Volvo S60 Complaints (2015)

60 consumer complaints on file.

#11773886October 27, 2026
ENGINE
Low Engine Failure with a 🐢 and had it repaired back in September '25 that costs me over 7k. Now it's worse and doing the same thing with 145k miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11773507October 25, 2026
AIR BAGS
Vehicle temperature started to overheat, pulled the car off the road and saw water vapor coming from the engine area and turned the car off. All airbags then deployed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11764934September 17, 2026
ENGINE
The contact owns a 2015 Volvo S60. The contact stated that on several occasions, the vehicle hesitated while starting. Upon starting, the vehicle shuddered, vibrated, lost power, and entered Limp mode. The contact stated that while driving at various speeds on several occasions, the vehicle stalled. The vehicle was restarted after each failure; however, after the last occurrence, the vehicle took longer to restart. The check engine warning light blinked on several occasions. The vehicle was driven to the contact's residence and later taken to an independent mechanic for diagnosis. The contact was informed that the engine had failed, and the piston rings or the engine needed to be replaced. The failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740292May 27, 2026
ELECTRICAL SYSTEM
The contact owns a 2015 Volvo S60. The contact stated while driving at an undisclosed speed, the vehicle stalled and lost motive power. No warning lights illuminated. The contact was a certified mechanic. The contact stated that the failure occurred when the outside temperature was too hot or too cold. The dealer was made aware of the failure. The contact was informed that the failure was a known failure with the vehicle. The contact inspected the vehicle and noticed that an unknown fuse on the battery cable that was extremely hot. The contact replaced the unknown fuse. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 128,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734068April 27, 2026
ENGINE
On 4/6/2026 At about 2:30 p.m. my son [XXX] stated that he started the car and was in the process of driving out of the parking lot when he saw smoke coming thru the vents in the car. My son [XXX] stated that he got out the car and opened the hood and the car was on fire. [XXX] stated that he called the fire department and they came and put out the fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11704171December 10, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2015 Volvo S60. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle had consumed 3 quarts of oil after driving 2,100 miles. Additionally, the contact stated that the low oil pressure warning light only illuminated after the vehicle had consumed over 3 quarts of oil. The dealer was notified of the failure; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that an unknown related extended warranty would not be extended to repair the vehicle. The failure mileage was approximately 90,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663339May 28, 2025
ENGINE AND ENGINE COOLING
The contact owns a 2015 Volvo S60. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and had flashed off and on while driving at highway speeds. The contact stated that the vehicle also stalled on several occasions. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the engine cylinders were faulty, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628340December 2, 2024
ENGINE
Requesting reimbursement from Volvo Cars USA for a known defect in the engine’s piston rings. This defect has resulted in excessive oil consumption and necessitated costly repairs. Volvo reached a legal settlement in May 2023 regarding this defect—which affects the piston rings, pistons, and/or piston heads in certain 2013–2016 models. I never received a recall notice or any communication from the company informing me of the issue and the extension of warranty for my car. Had I received a letter before the expiration of the 8-year extended warranty, I would have had the opportunity to have the oil consumption test performed and the piston ring repair completed, all at no cost to me per Volvo quality notice P10207. Vehicle: •Year/Model: 2015.5 Volvo S60, VIN [XXX] •Current Mileage: 92,850 •Purchase: Purchased new in 2015 from Volvo of Princeton, NJ (Princeton Volvo) and delivered at the factory in Gothenburg, Sweden May 2023 then shipped to Princeton Volvo in July 2023. •Maintenance History: The vehicle has been consistently serviced at either the Princeton Volvo dealership or at a local AAA-approved repair center. Defect Timeline (for details and costs incurred see full letter attached) 1.[XXX] (47,044 miles): “low oil” light came on. 2.April 2019–November 2024: oil additions needed each 750 to 1,000 miles. 3.September 01, 2023: Replaced oil trap. 4.January 8, 2024 (83,582 miles): Stage 1 oil consumption test. 5. January 29, 2024: Failed stage 2 of oil consumption test. Needed piston ring repair. 6.January – June 2024: Volvo Princeton and Volvo USA refused to cover full costs of repair. 7. November 2024: Piston rings replaced. Total Costs Incurred to Date: $1,431.68 Total Costs Incurred and Anticipated Costs: $2,065.68 I respectfully request full reimbursement from Volvo Cars USA for expenses incurred and anticipated due to this issue, totaling $2,065.68. Thank you for your attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11608500August 14, 2024
FORWARD COLLISION AVOIDANCE: WARNINGS
City Safety Is randomly Malfunctioning. Vehicle will aggressively apply brakes when there are no objects in front of the vehicle. This has happened in town and on a long driveway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11580623April 2, 2024
ENGINE
Alternator belt shredded and got underneath the timing belt causing the engine timing to go off and severe engine damage that I will now have to total the car or spend $13-15K to replace. The car stalled after leaving a stop sign so I wasn't going fast. I spoke to my local mechanic and he had another Volvo S60 T5 in his shop with the same issue showing up but that owner was lucky enough to not have the engine destroyed in the process. From what he is saying is that every other car has some kind of timing belt protection that the Volvo S60 is missing. In searching the Internet this is a very common issue that occurs. I registered a complaint with Volvo today.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11577907March 17, 2024
UNKNOWN OR OTHER
THE REAR DOOR LOCK IS NOT CLOSING THE DOOR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11568364January 28, 2024
UNKNOWN OR OTHER, STRUCTURE:BODY
The child safety lock is not engaged. The door latches on the rear right passenger door in my car has failed. It fails to unlock when from the inside. In an emergency situation. Passengers won't be able to exit the vehicle quickly. The Problem can be reproduced and there are current door latch recalls in other models but it needs to extend out these models too. It has not been inspected by police but. again there is a recall for similar models. The recall should extend out to these models. No warning signs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11565220January 12, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
We were driving down the road automatic emergency braking system engaged without warning and for no reason. This has happened before in the past a few times. We feel this is an safety concern and would like to see it addressed. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564518January 10, 2024
ENGINE
Was on the highway driving back from my aunts house and there were no signs anything was wrong with my car. No alerts on the dash besides low pressure tire which I filled up. As I was almost home, an alert randomly came up with “no oil pressure” along with a check engine light flashing and the car started shaking (misfiring). The car flashed a message that said something about reduced engine performance. As my car was shaking fervently, it was slowing down and failed to accelerate, causing cars behind me to almost crash. No oil pressure can also cause fires and put my life at risk. I had much time left to get my oil changed and yet I had oil message lights come on. I believe this is a problem with the piston rings that are defective & there was just recently a class action suit of them. I have had to continually fill up oil, and now I suddenly have an engine that does not work and threatened the safety of myself and others on the road. Volvo diagnosed the issue as being valve broken, piston ring damage, along with other engine components. I now need an entire new engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11564623January 10, 2024
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
The contact owns a 2015 Volvo S60. The contact stated while driving at approximately 35 MPH, the steering became extremely difficult to turn and several warning lights were illuminated. The contact stated that the "City Safety" light was illuminated and drove over a manhole cover on the road and the vehicle stopped. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the two EV batteries needed to be replaced because the battery could not be charged and tested out at 9 percent. The contact was advised that the battery failure caused the failure of several vehicle systems. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11547908October 3, 2023
ENGINE
I have been getting a low oil level sign in my car after 5 months of doing an oil change. This is not the first time this has happened. It is suspected this may be a oil consumption issue and not an oil leak as there is no visible sign of oil leak. The oil consumption problem has been confirmed by an independent mechanic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11539045August 17, 2023
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I bought the car as a CPO on 9/25/19 32,860 mi. On 8/19/20 at 50,052 the engine failed. The oscillating dampener rubber separated causing serpentine belt to break, which in turn got caught in timing belt which caused that to break which then caused bent valves and valves to break. The failure was sudden. Had I been on the interstate I’d be severely injured or dead. I was told that I needed a new engine but they could not find one. I was told they would completely re-build my engine. In the end they replaced the cylinder head and starter under warranty. I was never told they didn’t re-build the engine and also used “ good parts” from the old engine. In the following months I had the car in the Volvo shop (Hendricks Volvo Charleston, SC). At 50,277 miles the check engine light showed a problem with the Cam shaft position sensor on 9/3/20. They claim to have driven the car 100 miles and cleared the code w/no repairs. On 3/18/21 w/ 64,485 miles, I took the car into the dealer because it was running and idling rough. They found no codes and they aligned the car. “Couldn’t duplicate”. The right rear door never shut properly and I was repeatedly told it was fine. Re-call on latches. Seat belts on rt rear passenger constantly was stuck. This is where my granddaughter’s car seat was placed. I’ll have to skip some. At 110,024 miles on 11/28/22 the car continued to have bad gas mileage and heavy oil use. I was told that the EGR leak detection pump was faulty and was replaced. At 113,706 miles on 1/19/2023 the cam VVT Solenoid was changed. Cause of poor gas mileage stated. On 3/29/23 at 116,790 miles replaced brakes and had aligned. Service tech noticed oil under the car underside while up on racks. Said it would be fine until next service. On 7/3/23 the engine failed again on the road and was towed to the dealer. Apparently a fuel injector failed causing gas to spray into the engine causing it to lose compression. I’ve never been given a clear answer. Records of services done.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11532786July 17, 2023
UNKNOWN OR OTHER, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Driver side door latch does not clamp to secure the door.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11526285June 9, 2023
SERVICE BRAKES, HYDRAULIC
The contact owns a 2015 Volvo S60. The contact stated while driving 20 MPH, the brake pedal was depressed however, the vehicle failed to stop until the brake pedal had gone to the floorboard. There was no warning light illuminated. The vehicle was taken to the dealer, but no failure was found. The contact stated that the failure had occurred several times. The contact stated that the vehicle was test driven by the mechanic however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure and no assistance was offered. The failure mileage was approximately 14,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11521534May 11, 2023
ENGINE, ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2015 Volvo S60. The contact stated that the vehicle was previously repaired under an unknown recall for the catalytic converter and the check engine warning light illuminated. The contact was told that the catalytic converter had failed due to an oil leak. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle had exceeded the mileage. There was no additional assistance provided. The approximate failure mileage was 165,000. The dealer stated the vehicle is outside of the warranty perimeters by mileage.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60