Hyundai Santa Fe Complaints (2017)

972 consumer complaints on file.

#11774378October 29, 2026
ENGINE, FUEL/PROPULSION SYSTEM
The engine light came on. Upon driving it on the highway it would lost acceleration but was able to drive under 50 miles per hour about 5 miles. When opened the hood there was fluid splattered on the engine. There is a hole in the upper left quadrant beneath the engine cover.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11772926October 22, 2026
ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER
Odometer Fraud. The contact purchased a 2017 Hyundai Santa Fe. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase, the mileage was 45,000. However, when the vehicle was taken to a dealer for a trade-in, it was discovered via a Carfax report that the mileage was over 109,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11771344October 15, 2026
ENGINE, POWER TRAIN, ELECTRICAL SYSTEM
On [XXX], Laguna Niguel Hyundai performed Service Campaign 9C2 (ECU software update for Theta II emissions improvement, Hyundai TSB 26-01-013H) on my 2017 Hyundai Santa Fe Sport. Immediately after the update, the vehicle developed drivability problems that did not exist before: rough/harsh shifting, hesitation, and loss of power during cold-start operation (the first 1-3 minutes after engine start), plus intermittent infotainment and navigation system failures. Hyundai's own dealer notice dated 05/18/2026 acknowledges vehicles may exhibit 'hesitation or rough shifting' after the 9C2 update and states the matter is 'currently under review' — no permanent fix has been released. The dealership that performed the recall has since refused to service my vehicle again. I opened case #[XXX] with Hyundai corporate; my inquiries on 09/03/2026, 09/11/2026, and 09/17/2026 asking for a corrective action have gone unanswered. The hesitation and power loss are a safety hazard when merging into traffic or crossing intersections. I request NHTSA investigate this pattern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770978October 13, 2026
UNKNOWN OR OTHER
On XXX, [XXX] Hyundai performed Service Campaign 9C2 (ECU software update for Theta II emissions improvement, Hyundai TSB 26-01-013H) on my 2017 Hyundai Santa Fe Sport. Immediately after the update, the vehicle developed drivability problems that did not exist before: rough/harsh shifting, hesitation, and loss of power during cold-start operation (the first 1-3 minutes after engine start), plus intermittent infotainment and navigation system failures. Hyundai's own dealer notice dated XXX acknowledges vehicles may exhibit 'hesitation or rough shifting' after the 9C2 update and states the matter is 'currently under review' — no permanent fix has been released. The dealership that performed the recall has since refused to service my vehicle again. I opened case #XXX with Hyundai corporate; my inquiries on XXX asking for a corrective action have gone unanswered. The hesitation and power loss are a safety hazard when merging into traffic or crossing intersections. I request NHTSA investigate this pattern. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767901September 29, 2026
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
Was driving down road car went into limp mode about caused a big wreck, check engine was flashing and heard a loud noise as I was trying to get to safety. Had the car scanned and was for code p1326 and looking at all the recalls nothing is for the 2.4l but y'all have been having a lot of issues with these theta 2 engines.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11767289September 27, 2026
ENGINE, POWER TRAIN
Immediately following the mandatory Hyundai Servie Campaign Update 9C2-ECU THETA 11my vehicle began exhibiting severe hesitation, very rough idling, jerking at slow speeds and when gear changes, difficulty going up inclines and almost feel at times as though it is about to lose power which poses life threatening situations especially when turning into traffic. I have reported it to the dealers who never once test drove the vehicle but said to me that they did and could find no problem, however they did make me pay for repairs which never fixed the problem. I returned three times with the same issue. They recommended a Fuel Induction Service and a Auto Trans Service. Spark plug change. Igniton coils change. Nothing worked!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765645September 20, 2026
ENGINE, POWER TRAIN
Component/System Failed: Engine assembly (Theta II 2.4L GDI) and Exhaust/Catalytic Converter. Description: The vehicle suffered a failure associated with the known Theta II engine defects. Engine oil consumption and internal engine wear directly led to unburned fuel and debris entering the exhaust stream, resulting in severe catalytic converter restriction/failure. Safety Risk: The combined failure caused sudden loss of power while driving, engine stalling, and significant driveability hazards, creating an immediate risk of a rear-end collision on public roads. Confirmation & Inspection: The failure was confirmed and diagnosed by a certified service facility. Replaced components and diagnostic documentation remain available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765456September 19, 2026
ENGINE, FUEL/PROPULSION SYSTEM
Hyundai performed recall #9C2, on 7/2/26. Since that time, the engine has a full time miss. When it is cold, it will hesitate, kick and buck. Hyundai is aware of this. Their solution is to warm the car for 3 to 5 minuets before moving. What happens if there is an emergency and you can't wait? Possible accident with injuries trying to pull into, or cross traffic! I have filed a case with Hyundai, and they just update that they are aware and working on a solution with no expected date for the software fix. This is a serious problem, and they need to fix SOON! Also, when an engine runs like this, over a period of time it will destroy the catalytic converter. Who's going to pay for that??
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765542September 19, 2026
ENGINE, POWER TRAIN
Service update 9C2. Car hesitates or slightly bucks on a cold start. No remedy to fix yet.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765544September 19, 2026
ENGINE
My son was driving the vehicle normally. There were no issues, warning lights, abnormal feel to the drive, and no odd noises. Suddenly, all of the warning lights on the dashboard lit up, acceleration dropped and he could no longer accelerate. He pulled off the main road and there was a burning smell and the vehicle was inoperable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763180September 9, 2026
ENGINE, POWER TRAIN, VEHICLE SPEED CONTROL
Vehicle was brought to an authorized dealership for service, and while there Campaign 9C2 (ECU Software Update for Theta II Emissions Improvement) was performed. Immediately following this software update, the vehicle developed drivability degradation, specifically engine stutter/hesitation and rough transmission shifting during cold starts. When attempting to accelerate in the first few minutes of driving, the vehicle delays engagement and then suddenly surges or lurches forward unpredictably. This creates a safety hazard, as the unpredictable power delivery and lag prevent the vehicle from accelerating safely when merging into traffic or turning across oncoming lanes, placing occupants at an immediate risk of a collision. The software logic error is fully reproducible every time the vehicle has sat long enough to cool down. The dealership confirmed the update was applied. There were no warning lamps or symptoms prior to the 9C2 update; the failure was caused directly by the manufacturer's campaign software modification to the Engine Control Unit (ECU). The vehicle and its ECU are available for inspection upon request.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762822September 8, 2026
ENGINE
-The primary mechanical failure is a burned exhaust valve in Cylinder 2, which has resulted in 0 PSI compression and a persistent engine misfire. This severe top-end valve degradation occurred as a direct consequential result of a chronic, underlying defect in the engine's internal oil-delivery and consumption systems. The vehicle is currently fully assembled, intact, and available for immediate inspection upon request at Brown-Daub Hyundai. -The vehicle suffered a sudden, severe loss of motive power while operating in traffic due to the cylinder drop, triggering a sudden transition into a dangerous operating state. The extreme oil consumption rate (burning 5 to 6 quarts of motor oil every 3,000 miles) created an ongoing, severe risk of sudden highway stalling, catastrophic moving component seizure, and potential engine bay fire due to extreme internal operating friction and chronic oil starvation. -Failure has been confirmed by two independent automotive facilities: Independent Confirmation: On XXX, [XXX]’s Service Center performed a diagnostic scan and an engine compression test, formally documenting diagnostic trouble code P030200 (Cylinder 2 Misfire) and verifying 0 PSI compression in Cylinder 2.Dealership Confirmation: On XXX, the service manager at Brown-Daub Hyundai executed a formal electronic and mechanical inspection under Repair Order #XXX, duplicating the failure and logging active trouble codes P0301, P0302, and P0128. -Symptoms first appeared progressively through an accelerating, severe oil consumption defect, which was documented during multiple routine maintenance: XXX oil consumption (115,865 mi): XXX (119,601 mi) no external leaks: XXX (125,502 mi) excessive oil consumption:XXX (135,116 mi) excessive oil consumption:XXX (133,022 mi) P0420 Cat Code: XXX (approx. 137,000 mi)engine rough-riding, shaking, & violent misfires began, preceding the mechanical breakdown INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761955September 3, 2026
ENGINE
On May 26.2026, Southern States Hyundai performed mandated Service Campaign 9C2 (Theta II Emissions Improvement). The software immediately caused drivability degradation and a catalytic converter failure, mirroring the defects Hyundai acknowledged to the NHTSA on May 18, 2026. Corporate customer care is using an unrelated oil consumption testing protocol to deflect liability and charge me $1,400 for the testing and/or $4002 for the catalytic converter out of pocket for damage caused by their own recall software. This hesitation is a severe safety risk when accelerating into traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760878August 31, 2026
ENGINE, SUSPENSION, UNKNOWN OR OTHER
My truck began emitting a strong oil odor on XXX. I took it to Amato in [XXX], where I was told the oil pan was leaking. They replaced the oil pan, and I paid for the inspection as well. About an hour after picking up my truck, the check‑engine light came on. I returned to the dealership, and they then said additional repairs were needed, even though I had already paid $2,211.57 for the work they claimed was necessary. At that time, my truck had 145,776 miles on it. Because the manager at [XXX] refused to address my concerns, I was told to go to another Amato location, and I was effectively blacklisted from the first dealership. I went to Amato Glendale, where I experienced the same issues. They fixed only one of the problems, and that was only after I contacted Hyundai corporate. My truck continued to have oil‑consumption issues. Amato required me to complete a three‑month, 1,000‑mile oil consumption test before they would consider providing assistance. I completed the test as instructed. Now, however, they are saying that due to the age and mileage of my truck, they will not cover the engine replacement — even though the problems began at 145,000 miles, not 156,000. Other drivers have reported that Hyundai delays necessary repairs until major engine damage occurs, and I believe that is exactly what has happened in my case. There was also a suspension recall that applied to the 2018 model but not the 2017. Amato Hyundai covered part of that repair only because I contacted corporate again. My current complaint is about the failing engine and Amato Hyundai’s lack of responsibility in properly diagnosing and repairing my truck. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760934August 31, 2026
ENGINE, ELECTRICAL SYSTEM, POWER TRAIN
Cold-Start Hesitation & Rough Shifting: Following the 9C2 ECU update, my vehicle is experiencing a brief period of throttle hesitation, rough shifting, or jerky transmission behavior specifically during cold-start operations.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760479August 28, 2026
POWER TRAIN
Known as an issue with Hyundai, but unresponsive to correct because no diagnostic code is sent. Transmission will shift extremely hard from 1st to 2nd gear randomly. In keeping track of the mileage, this appears to happen every 200 miles or so. Also, it faild to upshift correctly, making the entire car shudder. Also, at times it will not go into reverse gear. On one occasion, after finally doing so, it slammed so hard into reverse I almost collided with the car behind me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759120August 24, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
My 2017 Hyundai Santa Fe, purchased new from Lynnes Hyundai in February 2017, has approximately 93,000 miles. The vehicle previously developed a significant oil-consumption/engine problem that was diagnosed by Hyundai, and Hyundai replaced the engine with a remanufactured engine. Approximately two weeks after the engine replacement, the check-engine light illuminated and DTC P1326 was identified. The dealership replaced the knock sensor. Approximately two weeks later, the check-engine light illuminated again with a recurring P1326 condition. The vehicle is currently at Lynnes Hyundai and has been there approximately three weeks while they attempt to determine the cause. Hyundai Techline is involved. Prior to the current repair visit, while traveling approximately 60 mph, the vehicle experienced a very forceful hesitation that jerked the vehicle. I immediately slowed down and pulled onto the shoulder. The vehicle continued to hesitate intermittently while I drove slowly to safety. I was concerned that the vehicle could lose power or shut down while I was driving at highway speed, creating a risk of a crash. The recurring P1326 condition has been confirmed by the Hyundai dealership. The vehicle and engine have been inspected by Hyundai/Lynnes Hyundai multiple times, including after the engine replacement. The current recurring condition has not been resolved. The check-engine light is the warning lamp associated with the current condition. I do not know the underlying cause of the recurring P1326 condition; Hyundai is currently attempting to diagnose it. The vehicle is currently available for inspection at Lynnes Hyundai.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758839August 23, 2026
ENGINE
My 2017 Hyundai Santa Fe 3.3L V6 (148,000 miles) has documented oil consumption and a recurring DTC P0278 (Cylinder 6 Contribution/Balance). Hyundai's formal oil-consumption test confirmed oil consumption, but said it was below the threshold for combustion-chamber cleaning. The check-engine light and P0278, and losing acceleration ability continue to recur. The vehicle is available for inspection. Hyundai has confirmed the oil-consumption issue but has not determined the cause of P0278 or performed the TXX8 engine inspection I am requesting. I am concerned about worsening engine performance, loss of power, or engine failure, particularly given Hyundai's history of engine-bearing issues with certain 2017 Santa Fe 3.3L engines. I am not claiming diagnosed bearing failure; I am requesting a TXX8 inspection to determine whether an eligible engine condition exists. I have contacted both the dealership and Hyundai Corporate, but have been told I must repeat the oil-consumption test. At 148,000 miles, I am requesting prompt inspection before the 150,000-mile TXX8 limit and covered repair/replacement if an eligible condition is found.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758484August 21, 2026
ENGINE, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
Directly after the dealer, Johnson Hyundai of Apex, completed Service Campaign 9C2 on 4/28/26, my vehicle began sticking, surging, and harshly changing gears. I have followed up with the dealer multiple times. They said they are not getting back any diagnostic error codes (outside mechanic shop also confirmed they're also not seeing error codes), but went ahead and recalibrated the ECM. They told me to drive for 200 miles and the issue should be resolved. I have now driven 1,500 miles and the issue persists. I'm now seeing Hyundai put out a 'Driveability Communication" about this issue, but there is no proposed fix/recall. This issue did not exist before this service campaign was performed by the dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758504August 21, 2026
ENGINE
After the update earlier this summer for an emissions issue, my car, a 2017 Hyundi Santa Fe Sport, has not run right. When it is cold, the first trip on the day, it hesitates and sputters to an extent that it is not safe on the nearest highway where the speed limit is 35. We have been compensating by driving slowly around the neighborhood for a few minutes, and then it's fine. It has been happening since the update of service campaign 9C2, the "Theta II Emissions Logic Improvement" recall. The local Hyundai dealer has been unable to provide a fix. We just picked it back up today, 8/21/26, after deciding against their latest idea, a fuel injector treatment for $200. Based on other examples I've read with similar or identical issues after the recall software update, I have concluded this is a safety issue that Hyundai must resolve.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe