Ford Expedition Complaints (2024)

71 consumer complaints on file.

#11752634July 24, 2026
STRUCTURE
The contact owns a 2024 Ford Expedition. The contact received notification of NHTSA Campaign Number: 26V368000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11751028July 17, 2026
SEAT BELTS
The contact rented a 2024 Ford Expedition from Enterprise Rent-A-Car. The contact stated that while the vehicle was parked and occupied, the contact was informed by his grandson that the seat belt was not operating properly. The contact inspected the seat belt and became aware that the third-row seat belt rear passenger’s side seat belt buckle assembly was damaged. Neither a dealer nor an independent mechanic was contacted. The vehicle was not taken to a dealer or an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure, and no assistance was provided. The failure mileage was 80,240.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11750993July 17, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Intermittent warning of front camera collision / braking malfunction. Usualy less then 10 seconds but on one occassion persisted for about 10 minutes. Has been to dealership for investigation without resolution. Happened last on 7/16/2026. Arrived at dealership withing 20 minutes, they were able to call up the alert on there service advisors computer but could not do further investigation at the time. Vehicle is again scheduled to go to dealership on 3 August 26. Prolonged alert was 6/2/26, immeadiatly went to dealer (within 3 miles) vehicle into dealer fror a week on 7/6/26 without resolution
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748388July 5, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Forward collision system does not work or alert under any circumstances. Vehicle has forward collision mitigation as well as collision mitigation alerting, but neither systems work. Dealer able to verify these systems do not work, but have no recourse for repair, as Ford engineering has not provided a solution.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11747128June 29, 2026
ENGINE
Incident happened 06/26/2026. My wife was driving with our 4 kids down the highway to family event. My wife smelled a funny odor coming from the vents and was going to drive to the next exit and then noticed smoke. At that moment she wasn’t sure where the smoke was coming from. She put the hazards on and started pulling off to the shoulder thinking possibly it was the radiator. She came to a stop and called me (husband) that something was wrong with the vehicle. She was going to leave the kids in the car, get out and check the radiator. That’s when smoke started coming in through the air vents. She didn’t want the kids to breath in the smoke so they exited the vehicle, that’s when she noticed a fire under the engine. At that point a state trooper arrived on scene. He checked on my wife and kids and brought them back to his patrol car. The trooper went back to the vehicle to grab the baby’s diaper bag and wife’s purse. The trooper tried to extinguish the flames but the front of the vehicle was well involved already. Within 10-15 minute from my wife stopping the whole car was burnt to the ground and nothing left of the car. Looking back my wife only had a couple minutes to get to safety, had they lingered before getting out of the vehicle this could have been a tragic fatality incident. Our children do not feel safe riding in a vehicle since the incident happened. The safety of the trooper on scene was at risk helping get everyone to safety. It seems that something on the engine failed with how quickly the fire started. Vehicle can and should be inspected to find out what happened so this does not happen to another family. The vehicle has not been inspected yet. No warning lights ever came on. There was never any symptoms prior to this incident and the vehicle has been serviced by the dealer prior to and since we purchased the vehicle.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11744309June 15, 2026
UNKNOWN OR OTHER
The spring for the door for the 4-flat trailer plug on vehicle is too powerful. This resulted in the door wearing away at the trailer plug and has resulted in the wires of the trailer light plug breaking. This is available upon request. It puts our safety at risk as our trailer lights can go out and result in less information for other drivers, possibly resulting in a rear-end crash. The problem has not been reproduced, and has not been inspected. The only symptom of the problem in the vehicle is it telling us the trailer was disconnected. The trailer was a 2020 Malone microsport trailer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743165June 10, 2026
STRUCTURE:BODY, ELECTRICAL SYSTEM
Several of automatic sensors were not working (tire pressure) and the horn. The dealer stated I had road damage and wires were torn loose. I'm a 76 year old woman and I do not take this car off road or have any recollection of such an incident. I maintain the underside of the vehicle is improperly protected. They charged me $2300 to fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740097May 26, 2026
UNKNOWN OR OTHER
No accident, malfunction, warning lights, or safety-related issues occurred. Vehicle is operating normally at this time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738433May 17, 2026
SEATS, ELECTRICAL SYSTEM
The third row seats both have reachable access to the third-row PowerFold buttons even in car seats. My two toddlers can easily reach the fold buttons while strapped in to their seats and are able to recline and move their seats forward and backwards. This caused major safety hazard because their car seats become loose. The buttons are placed very close to the third row seat and are accessible to 35 lb children to press and play with them. While strapped into their car seats, my children easily reached and both touched the buttons and loosened their car seats while the car was in motion and I was driving. There is no software setting or built-in dashboard switch to disable the third-row PowerFold buttons in a Ford Expedition. To prevent the seats from accidentally folding, the most effective permanent solutions are removing the associated fuse, disconnecting the physical wiring harness from the button panel, or physically blocking the switch. This is extremely dangerous and needs to be fixed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734560April 29, 2026
POWER TRAIN
Transmission failure. Vehicle has failed to accelerate and then failed to move at all. Still under warranty and no codes shown. Vehicle left immobile on interstate due to intermittent transmission failure. Initial repair was not sufficient as issue has returned. No solutions for additional repair to address safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731808April 17, 2026
POWER TRAIN, ELECTRICAL SYSTEM, ENGINE
