Ford Maverick Complaints

323 consumer complaints on file.

#11713754January 27, 2026
ENGINE
The throttle body component of the vehicle failed at approximately 40,000 miles. While this is an engine component that experiences normal wear and tear, throttle body valves fail anywhere between 75,000 and 100,000 miles. I have owned previous vehicles, each crossing the 100,000-mile mark, with no replacement or concern with the throttle body. My concern with this vehicle's throttle body relates to the outdoor weather conditions when the vehicle reported an issue. The outside air temperature was 3 degrees Fahrenheit with moderate winds and a wind chill of approximately -10 degrees Fahrenheit. Researching online, this appears to be a recurrent issue among other owners of this particular vehicle. When started, the vehicle appeared to misfire, potentially entering limp mode. An amber wrench light illuminated, indicating to have the vehicle serviced, and the engine light illuminated, indicating a problem with the emissions system. Additionally, the vehicle pushed a notification to my smartphone that stated the following: "The engine control system has detected the electronic throttle body is not responding as commanded and requires service." The vehicle was turned off and sat for 15 minutes. When the vehicle was restarted, the wrench light turned off, but the engine light remained on, not flashing. The vehicle operated normally, with no misfire. The failure of the throttle body in adversely cold conditions may cause the engine to stall or misfire, decreasing driver control and increasing the potential of a crash. It is of concern that this component seems to have failed early compared to other vehicles currently on the market. I believe the weather to be a contributing factor. The servicing dealership has confirmed that the throttle body must be replaced and has the appropriate part on back order. As this vehicle was not involved in an accident, no police reports or insurance claims have been filed. I plan on reaching out to the manufacturer to address these concerns.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713512January 26, 2026
VISIBILITY/WIPER
Front windshield developed a stress crack along to of windshield from one corner to other
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713200January 25, 2026
POWER TRAIN, UNKNOWN OR OTHER
Battery goes into deep sleep truck will not crank this the 3rd time for this truck.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11713024January 23, 2026
SERVICE BRAKES, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
While flat towing in Neutral Tow Mode yesterday, [XXX] (appx. [XXX]), we were headed west on [XXX] traveling at 55-mph in the #2 lane when the Maverick abruptly started screeching the tires and dragging behind our motorhome. I was able to safely get to the right shoulder within about 100-yards. We were 18-miles into the 104-mile journey to our home from the RV park in San Dimas. (Level ground.) I then got in the Maverick, placed my foot on the brake, started it and shifted to Park to take it out of Neutral Tow Mode. (It started right up) I then received an error message on the display “Electronic Parking Brake needs servicing” I then unhooked the Maverick from the motorhome and successfully backed it up 50-yards along the shoulder and then drove it forward, the drive train seemed to be fine. At that point I decided to hobble home with my wife driving the Maverick, following behind the motorhome… when I located the next convenient offramp we pulled over to a side street where I drove the Maverick about 2-miles just to verify that it was drivable (other than the flat spots on the front tires.) I know that the EPB activates the rear brakes when stopped, however there aren’t any distinguishable flat spots on the rear tires. I understand that the EPB activates the hydraulic system when activated while in motion. This leads me to believe that the EPB activated on the freeway, causing the malfunction. When we safely returned home I connected the Maverick to the RV and flat towed for 5-miles without any problems. (Appx. 3:00pm) Other Possibility Possibly Neutral Tow Mode disengaged causing the drivetrain to lock up? But it was still in Neutral Tow Mode when I got in the vehicle to start it after the braking incident, and the vehicle doesn’t seemed to have drive train damage. (It drove the remaining 85-miles home without issue.) BlueOx Towing Setup (we have towed for 5,000 miles without issue) and BlueOx Patriot 3 supplemental brake system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11712661January 22, 2026
SERVICE BRAKES, AIR BAGS, FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
