Hyundai Santa Fe Complaints (2023)

205 consumer complaints on file.

#11760160August 27, 2026
ELECTRICAL SYSTEM
Horn stopped working
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11756570August 12, 2026
POWER TRAIN
Subject: Formal Dispute: Warranty Breach and Failure to Repair – 2023 Hyundai Santa Fe Timeline & Facts:11/2/25 (~52,000 miles): I officially reported an intermittent loss of power and severe engine revving (up to 7,000 RPM). This created a severe safety hazard when merging and accelerating from an idle stop.3/28/26 (Under 60k miles): After months of diagnostic delays, Hyundai confirmed the Dual-Clutch Transmission (DCT) needed replacement under the 60,000-mile warranty. A Hyundai Case Manager tracked the issue.Service Delay: Hyundai delayed repairs due to a lack of loaner vehicles, which were grounded for recall updates. Commuting pushed my mileage to 60,218. The Case Manager assured me coverage was locked in because the defect was documented before 60,000 miles.4/8/26: Due to corporate protocol, they ordered a valve body installation instead of a new transmission.8/11/26: The valve body failed. Hyundai delaership resubmitted the transmission replacement request. Corporate denied 100% coverage because the odometer was now over 60,000 miles (60,218). They are offering only 80%, leaving me with a $1,000 plus out-of-pocket expense.Legal & Contractual Position:Hyundai is contractually and legally obligated to cover 100% of this replacement. Under federal and state consumer protection laws, any defect reported prior to warranty expiration must be fully repaired by the manufacturer, even if the final repair occurs after the mileage threshold. The current mileage is a direct result of Hyundai’s internal diagnostic and loaner delays.Demanded Resolution:I demand that Hyundai cover 100% of the transmission replacement costs immediately. I am hoping this escalation to the NHTSA will help in bringing this matter to a positive end result, otherwise I have no choice but to pursue formal legal remedies.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755949August 10, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
This complaint concerns a serious, unresolved powertrain/propulsion safety defect in my 2023 Hyundai Santa Fe. While traveling approximately 70 mph, the vehicle suddenly lost propulsion and would not accelerate normally while surrounded by highway traffic.MOST IMPORTANTLY, THERE WAS NO WARNING OR ADVANCE INDICATION. No warning lights, messages, or symptoms appeared before the loss of propulsion. I had no opportunity to anticipate the failure or prepare to safely exit traffic. This placed me and other motorists at immediate risk of a serious or potentially fatal collision.A Hyundai dealership inspected the vehicle and documented DTC P284001, Shift Fork D Position Fault. Despite this documented fault, the underlying safety issue remains unresolved. Hyundai has not identified a permanent correction or established that the vehicle is safe to operate.There has not been another incident because I will not risk another sudden loss of propulsion by driving the vehicle. The absence of another failure does NOT mean the problem is resolved. The vehicle remains available for inspection.I have repeatedly sought assistance from Hyundai and the dealership without a meaningful resolution. Newer information regarding a possible computer reset/relearn procedure has also been presented, but the dealership refuses to perform it.I reviewed NHTSA complaints for 2023 Santa Fe vehicles and found multiple reports describing similar safety symptoms, including sudden loss of propulsion, inability to accelerate, abnormal transmission shifting, and loss of speed. This raises serious concern that this may not be an isolated failure.A vehicle that can unexpectedly lose propulsion at highway speed WITHOUT ANY WARNING creates an extreme crash risk. I respectfully request that NHTSA review the similar complaints, investigate whether a broader transmission/powertrain safety defect exists, and determine whether corrective action is necessary before this results in serious injury or death.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11755136August 5, 2026
ENGINE
I was driving, and the SUV all of a sudden lost power. I was trying to press harder on the gas pedal to keep up with the traffic, but the SUV was stalling. The SUV would not move, and as I kept trying to press on the gas pedal, a roaring noise like something was trying to turn but the engine kept trying to move the car. It felt like something in the car was trying to move but something kept slipping. I had to turn the car off in the middle of the street and restart it before it would move. Cars were blowing their horns. This is a safety issue and a dangerous Problem. The SUV just did the same thing a few days ago. I am calling the dealer to see what is wrong. I brought this car new 2023. It is under 12,000 miles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754698August 4, 2026
UNKNOWN OR OTHER
The horn stopped working.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749868July 12, 2026
POWER TRAIN, VEHICLE SPEED CONTROL
