Ford E-250 Complaints

322 consumer complaints on file.

#10960296March 13, 2017
ENGINE, POWER TRAIN, FUEL SYSTEM, GASOLINE
MY TRANSMISSION WENT ABOUT TWO WEEKS AGO. I WAS TOLD THAT FORD HAD BAD TRANSMISSIONS IN THE YEARS OF MY VAN, BY THE MECHANIC. THEN FRIDAY NIGHT I WAS DRIVING ALONG AND THE VAN STARTED ACTING FUNNY, NOT ACCELERATING AND A WRENCH LIGHT CAME ON. THEN A LITTLE ENGINE LIGHT CAME ON AND MY CAR DIED. I GOT IT TO GO ABOUT 30MPH ON THE EXPRESSWAY AND GOT IT TO THE GARAGE. :[ I LOOKED UP WHAT HAPPENED AND FOUND OUT THAT THE THROTTLE BODY PROBLEM IS COMMON IN THE FORD, JUST NOT THE E250. BUT IT IS THE SAME PROBLEM AS THE ESCAPE, SO OBVIOUSLY A FORD PROBLEM!! I HAVE ALREADY PUT IN A NEW TRANSMISSION AND NOW THIS. I FEEL THAT THESE THINGS SHOULD NOT GO AFTER ONLY 9 YEARS. THIS VEHICLE IS FOR TRANSPORTING MY TWO BOYS IN WHEELCHAIRS WITH A MUSCLE DISEASE. I NEED MY CAR!!! BUT I AM GOING BROKE! IF THESE PROBLEMS ARE FORD AND YOU ARE FIXING THEM FOR FREE WITHIN TEN YEARS, THEN THAT IS WHAT YOU SHOULD DO! [XXX]. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954430February 14, 2017
SUSPENSION
THE DEATH WOBBLE OCCURS WHEN YOU HIT A BUMP IN THE ROAD LARGE OR SMALL . I HAVE BEEN REPLACING EVERYTHING ON THE FRONT END . JUST ROTATED TIRES GOING TO SEE IF THAT WORKS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10953949February 10, 2017
AIR BAGS
TAKATA AIR BAG ..WHILE CAR WAS PARKED AND IGNITION OFF FOR A COUPLE OF HOURS WOKE UP THE NEXT MORNING TO FIND THE DRIVER.SIDE AIR BAG DEPLOYED FOR NO REASON TOOK TO FORD DEALERSHIP THEY RAN DIAGNOSTIC AND TOLD ME THERE WERE NO ERROR CODES FOUND OTHER THEN AIR BAG DEPLOYED
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10947861January 26, 2017
ENGINE
SPARK PLUG ON CYLINDER #7 BLEW OUT OF THE CYLINDER HEAD. 2ND TIME THIS HAS OCCURRED ON THIS VEHICLE. REPAIR SHOP STATES IT IS NOT REPAIRABLE THIS TIME APPROX. $3000 FOR NEW HEAD INSTALLED. THIS IS A KNOWN PROBLEM ON THIS 5.4 TRITION ENGINE. FORD SHOULD RECALL TO FIX THIS PROBLEM 130,000 MILES ON THIS TRUCK.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10944073January 10, 2017
POWER TRAIN
THIS IS THE 11TH FORD WE HAVE REPLACED THE TRANSMISSION ON. BALSIE FORD IN HYANNIS,MA HAS NOW HAD THE VEHICLE FOR 32 WEEKS AND STILL NOT BACK YET.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10911231October 3, 2016
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
THE PCM AT 34,000 MILES CAUSED TWO FUEL PUMPS TO BURN OUT IN 4 DAYS. A "WRENCH" WARNING SYMBOL APPEARED ON THE DASH AND THE VANS ENGINE DIES WHILE GOING AT HIGH SPEED (WE PULL A PRESSURE WASHING TRAILER HOLDING WITH HAZARDOUS CHEMICALS & WATER). IF IT WAS RAINING OR EVEN HEAVY TRAFFIC THIS COULD CAUSE A DANGEROUS LIFE THREATENING CRASH. ON WET ROADS THESE HEAVY COMMERCIAL VEHICLES CAN EASILY HYDRO-PLAIN WHEN THIS OCCURS PUTTING THE DRIVER & OTHERS IN DANGER WHO MAY BE IN THE PATH. WE ARE NOW WITHOUT OUR SERVICE VAN FOR 2 WEEKS & FORD ESTIMATED IN THE EXCESS OF $2600 IN REPAIRS ON A VEHICLE WITH JUST 34,000 MILES ON THE VAN.WE JUST REPLACED THE TRANSMISSION 3 MONTHS AGO. MY STEP FATHER IS 84 YEARS OLD WHO OWNS THIS VEHICLE AND HE IS A RETIRED NAVY CAPTAIN OF OVER 25 YEARS. HE AND I ARE BOTH CONCERNED THAT THIS VEHICLE IS TOO DANGEROUS TO DRIVE AT HIGH SPEEDS (60-70MPH) WITH THE LOADS WE CARRY IN OUR EVERY DAY SERVICE SCHEDULE. FORD SEEMS TO OFFER NO ASSISTANCE FINANCIALLY AND NO COMFORT IN RESOLVING THE SAFETY ISSUES RESULTING IN THE FAILURE OF THE PCM (POWER TRAIN CONTROL MODULE) WHICH IS OBVIOUSLY VERY DANGEROUS WHEN LARGE COMMERCIAL VEHICLES HAVE THE ENGINE FAILING OR DYING AT HIGH SPEEDS. AFTER READING ABOUT THE THROTTLE BODY PROBLEMS THAT FORD EXPERIENCING WITH OVER 1,600,000 VEHICLES BEING RECALLED, IT SEEMS THAT THE SAME WARNING SYMBOL OF THE TWO SIDED WRENCH APPEARS ON THE DASH AND THE SAME ENGINE FAILING OCCURS AT HIGH SPEEDS. THE SERVICE MECHANIC AT BIG STAR FORD IN MANVEL TX. TOLD ME HE REPLACED THE FIRST FUEL PUMP, DROVE IT ON THE HWY AND HAD TO TOW IT BACK TO THE DEALER BECAUSE IT DIED WHILE TEST DRIVING THE VAN AND BURNED OUT THE NEW FUEL PUMP HE JUST INSTALLED, THEN HE SAID HE PUT A NEW FUEL PUMP IN AGAIN AND USED THAT TO DIAGNOSE THAT THE PCM WAS THE PROBLEM WHILE RUNNING IT ON IDLE FOR AN HOUR. WE ARE NOW CONCERNED THIS NEW PUMP IS DAMAGED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10907234September 16, 2016
TIRES
TIRE BRAND AND SIZE: PATHFINDER SPORT S A/T 245/75-16 PUT ON REAR OF 2003 FORD E250 EXTENDED LENGTH WORK VAN. BOUGHT NEW FROM DISCOUNT TIRE. AS SOON AS I GOT ON THE INTERSTATE I NOTICED THE VEHICLE FELT UNSTABLE. WAS WANDERING IN REAR. WHEN MAKING A LANE CHANGE IS WAS REALLY BAD AND FELT UNSAFE AS THE REAR SWAYED FROM SIDE TO SIDE. HAD THEM TAKE THESE TIRES OFF AND REPLACE WITH A MAJOR BRAND AND THIS PROBLEM WENT AWAY. I HIGHLY RECOMMEND SOME ONE LOOKS INTO THESE TIRES AS I THINK THE POTENTIAL IS THERE FOR CAUSING A SPIN OUT OR ROLL OVER.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875395June 20, 2016
POWER TRAIN
TL* THE CONTACT OWNS A 2012 FORD E-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE INDEPENDENTLY DOWNSHIFTED INTO FIRST GEAR AND THE WHEELS SEIZED. WHEN THE CONTACT SLOWED DOWN THE VEHICLE, THE FAILURE SUBSIDED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS RELATED TO NHTSA CAMPAIGN NUMBER: 16V248000 (POWER TRAIN), BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10874751June 17, 2016
WHEELS
LAST WEEK I RECEIVED NOTICE FROM MICHELIN NORTH AMERICA THAT MY CLAIM I PRESENTED IN WRITING ON MAY 18 HAD BEEN DENIED. I FILED THE CLAIM BECAUSE I HAD MY WARRANTY TIRE EXPLODED ON MY CARGO VAN RESULTING IN ABOUT $5000. IN DAMAGES. MICHELIN REPRESENTATIVE RITCH TOWNSEND SAYS THAT I AT SOME POINT I HIT SOMETHING SPLITTING THE INNER LINER THAT OVER TIME CAUSED THE TREAD DETACHMENT. THIS DID NOT HAPPEN! I AM THE ONLY PERSON THAT HAS DROVE THIS VAN WITH JUST 33,000. MILES. AREA ATTORNEY'S WITH DEFECTIVE TIRE LITIGATION EXPERIENCE ARE PERSONAL "INJURY ATTORNEY'S". NO INJURY; NO INTEREST! THIS LARGE TIRE MANUFACTURER WILL NOT TAKE RESPONSIBILITY FOR THEIR DEFECTIVE TIRE UNTIL THEY ARE FORCED UNDER JUDGEMENT AND THEN LIKELY ONLY AFTER PEOPLE HAVE LOST THEIR LIVES! ON 05/10/16 I WAS SOUTHBOUND IN CLEARWATER FL ON HWY 19 WHEN I HEARD A SUDDEN EXPLOSION. BEING IN THE FURTHERMOST RIGHT DRIVING LANE I PULLED OFF ONTO THE EMERGENCY LANE AT 12600 HWY 19. I FOUND THAT THE RIGHT REAR TIRE HAD COMPLETELY COME APART AND HAD BADLY BEATEN THE REAR PANEL OF MY VAN. AFTER PUTTING THE SPARE TIRE ON AND GETTING BACK HOME I CONTACTED MICHELIN CONSUMER CARE AND WAS TOLD TO TAKE THE TIRE TO TIRE KINGDOM IN DUNEDIN FOR EVALUATION. THE MANAGER AT THIS STORE IN TURN ALSO TALKED TO THE MICHELIN REPRESENTATIVE EXPLAINING THE TIRE WAS UNDER WARRANTY AND THE TREAD HAS DETACHED. AN OFFER WAS MADE AT THAT TIME TO REPLACE THE TIRE BUT I WOULD HAVE TO LEAVE THE TIRE; MY EVIDENCE OF THE CAUSE OF THE VEHICLE DAMAGE. I DECLINED THE OFFER ELECTING FOR THE MICHELIN CLAIMS PROCESS. AS REQUESTED I SENT THE DEFECTIVE TIRE TO MICHELIN FOR A NON-DESTRUCTIVE TEST OF THE TIRE AND REQUESTED THAT THE TIRE BE RETURNED TO ME AFTER INSPECTION AND I HAVE SINCE RECEIVED THE TIRE BACK IN DUNEDIN. I AM CONVINCED THIS TIRE TELLS A TALE THAT WILL GO UNNOTICED BECAUSE NOBODY LOST THEIR LIFE YET.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10763125September 11, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2002 FORD E-250. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE FUEL TANK STRAP DETACHED FROM THE VEHICLE AND CAUSED THE FUEL TANK TO NEARLY TOUCH THE GROUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10732449July 7, 2015
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 1997 FORD E-250. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE FAN SWITCH THAT CONTROLS THE FAN SPEED MELTED AND BURNED. THE CONTACT COASTED TO THE SIDE OF THE ROAD, PULLED THE COVER FOR THE DASHBOARD, AND REMOVED THE WIRES THAT WERE CONNECTED TO THE SWITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE BURNED WIRES SWITCH NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 236,092.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10693668March 11, 2015
FUEL/PROPULSION SYSTEM, ENGINE
VEHICLE WARNING SYSTEM INDICATED TO SAFELY STOP TRUCK IMMEDIATELY. TRUCK WOULD NOT RESTART. TRUCK WAS TOWED TO DEALERSHIP (~60 MILES). FORD REPLACED ONE OF THE EXHAUST GAS SENSORS UNDER WARRANTY. DEALERSHIP PERSONNEL INDICATED THAT THIS WAS A RECURRING PROBLEM AND IT WOULD PROBABLY HAPPEN AGAIN. MARCH OF 2015 SIMILAR CIRCUMSTANCES, VEHICLE WARNING SYSTEMS INDICATED TO SAFELY STOP TRUCK IMMEDIATELY. TRUCK CONTINUED RUNNING AND DROVE THE 80 MILES BACK TO DEALERSHIP. MILEAGE AT THE DATE OF THE SECOND OCCURRENCE WAS ~54,500. A DIFFERENT EXHAUST GAS SENSOR WAS REPLACE, NO WARRANTY COVERAGE. DEALERSHIP PERSONNEL CONTINUE TO INDICATE RECURRING PROBLEM AND IT WOULD PROBABLY HAPPEN AGAIN. CONTACTED FORD, NO RESOLUTION ON COST INCURRED OR IF THERE IS A RE-DESIGN AND REPLACEMENT OF SENSOR (S). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10660701November 24, 2014
STRUCTURE:BODY, ELECTRICAL SYSTEM, POWER TRAIN
AS I WAS DRIVING MY 2012 FORD F250 DIESEL A LIGHT CAME ON INDICATING A PROBLEM WITH THE ELECTRONIC LOCKING REAR DIFFERENTIAL. SECONDS LATER THE COMPUTER SCREEN STATED FLASHING DIFFERENT WARNINGS- THE COMPUTER CHIMED NON-STOP WITH THE ALARMS UNTIL, WITHIN 10 SECONDS FROM THIS STARTING, THE ENGINE WAS SHUT DOWN BY THE COMPUTER AND I WAS LEFT TO COAST TO A STOP. IT WAS NOT AN EASY STOP- THIS TRUCK WEIGHS 8,500 POUNDS AND WITH NO POWER IT IS EXTREMELY DIFFICULT TO NAVIGATE OVER TO THE SIDE OF THE ROAD. TWO CARS APPEARED TO COLLIDED WHEN THE ENGINE CUT OUT AND I COULD NOT KEEP IN THE LANE ON THE CURVE. I WOULD SURELY BE SERIOUSLY INJURED OR DEAD OR INJURED/KILLED OTHERS IF I WAS TOWING A LOAD ON ONE OF THE MOUNTAIN PASSES WHEN THIS SHUT DOWN OCCURED- THIS TRUCK HAS A DIESEL AND PURPOSELY DESIGNED FOR HEAVY TOWING- 16,000 MILES ON IT AND FORD'S NEW DIESEL IS A POTENTIAL KILLER. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10660112November 21, 2014
