BMW X5 Complaints (2021)

102 consumer complaints on file.

#11714543January 30, 2026
ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM
The contact owns a 2021 BMW X5. The contact received notification of NHTSA Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The contact stated that the VIN no longer showed the recall as being open. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712989January 23, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 BMW X5. The contact stated that while attempting to start the vehicle with the Push to START button, the vehicle failed to start. There was a clicking sound coming from under the hood. The failure was intermittent. The contact replaced the hybrid battery; however, the failure reoccurred. The contact stated that after several attempts, the vehicle started. The vehicle was taken to a dealer; however, the failure was not duplicated. The vehicle was taken to an independent mechanic, where it was diagnosed with a pinned-out emission circuit and starter failure. The contact was informed that the starter needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall; however, the VIN was not associated with the recall. The vehicle was manufactured a month outside the date for the vehicles included in the recall. The contact was advised to contact the manufacturer and make the manufacturer aware of the failure. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708344January 2, 2026
ENGINE
The contact owns a 2021 BMW X5. The contact stated that while driving at undisclosed speeds, unknown warning lights illuminated on several occasions. The failure had occurred while driving and while restarting the vehicle. The vehicle was taken to a dealer, where it was diagnosed, and determined that the starter had failed and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 44,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705036December 15, 2025
POWER TRAIN
I am writing to formally file a complaint and request an expansion of recall coverage regarding a starter motor failure on my 2021 BMW X5, which occurred at approximately 38,000 miles. Recently, my vehicle experienced a sudden failure to start. After inspection, the issue was diagnosed as a starter malfunction. I am aware that BMW has issued a recall addressing starter-related defects for certain vehicles of the same model year and configuration. However, I was informed that my vehicle’s VIN is not included in the current recall list. Given the relatively low mileage, the nature of the failure, and the existence of an official BMW recall for the same defect, I believe this issue represents a manufacturing or design defect rather than normal wear and tear. A starter motor failure at 38,000 miles is both unexpected and unacceptable for a premium vehicle such as a BMW X5
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704139December 10, 2025
ENGINE, SUSPENSION
In the middle of driving, multiple warning lights came on in the car and the steering became very stiff, which made it difficult to steer the car. We brought the car to the dealer service station and they identified that the crank pulley system had a failure and the vibration damper needed to be replaced. Apparently, this issue also resulted in the engine not properly charging the car battery, which also resulted in battery failure. This car only has about 38,000 miles on it and has been plagued by safety issues. The difficulty steering the car could have resulted in an accident on the road. This same car also had a water pump failure at approximately 35-36k miles that was separately reported to NHTSA previously.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703980December 9, 2025
ENGINE
BMW 2021 X5 Engine starter failed. BMW South Miami dealership troubleshooting found the starter motor faulty and replaced it. This failure is NOT part of the current starter recall for BMW X5. (25V644000) My X5 maufactured date is June of 2021. I purchased the X5 In July of 2021. I paid $2166.35 for repairs and I am seaking a refund.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703190December 5, 2025
UNKNOWN OR OTHER
I was driving 75mph on the highway and my sunroof exploded while driving. It sounded like a gunshot above my head and shattered while going 75mph. This vehicle and other bmws that share the same sunroof glass are not fit to drive on the road until investigated further. There has been recalls and lawsuits for this. This a supplier or install issue when the car was manufactured. It’s not safe while driving and the glass spontaneously combusts into a million pieces. I have contacted BMW NA and they stated there is nothing they can do about it. The service was paid for because I need a vehicle. I would like this investigated as a warranty claim so I can claim back the fees I have paid.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11701920November 28, 2025
POWER TRAIN:DRIVELINE:DIFFERENTIAL UNIT
The contact owns a 2021 BMW X5. The contact stated that while driving at various speeds, there was an abnormal grinding and clanking sound coming from the front end of the vehicle. The vehicle was taken to the local dealer, where it was diagnosed that the front differential was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,400.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11698378November 8, 2025
VEHICLE SPEED CONTROL, ENGINE, POWER TRAIN
The vehicle shakes at low speeds with a jolt and vibration when turning. When I pressed the accelerator from a standstill, the gas pedal broke off from its floor mounted bracket.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11695040October 22, 2025
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING
The contact owns a 2021 BMW X5. The contact stated that upon starting the vehicle, there was an abnormal sputtering sound coming from the vehicle. After several attempts, the vehicle was able to start. The vehicle was taken to the dealer, where it was diagnosed with starter failure. The contact was provided with the following DTC: 0012240600. The vehicle was not repaired due to the cost. The contact stated that the failure persisted. Upon further investigation, the contact associated the failure with NHTSA Campaign Number: 24V576000 (ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING). However, the VIN was not included. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693874October 16, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2021 BMW X5. The contact stated that while driving at an undisclosed speed, the coolant warning light illuminated with the message "Coolant Dangerously Low - Fill Right Away" displayed on the instrument panel. The message was displayed on several occasions. The vehicle was taken to a dealer where the dealer discovered coolant leaking from the bottom of the vehicle and diagnosed that the water pump needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was no longer under warranty. The failure mileage was approximately 40,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693718October 15, 2025
UNKNOWN OR OTHER
What component or system failed or malfunctioned, and is it available for inspection upon request? The engine/transmission mounts were diagnosed by Sterling BMW (Newport Beach, CA) as “sagging” and in need of replacement at only 38,437 miles. The components remain on the vehicle and are available for inspection. How was your safety or the safety of others put at risk? If engine mounts are in fact deteriorating prematurely, the drivetrain may shift during operation, affecting vehicle stability, steering alignment, and braking response. This could cause a sudden loss of control and create a hazard to occupants and other drivers. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Sterling BMW performed the inspection on October 2, 2025, and documented the issue in their inspection report, listing “motor mounts are sagging” under “Needs Immediate Attention,” with an estimated repair cost of $2,301.12. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? BMW of North America was contacted on October 15, 2025. They verbally denied warranty coverage, refused to provide a written response, and did not investigate further. The issue has not been independently inspected by police or insurance representatives. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No dashboard warning lights or messages appeared. The issue was only reported by the dealer during the October 2, 2025 service visit. I have not experienced noticeable vibration, noise, or performance changes that would typically indicate failed mounts. This raises concern that the diagnosis may either indicate a premature defect or an unnecessary upsell.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692077October 8, 2025
POWER TRAIN
The front differential on my BMW failed at just 47,000 miles. There were no warning lights—only a faint grinding noise that gradually worsened. After inspection, the dealership confirmed the failure and quoted $9,000 for replacement. In speaking with other BMW owners, I’ve discovered this issue isn’t isolated. Many have experienced front differential failures around the 50,000-mile mark, suggesting a troubling pattern. This raises serious concerns about the reliability of this component and whether BMW is adequately addressing what appears to be a recurring problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11690421September 29, 2025
POWER TRAIN
Around September, 2025 several small puddles was under the vehicle. Made an appointment with BMW to have a 2021, X5 inspected. The BMW dealership technicians diagnosed the problem as a Water pump -Engine coolant. There was no previous warning messages notifying a problem with the vehicle cooling system. Vehicle total mileage was around 58,000 miles at the time of problem found.Cost of damage was over $2,000 to fix at dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689259September 23, 2025
STEERING, POWER TRAIN
Steering the vehicle in a low gear causes the vehicle to tremble or shudder. The dealership identified the problem to be the transfer case fluid. In manufacturing, BMW put a fluid which did not meet the specifications of the vehicle. The transfer case fluid is documented in the manual of BMW X5 M50i (2021) to be something which does not require replacement in the lifetime of the vehicle. I raised this issue when the vehicle was under warranty, but the dealership ignored the issue. After the warranty period was over (62,000 miles), the dealer recommended that I replace the fluid to fix the shudder issue. It is a very well known issue, and there is a service bulletin issued to the dealerships to deal with this particular case (SIB 27 02 20). After the fluid replacement, the issue went away. This issue is widely known by the dealership, and it is a safety issue. I had to pay for the fluid replacement, and I believe BMW should have recalled this issue to replace the fluid for ALL X5s manufactured in 2020 and 2021. This is a safety issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11689062September 23, 2025
POWER TRAIN, ENGINE
Component Failed: Water pump (engine cooling system) - Part has been superseded by BMW with upgraded version, indicating manufacturer awareness of defect. Failed component retained and available for inspection upon request. Safety Risk: Complete water pump failure at 56,611 miles created immediate risk of catastrophic engine overheating and potential engine seizure while driving. BMW-certified mechanic warned that driving vehicle even short distances could result in total engine failure, creating risk of: Sudden loss of power on highways/intersections Engine fire from overheating Being stranded in dangerous locations/conditions Complete loss of steering assist if engine stops Confirmation: BMW-certified independent mechanic (formerly employed by BMW) confirmed water pump failure and identified it as "common B58 engine issue." BMW dealer (Silver Spring) immediately quoted exact repair cost of $2,300, indicating familiarity with this failure pattern. Mechanic documented that BMW has superseded the original part with an upgraded design, suggesting manufacturer acknowledgment of defect. Inspection Status: Failed part preserved by mechanic with full documentation including BMW's superseded part number from their system. Vehicle not inspected by BMW due to dealer network failure - three dealers failed to respond, one took 5+ hours to return call, none could provide service in reasonable timeframe. Warning Signs: No prior warning symptoms. Failure was sudden and catastrophic. Temperature gauge spiked without warning during normal driving conditions. No previous cooling system issues or warning lights. Regular maintenance performed per BMW specifications. Additional Pattern Evidence: Research reveals extensive documentation of identical B58 engine water pump failures between 40,000-60,000 miles across multiple BMW models (X5, X3, 3-series, 5-series) on owner forums. BMW's decision to supersede the part without issuing a recall suggests they are aware of the defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688338September 19, 2025
SEAT BELTS, SEATS, AIR BAGS
Described by BMW as a "malfunctioning passenger restraint system", the sensor detecting weight in the seats is faulty without any external factors. The safety of both minors and adults is placed at risk when a system like this malfunctions, either keeping the airbag on or off. The automatically-adjusting seatbelt is also affected by this. There was a warning message for this displayed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11681132August 17, 2025
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
A drivetrain malfunction warning, chassis warning, auto level suspension was locked, and check engine light was on while driving on the freeway. We made it home safely and parked the BMW X5 45e inside the garage. I plugged in my charger and was not able to charge. Went to start on electric mode/hybrid mode but was not able to turn on. Then I switched to sport mode via gas and engine started but stuttered, and was unable to switch gears from parking to reverse or to forward. Engine continued to shut studded and then engine and electrical completely shut down. I will contact BMW Riverside on Monday.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678308August 4, 2025
ELECTRICAL SYSTEM
Similar to the incident described in [XXX] , BMW has refused to assist with repairs related to defective vehicle cupholders, causing the headunit wiring to short out and fail. This also causes any number of safety items to become unavailable as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11674398July 17, 2025
SERVICE BRAKES, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS
Formally reporting a serious and recurring safety issue with my 2021 BMW X5. Over the past five months, I experienced three separate incidents where the vehicle abruptly stopped while driving, each time displaying a red car warning light on the dashboard. The red malfunction symbol was similar to the below image (found online) Description of the Issue: Each of these terrifying safety experiences occurred while the vehicle was in motion—all on surface streets—the car suddenly came to a jarring and immediate stop on its own without my input or applying the brakes. There were no cars close to or in front of me or debris in the road that would require the car to stop to avoid impact. The red car icon appeared on the dashboard (commonly associated with collision warning or automatic emergency braking systems). The abrupt stop caused my seatbelt to constrict, jarring of my neck and ongoing concern that it will happen again. Thankfully, no accident occurred, but the abrupt stops could have easily caused a serious or fatal accident, especially under highway conditions. My Concerns: This represents a serious safety hazard not only to me and my passengers but to other drivers on the road. The issue appears to be a malfunction in the automated safety or integrated systems, possibly involving the forward collision warning or automatic emergency braking systems. My local BMW dealership (Gwinnett Place BMW) has given me an estimate of $480 to perform 2 hours of scans/diagnostics to inspect the vehicle. No loaner car or transportation offered. This is a known issue and documented in online forums and comments. I have lost confidence and trust in my vehicle and feel unsafe. For a $70k automobile that should not be the case. Requested Action: I am requesting BMW investigate this matter urgently, outline next steps at no charge since multiple reports exist of similar incidents, and provide a clear resolution, including any necessary recalls
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to BMW X5