Hyundai Santa Fe Complaints (2017)

972 consumer complaints on file.

#11628124December 1, 2024
ELECTRICAL SYSTEM, SERVICE BRAKES, ENGINE
My complaint is the dealership that said had completed the recall on my brake systems according to both your and state records was not completed. They gave me a service notice stating the work was done. Since then the braked have continued to act up and the vehicle as a strange acceleration problem. The dealership is Don Wood Hyundai in Athens Ohio.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627525November 26, 2024
ENGINE, UNKNOWN OR OTHER, VEHICLE SPEED CONTROL
The engine seized due to an issue with the oil plug and another part, leading to a lack of oil in the system. The vehicle is currently with Hyundai and available for inspection upon request. How Safety Was Put at Risk: While driving on the highway, I suddenly lost acceleration (below 40mphs). I was forced to pull over to the left side of the highway where it was shallow, where I risked being hit by passing vehicles until there was a safe break in traffic, allowing me to maneuver to an exit. This created a hazardous situation for both myself and other drivers. Reproduction or Confirmation of the Problem: The issue has been confirmed by an independent automotive technician, who diagnosed the problem as a blown engine caused by a lack of oil. The vehicle is now with Hyundai for further inspection. Inspection by Others: The vehicle has been inspected by an independent service center and is currently being inspected by Hyundai. No other parties, such as the police or insurance representatives, have been involved. Warning Lamps or Messages Prior to Failure: The only warning sign prior to the incident was the check engine light blinking at the time of the failure. There were no other warning lamps, messages, or symptoms before the engine seized. The vehicle was within the oil range limit of 7,500 miles at the time of the incident. Additional Notes: The incident occurred suddenly, without prior warning or indication of an issue. Based on the diagnosis and known issues with the oil plug, I believe this failure was caused by a defect.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627161November 25, 2024
ENGINE, FUEL/PROPULSION SYSTEM
I have Hyudai Santafe 2017 Sport, bought it from dealership in 2020 with 46,000 Miles and in around past 4/5 years added 30,000 miles. Which is not much, in the past one year i have noticed that engine oil is burning faster than usual. On every oil change after driving between 1200 and 1500 miles the oil engine sign blinks and upon checking needed 2 Quarts of oil. I spoke the dealership and they are not very helpfull. Also they did the oil combustion test which i was charged. Later i was advised to do. ("Good morning, Just got off the phone with you sir warranty won't cover it due to the vehicle being out of manufacture warranty and mileage. My technician recommended starting with combustion chamber cleaning which would be around 1200 before taxes and shop supplies. Combustion chamber cleaning is the process of removing carbon buildup from the combustion chamber and intake valves of a fuel-injection engine. to see if that fixes the problem that you are having with the car burning oil. If that step doesn't work we we would submit a warranty pa again, to see if they would cover a new engine." Please advise what should be my next step, as per my mechanic the only solultion right now i have is keep adding oil carefully.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627127November 24, 2024
ENGINE
I was driving my 2017 Hyundai Santa Fe and suddenly I heard the knock sound from the engine and when I pulled over, I saw the oil came down from the engine. I towed my vehicle to Hyundai dealership and they diagnosed the issue is vertical square and potential rod bearing failure. My vehicle has only 91k miles. I want to find out if there is any recall on this issue that happened to my car. Please let me know.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626601November 21, 2024
ENGINE
Excessive oil consumption greater that 1 quart per 1000 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625743November 17, 2024
ENGINE
After a perfect dealership maintenance history and being babied since bought new, the 3.3L V6 engine in our 2017 Hyundai Santa Fe seized at 101,800 miles without any warning other than a slight knock on startup the day this occurred. The engine seized while being driven on a side road without any warning lights, causing loss of steering and braking power. Hyundai has extended the warranty on the 4 cyl engines for this model year vehicle, but based on online forums there is clearly a manufacturing defect with the V6 engines as well. We were forced to pay ($1,541) for 20% of the cost to repair the engine with rebuilt components after Hyundai kept the car for nearly four months. I feel this payment should be reimbursed given the warranty on the V6 engines also needs to be extended.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625178November 14, 2024
UNKNOWN OR OTHER
While driving down the road at around 50 mph with no one in front of us, we heard a loud bang above us, and our Panoramic Sunroof exploded. I continued driving to reach a safe area to pull off and look at the damage, and saw glass flying away behind me into oncoming traffic. When surveying the vehicle, there was a large whole in the middle of the panoramic sunroof. It seems to have simply exploded, as there were no cars in front of us and nothing could have hit the vehicle at the time. We were able to pull off safely and cover the hole with cardboard and duct tape to get home safely. However this is a huge safety risk. Had we been on the interstate, we would have had to drive for miles with a blown out sunroof creating unsafe conditions for ourselves and other drivers. Hyundai (so far) will not warranty this as part of their extended warranty even though there are numerous class action lawsuits against them for this part being defective. I believe that Hyundai should be held responsible for exploding panoramic sunroofs. This is not the first incident they have had as it seems to be a regular occurrence.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625241November 14, 2024
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
While driving on rural side road, two lanes, my check engine light (yellow, steady) came on. I pulled into a safe spot and did a quick survey, checked the owner manual, but could not identify any problem, and continued on my way. The check engine light was still on. About 15 minutes later the car would not accelerate past 25 mph (limp mode?). I was on a two-lane mountain road, speed limit 45 (but most cars were faster), visibility limited by terrain, trees, etc. Again, there was little traffic around me and I found a safe place to pull over. in neutral the engine revved normally. I turned the ignition off, checked oil level, (normal), turned the engine back on and started driving to find a safe place to pull over and summon help, but the car drove normally. I drove directly to my repair shop and had the codes pulled, (0436, 0021) which indicate a problem with timing. When a qualified tech examined it he recommended taking to the dealer. Unwilling to drive in traffic, I had it towed to the dealership. Their inspection revealed damage to CVVT components and the timing chain, and recommend an (expensive) engine rebuild.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11624481November 11, 2024
ENGINE
Engine blew due to excessive oil consumption (at time of incident I had not a drop of oil left) with no warning. My safety was put at risk by my car stalling in the middle of driving with my kids in the car. My vehicle is now at a service shop, mechanic informing me I need a whole new engine. My dashboard never showed low oil light or service engine light, I never had black smoke or smell.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622222October 28, 2024
ENGINE
I went for an oil engine and they told me that my engine didn't have any oil. I checked for oil leaks and the vehicle does not have any oil leaks. My car has 100,480 mileage and have never been in any sort of accident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622151October 27, 2024
ENGINE
My car has 81,000 miles on it, I have had regular oil changes and after reading many recalls on here I see I am definitely not alone. My check engine light stays on, after paying $100. for dealer to check the codes I was told nothing in particular showed a problem even though I have to put oil in my car between oil changes and there are no leaks on drive. Apparently the 100K mile warranty is not being honored from the other reports I have read on here. Why ??? The price of new cars is beyond reach and if dealer is claiming there is a warranty there be should be way to make them honor it!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622077October 26, 2024
ENGINE
The engine seized. Driving at 55 mph on a 4 lane highway outside of city limits, the vehicle went into limp mode. Luckily, it was later in the evening with less traffic and I was fortunate enough to be able to turn into a left turn lane and coast into an office building parking lot. There was no shoulder available if I had been in the right lane and somewhat of a rural area. There were no sensors that alerted me prior to this happening. But, when it did happen the dash board lit up like a Christmas tree! It was 6:30 pm, I coasted into a parking spot in the lot and turned the car off. It would not start and I contacted a tow service. I had it towed to an automotive shop near my home. They confirmed the next morning, that there was no oil on the dip stick and the engine seized. They alerted me to the fact that this has become a common problem with this Hyundai engine. I then had the vehicle towed the Hyundai dealership where we purchased the vehicle. We are the original owner. The vehicle is sitting at Rosen Hyundai in Algonquin, IL and should be available for inspection. Monica at the dealership called me after the inspection and confirmed that this is a common issue with this vehicle. She at first used the word recall...and when I asked if there was a recall, she said not a recall, but Hyundai has issued a BULLETIN about this problem. At first, she stated that my maintenance records were in order and being the original owner I qualified to file a claim with Hyundai for engine replacement. 3 days later, she called and stated that Hyundai needed more proof of maintenance than what they could pull off Carfax or my claim was going to be denied. She sent me a picture of the engine and stated that the valves show neglect. I replied of course they do....the engine seized! There was never ever any low oil warning light, check engine or or any warning lights what so ever prior to the event! Hyundai admitted that there is no low oil sensor warning.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11621577October 23, 2024
ENGINE AND ENGINE COOLING
The contact owns a 2017 Hyundai Santa Fe. The contact stated while starting the vehicle, there was an abnormal ticking noise detected. There were no warning lights illuminated. The contact stated the noise was coming from cylinder #3 and the lifters. The vehicle was taken to the dealer, who was unable to duplicate the failure while starting the vehicle. The vehicle was not diagnosed or repaired. The vehicle was taken to another local dealer Service Center at Gurley Leep Hyundai (5302 Grape Rd Suite #3, Mishawaka, IN 46545); which determined that the cam shaft and pump electronic body sensor, ABS, and harness needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620590October 18, 2024
ELECTRICAL SYSTEM
The liftgate randomly closes and I have to jump out of the way to avoid it hitting me. This obviously poses a huge risk to my young children when they are nearby. In addition to that, the liftgate will sometimes only open a quarter or half of the way, sometimes all the way then suddenly reverse and start closing, and sometimes does not open at all. I've gone on Hyundai forums online and found numerous other people with the exact same complaint. Seems to be effecting cars made from 2016 - 2020. I have multiple videos of this but can't upload them as you only accept pictures.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619790October 15, 2024
ENGINE
The engine consumed all of the oil and now has to be replaced
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619964October 15, 2024
ENGINE
Since this vehicle reached about 75,000 miles, it has been burning oil like crazy. We have to add a quart every 7-10 days. It drives fine, there’s no oil leaks, no smoke from the tailpipe. We took the car to Hyundai and they did their oil consumption tests. They came to the conclusion that this was within the normal range and would do nothing for us. This needs to be fixed, Hyundai!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11620000October 15, 2024
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
While driving a 1/2 second squeal came from engine compartment. Motor immediately stopped. No power steering or brakes. Vehicle is available for inspection. We were on an interstate We coasted to shoulder. There issue is frequent on Internet forums. A trusted mechanic old us the engine was totally seized. Could be turned manually. No oil in crankcase. At this time only aforementioned mechanic has inspected the vehicle. No warning sounds or performance changes prior to incident. No warning lights or notice warnings were seen prior coincident.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11619332October 11, 2024
ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC
The contact owns a 2017 Hyundai Santa Fe. The contact stated that while his wife was driving at undisclosed speeds, the vehicle lost automotive power and the vehicle failed to stop while depressing the brake pedal. The vehicle was allowed to decelerate and come to a stop. No warning light was illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the alternator needed to be replaced. The vehicle was repaired. In addition, the contact stated that the engine was previously replaced and the contact was concerned that the warning lights on the instrument panel might not properly display because the check engine warning light had not illuminated during the previous failure. The manufacturer was made aware of the failure. The failure mileage was approximately 121,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618953October 9, 2024
ENGINE
Like many others, car consumed a quart of oil each 500-1,000 miles driven. Car received synthetic oil changes every other month along with additional quarts of oil in between oil changes. All service records maintained with receipts of additional oil quarts purchased. Car NEVER displayed any warning lights for low oil pressure or check engine lights. While driving on the highway at 65 MPH, engine seized. Was able to pull over safely and had car towed to the dealership. Service manager at dealer claims it will be over $20k to fix but Hyundai is only willing to cover 70% because it’s no longer covered under warranty and isn’t backed by their extended warranty offer. What a way to admit fault but gaslighting the consumer into believing it’s the consumer’s fault for a faulty product. Hyundai does not allow outside mechanics to look at vehicle or make repairs if you want them to take responsibility. So stuck with paying inflated dealer fees for repair and labor.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11618780October 8, 2024
ENGINE
The contact owns a 2017 Hyundai Santa Fe. The contact stated while driving at an undisclosed speed, the engine was making an abnormal sound and the RPM increased. In addition, the contact stated that every 2,000 miles engine oil needed to be added to the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a cracked valve cover and excessive oil consumption. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the repair was not covered under warranty due to the codes received per the diagnostic test. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 142,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Hyundai Santa Fe