Ford Bronco Complaints (2021)

230 consumer complaints on file.

#11467964June 7, 2022
ENGINE
While pulling up to a yield sign the vehicle lost all power and shut off causing it roll past the yield sign and come to a stop in traffic blocking the roadway. The vehicle was towed to the Ford dealership and after being diagnosed it had a broken valve that caused catastrophic failure to the engines head and caused the head of the engine to be replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467446June 3, 2022
UNKNOWN OR OTHER, POWER TRAIN:AUTOMATIC TRANSMISSION
Loud grinding noise coming from transmission at 800 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11467210June 2, 2022
VISIBILITY:WINDSHIELD
The contact owns a 2021 Ford Bronco. While starting the vehicle the contact became aware of a line crack on the front of the windshield. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,337.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465923May 24, 2022
SERVICE BRAKES
-I bought the Ford Bronco to Flat-tow behind my Motorhome. (All 4 wheels on the ground) -Per Ford this is permitted, they outline a procedure in the owner's manual on how this must be performed. -At least 48 states require a supplemental braking system on towed vehicle. -The Bronco has an Electronic Break Booster (EBB) -When the Bronco is placed in the Flat - tow mode, the last step is to turn the key off. -Ford has set a timer (30 to 45 minutes) to shut down power to the EBB, when the key is turned off. -After timer expires, the brakes have no boost. This causes any after-market braking system installed on the Bronco to be useless. -In these circumstances, The Bronco is providing no help to the motorhome for braking, causing longer braking distances. Also, If the Bronco were to become detached from the motorhome, the emergency braking system that should come on and stop the vehicle, would not work. Could cause injury or death by having a runaway. -Ford has been unresponsive in attempts to remedy the situation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11465356May 19, 2022
POWER TRAIN
Transmission broke at 4,884 miles reversing out of the driveway. The driveway has no grade and never sits on a hill.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11464516May 13, 2022
ENGINE
Engine failure. My wife was driving the vehicle and was enveloped in smoke and the engine stopped and she was stuck in the middle lane of a busy road in rush hour. A dangerous section of road a few miles from our house. I drove down and gave her my SUV and then called AAA who towed it to the dealership. The motor was dead. The vehicle was towed to Future Ford of Sacramento. They then diagnosed it a few days later and informed us that it is a complete engine failure and that it will take several months to get the vehicle back to us. There were no warning lights or any warning prior to the engine stopping and a large amount of smoke to the point that my wife thought the whole vehicle was on fire. Four people stopped to help her and get her to the side of the road.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463296May 3, 2022
ENGINE
On Monday, March 7, 2021, my Ford Bronco First Edition with the 2.7 engine experienced catastrophic engine failure. I was driving near my home when my vehicle stopped running. I did feel a strange pull in my steering and tires; but I was also driving on ice and assumed it was the traction control system at play. I was wrong. It was my engine losing compression and my engine failing. My dash lit up with a series of errors (all in quick succession and could not catch them all) and my vehicle lost all power and control. As mentioned above, I was driving on ice covered roads and had difficulty steering. I attempted to pull off the road and into a parking lot; however, the drive sloped up and I could not get clear of the entryway. I had to stop blocking the entrance to the veterinarian's parking lot. To increase the risk here, my vehicle was not visible from traffic turning in because of snow banks that were taller than my vehicle. I want to stress how incredibly lucky I was that this happened close to home. I went on a road trip and had returned home the night before. We had contemplated taking the Bronco. If we had, we would have broken down on the Parks Highway in Alaska. This highway is remote at most times with spotty cell service. The risks of having broken down in subzero temperatures with zero help was extremely high in my area. I also consider myself extremely lucky that I had a friend that was able to come move my vehicle from blocking the business entrance. When I used the Ford app to get a tow, it quoted me 7 hours. I did call and complain that that was unacceptable. The vehicle was towed to the dealership and catastrophic engine failure was determined with a faulty valve being the contributing factor. This is a known valve issue and I have included my engine build date sticker in the photos. I included a photo of my Bronco being loaded on the tow truck showing the ice roads and snow bank blocking my car from view.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11463199May 3, 2022
ENGINE
at 2,000 miles the engine dropped a valve. Vehicle has already received a new engine. Vehicle shut off running down the interstate. safety was had to coast to shoulder and wait on tow truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461791April 22, 2022
