Kia Sorento Complaints (2020)

140 consumer complaints on file.

#11773405October 24, 2026
VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
**Suspected Sudden Unintended Acceleration – 2020 Kia Sorento EX V6** On October 24, 2026, the driver of a 2020 Kia Sorento EX V6 experienced two episodes of suspected sudden unintended acceleration. The vehicle reportedly accelerated unexpectedly while in Reverse (R), causing it to collide with an apartment building. Following the initial collision, the driver shifted the transmission into Drive (D), at which point the vehicle reportedly accelerated forward unexpectedly. According to the driver, both incidents occurred so quickly that she was unable to apply the brakes. The collision caused significant damage to the apartment building, including structural damage requiring reinforcement, and damaged two other vehicles. The airbags did not deploy. No injuries to the driver have been reported. The driver also recalls receiving a previous recall notice for a vehicle component that was not repaired. The specific recall has not yet been identified. The vehicle has been towed and is being preserved for a potential independent investigation, including examination of the Event Data Recorder (EDR). We request that NHTSA review this incident as a possible vehicle safety defect. The cause of the unexpected acceleration has not yet been determined.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11773067October 22, 2026
ENGINE
I bought a used 2020 Kia Sorento LX 2.4L in 2022. It had 15,000 miles on it. AT 50,000 miles I noticed it was consuming oil. I have been changing the oil at 5,000 mile intervals even though the manual calls out to do it every 7,500 miles. I have records of the maintenance for every oil change done on this vehicle. I kept a log and now at 54,740 miles it is consuming 1 quart every 500 miles or so. I took it to the dealer on 10/19/2026 and was told that since I was not the original owner there was no warranty coverage on it. So that nullified the 10 year/100,000 mile warranty. I was told they could do a chamber cleaning for $800.00 and if that failed I would need to replace the engine at an out of pocket cost to me of $9,000.00 to $10,000.00 I have to monitor the oil level constantly to avoid the engine seizing and breaking down in traffic . This auto is used by my spouse to drive my grand kids to and from school. There are no warnings or messages on the oil level so it is driven with uncertainty .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11771803October 17, 2026
VISIBILITY/WIPER, UNKNOWN OR OTHER
This incident occurred on 10/03/26 at approx. 11:45 AM. Location: Squankum-Yellowbrook Rd. (524A) Howell NJ. Temp: 73 F. Road condition: 2 lane rural clear and dry. Description of incident: While driving @ approx. 40 MPH with no on-coming or traffic ahead or behind, the entire right rear passenger window spontaneously imploded, explosively showering the entire rear seat with glass shards. Upon immediately pulling off the road and upon my own examination (and shortly thereafter by responding police) no impact object that could have caused the glass breakage was found. Had there been rear seat passenger(s) at that time undoubtedly that person(s) would have sustained head/face or eye injuries.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11769662October 7, 2026
ENGINE
The contact owns a 2020 Kia Sorento. The contact stated that while driving, there was an abnormal banging sound coming from under the hood of the vehicle and the vehicle shuddered abnormally. The contact stated that the Forward Collision Avoidance warning light was temporarily illuminated. The vehicle was taken to a local dealer where it was diagnosed; however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure. The failure mileage was approximately 34,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767149September 26, 2026
ENGINE, FUEL/PROPULSION SYSTEM, ELECTRICAL SYSTEM
Driving at highway speed, the vehicle began to make a loud rattling noise that came from under the vehicle. A passerby pulled even with my car and began frantically gesturing. After a few seconds of confusion, me daughter said the she thought the man was saying "it's on fire." We pulled over to the shoulder of the road, exited quickly and realized there was fire visible in the engine area, seen through the grill. A good samaritan attempted to suppress the fire with an exstinguisher but moments later, it was fully engulfed.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11765211September 18, 2026
VEHICLE SPEED CONTROL
The contact owns a 2020 Kia Sorento. The contact stated that upon starting the vehicle and shifting into gear with the brake pedal depressed, the vehicle unexpectedly jerked back and forth, accelerated unintendedly, and crashed into the corner plaster wall of a friend's garage, causing plaster to fall onto the front of the vehicle. The vehicle was towed to Caliber Collision to be repaired. The dealer was notified of the failure. Police officers responded to the scene, inspected the vehicle, and filed a report. The failure mileage was approximately 35,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11761230September 1, 2026
UNKNOWN OR OTHER
While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered, and there were no warning lights, messages, noises, cracks, or other indications that the glass was about to fail. Because I was traveling at freeway speed when this occurred, the sudden explosion/shattering of the glass was extremely distracting and created a serious safety concern. I was frightened by the unexpected loud noise and could have lost control of the vehicle. Broken glass from a panoramic sunroof also presents a risk to the occupants of the vehicle and to other motorists. The component that failed was the panoramic sunroof glass. To my knowledge, the failure has not yet been reproduced or confirmed by a Kia dealer or independent repair facility, and the vehicle has not yet been inspected by Kia for the cause of the failure. I am reporting this incident because the sunroof appeared to shatter suddenly during normal highway driving without any prior warning, and I am concerned that this may represent a safety defect.
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#11761097August 31, 2026
AIR BAGS
The contact owns a 2020 Kia Sorento. The contact stated that the front passenger’s side air bag warning light remained illuminated while an occupant was seated in the front passenger’s seat. The dealer was notified of the failure and informed the contact that there were no recalls or warranty associated with the vehicle failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 9,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757589August 18, 2026
ENGINE
My 2020 Kia Sorento stalled and shut off while driving and eventually stopped working completely, requiring it to be towed to a Kia dealership. The dealership first replaced the starter and then the high-pressure fuel pump, but the vehicle still would not operate. After further diagnosis, I was informed that the timing chain had failed/broken and the engine needed to be replaced, with a new engine quoted at approximately $12,000. I am concerned that this type of sudden engine failure and shutdown could create a serious safety hazard, especially if it occurs while driving in traffic or at highway speeds. I am requesting that NHTSA document and review this incident for similar failures involving 2020 Kia Sorento vehicles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753507July 29, 2026
POWER TRAIN
The contact called on behalf of his daughter who owns 2020 Kia Sorento. The contact stated that the vehicle was taken to a dealer for a routine oil change when the contact was informed that there was an unknown issue with the vehicle however, the vehicle was not diagnosed or repaired. The vehicle was taken to a different dealer where it was diagnosed that the transmission fluid was leaking and the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749809July 12, 2026
AIR BAGS, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749302July 9, 2026
STEERING
The contact owns a 2020 Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but the repair was delayed because the manufacturer required information from the dealer, while the dealer claimed to be waiting for a response from the manufacturer. The failure mileage was 19,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741669June 2, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
The vehicle suffered a sudden, severe engine malfunction/misfire while in operation, presenting a serious safety hazard on the road. Following the incident, the vehicle was taken to an authorized dealership service center (Repair Order #XXX), where technicians verbally confirmed that the engine requires a complete replacement due to internal mechanical failure. The catastrophic mechanical failure of the engine directly caused consequential damage to the emissions system, entirely clogging the catalytic converter with unburned fuel/debris. Despite the clear link to the known, systemic defects inherent to the Theta II engine line—which is subject to active federal consent orders, safety recalls, and lifetime warranty extensions—both the dealership and Kia Corporate are refusing to honor the 8-year/80,000-mile Federal Emissions Defect Warranty. The manufacturer is attempting to use the catastrophic failure of their own defective, recalled engine line to evade their legal environmental and safety warranty obligations, leaving the consumer stranded without alternative transportation. This represents a systemic effort by the manufacturer to deflect liability for documented powertrain safety failures onto individual consumers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738870May 19, 2026
ENGINE
Engine is burning oil at a significant rate, when I get my oil changed at the dealers recommendation it is extremely low. I have to replace the oil regularly between oil changes, and there is an exhaust smell. Also lagging when I hit the gas.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738032May 15, 2026
ENGINE
Car is 6 years old less then 100k miles and losing oil and motor problems Went through entire oil change in 1 month Kia unable or willing to assist with any coats I was told by a private garage that the motor in my car should be part of a recall that was already listed for 2021 through 2026 but they’re saying it’s not covered
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733852April 26, 2026
ENGINE
2020 Kia Sorento consuming 1.5 or more quarts of oil every 1,000 miles. Completing oil consumption testing with Kia dealer, which requires I take the car back to the dealer every 1k miles, times, so they can verify the oil levels. Last check, when issue was discovered, vehicle was down to only 1qt of oil after driving only 2k miles from previous oil change. Note: the lambda engine was initially included in the latest Kia class action settlement but was dismissed per the plaintiff’s attorney in that case. However there are numerous reports from a large number of 2020 Kia Sorento owners now with the same issue and running into complete roadblocks in terms of recourse as for most the issue does not begin until they exceed the powertrain warranty. Especially if they’re secondary owners and not the original owner.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733472April 23, 2026
SEAT BELTS
Driver seatbelts randomly unlatches itself while operating vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730918April 13, 2026
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
Oil pressure light would come on and off, dealer said was probably the sensor got it replaced. Came back on the night I picked it back up.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727148March 26, 2026
ENGINE
I own a 2020 Kia Sorento. There is currently a class action lawsuit settlement ongoing. I have been informed that my 2020 Kia Sorento is not eligible while the settlement clearly states the 2020 Kia Sorento is included as part of the settlement. My Kia’s engine did not fail until after the settlement was finalized because I don’t drive a lot anymore and my mileage was just over a 100,000 miles when it started showing problems. It seems to be a new timeline for new claims and I’m still not allowed to file a claim for the same reason. I bought my car new in 2020. If you need additional information, please advise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725785March 20, 2026
ELECTRICAL SYSTEM, ENGINE
My Oil Pressure Switch is diagnosed as faulty by independent service center as well as Kia. Kia is denying coverage. I have found information that it should be covered. My check engine light shows an oil can light.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Kia Sorento