Ford · Model Report
Showing safety data for the 1991 model year only.
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
EQUIPMENT DESCRIPTION: AFTERMARKET BRAKE ROTORS FOR USE ON CERTAIN FORD AND MAZDA TRUCKS. CRACKED CASTINGS CAUSED CRACKS TO APPEAR ON THE OUTER DIAMETER OF THE ROTOR HAT OR AROUND THE STUD HOLE.
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
TL* THE CONTACT OWNED A 1991 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN IT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND NO INJURIES WERE REPORTED AT THE SCENE. THE VEHICLE WAS DESTROYED. THE DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 150,000. UPDATED 8/23/12 *CN
TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE OF THE VEHICLE HAD DROPPED APPROXIMATELY FIVE INCHES FROM THE REGULAR POSITION AND THE FRONT FENDER WAS COVERING THE TOP OF THE FRONT PASSENGER SIDE TIRE. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTICS. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE COIL SPRING MOUNT WAS CORRODED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT A LOCAL AUTO SHOP WAS CONTACTED AND ADVISED THAT THE PART WAS NO LONGER AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1991 FORD RANGER. THE CONTACT STATED THAT THE FUEL TANK STRAP BECAME CORRODED AND WAS PARTIALLY FRACTURED FROM THE VEHICLE. THE CONTACT WAS CONCERNED THAT IT WOULD CAUSE THE FUEL TANK TO DETACH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE STRAP WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THERE WERE NO RELATED RECALLS TO THE FAILURE AND PROVIDED NO FURTHER ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 142,800 AND THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
No injuries · No fire · No crash
THE FRAME HAS HORRIBLE CORROSION. ALL THE SPRING HANGERS ARE WERE FAILING BAD. I DON'T EVEN THINK IT CAN BE WELDED BECAUSE IT IS RUSTED FROM ONE END TO ANOTHER. FORD REALLY MESSED THIS ONE UP. AND WHY DO ALL THE FUEL GAUGES QUIT WORKING? *TR
No injuries · No fire · No crash
PEELING FACTORY PAINT PRIMARILY ON TOP SURFACES..I.E. HOOD, CAB ROOF, COWLING. I HAVE OWNED TRUCK SINCE 12/8/99 AND HAS HAD PROBLEM SINCE,IT HAS LOST NEARLY ALL PAINT ON ROOF , HOOD HAS ABOUT 1/3 LEFT. PRIMARILY LIFTS/PEELS WHEN WASHED OR WHEN LEFT OUT IN RAIN. HAS HAD BITS PEEL BACK AT HIGHWAY SPEEDS. MAINLY OCCURS THOUGH WITH WASHING. HAVE INQUIRED WITH DEALERS TO NO AVAIL. WAS TOLD BY ONE THAT THERE WAS A RECALL BUT THAT THE PERIOD FOR REPAIR OF CONDITION HAD PASSED. I HAVE NOT RECEIVED NOR HEARD ANYTHING FROM MFR REGARDING THIS ISSUE WHATSOEVER. *TR
No injuries · No fire · No crash