Volvo S80 Complaints

954 consumer complaints on file.

#10152819March 15, 2006
POWER TRAIN:AUTOMATIC TRANSMISSION, ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY, SUSPENSION:FRONT, FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
1999 VOLVO S80 T6 3/08/06 REPLACED TRANSMISSION ( 75,000 MILES) ( $4,800) 08/05 REPLACE RADIATOR 08/05 REPLACED ETM 04 - REPLACED FRONT SUSPENSION / SWAY BARS / STRUTS/ ETC.. VOLVO UNDER ENGINEERED THE FRONT END OF THIS CAR AND IF YOU GO TO WEB BLOGS IT IS IN ALMOST EVERY 1999 - 2000 S-80 VEHICLE... ITS DISGUSTING THAT THIS CAR IS ALLOWED TO CONTINUE OR FORD/ VOLVO ISN'T HELD LIABLE...*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152668March 14, 2006
FUEL SYSTEM, GASOLINE
I OPERATE A 2000 VOLVO S-80. IT HAS 70,000 MILES. RECENTLY IT HAS UNEVEN ENGINE IDLE PROBLEM ESPECIALLY WHEN A/C IS ON. FOR TWO OCCASIONS, THE CAR WAS STRANDED ON THE FREEWAY BECAUSE THE ENGINE SUDDENLY STOPPED. THE CAR WAS INSPECTED BY THE LOCAL GARAGE, THE THROTTLE ASSEMBLY WAS CLEANED, BUT THE MECHANIC GAVE NO GUARANTEE BECAUSE HE SAID THE COMPUTER WHICH CONTROLS THE THROTTLE MAY HAVE THE PROBLEM AND HE HAS NO REPLACEMENT PARTS. TWO WEEKS LATER, I RECEIVED A NOTICE FROM THE VOLVO STATING MY CAR MIGHT HAVE THE ETS (ELECTRONIC THROTTLE SYSTEM) PROBLEM AND THEY OFFER THE REFUND OF REPAIR COST. I SUBMITTED MY REFUND REQUEST THREE WEEKS AGO BUT RECEIVED NO RESPONSE. CURRENTLY THE CAR STILL HAS THE SAME PROBLEM.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10153040March 9, 2006
VISIBILITY:WINDSHIELD WIPER/WASHER, VEHICLE SPEED CONTROL, SUSPENSION
CONSUMER REQUEST REIMBURSEMENT FOR PREVIOUSLY REPAIRED RECALL FOR ELECTRONIC THROTTLE SYSTEM. *TS THE DEALER REPLACED THE WIPER BLADES. THE STRUT SPRING WAS REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10152090March 7, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED THE VEHICLE LURCHES FORWARD AND STALLS. THE VEHICLE SPEED IS 25MPH AND BELOW WHEN THE STALLING HAPPENS. IT WAS TAKEN TO THE DEALER FOR INSPECTION AND THE ETM WAS DIAGNOSED AS THE PROBLEM. THE ETM WAS REPLACED; HOWEVER THE PROBLEM STILL OCCURS. THE PERFORMANCE REDUCED LAMP ILLUMINATES EACH TIME BEFORE THE VEHICLE STALLS. THE VEHICLE IS CURRENTLY AT THE DEALER FOR ADDITIONAL TESTING.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151449February 28, 2006
VEHICLE SPEED CONTROL
MY CAR STARTED ACCELERATING BY ITSELF. IT WOULD START TO CHUG LIKE IT WAS GOING TO CUT OFF. THERE WAS LITTLE ACCELERATION WHEN I DID GIVE IT THE GAS. I TOOK IT TO THE VOLVO DEALER IN MILWAUKEE AND HAD IT FIXED. THE COST WAS JUST UNDER $979.73. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10151142February 24, 2006
SEAT BELTS:FRONT:RETRACTOR
THE FRONT PASSENGER SEAT BELT IN MY 1999 VOLVO S80 STOPPED WORKING. THE BELT FROZE IN THE RETRACTED POSITION MAKING IT IMPOSSIBLE TO USE. THIS RESULTED IN THE FRONT PASSENGER SEAT BEING UNUSABLE. MY OUT OF POCKET COST TO REPAIR THE PROBLEM WAS $433.45. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150422February 16, 2006
ENGINE AND ENGINE COOLING:ENGINE
CAR STALLED IN THE MIDDLE OF A BUSY INTERSECTION. CAR HAS STALLED INTERMITTENTLY SEVERAL TIMES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10150267February 14, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE IN REVERSE THE VEHICLE ACCELERATED SUDDENLY AND RAN INTO A CACTUS. AS A RESULT, THE VEHICLE SUSTAINED BODY DAMAGE. THE DEALERSHIP INSPECTED THE VEHICLE; HOWEVER THEY WERE UNABLE TO DUPLICATE THE PROBLEM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHICH REPLACED THE REAR PASSENGER DOOR AND PANEL. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE. UPDATED 5/10/2006 - THE DEALER REPLACED THE ELECTRONIC CONTROL MODULE. *NM
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10150186February 13, 2006
VEHICLE SPEED CONTROL
AFTER REPORTING SEVERAL PROBLEMS TRACED TO EMT MALFUNCTION I HAD TO PAY OUT OF POCKET IN EXCESS OF $800.00 TO HAVE EMT REPLACED IN 11/2002. LESS THAN TWO YEARS AFTER THAT, I'VE EXPERIENCED THE SAME PROBLEMS LISTED ON PREVIOUS COMPLAINTS, TO THE POINT WHERE I CONSIDER THE VEHICLE UNSAFE. I HAVE EXPERIENCED NO LESS THAN 15-20 INCIDENTS IN THE PAST 6 MONTHS ALONE. THE LAST ONE BEING JUST YESTERDAY WHERE THE VEHICLE ALL OF A SUDDEN STALLED DOWN TO ABOUT 20 MPH ON THE HIGHWAY FOR NO APPARENT REASON AND THEN BACK TO NORMAL SPEED SEVERAL TIMES. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10149598February 6, 2006
VEHICLE SPEED CONTROL
IN AUGUST 2005, WE TOOK OUR VEHICLE IN FOR ROUTINE MAINTENANCE AT 67500 MILES. I AM THE PRIMARY DRIVER OF THIS VEHICLE AND HAD NOTICED SOME PROBLEMS WHICH WERE DISCUSSED WITH THE SERVICE DEPARTMENT. THIS VEHICLE HAD STALLED AT PARKING LOT SPEEDS AND IT HAD BEEN SPUTTERING AT TAKE-OFF. MY HUSBAND PRESENTED THE SERVICE DEPARTMENT WITH A PUBLICATION FROM THE HIGHWAY SAFETY BOARD WHICH DISCUSSED A PROBLEM WITH THE THROTTLE BODY ON THE VOLVO S80. AS WE WERE HAVING THE SAME PROBLEMS DESCRIBED IN THIS PUBLICATION, MY HUSBAND ASKED THE SERVICE DEPARTMENT TO REPLACE THE THROTTLE BODY ON OUR VEHICLE. THE SERVICE DEPARTMENT WAS AWARE OF THE PROBLEM BUT AS VOLVO HAD NOT ISSUED A RECALL, THEY WERE NOT AUTHORIZED TO REPLACE THIS WITHOUT THE VOLVO WARRANTY COMPANY REVIEWING THIS ISSUE WITH OUR VEHICLE. THE WARRANTY COMPANY DID EXAMINE OUR VEHICLE, BUT DECLINED TO REPLACE THE THROTTLE BODY AT THAT TIME. ON DECEMBER 11, 2005 MY FAMILY (HUSBAND AND TWO CHILDREN, AGES 2 AND 10 MONTHS) WERE TRAVELING HOME TO THE ATLANTA AREA FROM NASHVILLE, TENNESSEE. WHILE DRIVING THIS VEHICLE, I NOTICED THAT IT BEGAN TO ACCELERATE AND DECELERATE AND THEN COMPLETELY LOST POWER. WE WERE TRAVELING ON I-75 SOUTH AT INTERSTATE HIGHWAY SPEEDS AND WERE ABLE TO GET TO THE SHOULDER OF THE ROAD WHEN THIS HAPPENED. UNFORTUNATELY, WE HAD TO PULL OVER ONTO THE LEFT SHOULDER AS THE TWO RIGHT LANES WERE IN A CONSTRUCTION ZONE. WE WERE THEN ENDANGERED BY TRAFFIC MERGING TO THE LEFT WHICH IN SOME CASES ATTEMPTED TO PASS ON THE LEFT SHOULDER. WE HAD TO HAVE THE CAR TOWED TO NALLEY VOLVO IN MARIETTA, GEORGIA WHICH WAS APPROXIMATELY 34 MILES FROM WHERE WE ORIGINALLY BROKE DOWN. AS THIS HAPPENED ON A SUNDAY EVENING AND NO RENTAL CAR BUSINESSES WERE OPENED, WE THEN HAD TO GET A TAXI TO TAKE US THE REST OF THE WAY TO OUR HOME. ON MONDAY MORNING, MY HUSBAND SPOKE WITH THE SERVICE DEPARTMENT ABOUT WHAT HAD HAPPENED. THE PROBLEM WAS DIAGNOSED AS A DEFECTIVE THROTTLE BODY. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148905January 28, 2006
VEHICLE SPEED CONTROL
ENGINE SHUT DOWN ON NUMEROUS OCCASIONS WHILE DRIVING ON THE HIGHWAY. NO STEERING RESPONSE OR POWER BRAKES TO HELP TO STOP THE CAR. VERY DANGEROUS! THE ELECTRONIC THROTTLE MODULE (ETM) ON 1999 VOLVO S80 WAS REPLACED AT THE COST OF 843$. *AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148330January 23, 2006
VEHICLE SPEED CONTROL, EQUIPMENT:ELECTRICAL
2001 S80, MULTIPLE FAILINGS OF THE ELECTRONIC THROTTLE MODULE. THIS HAS HAPPENED REPEATEDLY OVER THE LAST 2 WEEKS. TOO MANY TIMES TO COUNT. CAR W/O NOTICE WILL NOT ACCELERATE BEYOND 20 MPH, IDLES ROUGHLY. HAS ALMOST CAUSED SEVERAL ACCIDENTS.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148313January 22, 2006
VEHICLE SPEED CONTROL
VEHICLE STALL WITHOUT WARNING. ALMOST CAUSE AN ACCIDENT. DEALER REFUSE TO ACKNOWLEDGE THE PROBLEM AND STATED THAT EVERY IS FINE. SEND ME BACK WITHOUT ANY WORK DONE. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147731January 13, 2006
ELECTRONIC STABILITY CONTROL:AUTOMATIC (ASC), ENGINE AND ENGINE COOLING:ENGINE, SERVICE BRAKES, HYDRAULIC
DT*: THE CONTACT STATED THE ABS, TRACTION CONTROL, CHECK ENGINE, AND TOTAL BRAKE FAILURE LIGHTS ILLUMINATE AT DIFFERENT TIMES. THERE IS A NOISE THAT SOUNDS AS IF THE ABS IS ACTIVATING. THE VEHICLE HAS NOT BEEN SEEN BY THE DEALERSHIP OR AN INDEPENDENT REPAIR SHOP. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147442January 11, 2006
VEHICLE SPEED CONTROL
DT*: THE CONTACT STATED WHILE STOPPING AT A RED LIGHT THE VEHICLE STALLED WITH NO WARNING. THE ENGINE WAS RESTARTED AND AGAIN STALLED. THE VEHICLE WAS TOWED TO A LOCAL DEALERSHIP WHERE THE VEHICLE WAS INSPECTED. THE DEALER DETERMINED THAT THE THROTTLE BODY NEEDED CLEANING AND THE SOFTWARE UPDATED. AFTER THE REPAIRS WERE MADE THE VEHICLE WAS SOLD.*AK
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147391January 10, 2006
VEHICLE SPEED CONTROL
IN MID 2005, I STARTED HAVING PROBLEMS WITH MY VOLVO S80 (YR 2000) IDLING AT STOP LIGHTS. THE IDLE WOULD FLUCTUATE FROM 400 TO 1100 RPMS. AT TIMES THIS WOULD CAUSE MY CAR TO DIE. WHILE IT WAS A NUISANCE AT STOP LIGHTS, IT STARTED TO FLUCTUATE AT HIGHER RPMS AND THREE TIMES WHILE ON THE INTERSTATE GOING APPROXIMATELY 55 MPH THE CAR DIED AND I HAVE TO PUT IN NEUTRAL AND RESTART WHILE IN RUSH HOUR TRAFFIC. I TOOK TO SERVICE PLACE AND THEY DID A DIAGNOSTIC, AND REMOVED AND CLEANED THE THROTTLE BODY BEFORE REPLACEMENT. THE FOLLOWING CODES WERE FOUND IN THE ECM 9160, 9150, 904C 903F 9040 AND 130A. AFTER THEY RESET THE FAULTS AND REMOVED AND CLEANED THE THROTTLE BODY, THEY TEST DROVE THE CAR AND THE SAME IDLE AND (AND IT DIED) PROBLEMS EXISTED. THEY REPLACED THE THROTTLE BODY ACTUATOR ASSY, UPGRADE ENGINE MANAGEMENT SOFTWARE TO WORK WITH NEW ACTUATOR. SINCE THEY HAVE REPLACED THE ELECTRONIC THROTTLE BODY I HAVE HAD ZERO IDLING PROBLEMS TO DATE. I HAVE ALL COPIED OF MY PAPERWORK IF NEEDED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10148674January 9, 2006