SERVICE BRAKES
Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental brake system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. This is extremely dangerous as a break-a-way tow vehicle would have no brakes and become a missile, or the additional weight with no assisted braking could cause a 40,000lb Class A RV to lose it's brakes down a steep grade.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11461178April 18, 2022
ENGINE
CONSTITUENT WRITES IN REGARD TO THEIR 2021 FORD BRONCO. CONSTITUENT STATED THAT THE ENGINE HAS A KNOWN DEFECT IN THE VALVES CAUSING CATASTROPHIC ENGINE FAILURE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460137April 8, 2022
VISIBILITY/WIPER
The wipers slow down to intermittent after 45 seconds or so every time driving in the rain when they are set on continuous or continuous high. This temporarily hampers your visibility when driving in the rain and the Bronco is not even supposed to have auto sensing wipers. You have to change the wiper setting then put in back where you want the speed to be only to have it slow down again in 45 seconds or so.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460125April 8, 2022
ENGINE, UNKNOWN OR OTHER
2021 FORD BRONCO. CONSUMER WRITES IN REGARDS TO KNOWN DEFECT WITH VALVES THAT CAUSES CATASTROPHIC ENGINE FAILURE. THE CONSUMER STATED THE MANUFAUCTURER HAD NOT MADE ANY EFFORT TO ACKNOWLEDGE THE FAILURE. THE CONSUMER BELIEVED THE ENGINE SHOULD BE RECALLED AS MANY OTHER VEHICLES SHARE SAME THE DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460124April 8, 2022
ENGINE
2021 FORD BRONCO. CONSUMER WRITES IN REGARDS TO A KNOWN VALVE DEFECT WHICH CAUSES ENGINE FAILURE. THE CONSUMER STATED THE MANUFAUCTURER HAD NOT MADE ANY EFFORT TO ACKNOWLEDGE THE FAILURE. THE CONSUMER BELIEVED THE ENGINE SHOULD BE RECALLED AS MANY OTHERS SHARE THE DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11460118April 8, 2022
ENGINE, UNKNOWN OR OTHER
2021 FORD BRONCO. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. THE CONSUMER STATED THE MANUFAUCTURER HAD NOT MADE ANY EFFORT TO ACKNOWLEDGE THE 2.7 LITRE ECO BOOST ENGINE FAILURE. THE CONSUMER BELIEVED THE ENGINE SHOULD BE RECALLED AS MANY OTHERS SHARE THE DEFECT.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11459262April 1, 2022
ENGINE
I was driving to work on the morning of March 14, 2022, on the highway approx. 70 mph. I felt a falter or engine buck, I began to lose power to the engine. The engine light began to flash and I was only able to drive 55mph. I was in a very unsafe area on a highway with a very narrow shoulder and so I proceeded to manage my speed to reach work safely. I was able to make the additional 10 miles to my workplace. When I stopped at the gate for security, the engine died and I was unable to restart it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457806March 22, 2022
SERVICE BRAKES
When Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After we connect our Bronco to the motorhome and putting it in Tow Mode we lose Electronic Brake Boost about 45 minutes after turning the ignition off and closing the doors. The EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system not working. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental braking system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. This is dangerous and potentially life threatening.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11457360March 18, 2022
ENGINE
After 625 miles the low engine oil pressure alert came on. Had vehicle towed to dealership. After inspection they stated the engine will need to be replaced. It has now been two months and I’m still waiting for my vehicle to be repaired.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456713March 14, 2022
ENGINE
I was on cruise control going about 70 yesterday when I lost all power at the gas pedal. I made it to the side of the highway and waited 90 minutes for a tow truck to come get me. I had my dogs with me and it was 25 degrees out. We were three hours from home. The service department reported today that I had a catastrophic engine failure. A valve came loose and was crushed by the pistons or some such.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11456219March 10, 2022
ENGINE, UNKNOWN OR OTHER
My 2.7L V6 engine dropped a valve, it was inspected and determined by the dealer. This happened after a 1 hour freeway trip on Christmas Eve. Luckily, the incident was in my driveway after shutting off the engine. If it would have happened minutes before we would have had complete power failure at 65mph. The problem was determined to be a defect and was replaced under warranty by the dealer. Unknown whether Ford has done a post mortem inspection. No warning whatsoever prior to failure. It happened on shut down so no indication of an issue until attempting to restart 2 days later.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11455913March 9, 2022
SERVICE BRAKES
Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental bakes system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. Also, if for some reason the Bronco becomes detached from the motorhome that is towing it, then the Bronco becomes a missile waiting to hit what ever is in it's path as the emergency braking from the supplemental braking from the Coach would not engage and stop the Bronco.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco