Volvo S60 Complaints

1,272 consumer complaints on file.

#10610925July 16, 2014
VEHICLE SPEED CONTROL, FUEL SYSTEM, GASOLINE
LOSS ACCELERATION IN THE VEHICLE ON THE HIGHWAY AT 60 MPH. THE CAR WOULD NOT SPEED UP AND CONTINUE TO SLOW DOWN BUT NEVER CAME TO A FULL STOP. I WAS NOT ABLE TO GO PASS 40 MPH IN THE CAR AND ACCELERATION WAS SLOW. FIRST TIME IT HAPPEN, THE DEALER SAID THROTTLE BODY AND OIL COLLECTION SYSTEM NEEDED TO BE REPLACED. I REPLACED BOTH. IT HAPPENS AGAIN, TOOK IT TO A DIFFERENT PERSON, THE MECHANIC SAID FUEL CONTROL NEEDED TO BE REPLACED. I REPLACED THAT. IT HAPPEN THE THIRD TIME AND TOOK IT TO DEALER AND HE INFORMED ME THE SPARK PLUGS. I REPLACED THAT. NOW, THE PROBLEM IS STILL HAPPENING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610605July 15, 2014
EQUIPMENT:APPLIANCE:AIR CONDITIONER
TL* THE CONTACT OWNS A 2012 VOLVO S60. THE CONTACT STATED THAT THE AIR CONDITIONER UNIT EMITTED AN ABNORMAL CHEMICAL SMELL THAT CAME THROUGH THE VENTS. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED DAILY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS STATED THAT MOLD WAS BUILT UP ON THE EVAPORATOR THAT WAS CONNECTED TO THE AIR CONDITIONER. THE SOFTWARE WAS UPGRADED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 41,000. UPDATED 08/19/14*LJ
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10610083July 12, 2014
ELECTRICAL SYSTEM
VEHICLE DRIVER INFORMATION MODULE (DIM) STOPPED WORKING WHILE VEHICLE WAS TRAVELING ON THE ROAD AT APPROXIMATELY 45 MILES PER HOUR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10609526July 10, 2014
ENGINE AND ENGINE COOLING
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH ATTEMPTING TO COME TO A COMPLETE STOP, THE VEHICLE STALLED WITHOUT NOTICE. THE CONTACT MENTIONED ALL LIGHTS ON THE CONTROL PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO MADE THE CONTACT AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10607880July 2, 2014
ELECTRICAL SYSTEM
WHILE DRIVING AT APPROX. 70 MPH, MY CAR EXPERIENCED A COMPLETE AND TOTAL ELECTRICAL AND POWER FAILURE. QUITE LITERALLY, THE CAR'S ELECTRICAL AND POWER SYSTEM STOPPED OPERATING WHILE DRIVING AT HIGHWAY SPEED. I BROUGHT THE CAR TO THE VOLVO DEALER WHO CHARGED ME $1911 TO REPLACE A CIRCUIT BOARD ASSUMING THIS WOULD RESOLVE THE PROBLEM. SINCE THIS ORIGINAL OCCURRENCE IT HAS BEEN REPEATED ANOTHER 3 TIMES, AGAIN AT HIGHWAY SPEED BY BOTH MY WIFE AND MYSELF. I HAVE SUBSEQUENTLY CALLED VOLVO BUT WAS TOLD IT IS NOT AN IDENTIFIED ISSUE ALTHOUGH IT IS EXTREMELY DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10604730June 20, 2014
AIR BAGS
ON JUNE 1ST ANOTHER CAR FAILED TO YIELD THE RIGHT OF WAY AND PULLED INTO THE PATH OF MY CAR WHILE I WAS GOING APPROX. 45MPH. I HIT THE BRAKES HARD AND TURNED TO THE LEFT TO TRY AND AVOID THE CAR AND COLLIDED WITH THE OTHER CAR. I ESTIMATE THE SPEED OF AT LEAST 35MPH AT IMPACT. THE RIGHT FRONT OF THE CAR TOOK MOST OF THE IMPACT. THE DRIVER'S SIDE AIRBAG DEPLOYED AND BURNED MY ARM. HOWEVER, DESPITE THE PASSENGER SIDE OF THE CAR TAKING THE BRUNT OF THE IMPACT, THE PASSENGER AIRBAG DID NOT DEPLOY. THE PASSENGER (MY FIANC) WAS DIAGNOSED WITH A CONCUSSION DUE TO THIS ACCIDENT. I BELIEVE THE CONCUSSION MAY HAVE BEEN AVOIDED HAD HER AIRBAG DEPLOYED. VOLVO INSPECTED THE VEHICLE AND CLAIMS FOR SOME REASON THE AIRBAG SHOULD NOT HAVE DEPLOYED IN THIS ACCIDENT. I SUSPECT THEY ARE COVERING UP A PRODUCT FAILURE. I HAVE PICTURES OF THE ACCIDENT AVAILABLE FOR YOUR REVIEW. *TR
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#10604873June 20, 2014
ELECTRICAL SYSTEM, AIR BAGS
I STARTED MY CAR AND WHERE IT TELLS YOU IF SOMETHING NEEDS TO BE DONE TO CAR IT SAID AIRBAG WARNING URGENT SERVICE NEEDED. THEN LATER WHILE DRIVING ALL THE GAUGES STOPPED WORKING. NOW THE GAUGES DON'T WORK AT ALL. PLUS WHEN DRIVING AND TURNING A CORNER THE CAR STALLS NOW THIS HAS BEEN HAPPENING FOR A COUPLE YEARS NOW. PLUS A COUPLE YEARS AGO ALL MY HEAD LIGHTS BURNT OUT AT ONCE THEN THEY ONLY LASTED A COUPLE DAYS HAD TO BUY MORE THAT HAPPENED 5 TIMES IN ONE YEAR STILL HAVE NO BRIGHTS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10598471June 16, 2014
VEHICLE SPEED CONTROL
RECALL DONE. BUT VOLVO SAYS THROTTLE BODY IS BAD,SHOULD THROTTLE BODY BE COVER? IF PROGRAM IS EXTENDING SWEEPS INTERNALLY OF POTENTIOMETERS. WOULD THAT WEAR PATTERN FROM PREVIOUS PROGRAM WEAR OUT POTENTIOMETERS,CREATING MORE PROBLEM WITH THROTTLE BODY.VOLVO SHOULD REPLACE THROTTLE BODY.AS A SAFETY ASSURANCE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10597662June 11, 2014
UNKNOWN OR OTHER
HANDBOOK SAYS TRANSMISSION NEVER HAS TO BE SERVICED BUT IT IS NOT. TRANSMISSION SLIPS GOING IN AND OUT OF THIRD GEAR CAUSING HIGH REVS AND TIRE SPIN. I AM A MECHANIC AND THE ISSUES ARE THAT THIS TRANSMISSION HAS NO ACCESSIBLE FILTER WITHOUT REMOVING THE ENTIRE TRANSMISSION AND NUMBER 4 SERVO CAP IS FAULTY DUE TO THE CAP BEING MADE OF ALUMINUM AND WASHER MADE OF STEEL.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10596307June 5, 2014
ELECTRICAL SYSTEM
CAR WAS IN PARK AND RUNNING WHEN ELECTRICAL WIRES TO THE WINDSHIELD WIPERS CAUGHT FIRE. THE BUNDLE OF WIRES ARE HOUSED IN A RUBBER TUBE. MY UNDERSTANDING IS RUBBER IS QUITE FIRE-RESISTANT. THERE HAVE BEEN 5 RECALLS ON THIS MODEL, TWO WHICH WERE RELATED TO ELECTRICAL FIRES. NEITHER APPLIED TO THIS PARTICULAR CAR FIRE. LOCAL VOLVO DEALERSHIP WANTS NOTHING TO DO WITH THE SITUATION; THEY SEND US TO CORPORATE CUSTOMER SERVICE AND THEY, IN TURN SEND US BACK TO THE LOCAL DEALERSHIP . SERVICE MANAGER SAID HE WAS NOT A KNOWLEDGEABLE FIRE INSPECTOR AND SUGGESTED THAT WE HIRE AN EXPERT IN THAT FIELD. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10595673June 2, 2014
VEHICLE SPEED CONTROL, ENGINE
TL* THE CONTACT OWNS A 2008 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED. AFTER RESTARTING THE ENGINE THE VEHICLE OPERATED NORMALLY. THE VEHICLE STALLED A SECOND TIME WHILE THE CONTACT WAS SITTING AT A TRAFFIC STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE MOTOR THROTTLE WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10594976May 29, 2014
ELECTRICAL SYSTEM
DASHBOARD WENT DEAD WHILE DRIVING. GAS METER, RPM, EVERYTHING WENT DEAD. THE DASH LIGHTS LATER CAME ON FOR A WHILE, BUT THE SPEEDOMETER WENT BACK TO 40 MPH. NOTHING WORKS PROPERLY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10592768May 20, 2014
EQUIPMENT:OTHER:LABELS
THE TIRE AND LOADING INFORMATION LABEL ON MY CAR HAS 4 ERRORS. 1. LOADING: THE INSTALLED LABEL SPECIFIES A WEIGHT LIMIT OF 1200 LBS. THE CORRECT WEIGHT LIMIT FOR MY CAR IS 1025 LBS. 2. FRONT TIRE SIZE: THE INSTALLED LABEL SAYS MY CAR HAS 215/50R17 FRONT TIRES. THE CAR HAS 235/45R17 TIRES. VOLVO CARS OF NORTH AMERICA CONFIRMED THAT 235/45R17 TIRES WERE INSTALLED AT THE FACTORY. 3. FRONT TIRE PRESSURE: THE INSTALLED LABEL SPECIFIES 38PSI, BUT THE CORRECT VALUE IS 36PSI. 4. REAR TIRE SIZE: SAME ERROR AS FRONT TIRE SIZE. 5. REAR TIRE PRESSURE: SAME ERROR AS FRONT TIRE PRESSURE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10588205May 13, 2014
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING A VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL PRESSURE SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 127,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10586898May 6, 2014
WHEELS, ENGINE, ELECTRONIC STABILITY CONTROL (ESC), VEHICLE SPEED CONTROL
FRONT LEFT WHEEL CAME OFF WHEN PULLING INTO GARAGE ONLY HELD ON BY 1 AND 1/2 BOLTS. 4/13/2014 ENGINE STOPPED RUNNING WHILE PULLING INTO TRAFFIC CAR STALLED IN MIDDLE OF THE ROAD. 5/5/2014 DYNAMIC TRACTION CONTROL SYSTEM FAILED AND CAR BECAME UNCONTROLLABLY WOBBLY WHILE DRIVING. 5/5/2014 OTHER NUMEROUS FAILURES INCLUDE: BREAKDOWN OF THE COLLISION AVOIDANCE SYSTEM. CRUISE CONTROL DOES NOT WORK. FRONT CAMERA MALFUNCTION-TOOK IT IN TO GET FIXED STILL NOT WORKING CORRECTLY. AC BREAKS DOWN ? TOOK IT IN TO GET FIXED STILL HAS PROBLEMS. SPEED LIMIT CAMERA DOES NOT WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10585460April 29, 2014
ENGINE, VEHICLE SPEED CONTROL
ON THE APRIL 23, 2014, MY HUSBAND WAS DRIVING AND THE CAR SHOT OUT AT HIGH SPEED HE DIDN'T REALIZE WHAT HAPPENED. ON APRIL 24, 2014, I WAS IN MY DRIVEWAY IN PARK AS I PUT THE CAR IN DRIVE TO SLOWLY ENTER MY GARAGE THE CAR TOOK OFF AT HIGH SPEED TIRES SPUN LEFT TIRE MARKS ON MY PAVEMENT AND I HIT THE BRAKES IN GARAGE NOT TO HIT THE WALL AND LEFT MARKS THERE AS WELL. MY NEIGHBORS WERE RIGHT THERE WITNESSING THIS SCARY EXPERIENCE. I CALLED CORPORATE IMMEDIATELY THEY TOLD ME TO GET IT TO THE DEALER. I CALLED A TOW TRUCK AND THE TOW TRUCK DRIVER TOOK THE KEYS TO SLOWLY DRIVE IT ONTO THE FLATBED AND THE CAR AGAIN TOOK OFF AT HIGH SPEED AND ALMOST FLEW OFF THE TOW TRUCK! ALSO, THE PUSH BUTTON START BUTTON WAS A PROBLEM, EVER SINCE THE VEHICLE WAS LEASED. UPDATED 07/28/14 UPDATED 10/27/2014 *JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574348March 24, 2014
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 2014 VOLVO S60 T6. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING AS THE CONTACT RELEASED THE CRUISE CONTROL FUNCTION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT A NEW PROGRAM NEEDED TO BE DOWNLOADED INTO THE CENTRAL COMPUTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 500 AND THE CURRENT MILEAGE WAS 2,200.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10574239March 23, 2014
FUEL SYSTEM, GASOLINE
I HAD MY CAR IN FOR SERVICE AT MY LOCAL VOLVO REPAIR SHOP AND ONE OF THE ITEMS I HAD THEM INVESTIGATE WAS A FUEL SMELL. THEY TOLD ME THEY FOUND A CRACK AT FUEL PUMP SENDER RH SIDE. THEY MENTIONED THAT THEY THOUGHT THERE WAS A RECALL FOR THIS SINCE THEY HAVE SEEN IT SEVERAL TIMES BEFORE AND THAT I SHOULD CONTACT MY VOLVO DEALER. I JUST LOOKED ONLINE AND FOUND WHAT THEY WERE TALKING ABOUT BUT IT DOES NOT LIST THE STATE WHERE I PURCHASED THE VEHICLE AND RESIDE? I AM THE ORIGINAL OWNER. THE REPAIR SHOP DID CONTACT A LOCAL DEALER FOR ME AND THE DEALER TOLD THEM THAT THERE WAS NOT A RECALL? I GUESS I WILL CONTACT SOME OTHER LOCAL DEALERS THIS WEEK AND SEE WHAT THEY SAY? SEEMS LIKE COLORADO SHOULD HAVE BEEN ADDED TO THIS RECALL EVERY STATE NEAR US IS PART OF IT. IF I CANT GET THIS REPAIRED UNDER THE RECALL WHAT SHOULD I DO TO MAKE IT HAPPEN? *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10573007March 17, 2014
STRUCTURE:BODY:DOOR, LATCHES/LOCKS/LINKAGES
MY DAUGHTER WAS SITTING IN THE BACK SEAT OF THE CAR AND WHEN WE STOPPED TO GET OUT HER DOOR WOULD NOT OPEN. I THOUGHT MAYBE THE CHILD SAFETY LOCK WAS LOCKED SO I WENT ON THE INTERNET TO FIND A REASON FOR THE DOOR NOT ABLE TO OPEN FROM THE INSIDE BUT WOULD OPEN FROM THE OUTSIDE. WHILE RESEARCHING WHAT THE PROBLEM IS I HAVE NOTICED MANY OTHER PEOPLE HAVING THE VERY SAME PROBLEM I AM HAVING. THE SAFETY PROBLEM IN THIS IS IF I WERE TO GET IN A ACCIDENT AND MY DAUGHTER NEEDED TO GET OUT OF THE CAR FROM THAT SIDE SHE WOULD NOT BE ABLE TO. THE PROBLEM APPEARS TO BE A PIECE OF PLASTIC BREAKS LEAVING THE HANDLE FROM THE INSIDE IN-OP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10568325March 10, 2014
FUEL SYSTEM, GASOLINE
SOME MODELS HAD A RECALL NOTICE FOR A CRACKED LEAKING FUEL PUMP (PE09039). THIS EXACT THING HAPPENED TO OUR CAR. VOLVO REFUSES TO COVER THE VEHICLE UNDER THE RECALL BECAUSE IT WAS NOT SOLD IN ONE OF THE STATES LISTED. THE PROBLEM IS EXACTLY AS DESCRIBED IN THE RECALL. THIS DOESN'T SEEM RIGHT AS IT THE SAME SAFETY ISSUE. PLEASE LET ME KNOW IF THERE IS ANY FURTHER ACTION THAT CAN BE TAKEN. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S60