Hyundai Santa Fe Complaints (2023)

293 consumer complaints on file.

#11633727January 2, 2025
BACK OVER PREVENTION: AUTOMATIC SYSTEM BRAKING
The contact owned a 2023 Hyundai Santa Fe. The contact stated that his partner was driving at 50 MPH, a light ahead had just turned red, with two vehicles stopped just a couple of feet ahead of her, the contact stated that his partner had proceeded to frantically attempt to brake, however, the vehicle did not brake in time, and the automatic braking assist did not initiate. The complete front end of the vehicle was destroyed, as the vehicle crashed into the vehicle ahead. There was no property damage. The vehicle came to a stop after the crash. The driver's side air bags were deployed, however, the contact emphasized that it appeared the air bag had not fully deployed. The vehicle was towed to a lot. No warning lights had illuminated. A police report was filed. The vehicle was destroyed. The contact partner was injured, and she was seated in the driver's seat, and a single civilian seated in the driver's seat of the vehicle that was hit from behind was injured. The contact stated that his partner suffered injuries to her chest, and the other individual suffered injuries to the neck. Medical treatment was needed for both individuals. The local dealer was contacted however the vehicle was not diagnosed, as the vehicle was a total loss, and the manufacturer was not notified of the failure. The approximate failure mileage was 23,824.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11633024December 30, 2024
ELECTRICAL SYSTEM, EXTERIOR LIGHTING
"check turn signal error". This message pops up at random times. When this error does pop up, the rear turn signal ceases to operate until the error message clears itself. Dealership "cannot duplicate". I have photographed the warning many times. Hyundai corporate is of no help. Check LED headlamp error issue as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633025December 30, 2024
ELECTRICAL SYSTEM, VISIBILITY/WIPER
Windshield wiper in auto mode. Sometimes wipers turn on automatically in bright sunny days with nothing on windshield. When it rains, sometimes automatic wipers will not activate until windshield is completely covered with rain, and visibility is greatly reduced. Sensitivity adjustment has zero effect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632762December 27, 2024
UNKNOWN OR OTHER
Horn Failed. Would not sound, making it impossible to warn people if car might hit them or their vehicles or about any other issue they would need timely reporting about. Car was brought into dealer and 2 horns assemblies were replaced as non-functional
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632758December 27, 2024
ENGINE, VEHICLE SPEED CONTROL, POWER TRAIN
Automobile approached and stopped at stop sign. When accelerator pressed to continue, car remained in place, shuddering (as if transmission were slipping),and making significant noise. Car would not shift out of gear, nor move. Operator shut off car and then restarted car. Car started normally and was in park without shuddering. Expectations at busy intersection was that it was my turn to move and did not do so, creating doubt on what my car might do next. Traffic flow was briefly confused and some drivers honked and were unsure what they should do. This could have caused an accident with an impatient driver re-ending my car, or with others going through the intersection "out of turn" and unclear on my situation. No lights or other warnings were displayed before this incident. It has not re-ocurred. I brought into the dealer who had no other reports of this type of behavior.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632756December 27, 2024
POWER TRAIN, ENGINE, VEHICLE SPEED CONTROL
While travelling at highway speed, attempted to accelerate to pass slow traffic. Rather than accelerating, the car hunted for a gear, and wouldn't shift properly. The car downshifted but engine would not go beyond 4000 RPM and speed remained the same. This has happened multiple times. By unexpectedly not accelerating, this created a risky situation by not allowing car to pass slower traffic as expected creating a potentially dangerous situation. (Video of one of the instances exists). No warning lamps, messages or symptoms occurred up to that point. Car was brought to dealer but since no codes were contained in the computer, they said there was no trouble found.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630804December 15, 2024
SERVICE BRAKES, WHEELS
I purchased my 2023 Santa Fe brand new off the show room floor in Jan 2024. After about 6k miles when braking on the highway the entire vehicle would shudder and shake including the steering wheel. I took it into the dealership where I was informed this is a KNOWN ISSUE with this year/make/model with the rotors. They claimed they would turn the rotors but if the issue persists they would replace them. About 2k miles later (apx 2 months) the shuddering happened AGAIN. So I made an apt to get them replaced where the new service tech tried to tell me again this is a KNOWN ISSUE but now I would be responsible for a $250 replacement of the rotors. I refused to pay as they are within the 12k or 1 year warranty and they refused to replace them. That service tech also said the day prior he had to deliver that news to 4 OTHER patrons about the replacement of their rotors. I feel extremely unsafe in this vehicle and the issue is still not fixed as I have a claim in process with the manufacture directly. The claim was put in on 12/7/24 where I was told I would be contacted within 2-3 BUSINESS DAYS by a manager due to my claim being escalated. It is now 12/15/24 and still NO CONTACT from Hyundai. The vehicle shuddering is increasingly worse and worse and I feel very unsafe in this suv.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629532December 8, 2024
UNKNOWN OR OTHER
Just purchased the vehicle one week ago. I bought it used from a Hyundai dealer. Just discovered that the horns don't work, either the high tone or the low tone. I discovered it when I went to use the horn to alert a driver who was coming into my lane, pushed the horn on the steering wheel and nothing! I've checked the fuse and it is fine. Internet research shows this to be a prolific problem with Hyundai's. Because the horns don't work, neither does the alarm system. I tested by pushing the panic button on the key fob. The lights flash, like the alarm is trying to fully work, except the horns don't sound. I will be bringing it to the dealer as it is still under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629441December 7, 2024
POWER TRAIN, STEERING
Shuddering Issue with Current Vehicle: - Problem: Progressive shuddering during take-off, accelerating, slowing down, and braking uphill.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628751December 4, 2024
POWER TRAIN, ENGINE, FUEL/PROPULSION SYSTEM
First- it has been reported to dealer at least twice when car was in for other service. They said they could not reproduce. When speeding back up from a stop on near stop, especially in a right turn, the engine will not accelerate. After a second or two it finally takes off. During this time, I fear getting hit by another vehicle, either from behind or to the side. It is very scary and puts me and my passengers at great risk! There was no warning indication at all. The date mentioned was the most recent time, but the issue has been happening since the car was brand new. Again, NO help from the dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628701December 3, 2024
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Emergency brakes engage while driving for no apparent reason. This has happened on several occasions over the last 6 months.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627757November 27, 2024
POWER TRAIN
Santa Fe will randomly experience inability to accelerate. I will hit the gas pedal, the engine will rev all the way up to power, it will slowly crawl forward and than violently accelerate. From the time I hit the gas pedal to the time it actually starts moving takes several seconds. It does this every time I come to a stop once it starts. It has done this 4 occasions now. It puts me at significant danger trying to turn across traffic. In general, it not accelerating as you would expect is a very dangerous situation. Dealer has had the car for over a month and has had the car reproduce the issue. The HEV light and check engine light had come on a couple of the occurrences.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626890November 22, 2024
VISIBILITY:SUN/MOON ROOF ASSEMBLY
As my wife and I were traveling down the interstate at 45 mph, we heard a loud POP, but we were unable to figure out where it came from. Just a few seconds later, the sunroof exploded into a million tiny pieces of glass that partially rained down on our heads and shoulders. It was quite a startling sound. There was a hole about 8 inches across in the moveable sunroof and more pieces were continuing to fall out. To protect our heads, I closed the shade. There was no evidence of an object striking. Windows were all closed when the incident occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626081November 19, 2024
ELECTRICAL SYSTEM, POWER TRAIN, ENGINE
Vehicle has gone into limp mode 2 times in the past week. Power when accelerating would not exceed 30 mph when pushing the gas pedal to the floor. Had to pull over as I was getting onto the highway and stop/ power down the car and restart.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625690November 16, 2024
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
Twice, the car refused to switch from EV mode back to gas mode. This resulted in the hybrid battery dying and the car losing power. The first time, I was merging onto the freeway and the gas pedal was all the way at the floor, but I was only maintaining speed (not accelerating). Both times, the car was driveable for approximately one mile on the hybrid battery alone. However, a warning came on the dash, “Check hybrid system. Stop safely.” The second time, I was able to pull into a parking lot before the hybrid battery died. The next day, I was able to drive the car normally. The dealership is unable to pull any codes or replicate the issue. Unfortunately, it only happens intermittently and we have not identified a common theme for the failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625631November 15, 2024
UNKNOWN OR OTHER
The rear section of panoramic sunroof exploded. We were traveling approximately 60 MPH on HWY 395 crossing the bridge on the Columbia River between WA and OR. Suddenly we heard a very loud explosion. When we stopped to investigate we found a hole in the sunroof. It exploded up and outward. There were very few glass shards inside the vehicle and no debris or evidence of anything that could have caused the breakage. The Hyundai dealer was unwilling to repair it as a warranty item. We paid a glass company through our insurance company to replace the glass. I’m aware that there were problems a few years ago with the Hyundai sunroofs and was advised to file this incident report. It was extremely scary to experience the noise.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623717November 5, 2024
SEAT BELTS
The seat belt in the middle seat of the second row did not work. And it was not fastened. So when braking, my child was thrown toward the center console. I think it's a big safety issue if the seat belt doesn't work.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622204October 27, 2024
FUEL/PROPULSION SYSTEM
I am afraid of getting myself or someone else killed because there is a 1-2 second lag after stepping on the gas pedal after coming to a stop. This is extremely dangerous. My street empties onto a county road with a blind curve. I have had several instances when the delay between the car moving after I’ve stepped on the gas has lead to oncoming cars needing to slam on their brakes to avoid hitting me. I even called the county and asked that they put up a “dangerous curve sign. They put up a squiggly arrow instead which has not helped. My previous gas vehicles made this turn safely for 20 years. My nephew told me it’s a new feature in cars called “stop and gol meant to save gas. I think saving my life is more important than saving a little bit of gas. It happens all the time so I will put todays date in the space below.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621783October 24, 2024
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS, SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
The contact owns a 2023 Hyundai Santa Fe. The contact stated that while his wife was driving at approximately 65 MPH and depressing the brake pedal to slow for a vehicle that had passed and switched into the lane she was driving, the vehicle was shuddering. The contact stated that as soon as she had stopped depressing the brake pedal the shuddering ceased. The contact stated there was no warning light illuminated. The contact stated that the shuddering when the brake pedal was depressed was intermittent but was recurring at various speeds while slowing down. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the brake pads and rotors needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 18,756.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621650October 23, 2024
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, LANE DEPARTURE: ASSIST
Currently have 518 Diagnostic History Codes (DTC)in memory. Additionally, I have 3 Active DTC’s. The codes are: DTC C160C87 DTC System CHASSIS DTC Sub System LKAS, and DTC C160C87 DTC System CHASSIS DTC Sub System SCC, and DTC C163881 DTC system CHASSIS DTC Sub System SCC FIRST OCCURRENCE: during actual assembly in Montgomery, AL plant. I have asked three Hyundai Service dealers for help. All have tried. Noting noted that contributes to the issues above. At first, my dealer replaced the front camera. Was told it was a heating issue. I have contacted Hyundai BLUELINK service for help. An information report was filed, TWICE. The first report I received feedback that Hyundai’s engineers had corrected the issue. On the following day, the codes returned. A second concern was filed with Hyundai BLUELINK. Hyundai Motor America Case#: [XXX] to wit: “Thank you for contacting Hyundai Motor America. We are in receipt of your e-mail and one of our representatives will get back to you shortly. Sincerely, Hyundai Motor America” Is my vehicle going to fail and cause me injury while operating it on an Interstate highway? This is quite concerning as I drive my car. All I want from Hyundai is to get this issue repaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe