Hyundai Santa Fe Complaints

8,019 consumer complaints on file.

#11727778March 29, 2026
ENGINE
Oil pan leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727630March 28, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I purchase the 2017 Santa Fe Sport in October of 2023 with just short of 80K miles. It was in great condition and had no issues. I have maintained it according to Hyundai specification and regular on schedule oil changes with recommended 5w-20 full synthetic. At approximately 100K miles, I experienced an oil pressure light on the dash, when checked, the engine was approximately 2 quarts low. From this point on, the engine started consuming oil at an increasing rate all while I maintained regular maintenance. First, 1 quart a month, or about 1200 to 1500 miles, then to 1 quart every 2 weeks or 800 miles. I maintained weekly checks on the oil level and on the evening of 3/24/2026, I had added a quart, bringing the level to the midway point between the high and low dipstick markings. On the afternoon of 3/24/26 while driving on the highway in heavy, but at speed limit, traffic on the highway, I experienced a loss of power and a check engine light. I was able to exit the highway but the car started to run very rough and unable to idle. Luckily, there was no traffic approaching when I turned off the exit and made a left into parking lot to shut off the vehicle. I will be having it towed to a dealership in the next few days for their analysis.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727699March 28, 2026
SERVICE BRAKES
My insurance company said I have an urgent Recall on my vehicle. Recall # 251 ABS fuse replacement. NHTSA# 23V651000. I would like this replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727705March 28, 2026
VEHICLE SPEED CONTROL, ENGINE
Gas Motor is not engaging to assist electric drivetrain on a hybrid AWD 2025 Santa Fe. This resulted in a dangerous situation crossing a busy road from a stop sign. The Santa Fe rolled into the intersection at the drivers request, but did not accelerate normally (only to a maximum of a few miles per hour) and felt like an eternity to cross the road. Fortunately oncoming drivers from left and right were paying attention and slowed down and in one case honked aggressively to point out we driving badly. Pulling over to the side of the road, turning the vehicle off and then back on again has sometimes made it run normally, but we limited our trips at that point to first getting safely home and then delivering it to the dealer. The 20 mile drive to the dealer required pulling over twice to reset the vehicle so the electric motor would assist. We have had repeated warnings from the onboard system including "Follow up checks required - Engine Management System" and "There may be a problem with the engine management system Contact your Dealer". I will note that we have 11,000 miles and 11 months experience with the vehicle with NO problems. It may not be relevant, but these new faults began 2 days routine service for oil and tire rotation when recall was performed including ECU Software Update for Recall 25-01-028-1. Dealer is uncertain of problem and referring with outside tech assistance from Hyundai but we were told to expect 2 weeks for parts and repair and uncertainty as to whether that would fix it. In the meantime a vehicle with unreliable acceleration and top speed is unsafe and parked. I do note on this NHTSA website 2025 HYUNDAI SANTA FE HYBRID SUV AWD that there are 47 Complaints. 9 relating to this problem all beginning October 2025 and none prior back to the first post of Nov 2024 for this model. Complaints similar to this for engine management and speed and power loss account for 50% of complaints for this vehicle on the NHSTA website since October 2025.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727441March 27, 2026
TIRES
This complaint goes with my issue 11727421. After I replaced my driver from in [XXX] , my passenger front blew out on XX entrance ramp from the expressway north of [XXX] . Called [XXX] and AAA took us to [XXX] . Replaced tire next day. Two tire failures on the same trip! This one was scary. Very busy highway there north of [XXX] . We were on the inside lane with little room to guardrail. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727421March 27, 2026
TIRES
255/45R20 We had a front driver tire get a bubble on our way to Florida. Had it replaced in [XXX] . On our trip back we had a blowout to the passenger front on XX just outside of [XXX] , in a very vulnerable area on the left side of the road. Called Hyundai SOS and they had AAA come. Got my wife out through the drivers door and over the guardrail while we waited. Called [XXX] as the traffic was flying by and the car has very little room on the berm. The tire blowing had no warning. Got a new tire the next day in [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727182March 26, 2026
ELECTRICAL SYSTEM, SERVICE BRAKES
Bottom brake lights will not work but top high brake light works. I was stopped by police three times. They state all three brake lights must operate.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727271March 26, 2026
UNKNOWN OR OTHER
Service Campaign Update 9C2 was installed. Since then erratic shifting occurs including up and down shifting without change in acceleration and deceleration or lag. This lasts between 1-5 minutes after initial vehicle start-up. This is dangerous when vehicle attempts to pull out into traffic. Hyundai has been aware of the issue as early as December 2025 but no notice of corrective action has been received.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727316March 26, 2026
STRUCTURE:BODY, SUSPENSION
Rear subframe suddenly collapsed and broke due to extreme corrosion. Incident occurred while driving, allowing rear wheel to turn out causing loss of control. Luckily I was traveling at a low rate of speed and nobody was hurt. Found rear subframe was completely rotten out and collapsed on the driver side. Vehicle is now completely undrivable and has to be towed. Found that there was a recall/service program from Hyundai (campaign #947) and my vehicle was affected. I called my local dealership to schedule an inspection appointment regarding the recall. Dealership told me I had to call Hyundai customer care. I called customer care on Tuesday and my claim was escalated. The representative told me that I would be contacted by Hyundai within two days. I have not received any correspondence from the case manager. Called Hyundai Customer Care once more and the representative told me that they can't contact claims representatives directly and I would have to wait until they decide to call me.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726897March 25, 2026
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that’s true—adjust if needed). Vehicle has approximately 28,000 miles. The vehicle is currently at a dealership for inspection and diagnosis, but the issue has not yet been confirmed or resolved at the time of this report.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727026March 25, 2026
ENGINE, EQUIPMENT, ELECTRICAL SYSTEM
The contact owns a 2010 Hyundai Santa Fe. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning lights were illuminated. The vehicle failed to immediately start, but started after several attempts. The vehicle was taken to an independent mechanic, who replaced the starter, oil filter, and engine filter, and changed the oil. On a hot day, there was a loud sound coming from the vehicle, and it was noticed that the unoccupied vehicle was attempting to start independently. The contact unlocked the vehicle and opened the vehicle door, put the keys in the ignition, and continued to crank for approximately four minutes. The accelerator pedal was pumped, and the vehicle stopped. There was smoke coming from the vehicle, and the vehicle eventually stopped. There were flames coming from the vehicle. The contact called 911, an independent mechanic, her father, and the fire department. The Fire Department was able to extinguish the fire and disconnect the battery. The mechanic determined that the engine cover was burned. There were no reported injuries. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact indicated that the failure was related to NHTSA Campaign Number: 11E040000 (Equipment). The insurance company referred the contact to the NHTSA Hotline for assistance. The manufacturer was not contacted. The failure mileage was approximately 145,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11726750March 24, 2026
UNKNOWN OR OTHER
I'm reporting a rearview camera issue in my Hyundai Santa Fe 2020. The camera image was previously static/distorted and has now completely stopped working. When the vehicle is placed in reverse, no image is displayed. This creates a safety risk, as the rearview camera is essential for visibility and preventing accidents while backing up. I am aware there has been a recall for similar rearview camera issues; however, my vehicle is not included because the recall is VIN-specific, despite experiencing the same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726855March 24, 2026
SEATS
My 2026 Hyundai Santa Fe has a dangerous power-fold feature for the middle row. This problem is making headlines in another model, the Hyundai Palisade, and for good reason. Why isn't the Santa Fe included in the recall(s) that are intended to correct the problem in the Palisade? In my vehicle, the second row has two seats (captain's chairs). The power-fold feature is the only way to fold the middle row for additional cargo space. When my wife activated the power-fold, I was unable to prevent that seat from folding. When I activated the power-fold, and an [XXX] relative was standing outside the vehicle, he was able to reach in, but he was not able to prevent the seat from folding, and he was very concerned when he learned this. Please note that, when the middle row seats are (manually) positioned forward in the vehicle, the power-fold feature does reverse when the folding seat contacts the back of a front seat. So there must be a sensor, but its threshold is set very high. In addition, when the conflict is removed, by (manually) moving the middle row seat backward in the vehicle, the auto-fold seems to take that as an invitation to fold again. I have only observed this once, but I argue that this is an uncommanded movement, and that there is no possible justification for this software/firmware action. Thank you for reading this. Please consider the Santa Fe for a future recall campaign. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726528March 23, 2026
ENGINE
These vehicles are not suitable to be on the road, and you NHTSA and Hyundai are doing NOTHING ABOUT IT. These vehicles are EATING oil, a quart every 200 miles. My daughter(college) can't even go on a short road trip to another city without adding oil. The engines in these crap cars are blowing up left & right. There are numerous Facebook page groups for these and sister Kia vehicles with the same 2.4 engines. Thousands upon thousands of posts about engine oil and engines blowing up, no one doing anything about it. My daughter's car is beautiful, but worth NOTHING due to this issue, so we are out thousands of dollars on this. We are about to go to WAR with Hyundai on this and I'm sure we'll get nowhere. If we're lucky, they'll install a rebuilt engine...BUT IT"S THE SAME CRAP ENGINE!!!!!!! So we are ALL back to square ONE and NHTSA is doing NOTHING. This is a well known FLAW for years now.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726542March 23, 2026
ENGINE, FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL
Vehicle would not accelerate in high speed zone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726394March 23, 2026
SEATS
When the power button on the seat is pressed to move the seat forward or fold it down, the second row captains chairs fail to stop from folding if someone or something is in the seat.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726392March 23, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS
Vehicle will not brake assist in the front even though all of the settings are selected it to work and assist in the event of needing to brake suddenly.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726318March 23, 2026
SEATS
vehicle unable to determine when a passenger is seated with seatbelt fastened in 2nd row captains chairs and the ‘one-touch’ tilt-and-slide button is pressed. The seat will keep folding and crushing the passenger. This is a known issue with the Hyundai Palisade at this time and is affecting my vehicle as well. Please have Hyundai issue a recall immediately. My teenage son was in the seat at the time this happened.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725726March 20, 2026
ENGINE, SERVICE BRAKES, ELECTRICAL SYSTEM
After performing regular oil changes, and even a new fuel pump sensor, I experienced an issue. Last oil change was within the past two weeks. Driving home from the mountains, I heard a knocking sound from the engine bay. I narrowed it down to all gears above 2500RPM, increasing knocking with RPM speed. I took it easy on the engine, mostly coasting down the mountain. Suddenly during acceleration on an uphill, a pop sounded, and copious white smoke started coming from the engine bay. I pulled over despite having no power brakes but I was fortunate to be near an off ramp in a rural area. Trying to troubleshoot roadside, i noticed fluid on the tie rod, but I wasnt able to determine what kind of fluid it was. When I try to start the car, there is one single click, the engine wont even attempt to turn over. Oil, battery and check engine lights are all on. After towing, I found that the fluid leaking from the vehicle is oil. The vehicle is currently at a transmission shop, but from my research, this isnt a transmission issue but a blown rod bearing the Hyundai engines are know for. I will be contacting a dealership to see if they will at least confirm my diagnosis.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11725733March 20, 2026
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, ENGINE
Engine rattles noise when starting the car after sitting for more than an hour it makes that sound another issue is that when i turn the headlights on all interior lights shuts off including the instrument cluster radio and ac climate control buttons
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe