Ford F-150 Complaints (2016)

2,093 consumer complaints on file.

#11634110January 4, 2025
ELECTRICAL SYSTEM, EXTERIOR LIGHTING, UNKNOWN OR OTHER
I NEED TO REPORT FAILURE FIXING MY CAR RECALL NAMED *Faulty door Latch HARVARD FORD TEXTED ME TO RAKE MY CAR TO GET DONE BUT THEY DID A BAD JOB REPAIR INSTEAD OF REPLACE RECALL PART THEY DIDNT THEY DID CUT OUT WIRE HARNESS INSTEAD .Therefore THAT DAMAGED TYE AUTO NOW REVERSE CAM SCREEN IS NOT WORKING .TYE DOORS OPEN ITSELF WHILE IM DRIVING IT .DASH Board IS NOT ALSO WORKING IM FILLING A COMPLAINT AGAINST HARVARD FORD DEALERSHIP THE SOLUTION zI need is the following they need to REPLACE ALL COMPLETE NEW WIRE HARNESS ASAP.ALDI NEW REVERSE CAM AND SCREEN .IM ATTACHED ALL PROOF OF THE DAMAGE ..
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633988January 3, 2025
POWER TRAIN, ELECTRICAL SYSTEM
Transmission gets stuck in 3rd or sometimes 5th gear when in Drive. Shifting to 1, 2, or M does nothing; shifting from Neutral to Reverse or Drive creates a large clunk and lunge. It seems to be the same issue as the 2014 F-150 & Expedition 6R80 transmission recall and is so common that it took no time at all to find out what my problem likely is.. This is the 5th time this has happened. Two times were when pulling out onto very busy roads, once in a parking lot, once in a field, and once turning into my alley; some incidents were years apart. If it were to happen again when I needed 1st gear to avoid being hit, I would not have the power for needed acceleration or to make a proper maneuver. It also acts very funny when it happens and creates a very large distraction from driving. When I was able to get back off the main road, it seemed like there was light smoke coming from under the truck so I shut the vehicle down in the middle of a smaller road, which was dangerous enough. I have less than 30,000 miles on my truck and am very maintenance minded; this should not be a worry I should have to have. This appears to be the result of a defective part in the transmission called the "Lead Frame" and it is not easy to find a new one right now due to the excessive amount of them needing replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11633786January 2, 2025
POWER TRAIN
When I was driving on the highway about 65 mph the truck abrubly downshift to 1st or 2nd gear causing the truck to dermaticly slow down. I am lucky there was nobody behind me because they could have rear ended me. The issue ended up being the transmission valve body harness which is apparently a common issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11632868December 28, 2024
UNKNOWN OR OTHER
Sunroof rails broke for the second time, and the sunroof will not close on the drivers side. This problem is putting extra pressure on the glass since it isn’t seated properly. Water also leaks in during rain storms and has caused electrical issues. I can now only drive this $95,000 vehicle in good weather.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631219December 17, 2024
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:THROTTLEBODY/MANIFOLD, POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving at an undisclosed speed and accelerating, the vehicle lost motive power. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the side of the road and turned off and restarted the vehicle. The vehicle was driven to a local dealer to be diagnosed; however, the cause of the failure was not determined. The dealer replaced the throttle control and the PCM; however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 94,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630839December 15, 2024
ENGINE, FUEL/PROPULSION SYSTEM, POWER TRAIN
I was getting married and setting to go a getaway immediately after we wed. I got a tune up and go my vehicle read. After the tune up it the drive felt great. So me and my wife took to the highway, and as my vehicle began to accelerate the engine began jitter as I press on the gas peddle. The car would not go past 50 mph. As I kept my feet on the gas you can feel the whole car shaking, then the eco boost kicks in and it immediately accelerate at a high rate of speed and as attempt to control the speed by letting go of the gas. The vehicle shakes as it looses power and settles on 50 to 60 miles shaking until the eco boost kicks in. It was a two hour ride and I couldn't look back just pray. Through out the ride it was the same thing over and over again. My wife and I were in constant fear, because I felt due to the erupt increase in speed I was putting other motorist at risk. The engine light came on and a wrench symbol and tire symbol came on. The component or system that failed or malfunctioned involves the eco boost. It appears to be the same recall reference NHTSA # 24V-635 & Manufacturer: # 24S55. My vehicle presently has 78,000 miles on it and it should not be doing that. I have also looked at other problems with the 2016 Ford F-150 Ecoboost as being the web belt system and head gasket failure. However, whatever is the case anyone with this type of vehicle and experiencing the same thing is catastrophic the public safety at large and it cannot be ignored. Ford must correct this problem before someone end up dying as a result of this problem. Thank you for taking the time to read my story and I pray this may help you properly investigate my experience. I can have my truck available for anyone from NHTSA to inspect. Presently there is no data regarding the problem with this particular vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11630037December 11, 2024
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated while driving approximately 65 MPH, the instrument cluster was flashing several unknown warning lights. The contact stated that the vehicle was towing a 16-foot RV at the time of the failure. The contact stated that the transmission had independently shifted to first gear, nearly causing the vehicle to stall. The contact stated that the failure was a recurring failure and occurred at various speeds. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure. The failure mileage was approximately 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629887December 10, 2024
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated while driving 75 MPH with the Adaptive Cruise Control activated, the transmission unexpectedly downshifted, causing the vehicle to decelerate. The contact pulled over to the side of the road. The contact stated that upon parking the vehicle, the gear indicator displayed that the transmission was shifting to different gears continuously. The contact stated that while driving 45 MPH, the transmission inadvertently downshifted to second gear, nearly causing the contact's face to strike the steering. The contact was able to pull over to the side of the road. The contact was able to continue driving. The contact stated that while attempting to drive from a complete stop, the vehicle started hesitating and went into LIMP Mode. The contact pulled over to the side of the road. The contact turned off and restarted the vehicle several times, and the vehicle was able to drive after 10 minutes. The contact stated that the vehicle experienced a significant delay while attempting to shift into first gear. The contact who is mechanically inclined had replaced the transmission lead frame; however, the failure recurred 4-5 months later. The contact stated that failure had progressively worsened, and the vehicle was shuddering upon depressing the accelerator pedal. The check engine warning light was illuminated. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 136,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629694December 9, 2024
POWER TRAIN
My truck only have 72000 miles and I’m experiencing transmission failure the transmission get stuck on shifting and I just took it to the mechanic and he’s asking for parts including the whole transmission and is on back order usually because I’m not the only one with the same problem Ford already know about the potential problem for 2011 and 2014 and they extend the warranty on this trucks but they use the same transmission for the 2015 and 2016 now I’m out of the blue with cost of more than $5000 to repair it , it should be investigated for sure it’s not fare for us as the owners to pay out of our pockets
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629074December 5, 2024
ENGINE
For the last 70k mile the vehicle will intermittently die when coming to a stop. Sometimes it just idles rough other times just dies. Not what you want when your trying to pull into traffic very dangerous situation. In August of 2019 a cel was finally displayed and dealer replaced cam solenoid. Unfortunately the fixed was short lived and the stalling continued. I delt with the problem from then forward the cel light never coming on and the dealer never able to duplicate the problem. Recently the dealer cleaned the solenoids in hopes of fixing the problem. It did not and they are unsure on how to fix vehicle. I have been on forums and many others have experienced the same issues it seems like a sizable problem that Ford does not want to address. This can sometimes happen multiple times in a day or go months without a problem Very frustrating
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11628366December 2, 2024
POWER TRAIN, VEHICLE SPEED CONTROL, ELECTRICAL SYSTEM
When shifting the truck into gear the lights such as the parking, driving, neutral, reverse and lower gears lights as well as the lights showing which gears the trucks shifting into do not light up! Therefore, you cannot tell what gear the truck is currently placed into. Also, if the lights do light up, they flicker very erratically, and the truck will change gears on its own. When driving the vehicle, the truck will just suddenly change gears and makes a hard shift into lower or higher gear or gears which is extremely dangerous. This makes the truck feel like I've been hooked up to another vehicle that is trying to snatch me backwards. I was driving on the highway the other day and the truck went from 6th gear doing over 70mph to all of a sudden downshifting and dropping down to 40mph on the highway. I thought the engine and transmission were both going to explode on me and cause an accident. This was extremely terrifying and if I didn't keep my cool it could have easily caused a wreck. Most people would have freaked out had an accident. The truck barely made it home because of the gears shifting all over the place and the truck wanting to lose power and shut down. This is extremely dangerous and the representative I spoke to from Ford agreed that considering the mileage of the truck and with the recent recalls concerning transmissions being recalled for the exact same issues that my truck is experiencing that I needed to call you guys and get my tuck added to the Ford F-150 recall list for the transmission issues ford trucks have been having. The Truck is a 2016 Ford F-150 XLT. This is the case number provided to me from Ford to give you Ford Case # CXH03020325
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627449November 26, 2024
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving approximately 53 MPH in the rain, the rear end of the vehicle suddenly seized. Several unknown warning lights were illuminated. The vehicle was taken to a certified mechanic, who diagnosed that the lead frame output sensor had failed and needed to be replaced. The dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was not informed of the failure. The failure mileage was 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11627458November 26, 2024
VISIBILITY, VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2016 Ford F-150. The contact stated that while the vehicle was parked and attempting to open the sunroof, the sunroof made an abnormal popping sound. The contact noticed that the panoramic sunroof panel had become inoperable. The contact stated that the sunroof panel and the sunroof rails had fractured. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened. The manufacturer confirmed that the VIN was not under recall and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 85,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11626873November 22, 2024
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while her husband was driving 70 MPH, the vehicle unexpectedly downshifted to first gear. The driving release and then depressed the accelerator pedal and the vehicle returned to normal functionality. The “Service Engine” warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V075000 (Power Train), but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 117,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11625448November 15, 2024
BACK OVER PREVENTION
The contact owns a 2016 Ford F-150. The contact stated that the rearview camera would display a distorted image while the vehicle was in reverse(R). The contact stated that the failure had obstructed the driver's visibility which prevented the driver from safely operating the vehicle. Due to the failure, the contact stated that they had been involved in two low-speed, parking lot accidents. The contact stated that no injuries were reported in either incident and that two separate police reports were filed; however, the police reports were unavailable. The vehicle was taken to multiple dealers and was given multiple estimates for the repair. The contact's husband attempted to replace the camera himself; however, the failure persisted. The manufacturer was notified of the failure and was given a case number. The vehicle had yet to be repaired. The failure mileage was unknown.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#11624023November 7, 2024
POWER TRAIN
The contact owns a 2016 Ford F-150. The contact stated that while driving at slow speeds, the vehicle independently shifted into neutral. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the output speed sensor. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V444000 (Power Train); however, the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 120,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623577November 5, 2024
POWER TRAIN, FUEL/PROPULSION SYSTEM
The transmission 6R80 is absolutely horrible, a part called the lead frame is all over youtube on how to fix it at home. the transmission causes slam shifts, missed shifts, or nothing at all. 2nd to 3rd, 3rd to 4th, and 4th to 5th. When slowing down again hard shifts back down again. local mechanics say they don't want to change transmission fluid as it could do more harm then good. I called my local ford dealership and was offered to bring it in where the test would show either a transmission fix or a full replacement which is absolutely crazy to me, Ford should be held liable for these mistakes because it should be fixed with a piece of Styrofoam over the sensors, and then transmission fluid changed. But ford knows for all of that and all of the 6R80 transmissions they've put out is an astronomical number. This is horrible that its happening to a very large majority of these transmissions and nothing from ford.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11623123November 1, 2024
POWER TRAIN, ENGINE
The contact owns a 2016 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle downshifted with the check engine and transmission warning lights illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,297.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622977October 31, 2024
ENGINE
The contact owns a 2016 Ford F-50. The contact stated while driving approximately 70-75 MPH, the vehicle unexpectedly downshifted to 3rd gear. The contact pulled over to the side of the road, turned off, and restarted the vehicle, and the vehicle drove normally. The “WRENCH” symbol was briefly illuminated. The vehicle was taken to the dealer and an unknown recall update was performed. The failure persisted and the vehicle was returned to the dealer. The dealer was unable to diagnose the vehicle. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 180,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11622265October 28, 2024
POWER TRAIN
The contact owns a 2015 Ford F-150. The contact stated that while driving approximately 60 MPH in heavy traffic, the contact attempted to slow down while approaching an intersection and the vehicle unexpectedly downshifted to third gear. The contact pulled over and disconnected and reconnected the battery and restarted the vehicle to reset computers. Additionally, the contact stated that occasionally while driving at high speeds, the transmission downshifted to 5th gear unexpectedly. There was no warning light illuminated. The contact stated that the failure had become a recurring failure. The local dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford F-150