Mercedes-Benz Sprinter Complaints (2019)

116 consumer complaints on file.

#11774076October 27, 2026
ELECTRICAL SYSTEM
“My 2019 Mercedes-Benz Sprinter was subject to NHTSA Recall 23V-100 / Mercedes campaign 2023040008 (tel:2023040008) involving the interior blower fuse circuit and risk of overheating/fire. Mercedes performed the recall remedy by relocating/replacing the blower fuse circuit. Approximately two years later, the relocated fuse connection overheated and burned, damaging the fuse terminal and fuse box. The dealer has confirmed the affected circuit/part is defective and the fuse box now requires replacement. Mercedes has offered only partial goodwill assistance rather than full coverage. I am concerned the recall remedy did not effectively correct the original safety defect and that the vehicle could be at risk of another overheating event or fire.”
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749207July 8, 2026
ELECTRICAL SYSTEM, STEERING, AIR BAGS
Description of Incident:The electronic ignition module suffered a sudden failure due to unsealed manufacturer water intrusion, leaving the vehicle completely stranded with an immediate safety hazard. Component failed & available for inspection: Electronic Ignition Switch (EIS) module / Ignition Control Module. Yes, it is available for inspection. Safety risk: The sudden failure causes an immediate safety hazard by leaving the vehicle completely stranded with no way to shift the transmission into neutral to pull it out of harm's way. Confirmed by dealer/independent center: NO, the vehicle has not been towed to a shop yet due to the high cost of repairs. Inspected by manufacturer/police/insurance: NO Warning lamps or symptoms prior: There were no warning messages. The ignition system simply went completely dead without warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744228June 15, 2026
POWER TRAIN
While taking off from a traffic light the rear end came apart on the inside of the differential. Has someone been in a dangerous area or remote areas like where I have to work it could have been a serious issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725258March 18, 2026
ENGINE
My 2019 Mercedes-Benz Sprinter 170 High Roof caught fire suddenly and without warning. The vehicle was in its original condition and had not been modified in any way. The fire escalated quickly and resulted in a total loss. The cause of the fire is unknown. This incident raises serious safety concerns.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11690596September 30, 2025
UNKNOWN OR OTHER
Hello, I recently took the vehicle to the official Mercedes Benz dealership for recalls and they have completed all of them , Also have proof of correction document I can send it over, please update the system Thanks
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11687809September 17, 2025
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated that while operating the vehicle, the front driver’s seat belt message remained displayed. The vehicle was taken to the local dealer, who diagnosed that the seat belt buckle was faulty. The seat belt assembly was replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 19V788000 (SEAT BELTS). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 58,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11675885July 24, 2025
ENGINE
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact received notification of NHTSA Campaign Number: 22V796000 (POWER TRAIN), and the vehicle was taken to a local dealer, where the vehicle was repaired under recall, and the contact was informed that the knock sensor was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 98,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11661916May 19, 2025
STRUCTURE:BODY, UNKNOWN OR OTHER
I was driving and the vehicle began to smoke through the air conditioning vent and within 30 seconds flames of fire entered the vehicle and the vehicle was completely burned. I never received any recall regarding that malfunction and never saw any signal that this would happen. I almost caught in fire due to the imminent flames. That's was my vehicle for work and I lost everything, materials, tools, merchandise and everything. I am struggling financially due to this situation. I tried to open the side door to take my belongings but it was locked. There's were not any previous symbols or indicators of the malfunction.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11635683January 13, 2025
STEERING
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated while driving at approximately 60 MPH, the vehicle lost power steering functionality. The contact stated that an unknown warning light was illuminated. The contact turned off and restarted the vehicle and the power steering functionality returned. The vehicle was towed to an independent mechanic who diagnosed that the power steering hose had detached and had lost power steering fluid. The vehicle was repaired, and the mechanic informed the contact that there were metal shavings found in the power steering pump. The contact was referred to the dealer for assistance. The vehicle was towed to a dealer who diagnosed and determined that the power steering pump needed to be flushed and refilled. The contact was informed that metal shavings were found in the power steering pump. The vehicle was in the process of being repaired. The contact researched online and related the failure to NHTSA Campaign Number: 21V241000 (Steering); however, the VIN was not included in the recall. The manufacturer was not informed of the failure. The failure mileage was approximately 22,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11634134January 4, 2025
POWER TRAIN
At high altitudes (it's happened over 5000ft and not under that) while in 4x4 mode, the car occasionally just simply does not respond to throttle input while in drive. This is usually from a start while shifting from park or reverse into drive, but there is zero power which has now been dangerous a few times for us while on inclines or near traffic. It eventually goes away after shifting back and forth to park/reverse/neutral and trying to rev the engine. But it's inconsitent, infrequent and not particularly easy to reproduce.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633974January 3, 2025
ELECTRICAL SYSTEM, VISIBILITY/WIPER
When driving on a cold rainy day, I turned on defrost heat to clear my windscreen. No heat came out. AC, fans and zone select worked fine, but no heat. So I had to stop repeatedly on a narrow road to wipe windshield. After reviewing user forums, some pointed to a known problem with these Sprinter vans. Apparently the actuator servo motor that controls the heater flap can get stuck at limit positions and fail. This explains why my heater is stuck on cold. Also mentioned in forum, there is also a manufacturer software update that prevents this issue by keeping the actuator servo motor from moving to the very last position (cold or hot). This simple preventive fix was never offered to us during our warranty period. Some forum users went further with a modification to servo motor shaft - apparently this fixed the undesirable flexing on heater flap. Now that the servo motor has failed and I no longer have any heat, I do recognize that there were warning signs. I now recall there were occasional instances where my temperature select did not have any effect until I drove the temperature all the way up or down. I believe this was the servo motor getting stuck briefly but it became unstuck before it completely failed. I feel this can be a grave safety issue because of individual circumstance. Most times it may be an annoyance. But in certain conditions (as I experienced) it will be a significant impediment to driver visibility. It also exposed me to roadside risk when I stopped to wipe inside of windshield.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627375November 25, 2024
ENGINE
The engine seized at 37,500 miles. It is available for inspection. The problem was confirmed by the dealer. There has been no inspections by manufacturer or any other representative. There were no warning signs. Manufacturer offered no warranties.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624407November 10, 2024
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The active distance assist inoperative appears when using the cruise control. This comes on when no traffic in front of the vehicle for 1 hour or less. Also Active Brake Assist functions limited - see operators Manual To reset: follow another vehicle for 5 minutes. This is Very Very Very frustrating and UNSAFE. This function should not automatically shut off. I paid a lot of money to try and figure out the problem. This is VERY UNSAFE for this feature of instantly shut off for no reason and is dangerous. Please fix this with a software update and allow me to download it at my dealer for no charge. Not happy as I use my cruise control on long trips in the USA.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11613946September 11, 2024
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, VEHICLE SPEED CONTROL:CRUISE CONTROL
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated that on several occasions when the vehicle was started, the message "Distance Assistance Currently Unavailable" was displayed. The contact also stated that while driving on several occasions at various speeds, the cruise control was activated, but the option failed to appear on the screen. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The manufacturer was notified of the failure. The failure mileage was 8,149.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11600124July 8, 2024
VEHICLE SPEED CONTROL
Depressing accelerator while in 'D'rive or 'R'everse does not increase RPM or power and vehicle does not move. While keeping the pedal pressed to the floor it will then slowly RPMs will increase and it will creep forward. It will rev. while in park or neutral.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11597997July 1, 2024
LANE DEPARTURE: ASSIST, LANE DEPARTURE: WARNING
The Crosswind Assist feature of this van has caused near-accidents for me several times over the last few years, and especially last week while on vacation. It is a KNOWN problem with owners with no known recall as far as I am aware. It is an extremely abrupt maneuver that has pushed me halfway into the other lane during just moderate winds. I am a professional driver, having pulled double 45' tractor trailers and am very skilled in my driving. This crosswind assist feature is DANGEROUS, and I can barely retain control when it kicks in. It applies the brakes on the side that is getting pushed by the wind and tries to correct the steering all at the same time. It is way too abrupt. The tendency of the driver at that point may be to correct this as it is happening. If this was on icy roads the results would be catastrophic. It is hazardous even on dry roads. This is not a feature that Mercedes allows to be disabled. How can NHTSA allow this hazardous feature to not be included in a recall? I am scared for my safety and for that of my family. I have discussed this with the dealership with no affirmation that there is a problem. I am putting this in your hands with a Certified letter to go out to both your Executive Director Jack Danielson as well as Mercedes US CEO, Dimitris Psillakis requesting action for all Sprinter van owners that have this Crosswind Assist feature. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11588842May 15, 2024
SEAT BELTS, AIR BAGS
Front Left Malfunction Warning Light came on randomly one day. There was an airbag symbol that appeared on the dash as well. The vehicle has not been in any collisions. Mercedes USA says seatbelt components are warranted against defects in workmanship and materials for 10 years, regardless of mileage. I called Mercedes USA and now they say it is not covered because we are past mileage limit and because we are past 3 years and don't have an extended warranty, they won't cover repair. Others have had this issue too listed on Sprinter-Forum where they have diagnosed it's from a cheap connector on the seats and unplugging the harness, adding dielectric grease, reset light, replace seatbelt solves the problem. This fix takes 30 minutes and they charge over $800 to repair. This seatbelt is original to the vehicle and if it's malfunctioning, this is a safety issue that should be addressed and covered for replacement or reimbursement if repairs have already been made. Some have noted that the shape of the seatbelt connector connection is causing this issue. Please keep me informed of progress with this. We will be paying $800 to fix this issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11588751May 14, 2024
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2019 Mercedes-Benz Sprinter 2500. The contact stated when the vehicle started, the instrument panel failed to display properly, with the check engine warning light illuminated. The contact was concerned that the vehicle was hazardous to drive and could be severely injured if the instrument panel failed to display warning features as needed. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 91,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11586577May 2, 2024
STRUCTURE, VISIBILITY
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated that while driving at an undisclosed speed, the passenger’s side bunk window detached and fell off. The contact stated that the window was a frameless window and was sealed with adhesive. The contact researched and discovered an unknown recall; however, the contact VIN was not associated with the recall. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 9,100.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11585870April 29, 2024
TIRES:TREAD/BELT, TIRES
Tire size: 245/75 R16 LT 120/116Q Tire: Kumho Crugen HT51 I was driving on [XXX] and had only been driving about 30 minutes. I heard a sound and could see rubber from rear passenger side tire separating from the tire. I assumed I had a flat tire and immediately pulled over to the right shoulder of highway. When I stepped out I was surprised to see a lot of damage due to the tire tread separating and thrashing around on rear passenger side of vehicle. A small section of the rear corner bumper that included a small door panel to get to propane tank was completely gone. There was a jagged hole in another section of bumper as well. A small section of the body panel had been torn off and was laying by tire. Also, tire tread had damaged side of RV with black rubber markings and scratches. There are some small dents too. The tire was NOT flat, but the tread was almost entirely gone leaving the tire without any rubber tread. This is a 2020 Mercedes Benz Airstream Interstate 19. So this is an RV Camper Van. Had this been the front tire, I believe it would’ve resulted in an accident or injury. Vehicle & tires were inspected by Mercedes Dealership just last June 2023. I’m very concerned that the remaining tires will have the tire tread separate as well. These are the factory tires that were on my vehicle when purchased new. I purchased this vehicle with only 17,500 miles. Vehicle only has 27,473 miles on it now and has only been driven on streets or highways. Tires do NOT show any signs of cracking or dry rotting. I drive vehicle often for weekend trips. So it hasn’t set for any lengthy amount of time to cause damage to tires. I believe these tires are defective and that’s why the tread separated with tires only having about 27,500 miles on them. I believe these tires are rated for 70,000 miles. I’m hoping for an investigation into these tires as I strongly believe they are defective. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Mercedes-Benz Sprinter