Toyota Tundra Complaints

6,958 consumer complaints on file.

#11762695September 8, 2026
AIR BAGS
The contact owns a 2004 Toyota Tundra. The contact stated that while driving approximately 60 MPH during heavy rains, the vehicle hydroplaned and spun several times before the front end crashed into a guardrail. The driver's side air bag failed to deploy, causing the driver's chest to strike the steering wheel. A bystander assisted the contact out of the vehicle and called an ambulance and the Police. The contact was transported to the emergency room by ambulance. The contact sustained internal and external bruises to the chest, stomach, and bruises to the armpit from the seat belt. The vehicle was towed to a tow yard. The failure mileage was approximately 185,000. The VIN and license plate were unavailable.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11762931September 8, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
I am the owner of a 2024 Toyota Tundra. My vehicle is subject to open NHTSA Recall No. 25V-332, for which I received notification. It has now been over a year since this recall was issued, and no remedy has been made available to me. I have contacted my Toyota dealership and was told the remedy parts are not yet available' or 'no timeline could be provided. This unresolved recall leaves my vehicle in a condition that Toyota itself has identified as an unreasonable safety risk. The prolonged delay in providing a free remedy, as required under the National Traffic and Motor Vehicle Safety Act, is my basis for this complaint. I am requesting that NHTSA investigate Toyota's compliance with recall remedy timelines and follow up on the status of parts/software availability for this recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762603September 7, 2026
ENGINE
I am writing to formally express my concern regarding my 2024 Toyota Tundra, VIN [XXX], and the engine recall involving certain 2024 Tundra vehicles. I am very concerned about the possibility of engine damage or failure related to machining debris and the potential for loss of power while driving. This is a major safety concern, especially considering the vehicle is relatively new. I would like Toyota to confirm whether my VIN is included in the recall and provide a clear explanation of the required repair or inspection process. If my truck is affected, I am requesting that the recall repair be completed as soon as possible at no cost to me. I would also like confirmation regarding whether Toyota will provide a loaner or rental vehicle if my truck must remain at the dealership for an extended period, particularly if an engine replacement is required. Please document this complaint and provide me with a written response explaining the next steps and expected resolution. Thank you, [XXX] Vehicle: 2024 Toyota Tundra VIN: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762486September 6, 2026
ENGINE
This is a follow-up to my NHTSA complaint tracking #11742382, filed June 5, 2026, before my recall repair. I'm filing again because the repair is now complete and it has raised two new concerns: undocumented warranty coverage on the replacement engine, and an unresolved question about whether a second, broader recall applies to that replacement engine. 1. Recall repair completed. Under NHTSA Campaign 24V381000 (Toyota internal 24TA07, filed 2024-05-30), my original engine was replaced with a new OEM assembly (part 04004-23370, serial [XXX], 2026 manufacture date, incorporating the post-April-2024 revised bearing design) at Teton Toyota, Idaho Falls, ID, June 19 to 22, 2026 (repair order [XXX], mileage in/out 28,252/28,281). Toyota's own recall record states the replacement unit was inspected clean. I have no reason to doubt that specific finding; my concern is what happens after. 2. Replacement engine's warranty terms were left undocumented. The repair order lists the warranty "Policy Number" covering the new engine as TBD. As of this filing, Toyota National (1-800-331-4331) has not given me a written answer to a direct question: does the replacement engine carry a new 5-year/60,000-mile powertrain warranty starting from the June 22, 2026 install date, or only the remainder of my original factory warranty? A safety recall remedy that leaves the owner without documented knowledge of what protection they actually received is, in my view, an incomplete remedy under 49 CFR Part 573's recordkeeping and notification requirements. Owners should not have to chase this down themselves months after the repair. 3. A second, broader recall may or may not apply to my replacement engine, and Toyota has not said which. NHTSA Campaign 25V767000 (Toyota internal 25TA14, filed 2025-11-06) expands the same underlying defect population to additional 2022-2024 Tundra, Lexus LX, and 2024 Lexus GX vehicles, with a remedy of inspecting the #1 main bearing via inspection software and INFORMATION REDACTED PURSUANT TO THE FREEDOM OF I
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762388September 5, 2026
ENGINE
REPEATED CATASTROPHIC ENGINE FAILURE / FAILED RECALL REMEDY. My 2022 Toyota Tundra suffered a complete engine seizure and sudden loss of motive power August 30, 2026, creating an immediate traffic hazard. This is the SECOND time this vehicle has experienced a catastrophic main bearing failure of its twin-turbo V6 engine. The original factory engine was replaced by an authorized Toyota dealership under Safety Recall 24V-381 / 24TA07 in March 2025. The defect should have been resolved. However, the replacement crate engine provided by Toyota carried the exact same engineering vulnerability as the original engine. It was manufactured prior to Toyota's mid-2026 engineering revision, which finally introduced a redesigned #1 main bearing to address localized crankshaft pressure stack-up (as noted in subsequent NHTSA filings like 26V-320).Furthermore, the previous engine replacement due to a federal safety recall was entirely withheld and not disclosed to me at the point of sale. Because Toyota replaced a recalled, defective engine with an identically flawed engine block, the initial recall remedy completely failed, leaving the vehicle dangerous and prone to repeated mechanical failure. The vehicle has driven approximately 16 months since the March 2025 replacement. I am demanding that Toyota provide a permanent remedy using the updated, structurally revised 2026 engine components. It is at the Toyota dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762287September 4, 2026
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
The passenger door handle was recently replaced. Inside door handle assembly broke and the passenger was unable to open the door from the inside. Now the driver door handle assembly just broke and I was unable to open the door from the inside. The inability to exit the vehicle from the inside should be a safety recall. Various online forums mention similar issues from other owners. Concern was raised with Toyota but not actions was taken.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761521September 2, 2026
SERVICE BRAKES, POWER TRAIN, FUEL/PROPULSION SYSTEM
Since taking delivery of this brand new 2026 Toyota Tundra Hybrid, I have experienced a persistent shuddering at low speeds, approximately 15 to 25 mph. The shuddering is most pronounced during slow, gradual brake application — the more gently the brake pedal is pressed, the more severe the shudder. It is also present to a lesser degree during acceleration. The issue appears to involve the transition between the regenerative braking system and the conventional friction brakes in the i-FORCE MAX hybrid system. The vehicle was taken to an authorized Toyota dealership for a first repair attempt. Tires were rebalanced and inflated to 40 PSI, exceeding the manufacturer's recommended specification. The repair order was closed with the notation "test drove and vibration is gone." This conclusion is inaccurate. The shuddering was only partially reduced — the root cause was not identified or resolved. The safety concern is significant. I have found myself instinctively adjusting how I apply the brake pedal to avoid triggering the sensation. A vehicle that changes the way its driver brakes is dangerous. A second repair attempt is being scheduled at the selling dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761574September 2, 2026
ENGINE
I was leaving work one day and pulled out in traffic and my engine stalled causing the car behind me to slam on their brakes to avoid crashing into me from the back my engine completely stalled and I got no gas to accelerate I then went to the dealership and stated what happened and they told me they could not help me at the moment so I wrote a letter to corporate Toyota and they put me in the loaner in the following week. I’ve been in the loaner for the past four months with no remedy on my truck and no answer to when it’s gonna be fixed or this problem is gonna be resolved.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761613September 2, 2026
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES
The contact's husband owns a 2022 Toyota Tundra. The contact stated that the key fob failed to unlock the front driver’s side door. Due to the failure, the contact was forced to lock the front driver’s side door manually after exiting the vehicle. The contact was forced to enter the vehicle through the front passenger’s side door and crawl over to the front driver side seat. The vehicle was taken to the dealer, and an estimate was provided for the repair. The vehicle was not repaired. The failure mileage was approximately 75,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761232September 1, 2026
SUSPENSION
The alignment has consistently been an issue since I purchased the truck in March 2025. I've had the wheels aligned 3 times since I purchased it. I took it in for the 25000 mile service and it's out of alignment again. I've never had a vehicle go out of alignment let alone 4 times in 18 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761247September 1, 2026
ENGINE
The contact owns a 2024 Toyota Tundra. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the short block engine needed to be replaced. The vehicle was repaired. The contact researched and became aware of an unknown recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 20,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761331September 1, 2026
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM), STRUCTURE:BODY:BUMPERS:ACTIVE SHUTTERS/GRILL
The contact owns a 2023 Toyota Tundra. The contact stated that while starting the vehicle, the check engine, Auto Start/Stop, and another unknown warning light illuminated. The message "Grill Shutter Malfunction Low Voltage" was displayed. The vehicle was taken to the dealer, who determined that the battery sensor, alternator, and ECU had short-circuited. The dealer replaced the battery sensor, alternator, and ECU; however, the failure persisted with the check engine and another unknown warning light illuminated. The vehicle was taken back to the dealer, who determined that the grill shutter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 57,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761432September 1, 2026
ENGINE
I am filing this complaint regarding my Toyota Tundra and Toyota Safety Recall 24TA07. My vehicle was previously affected by this engine recall, and Toyota replaced the engine as the recall remedy. The replacement engine has now failed with the same or substantially similar engine issue that resulted in the original recall and engine replacement. I am very concerned that a replacement engine installed as the remedy for a safety recall has experienced the same type of failure. This vehicle has now experienced engine failure involving two separate engines: the original recalled engine and the replacement engine installed by Toyota under Recall 24TA07. The Vehicle is at the Toyota dealer. I am requesting that NHTSA investigate whether replacement engines being installed under this recall may also be susceptible to the same or a similar defect. I would also like this complaint documented because I am concerned about the safety and reliability of the vehicle and whether Toyota's recall remedy adequately corrected the original safety issue. I am requesting that Toyota provide a permanent remedy for my vehicle at no cost to me. I would also like information regarding my rights and available remedies given that the engine replaced under the safety recall has now failed, including whether this repeat failure may qualify for additional manufacturer remedies or protections under applicable warranty or state lemon law.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761022August 31, 2026
POWER TRAIN
Full engine failure, Rod bearing 1 failed due to debris in engine after first oil change was completed at 9500 miles. Truck at 13,000 miles at failure Safety of all vehicle occupants was put at risk. vehicle came to sudden hault and had full loss of propulsion. Failure of engine was confirmed by Matick Toyota No warming lamps of mesages, small whine came from engine for ~1 mile before failure
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760854August 31, 2026
ELECTRICAL SYSTEM
THIS OWNER'S 2008 TOYOTA TUNDRA 5.7L DASHBOARD LIGHTS LIT UP INCLUDING THE VSC, TRACTION CONTROL, CHECK ENGINE AND 4 LO. THE 4 LO LIGHT WAS FLASHING. THE TRUCK WOULD NO LONGER GO PAST 3000 RPM ON SOME OCCOSIANS. VEHICLE CODE READER IDENTIFIED THIS VEHICLE'S SECONDARY AIR INJECTION SYSTEM REQUIRED REPAIR AND THAT THIS IS A KNOWN DEFECT WITH TOYOTA TUNDRAS. TOYOTA ISSUED AN EXTENDED WARRANTY TO COVER VEHICLES IMPACTED BY THIS DEFECT, CODE p0418. THIS IS A SAFETY ISSUE DUE TO LOSS OF POWER ESPECIALLY IF RANDOM AND UNKNOWN TIMES WHEN PULLING INTO TRAFFIC NORMALLY WOULD ALLOW TIME TO ACCELERATE SAFETLY BUT DUE TO THE SAIS MALFUNCTIONING IT COULD ACCELERATE SLOWLY AND CAUSE A COLLISION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760872August 31, 2026
WHEELS, SUSPENSION, STEERING
This 2022 Toyota Tundra TRD Pro is subject to Limited Service Campaign 24TD01 for premature tire wear, caused by a factory front toe/camber angle defect acknowledged by Toyota. The vehicle received the campaign remedy (front alignment adjustment and tire replacement) in May 2024, but the same wear pattern on the front tires reappeared and has continued for over a year, documented across multiple dealership visits. A dealership technician found abnormal front tire wear on three separate occasions (August 2025, September 2025, and March 2026) but never recommended a front-end alignment despite Toyota's own campaign identifying alignment/camber as the root cause. As of August 2026, the right front tire tread had worn down to approximately 1/32 inch, an unsafe condition, and only then was an alignment finally recommended in writing for the first time. The vehicle also had a documented brake rotor warping issue (front rotors) as early as November 2024, causing a braking vibration above 40 mph that has persisted. The recurring tire wear presents an ongoing safety risk due to reduced traction and control, particularly relevant given the near-bald tire condition reached before any alignment correction was recommended by the servicing dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760816August 30, 2026
ENGINE
Total engine failure in v35a at 65- 70 mph which dealer has confirmed was due to main bearing failure. Inability to accelerate vehicle in heavy traffic lead to extreme unsafe situation. No warning lamps came on until after the vehicle completed stopped running. Both the manufacturer and the NHTSA are well aware of the continued problems with these engines and the unsafe failure. The only warning ‘hybrid system malfunction “( which has nothing to do with dealer performed diagnostic of metal in oil pan failed main bearing) came on after the truck was inoperable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760653August 29, 2026
ENGINE
"I am writing to report a latent safety concern regarding my 2022 Toyota Tundra Hybrid equipped with the V35A-FTS engine. Non-hybrid 2022–2024 Tundras sharing this exact V35A engine block architecture are subject to active safety recalls (NHTSA Campaign IDs: 24V381, 25V767, and 26V320) due to crankshaft main bearing failure caused by manufacturing debris and oil film disruption. My hybrid model utilizes the same V35A internal engine short-block assembly and suffers from the exact same potential for main bearing contamination and catastrophic internal engine lockup. Although the hybrid battery provides limited low-speed auxiliary power, a sudden internal combustion engine failure or lockup while operating at highway speeds or under heavy towing loads creates a severe safety hazard, including immediate loss of throttle response, power steering loss, and high risk of rear-end collisions. My engine has not failed yet, but the presence of known, unaddressed manufacturing debris within the V35A assembly presents an ongoing safety risk. I request that NHTSA expand its safety defect investigation into the V35A engine architecture to explicitly include the i-FORCE MAX Hybrid models." Toyota has been lacking in taking responsibility that these exact same engines manufactured on the same assembly line are also subject to the same issues. I believe it is a significant safety issue especially since in the event of an engine failure the hybid system will NOT be strong enough to move the vehicle to the side of the road safely. In addition, when the powertrain warranty expires next year for the 2022 models, owners will be left holding the bag for a $30,000 dollar engine replacement when toyota knows this could and has happened. Currently, Toyotas way of evaluating engines consist of hitting the engine with a hammer to check if its affected or not. What?? Please investigate this and hold toyota responsible, all engines manufactured on that assembly line in AL should be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759976August 27, 2026
ENGINE, EXTERIOR LIGHTING
2023 Toyota Tundra CrewMax SR5 4x4, VIN [XXX], approximately 79000 miles. This vehicle has two open safety recalls. Both show "Recall Incomplete, remedy not yet available" on NHTSA's VIN lookup as of XXX NHTSA 25V322 (Toyota 25TB06) was filed XXX for moisture intrusion causing both reverse lamps to fail. Toyota's remedy notice estimated that the remedy would begin to be available in the fourth quarter of 2025. That estimate is now approximately nine months past and no remedy is available for this VIN. NHTSA 25V767 (Toyota 25TB14) was filed XXX for machining debris causing number one main bearing failure, with symptoms including engine knocking, rough running, no-start, and loss of motive power. Interim notices were mailed XXX. The remedy has been postponed and remains unreleased for this VIN, with rollout phased by vehicle age. I am filing because the manufacturer has been unable to provide a remedy for either recall within a reasonable time. I have owned this vehicle since XXX and have been unable to obtain repair for a known safety defect for more than fifteen months on the first campaign. I am requesting that NHTSA record this delay and address the manufacture's remedy timeline. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759732August 26, 2026
VISIBILITY/WIPER
My Toyota Tundra's windshield spontaneously cracked while I was sitting at a stop in the vehicle. The crack started below the hood line and there are huge number of Tundra owners having the same issues with Tundras manufactured from 2022 - 2026. Toyota refused to acknowledge the issue but it is widespread on the internet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Toyota Tundra