This is a report of a recurring, life-safety defect involving unintended vehicle movement in a 2024 Ford Expedition. The vehicle has experienced two separate incidents where it was placed in 'Park,' remained stationary for 13-30 seconds, and then began driving itself backward without driver intervention or throttle input. Incident 1: Occurred on March 29, 2026 and I have this one on video. Incident 2: Occurred on April 8, 2026. The video clearly shows the vehicle remaining stationary and in 'Park' for 13 seconds before the unintended movement begins. This delay proves the movement is not a 'start-up rocking' sensation or 'normal clutch drag,' but a delayed mechanical or electronic failure of the park actuator or transmission system. I presented the vehicle for service at a Ford dealership on April 17, 2026. Despite my report of a delayed-onset rollaway, the dealership documented the issue as a 'normal and desired characteristic' of the 10-speed transmission. They characterized the event as a minor 'rocking' sensation that occurs immediately, which is factually contradicted by my video evidence showing a 13-second delay. This leaves me with an unsafe vehicle prone to unintended movement. I am requesting a formal investigation into a potential park-engagement failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730668April 12, 2026
LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Since I purchased the vehicle brand new, none of the safety features have been functional. The following sensors are faulty and none of them have worked since I bought the vehicle: 1) Cross Traffic Alert; 2) Blindspot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance. I tried to take the vehicle into the service department of the dealership to fix the problem several times, but as of this time, there has been no solution. The dealership said the problem cannot be fixed, because only Ford Corporation can create a computer software fix for the problem. I was instructed by the dealership not to bring the vehicle back for the same issues, because nothing can be done, and they will not touch it. However, Ford has failed to launch a computer software fix, since I had had the vehicle to 2 years. Since the dealership can't fix it and Ford can't fix it, I am stuck with a defective vehicle that is "Unsafe" to drive, because all of these safety features that are not functional help prevent and reduce the probability of motor vehicle accidents. Ford is refusing to help me and rejected my claim even though they can't fix it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730471April 10, 2026
FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
I bought this vehicle brand new in 2024 and none of the safety features are functional and can't be fixed. Ford corporation cannot find a a computer software fix for it and the dealership can't fix it. The vehicle in unsafe to drive. The following sensors are faulty and have continued to give failure alerts since I purchased the vehicle: 1) Cross Traffic Alert; 2) Blind Spot System Fault; 3) Pre-Collision Assist; 4) Front Camera Fault; 5) Parking Sensor Fault; 6) Lane Keeping Assistance, 7) Rear backup assistance. It is a safety hazard and unsafe to drive because none of the "Safety Warning" or "Driver Assistance" features work, that would help prevent accidents. For the past 2 years, I have been driving this defective vehicle that is a safety hazard, which is not repairable, nor is the vehicle marketable. I have tried to resolve this issue numerous times, but there is no solution. The dealership advised me to not bring it in for service again, because there is nothing that can be done. I tried to file a claim with Ford Corporate and requested they buy the vehicle back, because it meets the criteria and the elements under the Texas Lemon Law, regarding electrical and safety concerns. However, my claim was rejected. As of right now, there is no solution for this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727088March 25, 2026
LANE DEPARTURE: BLIND SPOT DETECTION, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: ASSIST
I have had my car at the dealership twice, once in August of 2025 and once in February of 2026 because when I start I get a warning, front collision assist malfunction, lane keep assist malfunction, blind spot monitoring malfunction, and as a result, I have no cruise control, even in normal cruise control mode. I have been told it’s an electrical update, and it was October, then January, now it’s March. Just saw a recall was issued for Navigator, Nautilus, Aviator, and Explorer with this exact problem, but no recall for the expedition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11718826February 18, 2026
WHEELS, ENGINE
Bought the car on Feb 14th 2026. We were told Avis car sales in fontana does their vehicle inspection on every car before its sold. We noticed the two back tires on the expedition were bald and showing cords. We told Tawnya and George about the tires and they said they would order them, they'd be in within two days and to bring the car back to get them replaced. When we got home we setup ford diagnostics and found out the oil life was at 29% so they also lied and sent us out with bad oil. We checked the dip stick and yeah super dark oil. We've called two days in a row and keep getting told they are busy and they will call us back, they have not. We have tried to reach corporate but they dont have a department for this. The vehicle is currently sitting because of how bad the tires are, its 100% not safe to drive. Trying to get the dealership to honor the safety fix they promised but they are avoiding it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11716273February 6, 2026
UNKNOWN OR OTHER
The rear portion of the panoramic moonroof shattered spontaneously while the vehicle was being operated, without any impact or external cause.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711979January 19, 2026
UNKNOWN OR OTHER
On Monday, January 12, I was driving down the highway with 2 of my coworkers, when all of a sudden there was a loud pop and glass shattered. My sunroof had exploded. It was a sunny clear day, there were no vehicles in front of us and we were not going under an overpass. We pulled over to take pictures and drove the vehicle straight to Ford. We have since read that this type of incident has occurred before with multiple other Expeditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707227December 27, 2025
VEHICLE SPEED CONTROL
My wife tried to move my expedition from spot to another in our parking lot During that maneuver the gas pedal assembly broke down and the car in high speed created some personal and property damages I have the part handy and ready for inspection up on request The insurance knows about it And I had a police report No warning prior to the incident
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11706650December 22, 2025
STRUCTURE:BODY
Vehicle was driving approximately 65 miles per hour on interstate. Upon crossing a bridge the sunroof exploded sending glass flying inside the vehicle. The vehicle was equipped with a dash camera which also captured audio. No external object struck the vehicle. Two children and an adult in the vehicle were struck with flying glass. The video has been saved and can be provided in addition to the pictures.
Crash:
No
Fire:
No
Injuries:
3
Deaths:
0
#11702998December 4, 2025
UNKNOWN OR OTHER
I was driving on the I95 and just passed the McHenry tunnel when out of nothing I heared a loud bang and my moon roof spontaneously shattered into pieces. Nothing hit it and after inspection there was also no other damage on the car but the rear part of the moonroof that was completely shattered.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Expedition