my daughter rear-ended another driver as she was entering a turn lane. Moments prior to the accident, she described what sounds like a brake booster failure. There was no indication the AEB system activated and only the airbag at her feet deployed. She hit the car in front of her at ~35 mph. 1. Brake system failure - yes, it is currently available for inspection 2. Car failed to stop and resulted in an accident. Luckily no-one was seriously injured. 3&4 car has not be examined by anyone, yet. Trying to figure out who best to look at the vehicle. 5 unknown
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11712273January 20, 2026
POWER TRAIN, SUSPENSION, LANE DEPARTURE: ASSIST
Clunking in the front end around 20,000 miles. Brought to multiple dealers and they all said no problem found yet clearly hear clunking both sides front going over bumps or steering back and forth quickly. Finally I just replaced them and noise gone. Second thing is headliner is completely ruined from moisture intrusion and can visibly be seen but dealer states no leaks present yet my headliner is water stained looking like those wet tiles in a school. Third is my transmission. It is very erratic when shifting and sometimes flares when downshifting. Dealers state no problems exist. Operates as designed, yet I have driven other mavericks and they do not have the same issues as myself. I have changed the fluid with genuine ford ulv transmission fluid from dealer at about 50k miles. I change my oil every 3k, changed my differentials and transfer case all with genuine fluid. I am an AAS Automotive Technology graduate and currently ASE certified and have worked in multiple dealerships replacing transmissions, engines, almost anything since I have started. I need to gather my records as I have kept receipts and records as I do all my own maintenance and repairs. I have replaced the downstream oxygen sensor twice. Yesterday morning I got a frozen throttle body and limp mode and if I did not have my scan tool I would have been stranded as it would not let me drive due to the stuck closed codes. All codes since I owned the vehicle with 3 miles on it are stored in my ford app and on my scan tool with vin. I have tried calling ford, email, different dealerships and they deny me or want me to pay out of pocket when I have warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11711805January 19, 2026
WHEELS
Premature degradation of Passenger Side CV axel just before 16,000 miles (no complete failure) Replaced by dealership under warranty.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710852January 14, 2026
STRUCTURE:BODY
When it rains water gets into the passenger-side footwell and beneath the carpeting during rain events.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710848January 14, 2026
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING, FORWARD COLLISION AVOIDANCE: WARNINGS, LANE DEPARTURE: ASSIST
I got out of my truck this morning once I arrived at work and the parking brake function unavailable message came on. I got back in and started the vehicle and Parking Brake Unavailable, Advanced Trac unavailable, Hill Descent Assist unavailable, ABS unavailable, and Forward Collision/ Lane-Keeping System unavailable messages were all on dash. Attempted to take my truck to Ford of Murfreesboro as there is a recall that is out on this issue for some 2025 Maverick EcoBoost trucks, even though it doesn't show up on my VIN, all symptoms on the recall I am experiencing. Ford of Murfreesboro service personnel was rude from the start and when I told them I didn't have an appointment, but feel like this is a safety concern they were quick to tell me it would be over a week before they could even look at it, and even if I had an appointment, it wouldn't be looked at for a week. Worst experience I have ever had with a dealership, and I will be an advocate that people DO NOT bring their vehicle to Ford of Murfreesboro if they want to actually be taken care of if their vehicle has any issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11710413January 12, 2026
UNKNOWN OR OTHER
This is a 2024 Ford Maverick Hybrid with about 12000 miles. After leaving it in the garage for 4 days, I am not able to start the car at all. Upon checking the Ford APP, it shows that it's in battery saving mode, which is unbelievable for a car under such condition. Looking at online forum, seems like a common issue as well.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709634January 8, 2026
ELECTRICAL SYSTEM
After a little over 3 years, my truck has had issues maintaining its 12v battery putting me at risk of being stranded. The battery was replaced once under warranty. Now that I am out of warranty, the replacement battery is now going bad.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709428January 7, 2026
VISIBILITY/WIPER
The vehicle was exposed to extreme cold (11°)for the first time since ownership. When getting into the vehicle and starting to move the windshield suffered a "Stress Fracture". Impeeding the drivers vision. This stress fracture was confirmed by a independent glass shop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709160January 6, 2026
UNKNOWN OR OTHER
The vehicle experiences water intrusion into the passenger-side footwell and under-carpet area during rain events. The suspected failure involves the body sealing system, potentially including the windshield cowl area, firewall seams, HVAC intake/cowl drainage, or related body panel seals. The vehicle and all affected components are fully intact and available for inspection upon request. The carpet has been lifted to document standing water and mold growth but has not been replaced or permanently altered. This defect presents multiple safety risks, including: Visible Black Mold contamination inside the passenger compartment, airbag, and throughout HVAC system, creating a health hazard for occupants. Potential electrical system damage due to repeated water exposure. Possible impact on airbag and restraint system wiring, which is located beneath the passenger-side dash and carpet. Increased risk of window fogging and reduced visibility during wet conditions. The vehicle is currently unsafe to occupy during or after rain due to these conditions. The problem is consistently reproducible whenever the vehicle is exposed to rain. The issue has occurred repeatedly over the course of ownership. A Ford dealership has acknowledged the presence of water intrusion but has not performed a full diagnostic inspection, instead requiring a paid inspection fee, claiming they are "fully booked until further notice" and stating they are “unaware” of similar issues, despite widespread owner reports.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708485January 3, 2026
ELECTRICAL SYSTEM
I had a problem once with the interface module, and since it was still under warranty, the Ford dealership in Fairfield, California replaced it and at 3:32 AM today January 3, 2026. The interface module turned off for a couple seconds and then turned back on which was basically the same problem as it was when I complained and had them replace it.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707036December 25, 2025
POWER TRAIN
Front CV axles began failing at around 20,000 miles. The truck shakes when accelerating at all speeds but especially at 40-50mph or under load.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705413December 16, 2025
UNKNOWN OR OTHER
I have the latest software update as of June 2025, recently when I shifted from reverse to Drive, the display stuck in backup camera picture. I have to put it back to Park and try again to drive and get to driving map display screen.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705141December 15, 2025
ELECTRICAL SYSTEM
I believe the OEM 12v battery that is used in the Ford Maverick hybrid is underpowered and has issues that seem to plague the vehicle. I’ve owned the truck for almost two years now and started getting “battery saver” alerts when the truck would sit for a few days over the week or during a vacation. But recently I’ve been getting the warning far more frequently and not even siting for more than 24 hours. Last month I had a warning that the power could turn off at any moment and need to pull over immediately. The warning went away after powering the vehicle down and turning back on. Last weekend the car was completely dead after using it all week and only letting it sit Saturday evening to Monday morning. The battery seems to be an issue that plagues the vehicle and I think an investigation needs to be conducted to have this corrected. I even see new 2025 models having similar issues.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11704892December 13, 2025
AIR BAGS
Front driver airbag did not deploy. Vehicle has been totaled and may not be available for inspection. Driver seatbelt tightened requiring an X-ray due to chest pains. Ford has ignored complaint. Unsure if police or insurance inspected though both questioned the airbag not deploying.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11704005December 9, 2025
ELECTRICAL SYSTEM
Battery in the passenger compartment is charging at 15.2 volts constantly. Ford dealer claims this is not a problem, but the battery life has been shortened, and the battery model number states it should be charged between 13.8 and 14.2 volts. The battery is located under the rear seat, inside the passenger compartment. From my limited understanding of battery technology, over-charging can produce hydrogen into the passenger compartment. My vehicle is now on the third battery, and has only 73,511 miles.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703152December 5, 2025
UNKNOWN OR OTHER
Battery is constantly dead and truck loses power. Goes into BATTERY SAVER MODE. Had the battery replaced twice by Ford. Many other owners report the same problem.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Maverick