Ford Mustang Complaints (2018)

196 consumer complaints on file.

#11772491October 20, 2026
ENGINE
The engine has a head gasket defect that leaked coolant into the engine causing misfires and requires a very expensive repair for a defect that came with the engine when it was made. Two Ford dealerships have inspected and confirmed the issue. The car threw codes six months ago and we immediately stopped driving it and had the dealership inspect the problem. We have not fixed it yet as the repair is estimated at 6,000. Parts and labor. It is available for inspection. This seems to be a very common issue with this vehicle. We replaced the fuel rail, spark plugs, and have had an independent inspection by a non affiliated repair shop for a similar price.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11770803October 13, 2026
ENGINE, POWER TRAIN
The 2.3L EcoBoost engine failed due to coolant leaking into the combustion chambers. The dealer found coolant present in cylinders 1 and 4, the cylinder 4 piston washed, and vertical scoring on the cylinder 4 wall. The dealer's recommendation is complete engine replacement. Yes, the engine is available for inspection. The vehicle is currently at the Ford dealership and the engine has not yet been replaced. Coolant entering the cylinders causes misfiring and loss of engine power. The vehicle shook on startup and ran roughly, and the misfire was intermittent and unpredictable. A sudden loss of motive power while driving in traffic or at highway speed is a crash risk to me and to other drivers. Coolant loss into the cylinders also reduces the coolant available to cool the engine, creating a risk of overheating. The vehicle is currently not safe to drive. A Ford dealership has reproduced the issue and confirmed it. The technician retrieved stored codes P0304 and P0316, removed the spark plugs and coils, and borescoped the cylinders. A cooling system pressure test was performed and the vehicle was allowed to sit, after which borescope inspection confirmed coolant in cylinders 1 and 4. This was the second visit for the same concern. At the first visit, in August 2026, the dealer replaced all four spark plugs and the cylinder 4 ignition coil, and the misfire returned within weeks. The vehicle has been inspected by an authorized Ford dealership. A goodwill assistance case has been opened with Ford Motor Company and Ford has offered partial coverage of the repair. No police or insurance inspection has occurred. The check engine light illuminated and the vehicle shook on startup and ran roughly. These symptoms first appeared in August 2026 at approximately 32,600 miles. The dealer replaced spark plugs and an ignition coil at that time and the symptoms returned within weeks. Check engine light was not illuminated at the second visit, but codes were stored in memory.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11768592October 2, 2026
ENGINE
Check engine light came on Sunday night. Monday had AutoZone check the codes - indicated misfire on two cylinders recommended spark plug replacement - Spark plugs purchased with intent to change Tuesday evening- Tuesday morning -Engine overheated on the way to class added more coolant - got the vehicle home and towed to local Ford Dealership the next day to learn that the coolant was leaking into the engine due to head gasket failure. Ford said the engine needed to be replaced.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766779September 24, 2026
ELECTRICAL SYSTEM, FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The electrical components in the vehicle stopped functioning - for the lights on the interior the overhead stopped working on and off and then dimmed until one day never came back on. At the same time the sensor for cross traffic alert became buggy and then not functional which made all my safety features and cruise control not work. Now I have a TPMS sensor and check engine light with nothing serious wrong
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765966September 21, 2026
UNKNOWN OR OTHER
While driving at highway speeds passenger door spontaneously opened. Passenger was not touching or near latch. Has happened 3 times. Ford states no recall. Looking online seems to be a known issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763525September 11, 2026
UNKNOWN OR OTHER
I own a 2018 Ford Mustang EcoBoost convertible and am reporting persistent spider activity that has become a recurring driver-safety concern. Spider activity occurs on or around the vehicle essentially every day. I routinely see multiple spiders and webs on the windshield, hood, doors, roof, trunk, sides, and around both exterior mirrors. Spiders repeatedly build webs between the doors/body and both mirror housings, and I have seen spiders crawl out from behind the mirrors numerous times, especially the driver-side mirror. I also find web strands inside the passenger compartment. On three occasions, a spider rebuilt a large web across the driver’s-seat entry area after I removed it. On Sept. 10, 2026, after a commercial car wash earlier that day, I had about six spider sightings within roughly 10 minutes. While driving, I saw one crawl up the hood and disappear near the base of the windshield. Shortly afterward, a sizable spider appeared INSIDE the windshield directly in front of my face, apparently coming from where the dash meets the windshield. I have severe arachnophobia and had an immediate panic response. I was fortunate to reach a nearby parking lot and stop without crashing. During the same period, I saw two spiders on the trunk, then another crawling across the interior headliner directly above me, followed by another emerging from the driver-side mirror. I am becoming genuinely afraid to drive this vehicle. This is not a cosmetic complaint. Spiders repeatedly appear in the driver’s immediate environment and create a risk of sudden distraction, involuntary panic, abrupt steering/braking, loss of lane control, and a crash. The car is normally kept closed and I rarely lower the convertible top because of this problem. I am not asserting a specific defect or entry path. I am asking NHTSA to review similar complaints and determine whether a vehicle-design condition may be contributing to persistent spider habitation or intrusion into the driver’s area.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763539September 11, 2026
FUEL/PROPULSION SYSTEM, ENGINE
I own a 2018 Ford Mustang EcoBoost Premium with the 2.3L EcoBoost engine. The vehicle initially developed a check-engine light and was diagnosed with P0303 (Cylinder 3 misfire), P0316 (startup misfire), and P018C (fuel pressure sensor circuit low). On August 24, 2026, all four spark plugs and one ignition coil were replaced, and a fuel/induction cleaning service was performed. The P018C repair was declined at that time. On September 10, 2026, the vehicle started with an extremely rough idle and produced a very large cloud of white, sweet-smelling exhaust smoke. The check-engine light came on. The original codes, including the misfire codes, were present along with additional codes. The vehicle underwent approximately three hours of diagnostics and road testing. The codes were cleared, and afterward only P018C returned. Testing reportedly did not identify a head-gasket leak, but visible white smoke was still coming from the exhaust when I left the repair facility. Possible coolant intrusion involving the turbocharger was discussed, but the source was not confirmed. Later that day, the vehicle would not crank in Park but started in Neutral. While driving home, the engine began idling so violently at a traffic light that the entire vehicle shook and the tachometer fluctuated significantly. Before September 10, the vehicle had never produced white exhaust smoke, never shaken violently at idle, and always started. The repair facility attempted to inspect the cylinders with a borescope, but both of its borescopes were not functioning. I am concerned about possible coolant intrusion or another engine defect because of the Cylinder 3/startup misfire history, heavy white sweet-smelling exhaust, and severe intermittent rough running. The cause has not yet been confirmed, and I am concerned about possible engine failure or loss of power while driving.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11763758September 11, 2026
ENGINE
I own a 2018 Ford Mustang EcoBoost Premium with the 2.3L EcoBoost engine. The vehicle initially developed a check-engine light and was diagnosed with P0303 (Cylinder 3 misfire), P0316 (startup misfire), and P018C. On August 24, 2026, all four spark plugs and one ignition coil were replaced and a fuel/induction cleaning was performed. On September 10, the vehicle suddenly started with an extremely rough idle and produced a large cloud of white, sweet-smelling exhaust smoke. The check-engine light illuminated and the previous codes returned along with additional codes. The vehicle continued producing white exhaust smoke after several hours of diagnostic testing. Later that day, the engine shook violently while I was stopped at a traffic light and the tachometer fluctuated significantly. On September 11, the check-engine light returned and the previous diagnostic codes were again present. Firestone documented that coolant was present in the exhaust, that the coolant level was low again after coolant had been added the previous day, that the engine was burning coolant and producing white smoke, and that coolant was mixed with the engine oil. Firestone stated the engine may have a cracked head, failed head gasket, or internal engine crack and recommended complete engine replacement. The engine has now suffered a serious internal failure severe enough that the repair facility recommends replacement. The vehicle has exhibited violent shaking, unstable engine speed, repeated misfires, rapid coolant loss, coolant contamination of the engine oil, and coolant burning through the exhaust. I am concerned that continued operation could result in complete engine failure or sudden loss of engine power while driving, creating a significant safety hazard in traffic. Before September 10, the vehicle had never produced white exhaust smoke or experienced this severe shaking. I am reporting this as a potential safety defect involving the 2.3L EcoBoost engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11762411September 6, 2026
SERVICE BRAKES
It is a well-known issue across Mustang forms that the brake pedal sensor switch goes bad as well as the small rubber pad that presses against the brake pedal switch. This has happened to me multiple friends in my Mustang group as well as tons online. This is a serious issue because either it will make your vehicle believe the brakes are constantly being pressed letting you shift into gears while the brakes technically aren’t even depressed. That could result in someone getting ran over. Also, it makes it appear that you’re constantly pressing the brake pedal so drivers do not know when you are actually pressing the brakes. I had that issue, I resolved it, but then my switch failed later, which let me not even start the vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757459August 17, 2026
ENGINE
2018 WITH 118,000 MILES. Had to get a full block engine replacement due to coolant intrusion into the cylinders. This was diagnosed and replaced at a Ford dealership.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754868August 4, 2026
POWER TRAIN
Was driving my vehicle roughly 10-15mph after a stop, noticed vehicle wasn’t shifting into the gears properly as it was only in 2nd gear and the RPMs kept climbing, when it finally shifted into 3rd gear my transmission proceeded to lockup cause my rear tires to skid and stop in the middle of traffic and in the middle of an intersection disrupting the flow of traffic. Vehicle displayed a wrench light on the dash saying “see manual” as related to a Powertrain issue. Vehicle is in limp mode and barely drives, any shifting after 1st gear will cause the vehicle to lockup and lose all power for several seconds. ONLY HAS 28,330 MILES, DID NOT REACH THE FIRST SERVICE INTERVAL FOR MAINTENANCE ON THE TRANSMISSION.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11752476July 23, 2026
POWER TRAIN
My 2018 Ford Mustang EcoBoost with the 10R80 automatic transmission began experiencing hesitation, delayed engagement, and harsh jerking during low-speed acceleration (15-20 mph), especially when cold. Engine RPM would increase, but the vehicle would hesitate before engaging. The condition worsened over time and eventually the vehicle entered limp mode, causing a significant loss of power and illuminating a wrench warning light. An authorized Ford dealership diagnosed DTC P07F6 (Gear 9 Incorrect Ratio). The dealer verified fluid level, updated the PCM, and performed adaptive relearn procedures, but the problem remained. The transmission fluid was found to be dark with a burnt odor, and the dealer diagnosed an internal transmission failure requiring complete transmission replacement at an estimated cost of $9,250. This created a safety concern because the vehicle did not consistently accelerate as expected when entering traffic, crossing intersections, or merging onto roadways. Delayed engagement and loss of power reduced the ability to accelerate when needed. The vehicle has approximately 82,256 miles and has been maintained according to Ford's recommended service schedule. I am also aware of numerous publicly documented owner reports, technical discussions, and litigation involving the Ford 10R80 transmission used in vehicles from this generation. One of the commonly discussed concerns involves the CDF drum design in earlier 10R80 transmissions. My understanding is that Ford later revised the CDF drum design in subsequent production; however, when I contacted Ford regarding this transmission failure and requested assistance with repair const, they advised that my vehicle was not covered by any recall, customer satisfaction program, or warranty extension related to this issue. I am submitting this report so that my experience can be considered together with other reports to determine whether a broader safety-related defect exists.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11746432June 25, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Mustang. The contact stated that while driving at various speeds, the engine sputtered with the check engine warning light illuminated. There was heavy white smoke coming from the tailpipe. Upon arriving at the destination, the vehicle hesitated to restart, and the contact observed a significant loss of coolant. The vehicle stalled while driving at various speeds. Upon inspection, the dealer confirmed coolant intrusion in cylinders #2 and #3, resulting in total engine failure. The manufacturer was notified of the failure and stated that the VIN was not under recall, and there was no warranty associated with the vehicle. The vehicle was repaired out-of-pocket by the dealer. The failure mileage was approximately 56,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11744688June 17, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Mustang. The contact stated that the air conditioning system failed to function as intended. Additionally, the contact stated that while accelerating from a complete stop, several unknown warning lights were illuminated, and the vehicle chugged and failed to accelerate as intended. The contact pulled over to the side of the road. The vehicle was towed to the residence. The contact stated that the vehicle was inoperable. The dealer was notified of the failure and informed the contact that there was no recall or warranty coverage for the vehicle. The contact was provided an estimate for the repair. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and suggested to purchase a new vehicle. The contact declined due to the sentimental value of the vehicle. The failure mileage was approximately 69,900.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741698June 2, 2026
UNKNOWN OR OTHER
The trunk wiring which powers the tail lights, brake and parking lights, turn signals, trunk light, and the back up camera is too short, and it stretches and breaks when the trunk is opened and closed. Ford is aware of the issue, but is unwilling to fix it. The back up camera was already recalled, but it and the trunk light are not working again because the trunk wiring issue has not been addressed. The biggest auto safety issue is that the tail lights, brake and parking lights, turn signals, and back up light could also fail due to the trunk wiring being too short.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738968May 20, 2026
ENGINE
1. Component failed and availability for inspection: The engine assembly block failed due to a manufacturing defect known as "coolant intrusion into the cylinders." The vehicle and the defective engine are currently located at my residence and remain fully available for federal or manufacturer inspection upon request. 2. Safety risk: The safety of myself and others was severely compromised. Coolant entering the combustion chambers causes sudden, severe engine misfires across all cylinders, erratic power loss, and instantaneous stalling. Operating a vehicle where the engine can suddenly lose all power on high-speed roads creates an immediate risk of rear-end collisions and catastrophic traffic accidents. Furthermore, high-pressure internal coolant leaks pose an inherent risk of engine fires. 3. Problem confirmed by a dealer: Yes. The problem has been officially diagnosed and confirmed by an authorized Ford dealership service center, which documented internal coolant intrusion. 4. Inspected by manufacturer, police, or insurance: The component was inspected and verified by the vehicle manufacturer's authorized dealership technicians. It has not been inspected by the police or insurance representatives, as no crash has occurred yet. 5. Warning lamps, messages, or symptoms prior to failure: Prior to the diagnosis, the vehicle exhibited a "Check Engine Light." Currently, the vehicle is suffering from critical failure symptoms: the Check Engine Light is flashing constantly, the engine misfire codes are actively showing on all 4 cylinders, and the vehicle shakes violently at low RPMs (rough idling). These severe symptoms first appeared approximately 2 moths ago and have progressively worsened due to the coolant intrusion.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732274April 19, 2026
POWER TRAIN, FUEL/PROPULSION SYSTEM
While completing a turn at a T-intersection, the vehicle experienced a complete loss of motive power for several seconds, leaving the car stationary in the path of oncoming traffic. The transmission (10R80) failed to engage, a known symptom of internal CDF Drum sleeve failure (TSB 24-2254). This follows a 'Green' inspection by a dealer on March 23rd where an axle seal leak and shifting issues were overlooked. The failure to engage gear during a turn creates an unreasonable risk of a T-bone collision.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731787April 17, 2026
ENGINE
A check engine light turned on and the vehicle was taken to a local dealership. The check engine light was for an engine misfire and was diagnosed further. There was an engine failure due to coolant entering the system. Upon further research, I learned this is a common issue for 2016-2020 Ford Mustangs and it is due to a faulty engine design. The dealership is recommending a new engine install with a price tag of over 13,000 despite this being known to happen because of a badly designed engine with these cars.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731374April 15, 2026
ENGINE
The vehicle was subjected to the “ecoboom” due to Ford’s lack of care when designing the engine. The car blew the head gasket and now requires an engine rebuild.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730972April 13, 2026
ENGINE
I was told by my mechanic I have a head gasket leak. Turns out there is a class action lawsuit for my 2.3 ecoboost motor for this coolant intrusion problem. It is a known problem. It is a safety issue as I’ve heard of some engine fires. My car only has 56000 miles on it but it is a 2018 so just out of the manufacturer warranty. I’ve reached out to Ford but no definitive answer on whether they will help or not they want me to pay them to diagnose it even though I’ve already had it properly diagnosed
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Mustang