Volkswagen · Model Report
Showing safety data for the 2002 model year only.
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
The tire sidewall blew out. We were driving at 65 mph on an interstate highway in an urban area and had to change the tire in the triangular space between the highway lanes and an exit - very dangerous. These were sold as 60,000 mile tires, and this tire had 20,200 miles on it. It was maintained at proper pressure. Conditions were clear, dry, summer weather in Albuquerque, NM. The problem has not yet been confirmed by the service center, but we will be taking the damaged tire there because it is still under warranty. Tire size: 195 / 65 R 15
No injuries · No fire · No crash
Certain conditions cause the electrics door locks to not function. When this happens, it is not possible to exit the car from the inside as the door handles are not operative creating a trapped situation potentially leading to injury or death if the case of a fire.
No injuries · No fire · No crash
WHILE DRIVING AT ABOUT 45 MILES PER HOUR, THE SIDE CURTAIN AND SEAT BOLSTER AIRBAGS DEPLOYED ON THEIR OWN. THERE WAS NO IMPACT TO THE VEHICLE THAT PRECEDED THIS INCIDENT. THE AIRBAGS SIMPLY DEPLOYED BY THEMSELVES. THIS SEEMS TO BE A RECURRING PROBLEM WITH THIS GENERATION OF VOLKSWAGENS: HTTP://WWW.CARCOMPLAINTS.COM/VOLKSWAGEN/GOLF/2002/SEAT_BELTS_AIR_BAGS/AIR_BAGS-SIDE_WINDOW.SHTML
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN GOLF WITH A TDI ENGINE. THE CONTACT STATED THAT THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT HAD TO POP THE CLUTCH AND KILL THE IGNITION, BUT THE ENGINE CONTINUE TO OPERATE UNTIL THE VEHICLE RAN OUT OF FUEL. THE CONTACTS MECHANIC INSPECTED THE VEHICLE AND STATED THAT THE TURBO CHARGER SEALS WERE NOT LEAKING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 53,000. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS 2002 VOLKSWAGEN GOLF. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START IN RAINY WEATHER. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE IGNITION COIL WOULD NEED TO BE REPLACED. THE CONTACT LOCATED A VOLUNTARY MANUFACTURERS RECALL FOR THE FAILURE BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE VOLUNTARY RECALL. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 150,000.
No injuries · No fire · No crash