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
CONSUMER WAS REFUSED RENTAL VEHICLE WHILE 2001 VOVLO S80 WAS HAVING RECALL WORK DONE. CONSUMER HAS HAD PROBLEMS WITH FAULTY FUEL SENDING UNIT. *TS ****NO ANSWER REQUIRED*** THE CONSUMER STATED IT TOOK 4 TIMES TO FINALLY GET A WINDOW LIFT MOTOR REPLACED. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147296January 9, 2006
VEHICLE SPEED CONTROL
WHEN MERGING ONTO HWY. CAR LOST POWER WHILE TRYING TO ACCELERATE TO ENTER LANE. CAR BEHIND ME ALMOST HIT ME AND SWERVED INTO THE OTHER LANE WHERE HE WAS ALMOST HIT BY ANOTHER CAR. THE ELECTRONIC THROTTLE SYSTEM OF MY CAR FAILED. VOLVO IS REPLACING THESE PER AN EXTENDED WARRANTY. HAD I KNOWN ABOUT THIS PROBLEM, I WOULD HAVE HAD THE CAR REPAIRED BEFORE THERE WAS A PROBLEM. I HAD TO HAVE THE CAR TOWED AND WAS THEN TOLD THIS WAS A COMMON PROBLEM WITH THIS CAR. WHY HAS THERE BEEN NO RECALL. I AM THE ONLY PRIVATE OWNER OF THIS VEHICLE, HAVING PURCHASED IT FROM A DEALERSHIP. YET WHEN I CALLED VOLVO ABOUT THIS PROBLEM, THEY FOUND MY NEIGHBOR'S CAR IN THEIR DATABASE, BUT NOT MINE. I FEEL THERE ARE OTHERS BEING PUT AT RISK DUE TO THE AUTOS THROTTLE SYSTEM FAILURE. I HAVE SEEN A LETTER SENT TO A TELEVISION STATION STATING THAT THESE CARS HAVE A PROBLEM THEY CALL, "LIMP HOME MODE" . WELL, MINE WAS ALMOST "DEAD IN THE ROAD MODE" I HOPE THERE ARE NO DEATHS DUE TO THIS PROBLEM. I HAVE HAD MY CAR FIXED, BECAUSE I COULD NOT DRIVE IT UNLESS I DID. I WILL NOT PURCHASE ANY MORE VOLVOS, DUE TO THE OMISSION OF THE TRUTH CONCERNING THIS VEHICLE. THANK YOU. BRENDA TILLEY. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10147035January 5, 2006
SUSPENSION:FRONT:CONTROL ARM
AN S80, 2003 NEW, LOST THE RIGHT FRONT WHEEL WHEN THE BALL JOINT FAILED AT 27,000 MILES. VOVLVO REPLACED THE RIGHT AND LEFT FRONT BALL JOINTS UNDER WARRANTY. THEY SAID THIS HAPPENS SOMETIMES. HAD WE NOT BEEN ON A LOCAL ROAD TRAVELLING 20 MPH THERE COULD HAVE BEEN SERIOUS INJURY. THE STEERING PROBLEM HAS EXISTED SINCE 3/05. THE VOVLO DEALERSHIP SAID, IN MARCH OF 2005 THE STEERING PROBLEM WAS DO TO A LOOSE HOSE CONNECTION WHICH THEY CORRECTED. THE CAR CONTINUED TO STEER, FROM TIME TO TIME, LIKE IT WAS PLANING. CROWN VOLVO OF CHAPEL HILL NC IS THE DEALER. THEY HAVE OFFERED TO TAKE OVER THE LAST TWO LEASE PAYMENTS IF I BUY A NEW VOLVO. *NM
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10146673January 1, 2006
ELECTRICAL SYSTEM
VEHICLE DEFECT MAKE: VOLVO YEAR: 1999 MODEL: S80 NATURE OF PROBLEM: CHECK ENGINE LIGHT IS ON AND VOLVO TECHNICIAN DIAGNOSES THE PROBLEM AS A DEFECTIVE ELECTRONIC THROTTLE CONTROL MODULE WHICH I FOUND LATER TO BE A COMMON PROBLEM WITH VOLVOS. THE DEALERSHIP ESTIMATED THE REPAIR TO BE $850 PLUS THE COST OF THE DIAGNOSIS ($82.00). I REFUSED TO AUTHORIZE THE REPAIR AND SOUGHT ALTERNATIVES. PRESENTLY, THE CAR'S CHECK ENGINE LIGHT IS STILL ON AND THE CAR IDLES ROUGHLY AND SUFFERS FROM POOR GAS MILEAGE BUT CONTINUES TO START AND RUN. AS THIS IS AN APPARENT PROBLEM WITH VOLVOS AS I WAS TOLD BY OTHER MECHANICS, I FELT THAT THIS DEFECT SHOULD BE THE RESPONSIBILITY OF VOLVO RATHER THAN MYSELF. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S80