Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11693603October 15, 2025
ENGINE
The car is burning oil and Hyundai advises to change the oil every 7500 miles. The car holds 5.1 qt of oil and is currently burning about 1 qt of oil for every 5,000 miles. How is this not a forced recall? People are blowing up their motors all over the country. They knew it was an issue and bought their way out of a class action lawsuit. This endangers any driver if it happens on the interstate. Hyundai/Kia are being allowed to skirt accountability with these motors.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693361October 14, 2025
AIR BAGS, SEAT BELTS
To Whom It May Concern, I am writing to formally report repeated safety system failures in my Hyundai vehicle that have resulted in significant injury and ongoing hardship. The first incident occurred in 2021, when my vehicle was struck from the front by another driver who fled the scene. Despite the impact causing visible front-end damage, the airbags did not deploy, and the seatbelt did not engage properly. The vehicle was repaired by an authorized Hyundai dealership, yet at no point was I informed that the vehicle’s safety systems might be compromised or that it should not be driven. The second and more severe incident occurred in December 2024, when my vehicle was rear-ended by a commercial truck and subsequently pushed into four other vehicles. Once again, neither the airbags deployed nor the seatbelt engaged, resulting in multiple bodily injuries for which I am still undergoing treatment. After reporting this second failure to Hyundai, I was informed that the airbags and seatbelts may not activate when the vehicle is struck from behind. However, this explanation does not address the fact that the same safety failures occurred in the 2021 front-end collision as well. I believe these repeated malfunctions indicate a serious defect in the vehicle’s safety restraint and airbag systems that poses an ongoing danger to drivers and passengers. I am requesting a full investigation into these safety system failures, including whether the dealership’s repair process or Hyundai’s design or manufacturing contributed to these malfunctions. Due to these failures, I have experienced significant physical injury, emotional trauma, and ongoing medical issues, and I am seeking appropriate accountability and resolution.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11693461October 14, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I just purchased a 2025 Hyundai Santa Fe and the Smart Cruise Control won't work with sunglasses on. There is an Infared sensor on the steering column that has to see your eyes. Sunglasses are needed for this vehicle. If you don't wear them, the sunlight blinds you. The system will beep, display a message stating full face can't be seen, and it shuts the cruise control off and the vehicle decelerates, which is unsafe.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11693283October 14, 2025
AIR BAGS
The contact owned a 2025 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, a deer jumped out in front of the contact's vehicle. The contact's vehicle crashed into the deer, where it came to a stop by the side of the roadway. The contact stated that none of the air bags deployed. The vehicle was towed to a local tow yard. The vehicle was condemned as a total loss. The contact did not sustain any injuries. A Police report was filed. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was 10,024.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11692982October 12, 2025
ENGINE, FUEL/PROPULSION SYSTEM
My 2025 Hyundai Santa Fe Hybrid has experienced repeated, dangerously abrupt power loss while driving at highway speeds, causing the vehicle to go into "limp mode" without any warning or prior indication. This safety hazard occurred on three separate occasions: First Incident: 7/29/25; Mileage: 9,205. Situation: While traveling at 70 MPH on the interstate, the vehicle suddenly decelerated to 35 MPH and entered "limp mode" without any warning lights or notifications. Dealer Repair: Replaced ignition coil assembly (Parts: 27301R1H, 27301-2M417). Second Incident: 8/27/25; Mileage: 12,898 Situation: While accelerating to 65 MPH on the interstate, the same loss of power and abrupt forced deceleration occurred, again with no warning. This sudden loss of speed created a serious safety hazard for me and other drivers. Dealer Repair: Replaced fuel pump & O Ring Assy-High Pressure (Parts: 35326-2M500, 35305-2m414 LH). Third Incident: 9/25/25; Mileage: 14,830. Situation: Traveling at 70 MPH on the interstate, the car abruptly decelerated, again entering limp mode. This caused surrounding vehicles to swerve to avoid rear-ending me, putting myself and others at risk. Dealer Repair: Replaced High Pressure Sensor (3534202M400), Packing Fuel Pump (31115-0W000), and Fuel Pump and Tube Assy (31119-L1400). In all three cases, there was never any warning light, check engine notification, or app alert before the incident. Hyundai and my dealership confirmed and replicated the issue during each repair. I have reported the vehicle to the Texas DMV, Hyundai and the dealer.These recurring “limp mode” incidents have repeatedly jeopardized my safety, my family’s safety, and the safety of the public due to the sudden, unanticipated loss of power at high speeds. Since the underlying issue persists and has required three separate major repairs, I am fearful for my safety while operating this vehicle and believe it constitutes a serious safety defect needing federal investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692770October 11, 2025
UNKNOWN OR OTHER
Vehicles' charging side deck will heat up any phone we put in to charge inside that slot. We brought this to the dealers attention a couple times but they stated I needed to pay a service fee to have it looked at. It began happening a few weeks after we purchased the vehicle. We have not used the port ever since.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692565October 10, 2025
POWER TRAIN
Went By Lee Hyundai of Fayetteville my 2025 Hyundai Santa Fe [XXX] my vehicle gave a warning check transmission oil immediately vehicle was sluggish. I was told to bring it back Monday October 6th they kept it for a week pick it up today October 10th, 2025 they worked on it I had to bring it right back. Went to Sam's club up the street got ready to leave message pops up check your transmission oil immediately call dealer had me to bring it back light stayed on driving there RPM wouldn't get over 2.5 I thought I was going to get run into stopping and going back made there dealership working on it again just purchased it [XXX] little over 3,6004miles I was scared to death INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692363October 9, 2025
UNKNOWN OR OTHER, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Wearing any kind of polarized sunglasses prevents you from seeing the Heads-Up display and will abruptly disable the adaptive cruise control. The Santa Fe forum has hundreds of complaints about this, yet Hyundai has not done anything to correct the problem. I have asked three different dealers about this problem, and they just repeat the company line (you need to find sunglasses that don't cause a problem). This situation is dangerous and unacceptable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692357October 9, 2025
UNKNOWN OR OTHER
The alert, "Consider taking a break", produces visual and audible alarms. The audible alarm emits from the dash and has a similar sound to the seat belt not buckled alarm. There is no obvious event that causes the alert. Sometimes occurring minutes after starting the engine, other times randomly during several hours of driving. During normal driving conditions (low traffic, no weather problems) this alert is just annoying. However, during stressful driving with heavy traffic and or weather events, this distraction draws attention away from the task at hand, driving safely. There should be an option to turn this alert off or set the parameters for when it is triggered.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11692191October 8, 2025
ENGINE
Yesterday while I was driving I almost was hit by another car in an intersection. My car did not respond fast enough, the engine did not have any stregth. I found today after I took it for service that it needs a replacement of the oil pump. My car is new it only has 4 months of usage and this type of repairs is done in vehicles with a high mileage. This is very uncommon.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691832October 7, 2025
ELECTRICAL SYSTEM
The contact owns a 2017 Hyundai Santa Fe. The contact stated that the automatic power door locks failed to operate as needed. Due to the failure, the contact had to manually unlock and lock all doors inside the vehicle. In addition, the contact stated that the button to unlock the gas cap also failed to operate as needed. The vehicle was not yet diagnosed or repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 72,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691963October 7, 2025
ENGINE
Per our mechanic: Timing components blew a hole in the valve covers because they were so loose. It is burning massive amounts of oil. Could start with timing components and new valve covers, but it will most likely need a new engine because valve train damage is very likely.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691820October 7, 2025
AIR BAGS:FRONTAL:DRIVER CLOCKSPRING/SPIRAL CASSETTE
The contact owns a 2021 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the controls on the steering wheel became inoperable. In addition, the air bag warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with clock spring failure. The contact was informed that the clock spring needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the Department of Motor Vehicles declined the registration renewal due to the failure. The manufacturer was made aware of the failure, and several cases were filed. In addition, the contact was informed that the repair was not covered under the recall nor special program. The failure mileage was approximately 60,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691589October 6, 2025
ENGINE
We have continued to experience, over at least the past 6 months, and at least once a week and under all driving conditions, a stalling and unable-to-restart problem with this vehicle. Usually after waiting a short period of time it will restart, but in one case we had to have it towed to the dealer. The engine typically turns over just fine, so it's not a battery or starter issue. In a couple of instances it won't turn over. We've taken it to two different Hyundai dealerships and they haven't been able to diagnose the problem because they aren't able to replicate the problem when the vehicle is in their possession. The situation is becoming increasingly dangerous. The last time it stalled, my wife was in the middle of a very busy intersection. The problem doesn't produce any codes that the dealership can see; when it stalls and we attempt to restart, most of the dash lights that regularly come on when you start it are displayed. I am aware of a recall (uploaded PDF) for the make, model and year of my vehicle but apparently it only applies to certain VIN numbers. When I enter my VIN its shows no open recalls. However, the problem described in the recall is identical to the problem we are having.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691731October 6, 2025
UNKNOWN OR OTHER
My rear window suddenly shattered while I was driving. My safety was put at risk as it sounded like someone shot into my back window. The vehicle was inspected by state police.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691482October 5, 2025
UNKNOWN OR OTHER, ELECTRICAL SYSTEM
Horn No longer works in vehicle - A major safety issue
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691402October 4, 2025
ENGINE
Car was burning a significant amount of oil in between oil changes. The driving down the highway the car started missing and almost stalled out at 60 mph almost causing a accident now vehicle will not run properly and is blowing black smoke out of the tailpipe
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691252October 3, 2025
SEAT BELTS, STRUCTURE:BODY:DOOR
The contact owned a 2025 Hyundai Santa Fe. The contact stated that the driver's front door was making an abnormal creaking sound. The contact stated that while driving, but at a standstill, a 2008 Toyota Camry rear-ended the vehicle. There was significant damage on the driver's side of the vehicle. There were no warning lights illuminated. The alert was making the normal dinging sound for the approaching vehicle. The driver sustained a concussion. The passenger sustained injuries to her hip, back, pelvis, and orthopedic system, and medical attention was provided. The contact's daughter was occupying the passenger-side seat, and the seat belt dislodged near her waist from the outside near the door (the seat belt retractor connected to the vehicle's structure). A police report was filed. There was no fire or airbag deployment. The local dealer was contacted, but the vehicle was not diagnosed or repaired, as they were having mechanical issues at the time. The manufacturer was contacted, but no assistance was provided. The Hyundai inspector was able to inspect the vehicle, but the findings were unknown. The vehicle was taken to a collision center, and the vehicle was deemed a total loss. The failure mileage was approximately 5,000.
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11690932October 2, 2025
ELECTRICAL SYSTEM
2020 Hyundai Santa Fe Limited AWD, VIN [XXX] , 30,000 miles. Air conditioning fails to blow cold air; climate control displays -10°F, indicating a defective evaporator temperature sensor per Hyundai TSB 21-HV-002H (2021). Dealer diagnosed evaporator/thermostat failure, quoted $2,500, despite TSB specifying a $30–$50 sensor replacement. Vehicle is 9 months past 5-year warranty but under 60,000 miles. This known defect causes driver discomfort and potential visibility issues (fogging in humid conditions). I have dash photos and dealer quote. Request NHTSA investigate for recall due to widespread HVAC issues in Hyundai models. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11691077October 2, 2025
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: ASSIST
The driver assistance warning system continuosly goes into shutdown mode. Eye monitoring system always states that you are not keeping your eyes on the road. I have tried using different glasses or no glasses. Changing the steering wheel settings also seem to have no effect. This is very dangerous as it will start decelerating and stopping in the middle of a freeway in heavy traffic when this warning is activated. This only happens with the lane keeping assistance and adaptive cruise control are on. Hyundai issued Technical service bulletin 25-GI-001H, but they did not solve the problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe