Ford E-250 Complaints

322 consumer complaints on file.

#11655888April 21, 2025
AIR BAGS
The contact owns a 2014 Ford E-250. The contact stated that while driving approximately 40 MPH, the vehicle suddenly fishtailed, causing the rear passenger side of the vehicle to crash into an unknown object. The contact indicated that the vehicle would only operate in limp mode after the crash. After switching back to the drive position, the vehicle operated normally. During the crash, no injuries were reported, and no police report was filed. The contact used a scanner to determine that the PCU had malfunctioned and needed to be replaced. The contact also discovered that electrical wires in the vehicle were damaged by rodents. A Number 6 Injector Wire was chewed out by rodents, and the contact independently replaced the wire however, the vehicle continued to misfire. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered and was referred to the NHTSA Hotline. The manufacturer was aware that there was a software issue with the PCU and that it was a known failure, and the contact was concerned due to Ford acknowledging there was a fatality due to this known failure. The failure mileage was unknown.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11601030July 10, 2024
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
I purchased DORMAN Replacement TPMS Sensors 974-050 from ROCKAUTO for my van. Installed less than 2 years and all are bad. ROCKAUTO stated they were wholesale closeout on only offer a 30 day warranty. Contact DORMAN and they stated LIFETIME and that ROCKAUTO should not have sold out of date sensors and to contact ROCKAUTO. After several emails to ROCKAUTO they basically say sorry out of warranty. The date code on the sensors are 11326-385 they were built in 2011. They should have some kind of law for selling outdated safety equipment. I have my Shipping Packing List , one sensor that I never installed and 4 of the 5 boxes.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11571064February 9, 2024
UNKNOWN OR OTHER
HELLO I HAVE THIS 2013 FORD E250 VAN AND ITS STOP DRIVING AND TRANSMISSION STOP WORKING IN THE MIDDLE OF THE ROAD AND THERE IS A LINK SAY ITS HAS RECALL ON SAME PROBLEM LISTED ON RECALL BUT TODAY I WENT TO FORD DEALER AND THEY LOOK AND SAY THERE IS NO RECALL ON TRANSMISSION ISSUE PLEASE READ THIS LISTED ABOUT TRANSMISSION PLEASE HELP : 2009-2016 Ford Econoline Recalled For Loss Of Motive Power Issue Ford has issued a recall for 2009-2016 Ford Econoline / E-Series models over a transmission component that could result in a motive power loss issue. The defect: affected vehicles contain a capacitive discharge weld within a coast clutch component in the transmission. A substandard weld may fatigue and fail, causing the loss of the ability to move the vehicle. All normal engine, braking, and steering functionality is unaffected. Reports indicate that the majority of weld failures occur when torque is highest, which is when the driver attempts to accelerate from a stop. The hazards: an elevated rate of loss of mobility in school bus and ambulance vehicle applications could present a unique risk to passengers or occupants including a loss of mobility in school bus applications may result in the transfer of unchaperoned children when the vehicle is immobilized in a roadway. Loss of vehicle mobility in ambulance applications may result in delay of patient treatment. Ford is unaware of any accidents resulting from this condition. Components: coast clutch capacitive discharge weld (inside transmission).
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11513410March 23, 2023
ENGINE
The contact owns a 2009 Ford E-250. The contact stated that the vehicle was taken to an independent mechanic to be serviced and was informed that the catalytic converters and an unknown sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 95,484.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11507184February 14, 2023
ENGINE, FUEL/PROPULSION SYSTEM
The vehicle Blew a spark plug while driving. It took place right as I attempted to accelerate up to highway speed of 50 MPH. When I had it checked the mechanic said the number 3 plug was blown out and I had a busted injector. Vehicle mileage is 164k. The repair was over $1100.00 with none being covered under my full coverage insurance policy. I need to let others know what to expect from their Ford vehicle... Found out that this is a frequent problem with Ford Engines 5.4 Liter V-8..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11486809September 27, 2022
UNKNOWN OR OTHER
When I go to the lake boating, I always remove my battery from the engine compartment and take it with me as a backup in case my boat battery should fail. on September 26, 2022, when leaving the lake, I reinstalled the battery bas I always do and closed the hood. It appeared closed when the hood surface aligned with the side panel. After leaving the boat ramp I turned onto FM 2272 and was accelerating to the posted speed limit of 55. At 40 mph, all of a sudden, the hood flew up into the windshield shattering it from one side of the vehicle to the other. My view of the road was completely obstructed as I was covered in pieces of broken glass. Fortunately, I was able to see the white lane marker through the bottom of the windshield as there was about a 3-inch gap between the bottom of the hood and the bottom of the windshield so I could safely pull my vehicle off the roadway. I know I closed the hood before leaving the boat ramp and even if I hadn't fully closed the hood the secondary hood latch should have prevented the accident from occurring. The secondary. latch is not dependent on the release mechanism and is 100% a mechanical device requiring a person to physically push on the release lever under the hood in order to open it. Had the hood opened while I was on an interstate highway or at night the accident could have been fatal.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11468282June 8, 2022
UNKNOWN OR OTHER
I arrived at my destination, lined up to park, shifted my foot from accelerator to brake and ... YIKES the engine was racing like crazy. I put both feet on the brake, shoving hard, engine continues to accelerate over the curb & into a fence. Pulling against the brakes, the engine continued to race. I reached to yank it out of gear, when it TOOK OFF backwards across the parking lot. Still standing on the brakes, I frantically looked for a path that would give me time to kill the engine. skipped the window that I couldn't see if there were PEOPLE on the other side of it ... angled to go around parked cars and went for the ignition switch to kill the engine. After I got the engine switch off, the momentum carried me into the first parked car, which shoved it into the next parked car. THANK GOODNESS there were no people in either, nor in the parking lot!! No warnings of any kind. The entire vehicle is available for inspection; it has yet to be inspected. There is no way I would drive this suicidal-murdering death-trap ANYWHERE, so I had it towed. Police and insurance have been notified.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11465943May 24, 2022
STEERING, SUSPENSION:FRONT
The contact owns a 2016 Ford E-250. The contact stated that while his wife was driving at an undisclosed speed, the vehicle experienced a death wobble. The vehicle was taken to an independent mechanic who replaced the steering damper, drag link, connecting rod, and ball joint; however, the failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 87,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465755May 23, 2022
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
The contact owns a 2012 Ford E-250. The contact stated that the front passenger’s seat belt was locked as the seat belt was unable to be removed from the buckle. The vehicle was not taken to a dealer or independent mechanic for diagnostic test or repair. The contact stated that he called a dealer however, the vehicle was not taken to the dealer. The contact stated the manufacturer was not made aware of the failure. The approximate failure mileage was 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11452199February 16, 2022
VEHICLE SPEED CONTROL
The contact owns a 2013 Ford E-250. The contact stated that while driving at a very low rate of speed while approaching a stoplight the driver depressed the brake pedal to stop and the vehicle erroneously accelerated forward and crashed into the rear of a second vehicle. During the incident, no injuries were reported and no police report was taken. The vehicle was examined by an independent mechanic but the cause of the failure was not determined. The manufacturer and local dealer were not notified. The failure mileage was 53,200.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11451171February 9, 2022
ELECTRICAL SYSTEM, POWER TRAIN
The contact owns a 2004 Ford E-250. The contact stated while driving 45 MPH, the vehicle lost motive power and stalled. The vehicle coasted to the side of the road and the contact waited for a minute to restart the vehicle before starting to drive however, the failure persisted. No warning light was illuminated. The contact had the vehicle towed to an independent mechanic who inspected the vehicle but could not duplicate the failure. The mechanic believed that the failure was related to NHTSA Campaign Number: 05V270000 (Electrical System) and referred the contact to the manufacturer for assistance. The contact notified the manufacturer of the failure and the recall but was informed that the VIN was not included in the recall and that the recall only included the diesel engine vehicles. The vehicle was not repaired. The failure mileage was approximately 110,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11447150January 12, 2022
STRUCTURE:BODY
The rubber body mounts that are used between the body and chassis have deteriorated and crumbled to the point that there is nothing left but the bolt where a mount or bushing once was and this has happened within 100,000 or less on this vehicle when first noticed due to very harsh ride, body roll, popping and screeching noise from underneath van due to the rubber missing in places. This has been a constant problem with our f-250 Ford trucks as well and we do not drive the van or trucks off road and do not tow either and never drive in salt on roads in the winter so this is not due to road salt or muddy wet conditions of off roading as we are in the house cleaning business and never drive on anything other than paved or solid driveways on all jobs and do not work if bad weather is present. The bad mounts cause severe body roll, radiator damage due to bottom of radiator making contact with frame because rubber eventually fell apart and caused body to contact chassis cracking the radiator on bottom and the flexing due to instability cracked the side casing on radiator as well. This has been a safety issue for years and the new Ford trucks are still having this issue as we are dealing with this again on the new truck with less than 60,000 miles and this is the truck that we use to estimate jobs so it's basically a town truck and shouldn't be having failing body mounts. I believe during an accident the body could separate from chassis if this isn't corrected and it greatly affects the handling and ride of the vehicle when body contacts the chassis and also damages other components such as radiator. Reapirs about 2000.00 for new mounts replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440788November 17, 2021
TIRES:TREAD/BELT
The contact owns a 2013 Ford E-250 equipped with Cooper Tires, Tire Line: Discoverer A/T, Tire Size: 245/75/16, DOT Number: (N/A). The contact stated that while he was inspecting the rear tires, he noticed that the tires were cracked with tread separation. The contact called a tire shop and the tires were replaced with another brand of tires. The manufacturer was not notified of the failure. The approximate tire failure mileage was 10,000. The vehicle failure mileage was not provided.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11440238November 12, 2021
POWER TRAIN
The contact owns a 2022 Ford F-250. The contact stated while the vehicle was parked, the vehicle independently shifted into neutral without warning. The vehicle was taken to a local dealer where it was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to NHTSA for assistance. The failure mileage was approximately 460. Consumer stated vehicle slipped into drive without warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11435148October 1, 2021
AIR BAGS
Airbags deployed for no reason. I was doing 70 mph on the freeway and out of nowhere both airbags deployed didn't hit any bumps just smooth driving. Could of killed me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11387290January 9, 2021
ENGINE
THANKFULLY I WAS DRIVING SLOWLY BETWEEN CURVES ON A STRETCH OF ROADWAY WITH A 30MPH SPEED LIMIT (ONE LANE EACH DIRECTION) WHEN I 'BLEW A SPARK PLUG'. THE COIL WAS ALSO DAMAGED I WAS TOLD. I WAS ALSO TOLD THERE'S NO GUARANTEE THAT IT WOULD NEVER HAPPEN AGAIN, AND I HAVE 7 OTHER SPARK PLUGS AND COILS IN THE ENGINE, SO EXPECT IT. ALLEGEDLY 3 WERE REPLACED JUST BEFORE WE BOUGHT THIS USED IN 2016. I TRIED TO GET RECEIPTS FOR VEHICLE MAINTENANCE RECORDS, BUT THE SHOP REFUSED AND THE PRIVATE OWNER HAD MOVED AND THROWN HER PAPERWORK AWAY. THIS WAS IN MASSACHUSETTS. I HAD NO WARNING, THAT I KNOW OF. SUDDENLY THERE WAS A LOUD BANG AND A REPEATED BANG, BANG, BANG! I PULLED OVER IMMEDIATELY. (THANKFULLY IT WASN'T A 3 OR MORE LANE HIGHWAY WITH MY MOTHER IN HER WHEELCHAIR!) THE BANGING ONLY STOPPED WHEN THE ENGINE WAS OFF. I WAS UNABLE TO LOOK AT THE ENGINE COMPARTMENT WITH THE VAN ON BECAUSE I WAS AFRAID OF MORE DAMAGE! IT WAS PUT ON A FLATBED AND TOWED BY AAA, TO A SHOP A FEW MILES AWAY. UNFORTUNATELY, THIS SHOP COULDN'T GET IT INSIDE TO WORK ON. A FRIEND OF MINE DID THE REPAIR IN THE PARKING LOT. ***APPARENTLY THIS IS A VERY FREQUENT PROBLEM WITH THESE FORD E250 ENGINES. THERE IS A LOT OF PEOPLE EXPERIENCING THE SAME PROBLEM. I HAD NO IDEA! IT COULD BE EXTREMELY DANGEROUS ON A MULTI LANE HIGHWAY, TRAVELING AT HIGH SPEEDS, GOING UP AND DOWN THE MOUNTAINS (I TRAVEL BETWEEN NYS & MASSACHUSETTS), IN SUBZERO TEMPERATURES ESPECIALLY WITH SOMEONE IN A WHEELCHAIR ONBOARD!*** I HAVE NO RECEIPTS. AAA OF CENTRAL NY SHOULD HAVE A RECORD OF THE TOW.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11361882September 29, 2020
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS 2013 FORD E-250. THE CONTACT STATED THAT THERE WAS AN ABNORMAL ODOR INSIDE THE CABIN OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND DETERMINED THAT THERE WAS A LEAK AT THE FUEL RELAY PRESENT AFTER AT START-UP. THE CONTACT WAS INFORMED THAT THE FUEL RELAY NEEDED TO BE REPLACED. GERMAIN FORD OF BEAVERCREEK (2356 HELLER DR, BEAVERCREEK, OH 45434) WAS CONTACTED AND INFORMED OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE CONTACT DID NOT FEEL SAFE DRIVING THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11352441September 1, 2020
EXTERIOR LIGHTING
MY HEADLIGHTS AND TAIL LIGHTS JUST COME ON ALL BY THEMSELVES, OR IF YOU OPEN OR CLOSE THE DOORS---THEY COME ON OR GO OFF. REALLY SCARY STUFF.I TOOK THE COVER OFF, AND THERE IS WATER INSIDE THE REAR LIGHTS. I HAD THIS SAME PROBLEM ON MY F-150 TRUCK IN 1998. WHY HASNT FORD FIXED THIS PROBLEM BY NOW???
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11348719August 11, 2020
WHEELS, TIRES
ON 3/17/2014 WE HAD 4 2-LT225/75R16E HT 701 115S BW SENTINEL INSTALLED ON OUR VAN BY BIG BRAND TIRE & SERVICE IN LOMPOC CA. THESE TIRES ARE RATED FOR 50,000 MILES. WE HAVE DRIVEN ABOUT 13,000 MILES. ON 8/6/2020 WE WERE DRIVING FROM WA TO SOUTHERN CA. THE RIGHT REAR TIRE STARTED GOING FLAT WHILE DRIVING. WE HAD AAA INSTALL THE SPARE AND WE CONTINUED ON OUR TRIP. ABOUT 200 MILES LATER THE VAN STARTED SHAKING VERY BADLY. WE WERE ON I5 IN THE MIDDLE OF THE CA DESERT. USING OUR PHONE WE FOUND A TIRE SHOP ABOUT 50 MILES AWAY. WE MANAGE TO LIMP OUR WAY TO THE TIRE SHOP. THEY SAID THE THE TREAD WAS SEPARATING. WE HAD ALL FOUR BRAN NEW TIRES INSTALLED. I HAVE BEEN UNABLE TO FIND ANY CONTACT INFORMATION FOR THE SENTINEL TIRE MANUFACTURER. THESE TIRES ARE DANGEROUS AND SHOULD BE RECALLED. WE ARE VERY LUCKY, THIS COULD HAVE ENDED IN A CATASTROPHE. WE WOULD LIKE TO FIND CONTACT INFO FOR THE MANUFACTURER TO TRY AND GET SOME COMPENSATION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11331209June 27, 2020
TIRES, TIRES:TREAD/BELT
BOTH FRONT TIRES MERELY DEVELOPED TREAD BULGES , LESS THAN 15K MILES, NEVER HAD A FLAT, BEEN OVERLOADED ,OVERINFLATED , ECT.. THEY JUST BECAME VERY POOR DRIVING AND VIBRATED BADLY TO FIND THEY BOTH HAVE BULGES IN THE TREAD. THEY SEEMED FINE ABOUT TWO WEEKS AGO AND WHEN I WENT TO DRIVE IT A COUPLE DAYS AGO THE PROBLEM BECAME APPARENT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford E-250