Ford F-150 Service Bulletins (2018)

418 manufacturer communications on file.

• September 27, 2023•Document ID: 10243652

  Service Bulletin/Repair Instructions
  EQUIPMENT; ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 51947

  Date Added:

  October 6, 2023

  Manufacturer:

  FORD

  Summary

  Some 2015-2019 F-Super Duty and 2015-2020 F-150/Mustang vehicles may require replacement of the powertrain control module (PCM) for various reasons. While performing a programmable module installation (PMI) using the Integrated Diagnostic Service (IDS) scan tool, an error message may state: Configuration Failed, Would You Like To Retry? This may be due to improper module replacement steps. Make sure that the original module is installed in the vehicle, delete the vehicle session, then start a new vehicle session. Once the session starts, run the PCM PMI and install the new PCM only when the scan tool instructs. Finish the PMI by following the prompts given by IDS. If the original PCM is not available, it is possible to configure the module by running as-built programming on the PCM. When IDS asks to obtain part numbers or configuration data, select configuration data.

  Associated Products (32)

  2020 Ford F-1502020 Ford Mustang2019 Ford F-1502019 Ford F-2502019 Ford F-3502019 Ford F-4502019 Ford F-5502019 Ford Mustang2018 Ford F-1502018 Ford F-2502018 Ford F-3502018 Ford F-4502018 Ford F-5502018 Ford Mustang2017 Ford F-1502017 Ford F-2502017 Ford F-3502017 Ford F-4502017 Ford F-5502017 Ford Mustang+ 12 more
  Associated Documents

  • DownloadMC-10243652-0001.pdf↗
• September 21, 2023•Document ID: 10243648

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  SSM 51939

  Date Added:

  October 6, 2023

  Manufacturer:

  FORD

  Summary

  Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability. Use the Report a Vehicle Concern link at the bottom of OASIS to submit a report if there is a customer concern of whine noise describing operating conditions and noise severity.

  Associated Products (49)

  2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit+ 29 more
  Associated Documents

  • DownloadMC-10243648-0001.pdf↗
• September 20, 2023•Document ID: 10243609

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  SSM 51937

  Date Added:

  October 5, 2023

  Manufacturer:

  LINCOLN

  Summary

  Some vehicles equipped with power folding mirrors may exhibit power folding mirrors that are inoperative or exhibit a clicking sound. This may be due to the mirrors being manually folded in, during transportation, going through a car wash, bumped in a parking lot, or found during pre-delivery inspection (PDI). Prior to the replacement of any components, attempt to synchronize the mirrors by following the Power Mirrors Synchronization procedure. Refer to Workshop Manual (WSM) Section 501-09 Rear View Mirrors - General Procedures - Power Mirrors Synchronization.

  Associated Products (59)

  2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Expedition2021 Ford Explorer+ 39 more
  Associated Documents

  • DownloadMC-10243609-0001.pdf↗
• August 14, 2023•Document ID: 10241447

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  TSB 23-2250

  Date Added:

  August 30, 2023

  Manufacturer:

  FORD

  Summary

  This article supersedes TSB 22-2428 and 23-2176 to update the Issue, Action and Service Procedure. Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60/10R80/10R80MHT transmission may exhibit a harsh/delayed engagement and/or harsh/delayed shift, an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the powertrain control module (PCM) or transmission control module (TCM), the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve. To correct the condition, follow the Service Procedure to identify and correct the condition.

  Associated Products (45)

  2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Bronco2021 Ford Expedition+ 25 more
  Associated Documents

  • DownloadMC-10241447-0001.pdf↗
• August 2, 2023•Document ID: 10241627

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 51838

  Date Added:

  September 4, 2023

  Manufacturer:

  FORD

  Summary

  In various 2017-2023 Ford and Lincoln vehicles, customers may receive a message in the FordPass or LincolnWay App stating Feature Unavailable. Since this is a fleet vehicle, it cannot access the (SYNC Connect) FordPass or LincolnWay app through the TCU Embedded Modem. If this message appears, the vehicle may be equipped with a fleet telematics module. Replacement of the TCU or TCU related repairs will not prevent this message from appearing. Refer the customer to in app FordPass Guides or LincolnWay Concierge Teams to aid with fleet telematics removal. Open app, select Account > Help > CHAT or CALL option.

  Associated Products (127)

  2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Corsair2023 Lincoln Nautilus2023 Lincoln Navigator+ 107 more
  Associated Documents

  • DownloadMC-10241627-0001.pdf↗
• August 1, 2023•Document ID: 10240719

  Service Bulletin/Repair Instructions
  EQUIPMENT; VISIBILITY:REARVIEW MIRRORS/DEVICES

  Mfr Comm. #:

  SSM 51829

  Date Added:

  August 14, 2023

  Manufacturer:

  FORD

  Summary

  Some F-Super Duty and F-150 vehicles equipped with trailer tow mirror may exhibit various exterior rear view mirror functional concerns that require replacement after diagnosis. To properly determine if the defect is warrantable, cleaning and close inspection of the affected mirror may be required. To aid in proper warranty determination, the Rear-View Mirror Analysis general service bulletin (GSB) has been updated with a detailed cleaning procedure that should be followed prior to any inspection. New labor operations (17682ZZ or 17682ZZT) have been created that covers the cleaning and inspection process and may be used even if condition of failure is non-warrantable. Ford has inspected numerous returned parts and determined many cases are caused by damage which is unwarrantable and may be subject to chargeback. Refer to the latest version of the GSB on OASIS.

  Associated Products (35)

  2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502022 Ford F-1502022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-550+ 15 more
  Associated Documents

  • DownloadMC-10240719-0001.pdf↗
• June 8, 2023•Document ID: 10240743

  Service Bulletin/Repair Instructions
  EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

  Mfr Comm. #:

  SAN-Vol1 I1

  Date Added:

  August 16, 2023

  Manufacturer:

  FORD

  Summary

  The Service Awareness Newsletter is an informal communication that contains information that may not be presently available in a TSB, SSM, GSB, or other electronic communication. This article includes information on warranty, technical service tips and other service information.

  Associated Products (177)

  2024 Ford E-4502024 Ford Explorer2024 Ford F-6502024 Ford F-7502024 Ford Mustang2024 Ford Ranger2023 Ford Bronco2023 Ford Bronco Sport2023 Ford E-1502023 Ford E-2502023 Ford E-3502023 Ford E-4502023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-450+ 157 more
  Associated Documents

  • DownloadMC-10240743-0001.pdf↗
• June 7, 2023•Document ID: 10237786

  Service Bulletin/Repair Instructions
  POWER TRAIN; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; UNKNOWN OR OTHER

  Mfr Comm. #:

  SSM 51687

  Date Added:

  June 16, 2023

  Manufacturer:

  FORD

  Summary

  TSB 22-2428 is missing some labor operations. For any missing labor operations, claim available new model labor operations or m-time. Refer to this article on the repair order. When replacing the CDF cylinder, the current TSB does not require a complete transmission overhaul or cooler and converter flushing. Ford is currently reviewing the TSB. Monitor OASIS for updates.

  Associated Products (45)

  2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Bronco2021 Ford Expedition+ 25 more
  Associated Documents

  • DownloadMC-10237786-0001.pdf↗
• May 29, 2023•Document ID: 10236680

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  TSB 22-2428

  Date Added:

  May 30, 2023

  Manufacturer:

  FORD

  Summary

  Some 2017-2023 F-150, 2018-2023 Expedition/Navigator/Mustang, 2019-2023 Ranger, 2020-2023 Explorer/Aviator/Transit and 2021-2023 Bronco vehicles equipped with a 10R60 transmission and built on or before 23-Dec-2022 or with a 18R80/10R80MHT transmission and built on or before 15-Aug-2022 may exhibit a harsh/delayed engagement and/or harsh/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the software in the PCM or TCM, the transmission solenoid ID strategy, sticking valves in the main control valve body and/or axial movement of the CDF clutch cylinder (7H351) sleeve.

  Associated Products (45)

  2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Bronco2021 Ford Expedition+ 25 more
  Associated Documents

  • DownloadMC-10236680-0001.pdf↗
• May 23, 2023•Document ID: 10236685

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 23-2161

  Date Added:

  May 31, 2023

  Manufacturer:

  FORD

  Summary

  Some 2018-2021 F-150 vehicles equipped with a 3.0L diesel engine, 2016-2022 F-650/F-750 vehicles equipped with a 6.7L engine, and 2017-2022 F-Super Duty vehicles equipped with a 6.7L engine and built on or before 08-Mar-2022 may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P21DD, P20BA. P20B9, P204C, P208A, P208B, P208C, P203B, P205B, P21CD and/or U02A2 in the powertrain control module (PCM). This may be due to water intrusion within connectors C3613 and/or C4851/C3610 on the reductant harness going to the reductant pump/heater assembly and the reductant level sensor/quality module. This may also be due to movement of the wiring harness causing terminal fretting. To correct the condition, follow the Service Procedure to replace the reductant tank harness, the reductant pump/heater assembly and/or the reductant tank, as well as securing the wiring harness using a cable zip tie fastener.

  Associated Products (45)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-1502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-550+ 25 more
  Associated Documents

  • DownloadMC-10236685-0001.pdf↗
• May 23, 2023•Document ID: 10236683

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  TSB 23-2152

  Date Added:

  May 29, 2023

  Manufacturer:

  FORD

  Summary

  This article supersedes TSB 23-2123 to update the Issue statement. Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang and 2019-2023 Ranger vehicles equipped with a 10R80 automatic transmission may exhibit a harsh engagement/harsh shift/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to the keep alive memory in the PCM/TCM or the transmission main control valve body. To correct the condition, follow the Service Procedure to overhaul the main control valve body and/or perform an adaptive learning drive cycle.

  Associated Products (21)

  2023 Ford Ranger2022 Ford Ranger2021 Ford Expedition2021 Ford Mustang2021 Ford Ranger2021 Lincoln Navigator2020 Ford Expedition2020 Ford F-1502020 Ford Mustang2020 Ford Ranger2020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Ford Mustang2019 Ford Ranger2019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Ford Mustang2018 Lincoln Navigator+ 1 more
  Associated Documents

  • DownloadMC-10236683-0001.pdf↗
• May 5, 2023•Document ID: 10236037

  Service Bulletin/Repair Instructions
  POWER TRAIN; ENGINE AND ENGINE COOLING

  Mfr Comm. #:

  TSB 23-2143

  Date Added:

  May 31, 2023

  Manufacturer:

  LINCOLN

  Summary

  Some 2017-2020 F-150 and 2018-2020 Expedition/Navigator vehicles built on or before 30-Nov-2019 and equipped with a 3.5L EcoBoost engine may exhibit a ticking/tapping or rattle type noise from the top front cover area of the engine on initial start-up after a cold soak of 6 hours or more that may last for 2-5 seconds. Some vehicles may also exhibit an intermittent condition with no auto restart during auto-start-stop operation with or without diagnostic trouble code (DTC) P164C present in the powertrain control module (PCM). This may be due to a worn variable camshaft timing (VCT) unit. To correct the condition, follow the Service Procedure to replace the VCT units.

  Associated Products (10)

  2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Lincoln Navigator2017 Ford F-150
  Associated Documents

  • DownloadMC-10236037-0001.pdf↗
• April 17, 2023•Document ID: 10234593

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  TSB 23-2115

  Date Added:

  May 4, 2023

  Manufacturer:

  FORD

  Summary

  Some 2015-2020 F-150 and 2017-2022 F-Super Duty vehicles may exhibit a lack of heat or cooling from the cabin vents when the climate control settings are adjusted between hot and cold. This may be due to a stuck/binding temperature door within the climate control housing or binding/inoperative temperature door actuator. Diagnostic trouble code (DTC) B1081:07 may be present in the front controls interface module (FCIM) or heating ventilation and air conditioning (HVAC) module. To correct the condition, follow the Service Procedure to remove the climate control housing and replace the temperature door cam(s), lubricate the temperature blend door bearing surface, and apply flock tape to actuator to seal out debris.

  Associated Products (45)

  2022 Ford F-2502022 Ford F-3502022 Ford F-4502022 Ford F-5502022 Ford F-6002022 Ford F-6502022 Ford F-7502021 Ford F-2502021 Ford F-3502021 Ford F-4502021 Ford F-5502021 Ford F-6002021 Ford F-6502021 Ford F-7502020 Ford F-1502020 Ford F-2502020 Ford F-3502020 Ford F-4502020 Ford F-5502020 Ford F-600+ 25 more
  Associated Documents

  • DownloadMC-10234593-0001.pdf↗
• April 14, 2023•Document ID: 10234596

  Service Bulletin/Repair Instructions
  POWER TRAIN; ELECTRICAL SYSTEM

  Mfr Comm. #:

  TSB 23-2123

  Date Added:

  May 4, 2023

  Manufacturer:

  FORD

  Summary

  Some 2017-2020 F-150, 2018-2021 Expedition/Navigator/Mustang and 2019-2023 Ranger vehicles equipped with a 10R80 automatic transmission may exhibit a harsh engagement/harsh shift/delayed shift. It is possible the vehicle may also have an illuminated malfunction indicator lamp (MIL) or diagnostic trouble codes (DTC) P0751, P0752, P0756, P0757, P0761, P0762, P0766, P0767, P0771, P0772, P2700, P2701, P2702, P2703, P2704, P2705, P2707, P2708, P0729, P0731, P0732, P0733, P0734, P0735, P0736, P076F, P07D9, P07F6 and/or P07F7 stored in the powertrain control module (PCM) or transmission control module (TCM). This may be due to incompatibility of the adaptive calibration to adapt to hardware break-in over time. To correct the condition, follow the Service Procedure steps to overhaul the main control valve body and/or perform an adaptive learning drive cycle.

  Associated Products (21)

  2023 Ford Ranger2022 Ford Ranger2021 Ford Expedition2021 Ford Mustang2021 Ford Ranger2021 Lincoln Navigator2020 Ford Expedition2020 Ford F-1502020 Ford Mustang2020 Ford Ranger2020 Lincoln Navigator2019 Ford Expedition2019 Ford F-1502019 Ford Mustang2019 Ford Ranger2019 Lincoln Navigator2018 Ford Expedition2018 Ford F-1502018 Ford Mustang2018 Lincoln Navigator+ 1 more
  Associated Documents

  • DownloadMC-10234596-0001.pdf↗
• April 4, 2023•Document ID: 10235153

  Service Bulletin/Repair Instructions
  STRUCTURE

  Mfr Comm. #:

  SSM 51536

  Date Added:

  May 4, 2023

  Manufacturer:

  LINCOLN

  Summary

  For 2000-2024 Ford and Lincoln vehicles, swapping a module from a vehicle for diagnosis purposes is likely to cause errors and is not recommended. It is also not recommended to order a replacement module using a vehicle identification number (VIN) from a different vehicle. Most modules on these affected vehicles are VIN/vehicle specific and hardware variations between modules do exist. Swapping a module from a vehicle or ordering a module using a different vehicle/VIN can cause ineffective repairs and additional vehicle down time. Make sure all appropriate Workshop Manual (WSM) procedures are followed when diagnosing the condition prior to all module replacements and only order modules using the correct VIN.

  Associated Products (350)

  2023 Ford Bronco2023 Ford Bronco Sport2023 Ford Edge2023 Ford Escape2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford F-6502023 Ford F-7502023 Ford Maverick2023 Ford Mustang2023 Ford Mustang Mach-E2023 Ford Ranger2023 Ford Transit Connect2023 Lincoln Aviator2023 Lincoln Corsair+ 330 more
  Associated Documents

  • DownloadMC-10235153-0001.pdf↗
• March 21, 2023•Document ID: 10233745

  Service Bulletin/Repair Instructions
  VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

  Mfr Comm. #:

  SSM 51469

  Date Added:

  April 5, 2023

  Manufacturer:

  FORD

  Summary

  Some 2021 F-150 vehicles built on or before 01-Feb-2021, 2017-2020 F-150 vehicles equipped with a 3.5L EcoBoost engine, 2018-2020 F-150 vehicles equipped with a 2.7L EcoBoost or 5.0L engine, 2019-2020 F-150 vehicles equipped with a 3.0L diesel engine may exhibit a high pitched squeal or whistle type noise from the engine compartment after the engine is shut off. This condition may be due to the air conditioning (A/C) low side system pressure exceeding the high side pressure resulting in equalization of A/C system pressures through the A/C compressor. An updated A/C compressor has been released to resolve this concern. For claiming, use causal part 19703 and applicable labor operations in Section 11 of the Service Labor Time Standards (SLTS) Manual.

  Associated Products (5)

  2021 Ford F-1502020 Ford F-1502019 Ford F-1502018 Ford F-1502017 Ford F-150
  Associated Documents

  • DownloadMC-10233745-0001.pdf↗
• March 8, 2023•Document ID: 10233695

  Service Bulletin/Repair Instructions
  POWER TRAIN

  Mfr Comm. #:

  SSM 51419

  Date Added:

  April 4, 2023

  Manufacturer:

  FORD

  Summary

  Some 2017-2023 Ford and Lincoln vehicles equipped with a 10R60/10R80/10R80 MHT/10R100 transmission may exhibit a whine noise at idle and/or while driving. This may be identified as coming from the bellhousing and the front of the transmission fluid pan. The whine noise may become louder when the transmission is at operating temperature and may increase with engine revolutions per minute (RPM) in the park (P) position. A small amount of whine noise is considered to be characteristic of the 10R60/10R80/10R80 MHT/10R100 transmissions due to the offset gear drivetrain in the front support and has no effect on durability.

  Associated Products (49)

  2023 Ford Bronco2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford F-2502023 Ford F-3502023 Ford F-4502023 Ford F-5502023 Ford Mustang2023 Ford Ranger2023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Bronco2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Mustang2022 Ford Ranger2022 Ford Transit+ 29 more
  Associated Documents

  • DownloadMC-10233695-0001.pdf↗
• February 28, 2023•Document ID: 10232485

  Service Bulletin/Repair Instructions
  EQUIPMENT

  Mfr Comm. #:

  SSM 51392

  Date Added:

  March 4, 2023

  Manufacturer:

  FORD

  Summary

  Some vehicles equipped with a 2.7L, 3.0L,3.5L or 5.0L engine may require replacement of the long block engine assembly. New service kits have been released which include all the one-time-use components required in the service procedure for removal and replacement of the long block engine assembly. Refer to the Ford Electronic Parts Catalog (ECAT) for long block service kit part number by application.

  Associated Products (12)

  2022 Ford Explorer2022 Lincoln Aviator2021 Ford Explorer2021 Lincoln Aviator2020 Ford Explorer2020 Ford F-1502020 Lincoln Aviator2019 Ford F-1502018 Ford F-1502017 Ford F-1502016 Ford F-1502015 Ford F-150
  Associated Documents

  • DownloadMC-10232485-0001.pdf↗
• January 24, 2023•Document ID: 10230765

  Service Bulletin/Repair Instructions
  FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

  Mfr Comm. #:

  TSB 22-2260

  Date Added:

  January 31, 2023

  Manufacturer:

  LINCOLN

  Summary

  Some 2018-2020 F-150 vehicles equipped with a 2.7L EcoBoost and 2020-2021 Expedition/Navigator vehicles may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P0420 and/or P0430 stored in the powertrain control module (PCM). This may be due to high sulfur content in the fuel. To correct the condition, follow the Service Procedure to de-sulfate the catalytic converters.

  Associated Products (7)

  2021 Ford Expedition2021 Lincoln Navigator2020 Ford Expedition2020 Ford F-1502020 Lincoln Navigator2019 Ford F-1502018 Ford F-150
  Associated Documents

  • DownloadMC-10230765-0001.pdf↗
• January 19, 2023•Document ID: 10230835

  Service Bulletin/Repair Instructions
  ELECTRICAL SYSTEM

  Mfr Comm. #:

  SSM 51306

  Date Added:

  February 2, 2023

  Manufacturer:

  LINCOLN

  Summary

  Some 2018-2023 F-150, Expedition, Navigator, Transit, Aviator and Explorer vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0627, P025A, P025B, P00C6, P008A and/or U0109 stored in the powertrain control module (PCM). This may be due to an intermittent or partial disconnect of the harness to the fuel pump control module (FPCM) connector, connector pin push-outs, damaged pins/terminals, or loose/corroded grounds. Inspect FPCM connector, applicable grounds (F-150 - G401, Expedition/Navigator - G403, Transit - G401, 2018-2019 Explorer  G302, 2020-2022 Explorer/Aviator - G407) and confirm FPCM connector (F-150 - C4336, Expedition/Navigator - C433, Transit - C433, 2018-2019 Explorer - C3239, 2020-2022 Explorer/Aviator - C4033) is fully seated prior to performing PC/ED diagnostics or replacing any components.

  Associated Products (34)

  2023 Ford Expedition2023 Ford Explorer2023 Ford F-1502023 Ford Transit2023 Lincoln Aviator2023 Lincoln Navigator2022 Ford Expedition2022 Ford Explorer2022 Ford F-1502022 Ford Transit2022 Lincoln Aviator2022 Lincoln Navigator2021 Ford Expedition2021 Ford Explorer2021 Ford F-1502021 Ford Transit2021 Lincoln Aviator2021 Lincoln Navigator2020 Ford Expedition2020 Ford Explorer+ 14 more
  Associated Documents

  • DownloadMC-10230835-0001.pdf↗