Ford F-250 Complaints (1999)

830 consumer complaints on file.

#11547267September 29, 2023
AIR BAGS
i was involved in a collision on US30 3 miles west of Rainer Oregon. where I struck another Ford truck while cruising at 55 mph. The vehicle I struck pulled in front of me, my vehicle was severely damaged in the front end and the steering wheel and lower dash panel injured me.,
Crash:
Yes
Fire:
No
Injuries:
2
Deaths:
0
#11492314November 4, 2022
TIRES, TIRES:TREAD/BELT
The Belt in the tire separated while driving. This caused a "Bubble" to form causing my truck to shake violently and required changing to the spare tire. If this happened on the highway I could have lost control and caused an accident. I took my truck to a tire installer who documented the above finding and noted the tire was properly inflated and there were no impact marks on the tread or sidewalls. I am currently working with the supplier but they are being unreasonable with the requirements to have it inspected. No other reps have been contacted at this time. No ( its a 24 year old truck, I don't have any tire related warning lamps) LT235/85 R16
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11454680March 1, 2022
STEERING
My fiancé & I were driving down a 35mph road & I told her my steering wheel was a little crooked & I don't remember hitting anything to knock out of alignment. We got to my friends house to move a car trailer for him up his steep driveway. I hooked up to the trailer pulled it out, moved it around to line up to back up driveway & making the last adjustment all of a sudden I was turning my steering wheel but the tires were not turning, jumped out to find the output shaft of the steering box was cracked in half diagonally & the steering arm was laying on the street. When I got under the truck & looked at the part that broke you could see it was fractured for a long time. There was only about an 1/8" on one side that was raw metal from just finally breaking. Thank God we are alive if it would have happened going fast probably would have killed someone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11442845December 6, 2021
ENGINE
The contact owns a 1999 Ford F-250. The contact stated that the vehicle stalled while driving at various speeds. The contact stated that the check engine light illuminated for approximately 30 seconds. The contact would turn off and restart the vehicle and the vehicle would return to normal operation. The contact stated he took his vehicle to several independent mechanics and was informed that the camshaft sensor was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that similar vehicles were included in NHTSA Campaign number 07V553000 (Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 300,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11437517October 20, 2021
FUEL/PROPULSION SYSTEM
I was driving on the interstate going highway speed of 65 mph and the accelerator was stuck open and I could not slow down. The engine stayed at a high rpm. I had to press with a lot of force to slow down and come to a stop with the engine still at high rpm and had trouble stopping. Luckily, where I live there's not much traffic, and I made it to a shop with this issue. Upon investigating, the accelerator cable became frayed where it enters the sheath and gets stuck there. The Ford dealer didn't have a replacement in stock or any nationwide. So I went to a junk yard to find one and found the same vehicle that had the same frayed accelerator cable. I located a newer, second vehicle with less mileage with same cable that matched without any fraying. In the meantime, I ordered a new accelerator cable through Ford, but it was backordered several months and tied up in shipping. With this happening on these two same vehicles, I thought I should report it. Thank you.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11339023July 13, 2020
TIRES
TL THE CONTACT OWNS A 1999 FORD F-250 EQUIPPED TRAILERED TO 2019 FOREST RIVER EAST TO WEST TRAVEL TRAILER EQUIPPED WITH TBC BRAND LLC TIRES, TIRE LINE: TRAILER KING, TIRE SIZE: ST225/75R15, DOT NUMBER: 1ADB4HFT1). THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE PASSENGER'S SIDE FRONT TIRE EXPERIENCED A BLOWOUT. THE CONTACT PULLED OVER TO THE SIDE OF THE ROADWAY AND PLACED THE SPARE ONTO THE VEHICLE. THE CONTACT STATED THAT ABOUT 15 MINUTES LATER, APPROXIMATELY 10 MILES LATER, THE FRONT DRIVER'S SIDE TIRE ALSO EXPERIENCED A BLOWOUT. THE TIRES WERE REPLACED WITH NEW TIRES. THE CONTACT CONTACTED CAMPERS INN RV OF MACON - BYRON (125 PEACHTREE PKWY, BYRON, GA 31008, (478) 956-6111) AND WAS INFORMED BY THE DEALER THAT THE TIRES WERE NOT REPAIRABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGES WERE 221,000 ON THE VEHICLE AND 1,000 ON THE TIRES ON THE CAMPER. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11243670August 13, 2019
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 5 MPH, THE CONTACT HEARD SOMETHING SNAP ON HIS VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND DISCOVERED THAT THE REAR STRAP CONNECTED TO THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WIRED THE TANK BACK INTO PLACE AND DROVE HOME. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL; THEREFORE, HE WOULD BE RESPONSIBLE FOR THE REPAIRS. A DEALER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11233876July 22, 2019
ENGINE
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 55 MPH, THE FUEL TANK DROPPED OUT OF PLACE WITHOUT WARNING. THE CONTACT HEARD A DRAGGING, SCRAPING SOUND UNDERNEATH THE VEHICLE. THE CONTACT PULLED OVER INTO A PARKING LOT AND DISCOVERED THE FAILURE. BRAD HOWELL FORD (2170 E BLVD ST, KOKOMO, IN 46902) AND THE MANUFACTURER WERE CONTACTED AND STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS SINCE THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11208667May 20, 2019
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE OPERATING THE VEHICLE AT HIGHWAY SPEEDS, BOTH FUEL STRAPS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE); ALTHOUGH, THE VEHICLE EXHIBITED THE SAME FAILURE AS LISTED IN THE RECALL CAMPAIGN. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11203772April 25, 2019
ELECTRICAL SYSTEM, ENGINE
TL* THE CONTACT OWNS A 1999 FORD F-250. WHEN THE CONTACT EXITED AND RETURNED TO THE VEHICLE, IT MADE AN ABNORMAL SOUND WHEN IT WAS RESTARTED. SUDDENLY, A FIRE ERUPTED UNDER THE HOOD, WHICH SPREAD TO THE CABIN OF THE VEHICLE. THE DRIVER FELL AND HURT HER KNEE WHILE ATTEMPTING TO EXIT THE VEHICLE QUICKLY. MEDICAL TREATMENT WAS REQUIRED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THERE WAS EXTENSIVE DAMAGE TO THE FRONT END OF THE VEHICLE. THE INSURANCE COMPANY WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE DEALER WAS NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 300,000.
Crash:
No
Fire:
Yes
Injuries:
1
Deaths:
0
#11189747March 18, 2019
ENGINE
TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED ON THE SIDE OF THE ROAD. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE WITH SNOW. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 69,000.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11174795February 6, 2019
FUEL/PROPULSION SYSTEM
FILLED THE GAS TANK FULL THE DROVE DOWN THE STREET AT 45 MPH. ABOUT 1 MILE INTO THE DRIVE THE REAR FUEL TANK STRAP BROKE IN HALF AND THE REAR END OF THE FUEL TANK FELL TO THE GROUND SPILLING MOST OF THE FUEL. THE STRAP LOOK CORRODED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11082708April 3, 2018
ENGINE
BLOWS SPARK PLUGS OUT & BREAKS COIL PACKS FROM SITTING STILL AT INITIAL TAKE OFF. HAS HAPPENED 4 PREVIOUS TIMES
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11035709October 23, 2017
STEERING
I WAS GOING DOWN THE FREEWAY @ 65MPH AND I NOTICED MY STEERING WAS NOT RESPONDING IN THE NORMAL WAY. I HAD MADE IT TO A EXIT AND STOPPED AT LIGHT TRIED TO MAKE RIGHT TURN TRUCK CONTINUED STRAIGHT, AND I WAS STOPPED IN RUSH HOUR TRAFFIC IN CA. GOT OUT AND SAW MY SECTOR SHAFT HAD BROKEN OFF MY STEERING GEAR BOX.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11004943July 12, 2017
FUEL/PROPULSION SYSTEM, VEHICLE SPEED CONTROL, UNKNOWN OR OTHER
RUSTED THREW FUEL TANK STRAPS NO CRUISE CONTROL NO AIR CONDITIONING
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10970835April 5, 2017
ENGINE
I WAS DRIVING DOWN INTERSTATE 75 AND SUDDENLY I LOST POWER AND HAD A EXTREMELY LOUD PIPING NOISE COMING FROM UNDER THE HOOD . I STOPPED IMMEDIATELY AND CHECKED UNDER THE HOOD I COULD NOT TELL WITH THE ENGINE OFF SO I RESTARTED IT AND INSPECTED IT AND FOUND THAT MY NUMBER 2 SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD AFTER BUYING A NEW COIL PACK AND SPARK PLUG SET I DISCOVERED THAT ALL THE THREADS HAD BLOWN OUT OF THE HEAD WITH THE SPARK PLUG AND AFTER CHANGING ONE OF THE OTHER SPARK PLUGS I FOUND THAT IT WAS BARELY HOLDING IN .I THINK THAT THE HEADS DESIGN WAS POOR AND WEAK AND IS S SAFETY HAZARD.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10929410December 1, 2016
ENGINE
I WAS HEADING BACK TO COLLEGE IN BROOKINGS SD, WHEN I WAS STOPPED WAITING FOR A TRAIN TO PASS. AFTER THE TRAIN PASSES I PUT IT FROM PARK INTO DRIVE AND RIGHT WHEN I STARTED MOVING I HEAR A LOUD POP. AFTER I DRIVE ANOTHER BLOCK TO A GAS STATION TO LOOK UNDER THE HOOD I CAME TO THE CONCLUSION THAT I HAD BLOWN A SPARK PLUG. AND IT TOOK OUT THE IGNITION COIL WITH IT AND STRIPED THE THREADS ON THE HEAD. ALONG WITH THAT THERE WAS GAS EVERYWHERE ON THE DRIVERS SIDE OF THE ENGINE BLOCK. THAT'S NOT ONLY SUCKS BECAUSE I HAD TO PAY TO GET IT FIXED, I'M IN COLLEGE I DON'T HAVE MONEY TO PAY FOR THIS. BUT IF THAT GAS WOULD HAVE HIT I SPARK MY TRUCK COULD HAVE BLOWN UP. PLEASE TAKE RESPONSIBILITY FOR UR MISTAKES FORD. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10873221June 8, 2016
STRUCTURE:BODY, TIRES:TEMPORARY/EMERGENCY SPARE TIRE
TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE SPARE TIRE DETACHED AND WENT UNDER THE TRAILER THAT WAS BEING HAULED. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO THE MEDIAN. A POLICE REPORT WAS NOT FILED. THE CONTACT WENT TO THE HOSPITAL, BUT THERE WERE NO INJURIES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS BEING REPAIRED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10864577May 12, 2016
POWER TRAIN
TL* THE CONTACT OWNS A 1999 FORD F-250. AFTER THE VEHICLE WAS PLACED INTO THE PARK POSITION, IT INDEPENDENTLY ROLLED BACKWARDS WITHOUT WARNING. THE PASSENGER WAS ABLE TO STOP THE VEHICLE. THE CONTACT DISCOVERED THAT THE VEHICLE INADVERTENTLY SWITCHED INTO THE REVERSE POSITION. AS A RESULT, THE CONTACT WAS KNOCKED DOWN AND SUSTAINED INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 245,000. ....UPDATED 07/05/16 *BF THE CONSUMER STATED HE EXITED THE VEHICLE AND WALKED TO THE REAR OF THE VEHICLE. THE VEHICLE SOMEHOW WENT INTO REVERSE, WHILE THE DOOR WAS STILL OPEN. UPDATED 07/21/16.*JB
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10862708May 3, 2016
FUEL/PROPULSION SYSTEM
REAR FUEL TANK STRAP FAILED, CAUSING FUEL TANK TO DRAG ON GROUND WHILE VEHICLE WAS IN MOTION. SEE SAFETY RECALL 11S21 WHICH RECALLED FUEL TANK STRAPS ON OTHER 1999 FORD TRUCKS INCLUDING F-150 AND F-250 LIGHT DUTY BUT NOT F-250 SUPER DUTY. RECALL SHOULD BE EXTENDED TO 1999 F-250 SUPER DUTY.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-250