COMPONENT/SYSTEM: The powertrain launch control system — the Transmission Control Unit (TCU) and 8-speed wet dual-clutch transmission paired with the 2.5T engine — fails to deliver engine power in response to full accelerator input from a stop. The engine does not rev and the vehicle does not move for approximately 1–2 seconds despite the accelerator pedal being fully depressed, then power engages abruptly and violently. The vehicle is available for inspection upon request. SAFETY RISK: The failure occurs when launching from a stop into intersections and cross-traffic. In the most recent incident, I was turning left across the roadway from a stop with an oncoming vehicle approaching. I applied full accelerator and the vehicle did not respond at all for approximately 2 seconds — no engine response, no movement — leaving me stationary in the oncoming vehicle’s path. Power then engaged violently and without warning, causing the vehicle to lurch across the road. I was nearly struck. Similar events have occurred multiple times throughout my ownership; this was the closest to a collision. DEALER CONFIRMATION: Not yet inspected by a dealer. A dealer service appointment is being scheduled. OTHER INSPECTIONS: The vehicle has not been inspected by the manufacturer, police, or insurance representatives. WARNING LAMPS/PRIOR SYMPTOMS: No warning lamps or messages have appeared before, during, or after any of the events. The failure is intermittent and occurs without warning. The condition has been present since I purchased the vehicle in October 2022 and has occurred regularly throughout ownership — numerous occurrences over more than three years. No warning lamps have ever accompanied it. ADDITIONAL: Condition persists with Idle Stop & Go disabled, ruling out engine-restart delay. Same 8-speed wet DCT was subject to Recall 236 (NHTSA 22V-746) on 2021–2022 models for similar throttle non-response; 2023 excluded despite identical hardware.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11748226July 3, 2026
SERVICE BRAKES
My dealership has reground the rotors on my car twice. Now with less than 40,000 mileson the car the brakes need ground again. The issue with the brakes is it causes the front end of the car to shake when the brakes are applied. This could lead to loss of control on down hill stops in slippery conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746876June 27, 2026
VEHICLE SPEED CONTROL, LANE DEPARTURE: BLIND SPOT DETECTION, UNKNOWN OR OTHER
First Failure occurred 7 months after purchase at 5,270 miles on August 1, 2024. The vehicle suddenly went into "Limp Mode" abruptly decelerating to 25 mph with a non-responsive gas pedal. A code reader displayed PO653 Sensor Reference: "Voltage B Circuit High". Dealer found corroded wire to battery and cleaned it. Second Failure: Horn loss to 1 tone. Fixed at 30K mile dealer service on June 12, 2026 and found to have faulty packing resulting in corrosion. At the same standard service the Brake System was flushed. 3rd Failure was 5 days and 437 miles (30,712 miles) after the 30K dealer service. On June 17, 2026 during my early morning commute while merging onto the interstate, alarms began to blare and the gas pedal suddenly became unresponsive. The initial alarms read Blind Spot Failure. Car would not accelerate from 40 mph that it was going coming down the bridge ramp so I took the very close off ramp down from the aqua duct and the console display alert showed "Engine Management System: details: Braking and Body Control System with a recommendation to get "a full system check...TODAY". I brought it to the dealer that afternoon and as of yesterday, 6/26/26 they can find nothing wrong, declaring it an intermittent issue and asked me to come get the car, refusing to continue looking or providing alternate options other than referring me to Hyundai Consumer Affairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746699June 26, 2026
ELECTRICAL SYSTEM, POWER TRAIN, UNKNOWN OR OTHER
Vehicle stalled while driving — unsafe loss of power. While driving at normal speed, the vehicle suddenly shut off without warning and the electrical system malfunctioned. I had to pull over and restart car. This created a dangerous situation and could have caused a collision. Prior to this incidenct, the vehicle had intermittent electrical issues during startup (flickering electronics). This is the first time the car has experienced during driving, and is now at the Hyundai dealership. The car has been reported as unsafe to drive. This appears similar to other Hyundai stalling/power loss issues and may indicate a developing safety defect. Requesting investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11743508June 11, 2026
ENGINE, FORWARD COLLISION AVOIDANCE: WARNINGS
We were at full stop with Auto Hold feature enabled. Car lurched / jumped forward with no depression of the gas pedal. This caused us to strike the car in front of us.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11742763June 8, 2026
ENGINE AND ENGINE COOLING, FUEL SYSTEM, GASOLINE
The contact owns a 2023 Hyundai Santa Fe. The contact stated that while driving and decelerating to approximately 10 MPH onto an exit ramp, the vehicle suddenly stalled and failed to restart. The contact noticed that there was blue smoke coming from the exhaust pipes, and several unknown warning lights and messages illuminated, including the Check Engine warning light. The vehicle was towed to the local dealer, who diagnosed that a fuel injector had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not yet contacted. The failure mileage was 35,652.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741734June 3, 2026
ELECTRICAL SYSTEM, VEHICLE SPEED CONTROL, ENGINE
I was driving down the road and came to a stop at a stop light. After accelerating again my car lost the ability to increase speed above 20 miles/hour and would not shift gears. I was heading to the turn lane to get on the interstate and quickly had to change lanes to find an area to pull over as I could not reach highway speeds. I turned the car off. I turned the car back on and the problem resolved. This is the second time this has happened. I have seen this problem mentioned dozens of time on Reddit message boards including Hyundai buybacks on some of these vehicles. It doesn't sound like Hyundai has any idea what is causing this issue. This issue should be looked into further.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740635May 28, 2026
POWER TRAIN
While running errands around town, I noticed my 2023 Sante Fe 2.5T was sluggish shifting out of first gear into second. The RPMS revved to about 3K before the transmission shifted into 2nd. I didn't notice any problem shifting into 3rd and above. I drove to a gas station for fuel and shut off my car. When I started it and began to drive, I received an immediate warning to take the car to a dealer and the check engine light came on. The car had the same problem getting out of 1st gear at each of the traffic signals I got caught at on my way to the dealership about 2 miles away. The following day, the service department contacted me and determined I needed a new transmission due to the failure of the Dual Clutch electric high pressure oil pump in the transmission. They submitted a parts request and Hyundai approved a refurbished DCT warranty replacement. The transmission only has 50200 miles on it I am second owner but the car was a CPO so I have full warranty coverage. I was given a loaner under Hyundai' warranty provisions. My main concern is that although this vehicle is a 2023 Sante Fe, it was put in service around August of 2022 and would therefore have the same transmission as the 2021 and 2022s covered under Hyundai recall 236, but this has yet to be acknowledged as far as I know. Please investigate my situation and consider further requirements of Hyundai! Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740547May 28, 2026
POWER TRAIN
Hyundai Corporate is refusing to ground or provide alternative transportation for a documented, warranty-covered engine cooling fault (Code P2181), creating a highway stalling risk. Hyundai's legal compliance team reviews these logs daily.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740276May 27, 2026
SERVICE BRAKES, ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
My vehicle activates the emergency braking system while driving. It has happened several times now, almost causing a collision. I took it to the dealership, they held it for a week and gave it back to me telling me they could not find anything wrong with it. They did not fix anything at all. It has since done it once more.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11740013May 26, 2026
POWER TRAIN
Shifter malfunction has appeared since I bought the vehicle new. Once I took it in, they said it was the software. The vehicle now skipped and hesitate in the lower gears. When in high gears ride fine. But once it stops and start driving again, lower gears won’t drive properly. Drives with hesitation and skips.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11739797May 24, 2026
UNKNOWN OR OTHER
Two unsafe scenarios in past two months: 1) Driving 80 mph, engine misfire, vehicle will not accelerate past 1 rpm, had to drive home from out of town with very slow acceleration, dangerous to not be able to accelerate efficiently on highways 2) Driving 55 mph, all driver safety systems malfunction, accelaration completely disabled, had to coast to safe stopping point. Restarted vehicle and could drive home with check engine light on, incredibly dangerous for car to lose all ability to accelerate in the middle of a highway.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737167May 11, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
While driving on the interstate, while using cruise control, my vehicle braked and decelerated, uncontrollably. The collision alert alarm went off. I forced the vehicle to accelerate and it stopped the braking and the collision alarm ceased. I took the car to the dealer and they spend the day checking it over. They said they couldn’t get the same reaction I reported, but reset the cruise control. On my way back home on, again on the interstate, and with the cruise control activated, it again had the same failures. I called the dealer and told them. They asked if I had recently mounted any new equipment on the windshield. I said I had Velcro attached and EZPASS toll reader. They asked me to remove it, because might be interfering with the cruise sensor. After I removed it, and while continuing on the interstate, with cruise activated, it again repeated the same failures. The dealer arranged to have my vehicle towed to their shop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734056April 27, 2026
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
It is not just this vehicle; it is ALL vehicles with adaptive cruise control and automatic emergency braking. When sensors get snow or debris on them, they shut the vehicles down without warning. I have had 3 times this winter when the roads were fine, cruise control set, and because another vehicle was kicking up road salt, the vehicle instantly shut off the cruise control without any warning to the driver, all 3 times I had traffic behind me at 55mph or on the highway at 70mph. The emergency braking is another issue, as it will bring the vehicle to almost a stop, and does not take into account if there are other vehicles behind it or not! How more people have not been killed because of these 2 systems is beyond me! BOTH of these systems and the vehicle they are on NEED to be recalled and either sensors removed or workarounds implemented, that at least give the driver some advanced notice before the cruise control is turned off or before a vehicle decides to hard-brake itself!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732147April 18, 2026
SERVICE BRAKES
The front rotors need machining every 10,000 to 15,000 miles. The rotors experience exceeding distortion due heating by the brake pads. When brakes are applied, there are large vibrations in the front suspension which inhibits braking. This is especially true when braking on wet pavement where stopping distances become unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe