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647945March 12, 2025
UNKNOWN OR OTHER
Backup camera on the car has a clear picture but does not have a usable field of view. The problem occurred sometime in mid 2024 and was first reported to the dealer in Sep 2024. When in reverse, at 20' behind the vehicle you can see approximately 1' of height. The dealership seems to have no specs against which to compare this and simply reports that since the image is clear, it is the expected image. The camera system was recalled recently, but even with a new physical camera, the vehicle still has this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647596March 11, 2025
AIR BAGS
POLICE VEHICLE WAS CLEARING INTERSECTIO WHEN A UPS TRUCK COLLIDED WITH IT'S RIGHT SIDE FORWARD. THE COLLISION CAUSED THE SIDE AIRBAG TO DEPLOY. THE OFFICER'S VEST, SWEATER, UNDERSHIRT, T-SHIRT AND THE OFFICER'S RIGHT SIDE SUFFERED THERMAL BURNS FROM THE EXHAUST PORT. THE OFFICER SUFFERED 3RD DEGREE BURNS AND HAD TO HAVE SURGERY AND SKIN GRAFT.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11647485March 10, 2025
UNKNOWN OR OTHER
Sunshade cover for sunroof malfunctioned and it hangs down causing a visibility issue as it obstructs the view from the rear view mirror. After doing a search on Reddit and the Ford forum, it seems to be a common issue. My vehicle only has 35,000 miles on it and this should not be happening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647026March 7, 2025
SUSPENSION
The contact owns a 2025 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact heard an abnormal rattling sound coming from underneath the vehicle. A dealer was contacted. The vehicle was then taken to the dealer where it was diagnosed and determined that the front struts needed to be replaced. The front shocks were replaced, and the vehicle was repaired. The contact stated that the front struts had been replaced twice; however, the failure persisted. The manufacturer was not notified of the failure. The approximate failure mileage was 2,289.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11647022March 7, 2025
ENGINE
I had complete engine failure on my 2021 115,000 mi Ford Explorer ST. The truck was only 3 years old. I heard a knocking noise and pulled over. Throughout the summer smoke had been coming out of the exhaust pipe every time I turned on the car before work. There was a cloud of smoke. A week before the engine failure I had the vehicle in the ford shop. They said everything was fine. I towed the vehicle to Currie Ford in Frankfort and they stated that there was catastrophic engine failure. Nothing could be done but I needed to put a new $12,000 engine in a $63,000 car. They said the warranty did not cover nor do I have any recourse. The safety of my family was placed at risk., I was travelling with my family, my wife, son, daughter, nephew who is [XXX] old and niece who is [XXX] . It left us stranded. There were no warnings. The dealership inspected the car a week before and said it was good to go. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11646004March 3, 2025
STRUCTURE:BODY:DOOR, VISIBILITY
The contact owns a 2025 Ford Explorer. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the doors and windows. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed; however, the cause of the failure was unknown. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11645827March 2, 2025
SERVICE BRAKES, UNKNOWN OR OTHER
Put car in park. sUV rolled back & damaged my garage door. Also damaged my trunk of SUV.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Explorer