Volvo S40 Complaints (2005)

69 consumer complaints on file.

#11578530March 20, 2024
POWER TRAIN, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated the failure was due to the pump electrical module being located out of the vehicle. The contact spoke with the dealer. The contact referenced The manufacturer was made aware of the failure. The approximate failure mileage was 170,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11546212September 24, 2023
SEAT BELTS
The drivers seat belt does not lock/latch in properly. Everytime I enter the vehicle I reach for my seat belt and buckle myself, well so I thought I did. When I insert the belt it seems as though its buckles however once I start to drive the belt comes un done and it i always have to pull over to put it back on becsuse it locks the seat belt so I'm not able to just buckle back in.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11403711March 18, 2021
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE HAD FAILED DUE TO RUSTING AND CORROSION. THE FUEL PUMP ELECTRONIC MODULE WAS REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER 08V033000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE FAILURE LISTED IN THE RECALL. ADDITIONALLY, THE VEHICLE WAS ORIGINALLY SOLD IN THE STATE OF CALIFORNIA AND HAD BEEN DRIVEN IN THE STATE OF MICHIGAN THE PAST 6 YEARS. THE FAILURE MILEAGE WAS 147,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11329021June 15, 2020
FUEL/PROPULSION SYSTEM
I WAS TOLD BY SHOP THAT WORK ON MY CAR THAT WERE A RECALL ON THE PVC VAUL ON THE 2005 VOLV S40 2.4. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11327540June 6, 2020
UNKNOWN OR OTHER, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
MY VEHICLE SHUTS OFF WHILE IM DRIVING IT. I TOOK IT TO A MECHANIC 3 TIMES AND WAS ADVISED ITS AN ISSUE WITH THE FUEL PUMP. I WAS ALSO ADVISED THIS IS AN KNOWN ISSUE WITH THIS PARTICULAR VEHICLE AND WAS PROVIDED A NHTSA CAMPAIGN ID # 08V033000. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11246021August 23, 2019
ENGINE
2005 VOLVO S40 ENGINE AIR CONDITIONING MALFUNCTIONED. WHEN THE PROBLEM FIRST BEGUN THE CAR WOULD BE COOL AT START THEN GET WARM UNTIL ONE DAY THE AIR CONDITIONING JUST QUIT WORKING. I READ ON THIS FORUM AUTHORIZED VOLVO DEALERSHIP ADMITS THIS IS A COMMON PROBLEM IN THIS YEAR/MAKE/MODEL. THE COMPRESSOR CLUTCH OR COMPRESSOR OR BOTH REQUIRED REPLACING. IN A CLASS ACTION LAWSUIT [FILED 2018] HTTP://WWW.AUTOPARTSCLASS.COM/INDEX.PHP INCLUDES THE 2005 VOLVO S40 AIR CONDITIONING UNIT: [SEE BELOW] CONGRATULATIONS! YOUR 2005 VOLVO S40 IS INCLUDED IN THE FOLLOWING AUTO PARTS CASES: IN RE: INSTRUMENT PANEL CLUSTERS IN RE: AIR CONDITIONING SYSTEMS IN RE: ALTERNATORS IN RE: WINDSHIELD WIPER SYSTEMS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11194589April 8, 2019
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE REAR PASSENGER SIDE CARPET WAS SATURATED WITH WATER AFTER A RAIN STORM. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,506. *BF CONSUMER STATED THE FOAM IN ROOF OF CAR IS CRUMBLING AND ROOF SEAMS ARE NO LONGER INTACT.*JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11111793July 16, 2018
FUEL/PROPULSION SYSTEM
THE CAR STARTS MISSING THEN STALLS OUT AFTER ABOUT 30MILES OF DRIVING IT STALLED IN THE MIDDLE OF CROSSING A 4 LANE AND WAS ABOUT HIT.IT IS THE PEM THEY HAD RECALLS ON THEM BUT NOT MY CAR FOR SOME REASON
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11111408July 15, 2018
FUEL/PROPULSION SYSTEM
EVERY TIME I DRIVE THE CAR IT MISSES A LITTLE THEN IT JUST SHUTS DOWN LIKE IT'S NOT GETTING ANY FUEL THE CAR DON'T DIE JUST WON'T PULL OUT I TRIED TO CROSS A 4 LANE AND IT STALLED IN THE FIRST LANE AND I ABOUT GOT HIT IN THE SIDE IT ALSO DID IT ON THE INTERSTATE.IT IS VERY DANGEROUS I WAS TOLD IT'S THE ELECTRONIC FUEL MODULE,OR PEN AND WAS TOLD THERE WAS A RECALL ON THAT PART ALL OVER THE INTERNET BUT VOLVO SAID THERE WASN'T WHICH I DON'T BELIEVE WHY WOULD THE INTERNET SAY THERE WAS ON LIKE 5OR NOTRE WEBSITES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11057910January 2, 2018
ENGINE
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHEN THE VEHICLE WAS STARTED, THERE WAS AN ABNORMAL VIBRATION COMING FROM THE VEHICLE. UPON OPENING THE HOOD AND CHECKING THE ENGINE, THE CONTACT NOTICED THAT THE PASSENGER SIDE OF THE ENGINE WAS FRACTURED. THE CONTACT STATED THAT THE FRACTURE WAS ALONG THE TOP SIDE OF THE ENGINE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 43,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11054027December 11, 2017
ENGINE
CAR LOOSING POWER AND ENGINE MISSING AT HIGHWAY SPEEDS. ENGINE LIGHT WENT ON. FAILURE OF FUEL PRESSURE MONITOR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11041947November 1, 2017
ENGINE
CAR IS ALL OF A SUDDEN ACCELERATING ON ITS OWN. IT HAS HAPPENED A HANDFUL OF TIMES WITHIN THE LAST MONTH. I WILL MAKE A TURN, LET OFF THE GAS PEDDLE AND THEN THE CAR WILL JUST JERK FORWARD REVVING UP THE RPMS AND ACCELERATING ON ITS OWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10985089May 12, 2017
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
FUEL PUMP CONTROL MODULE (PEM) FAILS DURING WET CONDITIONS. CAR WILL CRANK LIKE NORMAL BUT WILL NOT START. LET CAR DRY OUT FOR A FEW DAYS AND THEN THE CAR WILL RUN NORMAL AGAIN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10955043February 16, 2017
FUEL/PROPULSION SYSTEM
TAKATA RECALL. I HAD ENGINE STUTTERING AT HIGH SPEED. MY FUEL PRESSURE SENSOR FAILED AND WAS REPLACED. I QUESTION WHY IT IS NOT COVERED UNDER THE NHTSA CAMPAIGN I.D. # 07V226000 WHICH IS FOR THE SAME PART IN THE SAME ENGINE BUT IN 2004 S60 MODELS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10954466February 14, 2017
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE KEY WAS UNABLE TO TURN AND PREVENTED THE VEHICLE FROM STARTING. THE BATTERY WAS TESTED BY AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10944096January 10, 2017
AIR BAGS, SEAT BELTS
[THIS IS A PREVENTATIVE COMPLAINT. NO INJURY SUSTAINED.] THIS CAR HAS A FAILED PASSENGER SEAT SENSOR THAT WHEN DEPRESSED ACTIVATES THE PASSENGER SIDE AIR BAG. THIS VEHICLE ALSO HAS A DRIVER SIDE SEAT BELT THAT CLICKS AND THEN CAN BE PULLED OUT OF THE LOCKING HARNESS. THESE ITEMS ARE NOT RECALLED BY THE MANUFACTURE BUT, IN MY OPINION, SHOULD BE FOR CUSTOMER SAFETY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10861933April 28, 2016
AIR BAGS, ELECTRICAL SYSTEM, SUSPENSION
TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE STEERING WHEEL AND ENTIRE VEHICLE BEGAN TO SHAKE AS THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE AIR CONDITIONER, RADIO, HORN AND SUN ROOF FAILED TO FUNCTION WHEN ACTIVATED. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECM, FRONT AXLES AND STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10821737January 22, 2016
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT LET THE VEHICLE DECELERATE AND THEN SLOWLY DROVE THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THAT THE BRAKE VACUUM PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V474000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10816978December 30, 2015
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10721259May 24, 2015
ELECTRICAL SYSTEM
INSERTED KEY IN IGNITION AND NOTHING HAPPENED. COMPUTER READS KEY ERROR TRY AGAIN. KEPT TRYING AND FINALLY STARTED. NEXT DAY SAME THING HAPPENED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Volvo S40