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
TL* THE CONTACT OWNS A 2012 FORD E-250. THE CONTACT STATED THAT THE RADIATOR WAS LEAKING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10654652November 13, 2014
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:HEATER CORE, ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2006 FORD E250. THE CONTACT STATED THAT THE HEATER SWITCH MELTED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE CONTACT OWNS A FLEET OF VEHICLES WITH THE SAME FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10630825September 4, 2014
ELECTRICAL SYSTEM
HAD 1ST EXHAUST HEAT SENSOR GO OUT LAST YEAR APPROX. 50,000 MILES. SECOND ONE ON 8/15/14 APPROX. 110,000 MILES THIRD ONE ON 9/1/14 APPROX. 113,000 MILES ALL THREE TIMES LEFT ME STRANDED ON BUSY INTERSTATE HI-WAY. HAVE EXTENDED WARRANTY SO COVERED FOR PARTS AND LABOR LESS THE 100.00 DEDUCTIBLE. BUT WITH OUT MY TRUCK FOR 2 TO 3 DAYS EACH TIME OVER A 40.00 PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10621472August 11, 2014
ENGINE
TL* THE CONTACT OWNS A 2011 FORD E-250. THE CONTACT STATED THAT THE ENGINE WARNING INDICATOR WAS CONSTANTLY ILLUMINATED. THE DEALER STATED THAT THE UREA PUMP WAS CONTAMINATED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 36,606. JCC
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10617968July 31, 2014
WHEELS, TIRES
VEHICLE HAD FOUR NEW TIRES ALL OF SAME BRAND AND SIZE ONE OF THE TIRES HAD A BLOW OUT, REPLACED THE TIRE WITH NEW TIRE OF SAME BRAND AND SIZE. ONE WEEK LATER ANOTHER TIRE STARTED VIBRATING SO WE TOOK IT IN AND THEY CHECKED IT AND FOUND THE TREAD IS SEPARATING FROM THE CARCASS. I HAD THEM PULL ALL FOUR TIRES AND REPLACE WITH NEW TIRES OF DIFFERENT BRAND. I KEPT THE FOUR TIRES AND CHECKED FOR ANY RECALLS. THIS PARTICULAR TIRE DOES NOT HAVE A RECALL YET BUT ANOTHER SIMILAR DOES. THE TIRES WE HAVE ARE THE HANKOOK DYNAPRO AS LT245/75R16 THE TIRE THEY HAVE RECALLED IS HANKOOK DYNAPRO MT LT325/60R18. HANKOOK SAYS THEY WILL ONLY WARRANT THE ONE TIRE SHOWING SEPARATION BUT WILL NOT DO ANYTHING ABOUT THE FIRST ONE BECAUSE WE DON'T HAVE IN OUR POSSESSION OR THE OTHER THREE BECAUSE THEY HAVE NOT FAILED YET. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10616333July 25, 2014
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2013 FORD E-250 EQUIPPED WITH HANKOOK TIRES, TIRE LINE: DYNAPRO AS, TIRE SIZE: LT245/75R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE REAR PASSENGERS SIDE TIRE TREAD SEPARATED FROM THE WHEEL. THE VEHICLE WAS TAKEN TO A DEALER AND THE TIRE WAS NOT REPLACED. THE FAILURE MILEAGE ON BOTH THE VEHICLE AND THE TIRES WAS 11,000. UPDATED 9/4/14*CN THE COMSUMER STATED THE TIRE LOOKS AS IF IT CONTAINS DRY ROT. UPDATED 12/18/2014 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10594474May 28, 2014
EXTERIOR LIGHTING
A SHORT WHILE AFTER OWNING THE VEHICLE, THE BRAKE LIGHT BULBS BURNT OUT. I'VE HAD TO REPLACE ALL THE BRAKE LIGHT BULBS APPROXIMATELY EVERY 3 MONTHS OR SO. AFTER A FEW BULB REPLACEMENTS I NOTICED THE SOCKETS THAT HOLD THE BULB STARTING TO LOOK BURNT. NOW ALL THE SOCKETS IN THE REAR OF THE VEHICLE ARE TO THE POINT WHERE THEY ARE COMPLETELY "FRIED" AND MELTED NEEDING REPLACED. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford E-250