Ford F-150 Complaints

39,812 consumer complaints on file.

#11741745June 3, 2026
STEERING, SUSPENSION
Component Failed & Inspection Status: The front-left upper and lower control arms, ball joints, wheel hub assembly, steering knuckle, and front axle shaft have failed. Severe environmental corrosion has completely seized and fused the steering knuckle inside the wheel hub. All original failed components are currently intact and are fully available for physical inspection upon request. Safety Risk: This severe structural corrosion causes the steering knuckle and axle to seize, creating an imminent risk of primary steering component separation while driving. A steering separation on a heavy electric vehicle (over 6,000 lbs curb weight) causes a sudden, complete loss of directional control, creating an immediate life-threatening hazard to the occupants and surrounding traffic. Confirmation & Testing:The failure and severe structural corrosion were officially diagnosed and confirmed by a certified technician at an authorized Ford dealership service center. Warning Signs & Symptoms: The symptom appeared as a very noisy, distinct creaking sound coming from the front-left suspension. This noise occurred specifically when turning the steering wheel and when operating the vehicle at speeds below 40 mph. The sounds may have been present but obscured by road noise at higher speeds. There were no dashboard warning lamps or error messages prior to the diagnostic inspection. Systemic Concerns: This 2022 model is experiencing a severe vulnerability to premature environmental corrosion that causes the steering knuckle, axle, and control arms to seize to the point of failure. This demonstrates a critical structural durability issue under heavy EV loads in road-salt regions that warrants federal safety tracking for the 2022 model year.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741780June 3, 2026
SERVICE BRAKES, HYDRAULIC
The contact owns a 2020 Ford Escape. The contact received notification of NHTSA Campaign Number: 25V236000(Service Brakes, Hydraulics) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and an appointment was made to have the vehicle serviced. Once the contact arrived for the appointment, he was informed that parts were not yet available and on backorder. Recently, another appointment was made to have the vehicle serviced; however, the contact was informed that the parts were defective and needed to be re-ordered. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741816June 3, 2026
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated that while driving, the unexpectedly shifted from sixth to second gear. The wrench warning indicator illuminated after the incident occurred. The vehicle was pulled over to the side while malfunctioning and then the vehicle was able to drive properly. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The approximate failure mileage was 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741826June 3, 2026
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact recieved notice of a NHTSA Campaign Number: 26V237000 (Power Train). The contact stated while driving on two occasions at approximately 25 MPH the steering wheel became stiff and the power train warning light illuminated and he felt the vehicles gears changing. during the first occasions he continued to drive the vehicle, during the second occasion he parked the vehicle at his residence. The vehicle was turned off during the second occasion, however when he attempted to restart the vehicle, the vehicle did not turn on. The contact stated that an independent mechanic arrived at his residence where it was diagnosed starter needed to be replaced. The vehicle was repaired but the failure persisted. The mechanic then made the determined that the transmission range sensor needed to be repaired. The vehicle was not repaired. The vehicle towed to the dealer where it was diagnosed it was diagnosed that the transmission range sensor needed to be replaced. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 130,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741866June 3, 2026
POWER TRAIN, ENGINE
The contact owns a . The check engine light illuminated, while driving, the vehicle shifted to a lower gear unexpectedly and the turbo began to make a noise., the RPM's rapidly increased. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unavailable.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741943June 3, 2026
UNKNOWN OR OTHER
Transmission kept slipping out on the freeway. Led to a near accident. Then ended up broken down on a highway while towing a trailer. Transmission couldn’t find gear for the next serval times we tried to place in gear. Then on the third time it went into gear and started driving again only to slip out and lead to another breakdown on the highway. Still had to drive it into dealership in its unsafe condition.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741825June 3, 2026
POWER TRAIN
Odometer Fraud. The contact purchased a _____. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale/dealer sale. At the time of purchase, the vehicle mileage was ___ and at the time of registration, it was discovered that the mileage was ___.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741778June 3, 2026
POWER TRAIN
The contact own a 2022 Ford F-150. The contact stated while at an stop the contact herd a a snapping coming the vehicle and the vehicle failed to ilthe contact stated that the headlights and both turn signals were inoperable and failed to to illuminate. The vehicle was taken to the dealer where it was not diagnosed or repaired. The contact was informed that the failure could not be duplicated. The contact also stated that the failure peristed after taking the vehicle to the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 66,000
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741477June 2, 2026
VEHICLE SPEED CONTROL
The contact owns a Ford F-150. The contact stated that the vehicle unexpectedly accelerated while in a drive through, a vehicle was ahead, the vehicle appeared to be rolling forward even though the foot was on the brake pedal. The front grill fender area was impacted. The other drivers vehicle the trunk and rear bumper were impacted. No additional property damage. No airbags deployed. No warning lights illuminated including any collision indicators. No injuries were sustained. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate mileage 15,002.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11741531June 2, 2026
POWER TRAIN
My 2018 Ford F‑150 experiences harsh shifting, sudden downshifting, gear hunting, delayed engagement, and shuddering during normal operation. These issues occur regardless of weather, temperature, or driving conditions and present a serious safety concern when accelerating or maintaining speed. Detailed Description of the Problem: The transmission consistently behaves unpredictably, including: Abrupt and harsh upshifts Sudden, unexpected downshifts (including multi‑gear drops) Gear hunting at steady speeds Shuddering or vibration during light acceleration Delayed engagement when shifting from Park or Reverse These symptoms occur every time the vehicle is driven, whether accelerating from a stop or maintaining a constant speed. The behavior is unpredictable and creates a risk of loss of control, especially when merging, crossing intersections, or driving in traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741568June 2, 2026
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact received a notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle suddenly failed to accelerate or maintain velocity as intended while the accelerator pedal was depressed. The check engine warning light illuminated. The vehicle was towed to a local independent mechanic, where it was diagnosed with an engine failure and later towed to the contact's residence. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741572June 2, 2026
POWER TRAIN, ENGINE
The 2018 F150 I purchased started out a good vehicle like most vehicle do. The problems then began to come one after the other. Routine oil changes on the vehicle at the dealership with no hiccups turned into “Your motor is low on oil”. The tech tried to find a leak. The motor wasn’t leaking ANYTHING, so naturally the tech told me the motor was burning the missing oil. The tech told me “they all burn alittle oil” and topped it back off. I had another “incident” where I was driving on the highway a few weeks later and my engine light came on, and I lost oil pressure. The red “low oil pressure” message came on the dash and I promptly limped my truck to the dealership once again. The tech diagnosed the truck and found a plugged PCV valve. It was changed for a brand new one from the dealer, followed by another oil change well under the recommended interval naturally, due to the motor burning almost all of the oil. The truck still burns oil, and the issue seems to be impossible to remedy. The issue that followed the engine burning oil is the 10R80 Transmission installed from the ford manufacturer. Once again everything seemed fine when I purchased the truck. After driving it for 20-30k miles, the transmission has developed a flare shift between the 3rd-4th gears. The transmission is getting more and more hesitant to upshift and maintain and gain speed. This is considerably noticeable when attempting to get on the highway. This is unacceptable. It puts me in a very vulnerable spot because it doesn’t happen all the time. So I have to be EXTREMELY aware and prepared for the truck to become inoperable while merging into the flow of traffic. On two occasions now, while merging onto the highway with traffic, I have had to pull over to the shoulder of the road and put my hazards on to allow traffic to go around me due to my 2018 F150 with the 5.0/10R80 combination NOT increasing speed, and reving close to 5k RPMs. THESE ISSUES MUST BE ADDRESSED.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741603June 2, 2026
POWER TRAIN
Known transmission issue from Ford with 10-speed transmission. Transmission failed at 106,500 miles, and needing to be replaced. Ford has knowingly ignored issue, and is charging for repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741612June 2, 2026
SERVICE BRAKES, HYDRAULIC, POWER TRAIN
The contact owns a 2016 Ford F-150. The contact received notification of NHTSA Campaign Number however, the part to do the recall repair was not yet available. The local dealer was/was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was/was not made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741670June 2, 2026
ENGINE
Our truck was smoking from the exhaust and we took it to the local Ford service department. They determined the oil pan is leaking, there is a coolant leak from the engine, requiring a new engine, and also the need for turbos. These are the EXACT issues that are included in this service bulletin making dealerships aware. If this is such a widespread problem with these trucks, why is there not a recall to make proper repairs?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741643June 2, 2026
POWER TRAIN
2024 Ford F-150 The contact received notification of NHTSA Campaign Number: 25V512000 (POWER TRAIN) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741581June 2, 2026
ENGINE, POWER TRAIN, UNKNOWN OR OTHER
2021 Ford F-150 Lariat, 5.0L Coyote V8, purchased new, now 65k miles. Two interrelated safety defects: OIL CONSUMPTION: On 3/21/2026 at 62k miles, I discovered the engine was critically low on oil. Only 3 quarts drained during a full oil change, against a rated 8.8 quart capacity. The engine had been running on one third of required oil. The onboard oil life monitor showed 9% remaining and gave NO low-oil warning, no warning lights, no alerts. No external leak. On 5/22/2026, Koons Ford Woodbridge formally confirmed excessive oil consumption after a documented oil consumption test. Ford TSB 19-2365 acknowledges this exact defect on the 5.0L Coyote for 2018-2020 model years, attributing it to high intake manifold vacuum during deceleration fuel shut-off pulling oil into the combustion chamber. The 2021 engine is mechanically identical. TRANSMISSION: Hard and slipping gear shifts reported to Ford within months of purchase in 2021. Ford issued multiple software updates over the years to mitigate the behavior, most recently late 2025. Fix was temporary; hard/slipping shifts returned. CATASTROPHIC FAILURE: While awaiting Ford HQ authorization on repairs, the vehicle suffered complete drivetrain failure on Friday night. Engine lost power and transmission failed entirely. I was near home and coasted safely off the road. Had this occurred at highway speed during my daily commute, the result could have been catastrophic. Vehicle towed to Koons Ford Woodbridge. SAFETY CONCERN: This is my only vehicle, used for daily highway commuting. The oil consumption defect provides no warning before engine damage. The transmission has degraded despite years of Ford software patches. The vehicle has demonstrated total drivetrain failure capability with no driver warning. Ford Corporate case opened: CXH-07446845-G0J0K0. Filing to document this at the federal level and add to the existing pattern of complaints. Requesting NHTSA review whether these defects warrant investigation.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741532June 2, 2026
EXTERIOR LIGHTING
The driver-side integrated factory LED headlight assembly experienced a sudden, complete failure of the vertical LED Daytime Running Light (DRL) / parking lamp strip. The vehicle is completely stock, and the electrical system has never been modified or altered. The component failed suddenly with no prior warning lights, dashboard messages, or symptoms. Safety Risk: The failure of the LED DRL significantly reduces the vehicle’s forward visibility and conspicuity to oncoming traffic, pedestrians, and cyclists, particularly during daytime hours, dusk, dawn, and inclement weather. Because only one side is illuminated, oncoming drivers may misjudge the width, position, or presence of the truck, significantly increasing the risk of a front-end or sideswipe collision. Inspection Status: The failed component is currently intact and installed on the vehicle, making it available for inspection upon request. At this time, the problem has not yet been inspected or confirmed by a dealer, independent service center, manufacturer, insurance, or law enforcement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741475June 2, 2026
FUEL/PROPULSION SYSTEM
Recall has been out for 11 months and still no fix.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11741210June 1, 2026
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving on the highway at 55 MPH, she depressed the brake pedal as she attempted to exit the highway. Upon depression of the brake pedal, the vehicle suddenly downshifted as several warning lights appeared on the instrument panel. Due to the failure, the contact lost control of the vehicle as the vehicle began to skid off to the shoulder of the road. The contact pulled over to the shoulder of the road and placed the vehicle into park(P). The contact resumed normal driving after the initial failure; however, the contact stated that the failure occurred again just before reaching her destination. Prior to the failure; the contact received a recall notice for NHTSA Campaign Number: 26V237000(Power Train); however, the part for the repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle was not repaired. The failure mileage was approximately 47,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150