Ford E-350 Complaints (1999)

72 consumer complaints on file.

#11483072September 6, 2022
TIRES:TREAD/BELT
The contact owns a 1999 Ford E-350 Jamboree equipped with Sailun Tires, Tire Line: Terramax H/T, Tire Size: 225/75/R16, DOT Number: (535PLE50). The contact stated that while driving approximately 55 MPH, there were pieces of the driver's side inside dual tire striking the underside of the vehicle and hitting the highway. The contact managed to drive the vehicle back to his residence. The contact stated that the tread had separated leaving only the steel belt and the side wall. The vehicle was not taken to be diagnosed. The dealer was not contacted. The manufacturer was notified of the failure. The approximate vehicle failure mileage was 80,000 and the tire failure mileage was 5,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11280548November 16, 2019
STEERING, WHEELS
I RECENTLY PURCHASED A USED 24' 1999 WINNEBAGO ITASCA SPIRIT WITH VERY LOW MILEAGE AND AT THAT TIME I NOTICED A SHAKING OR VIBRATION PROBLEM POSSIBLY COMING FROM THE TIRES. I OWNED A MOTOR HOME IN THE PAST AND HAVE SOME EXPERIENCE. THIS MOTOR HOME SAT FOR SEVERAL YEARS SO I ATTRIBUTED THE SHAKING TO THE MEMORY IN THE RUBBER OF FLAT SPOTS ON THE BOTTOM FROM SITTING FOR A LONG TIME THAT USUALLY SMOOTH OUT WHEN DRIVEN ESPECIALLY AFTER 30 OR 40 MILES ON A WARM DAY, BUT AFTER A 400 MILE TRIP IT DIDN'T SMOOTH OUT, IN FACT IT SEEMS TO HAVE WORSENED. BEFORE PURCHASING IT FROM A PRIVATE PARTY I RAN AN INSTAVIN AND CARFAX REPORT AND ONLY DISCOVERED AN UNCOMPLETED NHTSA RECALL #05S28 ON THE SPEED CONTROL ONLY. I THEN SEARCHED SEVERAL FORUMS AND DISCOVERED MANY, MANY REPORTS OF THE SAME PROBLEM WITH THE SHAKING AND LEARNED IT IS DUE TO FAULTY WHEELS AND FORD IS NOT MAKING GOOD THE PROBLEM BUT OFFERED AN EXPENSIVE FIX THAT I UNDERSTAND IS ALSO IFFY. I AM VERY CONCERNED ABOUT MY FAMILY'S SAFETY DRIVING ON THESE DEFECTIVE WHEELS AND FIRST LOOKED INTO REPLACING THE TIRES WHICH I LEARNED ISN'T THE PROBLEM BUT THE FAULTY WHEELS THAT WERE AN OEM FORD PART, SO I WANT TO ADD MY COMPLAINT TO THE MANY YOU ALREADY HAVE AND MAYBE FORD WILL FIX THIS POTENTIALLY SERIOUS SAFETY PROBLEM.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10979428April 20, 2017
AIR BAGS
I WAS IN AN ACCIDENT AND MY AIR BAGS DID NOT WORK I HAVE DAMAGE TO FRONT END AND REAR END
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
1
#10807189November 27, 2015
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1999 FORD E-350 EQUIPPED WITH NEXEN TIRES, TIRE LINE: ROADIAN HT, TIRE SIZE: LT225/ 75R16 (N/A), AND DOT NUMBER: BEAKBAMR3312. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL STARTED VIOLENTLY SHAKING WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT PASSENGER SIDE TIRE STEEL BELT WAS FRACTURED AND NEEDED TO BE REPLACED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 91,012 AND THE APPROXIMATE TIRE FAILURE MILEAGE WAS 14,913.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10705496April 13, 2015
FUEL/PROPULSION SYSTEM
THE VEHICLE STALLS ON NUMEROUS OCCASIONS DUE TO LACK OF FUEL. INVESTIGATION PROVED THAT THE INTERIOR PAINT OF THE GAS TANK PEALS BLOCKING THE FUEL PUMP. RESEARCH SHOWS THAT DELAMINATION OF THE GAS TANK IS FREQUENT IN THIS MODEL CAUSING A VERY UNSAFE CONDITION AS THE VAN CAN STOP AT ANYTIME AS IT LOOSES POWER AND PROPULSION DUE TO THE PAINT FLAKES BLOCKING THE FUEL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10546674October 3, 2013
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD F350. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE CONTACT NOTICED THAT THE FUEL TANK WAS DANGLING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE FUEL TANK SUPPORT STRAPS WERE RUSTED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474110September 6, 2012
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS 1999 FORD E-350 EQUIPPED WITH RUNWAY ENDURO HT TIRES, LINE SIZES LT225/75/R16. THE CONTACT STATED THAT AFTER INSPECTING THE DRIVER SIDE REAR OUTER TIRE SHE NOTICED THAT IT HAD BECOME DEFLATED. THE TIRE WAS TAKEN TO A TIRE SHOP WHO STATED THAT CRACKS HAD DEVELOPED IN THE TIRE WALLS AND THE STEEL BELT SEPARATED. THE FAILURE MILEAGE WAS 73,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10474112September 6, 2012
TIRES, TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 1999 FORD E-350 EQUIPPED WITH UNICORN CREATION LT TIRES, LINE SIZE 225/75/R16. THE CONTACT STATED THAT SHE HEARD A LOUD NOISE OUTSIDE THE VEHICLE AND NOTICED THAT THE PASSENGER SIDE REAR OUTER TIRE BLEW OUT. THE TIRE WAS TAKEN TO A TIRE SHOP AND THEY STATED THAT THE STEEL BELT SEPARATED. THE FAILURE MILEAGE WAS 73,498.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10462456June 20, 2012
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 FORD E350 VAN. THE CONTACT STATED THAT THE DIESEL FUEL TANK DEVELOPED CORROSION. THE CORROSION HAD FILTERED INTO THE ENGINE AND CAUSED THE ENGINE TO STALL WHILE THE CONTACT WAS DRIVING 65 MPH. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO ADVISED THAT THE ENTIRE FUEL SYSTEM NEEDED TO BE REPLACED DUE TO THE CORROSION. THE CONTACT HAD THE FUEL TANK AND FUEL INJECTORS CLEANED PREVIOUSLY BUT THE CLEANING DID NOT REMEDY THE ISSUE. THE FAILURE MILEAGE WAS 285,000. THE VIN WAS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10460555June 4, 2012
ENGINE
TL* THE CONTACT OWNS A 1999 FORD E350. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE EXHIBITED AN ABNORMAL POP. IMMEDIATELY, FUEL FLOODED INTO THE VEHICLE CABIN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER ADVISED THE CONTACT THAT THEY HAD TO REPLACE THE SPARK PLUG. THE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 372,000 AND THE CURRENT MILEAGE IS 372,500 UPDATED 07/06/12 *BF THE CYLINDER HEADS WERE REPLACED AS WELL. UPDATED 07/12/12
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10384324February 24, 2011
SERVICE BRAKES, ELECTRIC
FORD E-350 AND E-250 VANS, BOTH ARE YEAR,1999 THE ANTILOCK AND BRAKE LIGHTS CAME ON SIMULTANEOUSLY AT A 105K MILES ON EACH. THERE SHOULD BE NO REASON FOR THIS AND I ALSO NOTICED MANY OTHERS WITH THE SAME ISSUES. IT WILL IMPOSE A SAFETY ISSUE BECAUSE I SEEN A WEB SITE MENTIONING HOW TO DISCONNECT DASH LIGHTS FOR BOTH. PLEASE TAKE THIS INTO CONSIDERATION BEFORE AUTO OWNERS START DISCONNECTING WIRE HARNESS. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10379984February 2, 2011
WHEELS
TL*THE CONTACT OWNS A 1999 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT NOTICED THAT THE REAR OF THE VEHICLE WAS LOW. THE CONTACT STOPPED AND INSPECTED THE VEHICLE BUT COULD FIND NOTHING WRONG. WHEN SHE REACHED HER RESIDENCE, SHE SAW THAT THE DRIVER SIDE REAR TIRE LUG NUTS HAD RIPPED OF THE WHEEL AND FRACTURED THE RIM. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10371883December 21, 2010
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING:ENGINE, VEHICLE SPEED CONTROL
1999 FORD E350 CAUGHT FIRE AND BURNED TO A TOTAL LOSS WHILE SITTING COLD IN MY DRIVEWAY. I BOUGHT THE VEHICLE USED ON NOV 8, 2010. DEC 12, 2010 I DROVE ABOUT 3 MILES TO THE GROCERY AROUND 20:30; I RETURNED HOME AND PARKED THE VEHICLE IN MY DRIVEWAY ABOUT 20:45. ABOUT 22:15 A PASSING CAR OBSERVED FLAMES COMING FROM THE FRONT OF THE VEHICLE AND FLARING TO CONTACT MY HOUSE. THE WITNESS ALERTED ME AT MY DOOR. I IMMEDIATELY GRABBED THE GARDEN HOSE AND ATTEMPTED TO SPRAY WATER INTO THE FRONT GRILL, LEFT SIDE TO PUT OUT THE FIRE. I COULD NOT SEE WHERE THE ACTUAL FIRE WAS AS THE HOOD WAS CLOSED, I SPRAYED WHERE THE FLAMES EXITED THE GRILL. THE WIND WAS BLOWING ABOUT 20 MPH AND I COULD NOT EXTINGUISH THE FLAMES. THE VEHICLE WAS FACING NORTH, THE WIND BLOWING FROM WEST TO EAST. THE FLAMES BEGAN TO SHOOT OUT FROM THE PASSENGER WHEEL WELL IN A HORIZONTAL STREAK AS THE WIND STOKED THE FIRE. NEIGHBORS CALLED 911 WHILE I DIVERTED THE WATER SPRAY FROM THE VEHICLE TO THE HOUSE AND GARAGE SINCE THE VAN WAS PARKED WITHIN 2 FEET OF THE GARAGE DOOR AND THE WIND NOW HAD FLAMES SHOOTING 8-12' HIGH AND BRUSHING THE WOOD GARAGE DOOR. THE FIREMEN ARRIVED, KNOCKED THE VEHICLE HOOD OFF WITH A TOOL AND SPRAYED THE ENGINE COMPARTMENT TO EXTINGUISH THE FIRE. DUE TO THE WIND, THE VAN WAS COMPLETELY FIRE GUTTED AND A TOTAL LOSS. THE FIRE INSPECTOR ADVISED ME OF THE FORD CRUISE CONTROL RECALL AND SAID HE COULD FIND NO OTHER POSSIBLE CAUSE FOR THE FIRE IN THE ENGINE COMPARTMENT AS THERE WERE NO LEAKS OF ANY KIND AND NO RECENT REPAIRS IN THE ENGINE COMPARTMENT. LOCAL FORD DEALERS HAVE DECLINED TO TELL ME IF MY VIN HAD WARRANTY WORK TO REPAIR THE SWITCH. *TR
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10335796June 11, 2010
ENGINE AND ENGINE COOLING:ENGINE
I WAS DOING SOME CITY DRIVING IN MY FORD VAN AND ALL OF A SUDDEN IT STARTED TO SOUND ROUGH AND LIKE MY MUFFLER FELL OFF. I STOPPED HAD IT TOWED AND THEY TOLD ME THE SPARK PLUG HAD BLOWN OUT OF THE ENGINE. WHEN LOOKING INTO IT SEEMS THAT IT IS A FAIRLY COMMON PROBLEM. MY UNDERSTANDING IS THAT IF I HAD NOT TURNED THE ENGINE OFF QUICKLY I COULD HAVE HAD A FIRE IN THERE AS THERE STILL IS GAS AND COMBUSTION GOING ON(THE OTHER 9 PLUGS) NOW I DON'T KNOW IF OR WHEN THE OTHER PLUGS WILL GO ON ME ANDS AM AFRAID TO DRIVE THE CAR MORE THAN A TAXI CAB RIDE HOME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10302543January 27, 2010
FUEL SYSTEM, OTHER
RECALL 01V114000: POSSIBLE FUEL TANK CRACK. I TOOK MY VAN IN FOR BRAKE WORK. IT WAS DISCOVERED THAT THERE IS A FUEL TANK CRACK. I RECEIVED A RECALL REPORT FROM MY MECHANIC FROM ALLDATE ONLINE STATING THAT THIS IS AN ISSUE THAT HAPPENS TO MY TYPE OF VEHICLE. IT IS A VAN THAT I USE FOR WORK.*CW
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10302185January 25, 2010
ENGINE AND ENGINE COOLING, ENGINE AND ENGINE COOLING:ENGINE
I HAVE A 1999 CHINOOK CLASS C WITH A FORD E-350 CHASSIS POWERED BY A TRITON V-10. SHORTLY AFTER BUYING IT USED WE HAD A SPARK PLUG POP OUT. IT WAS AN ORIGINAL PLUG. WE HAD THEM CHANGED AND TOOK A CROSS COUNTRY TRIP. AS WE WERE COMING UP ON MEMPHIS TN. ANOTHER PLUG BLEW OUT. WE WERE ON AN INTERCHANGE IN A VERY DANGEROUS PLACE. WE COULD NOT GET OUT AS THERE WAS A FREEWAY ON BOTH SIDES. IT TOOK 3 1/2 HOURS TO GET US OUT OF HARMS WAY. JUST LAST WEEKEND IT HAPPENED AGAIN THOUGH I DROVE OFF THE FREEWAY. I HAVE SINCE READ THAT THIS COULD CAUSE A FIRE AS THE GAS IS GETTING PUSHED OUT THE PLUG HOLE AND THE PLUG IS OUT AND FIRING. I HAVE DONE SOME RESEARCH AND FORD SAYS THE PLUGS WERE NOT TORQUED TO SPEC WHICH CAUSED IT TO HAPPEN. WE HAD OUR ORIGINAL PLUGS WHEN IT 1ST HAPPENED. I ALSO READ ONLINE WHERE A DEALER HAD A VERY LOW MILEAGE V-10 WITH ORIGINAL PLUGS AND IT HAPPENED TO HIM. I THINK THESE HEADS ARE DEFECTIVE AND SHOULD BE REPLACED. I CANNOT FIND AFTERMARKET HEADS SO I WOULD FEEL SAFER. IT HAS ALWAYS HAPPENED GOING DOWN THE FREEWAY. THE MECHANIC AT THE SHOP WHERE IT IS SAYS HE HAS A FORD KIT TO REPAIR THE HEADS. HE SAYS IT IS THE ONLY KIT FOR THIS HE HAS EVER SEEN YET FORD DENIES THERE IS A REAL PROBLEM. I JUST FEEL LUCKY I HAVE BEEN ABLE TO GET OFF THE ROAD EACH TIME. THESE ENGINES ARE IN MANY RV'S AND LARGER TRUCKS WHICH ARE HARDER TO MANEUVER I.E. MORE DANGEROUS. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10276246July 9, 2009
TIRES, TIRES:TREAD/BELT
TL*THE CONTACT OWNS A 1999 FORD E350. THE VEHICLE HAS KUMHO ROAD VENTURE TIRES, SIZE LT/225/75/R16 (NA). WHILE DRIVING 65 MPH, THE FRONT DRIVER'S SIDE TIRE BLEW OUT AND THE TREAD SEPARATED. THE DOOR OF THE VEHICLE WAS DAMAGED. HE TOOK THE VEHICLE TO THE LOCAL TIRE REPAIR SHOP AND THE TECHNICIAN STATED THAT THE TIRE WAS DRY ROTTED. NO REPAIRS HAVE BEEN MADE. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 15,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10227987May 16, 2008
VEHICLE SPEED CONTROL:CRUISE CONTROL
TL*THE CONTACT OWNS A 1999 FORD E-350. THE CONTACT RECEIVED A RECALL NOTICE IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL. SHE CALLED THE DEALER AND THEY EXPLAINED THAT THE PARTS WERE ON BACKORDER, BUT THEY WOULD DISCONNECT THE CRUISE CONTROL UNTIL THE PARTS ARRIVED. AS OF MAY 16, 2008, THE PARTS ARE STILL UNAVAILABLE. THE CONTACT BELIEVES THAT NEARLY A YEAR IS COMPLETELY UNREASONABLE TO NOT HAVE RECEIVED THE PARTS BY NOW. THERE HAD BEEN NO FAILURE TO DATE; HOWEVER, SHE WANTS HER CRUISE CONTROL RECONNECTED. THE RECALL NUMBER WAS UNKNOWN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10213306December 31, 2007
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
1999 FORD E350 WITH ONLY 48,000 MILES HAS THE BRAKE LINES SO BADLY RUSTED THAT THEY ARE LEAKING BRAKE FLUID. THE VEHICLE CAN'T BE DRIVEN UNTIL ALL THE BRAKE LINES ARE REPLACED. REPLACEMENT PARTS ARE NOT AVAILABLE FROM FORD. I MUST FABRICATE REPLACEMENTS FROM GENERIC PARTS. IT SHOULD BE A REQUIREMENT THAT BRAKE LINES BE MADE FROM STAINLESS STEEL SO THEY CAN'T RUST OUT. THIS IS A CLEAR DANGEROUS CONDITION THAT COULD BE ELIMINATED IF MANUFACTURER WERE REQUIRED TO USE STAINLESS STEEL WHICH WILL NOT RUST. I ALMOST DROVE THROUGH MY GARAGE DOOR WHEN THE BRAKE PEDAL WENT TO THE FLOOR WHEN THE RUSTED BRAKE LINE BURST. I HAD TO JAM ON THE PARKING BRAKE TO STOP THE VEHICLE. THIS HAPPENS WITHOUT WARNING ONE DAY THE BRAKES WORK THE NEXT DAY THEY DON'T. MAKE BRAKE LINES FROM STAINLESS STEEL SO THEY WON'T RUST!! *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10198629August 6, 2007
ENGINE AND ENGINE COOLING:ENGINE
TL*THE CONTACT OWNS A 1999 FORD E-350. THE CONTACT STATED THAT THE SPARK PLUG HAS BLOWN OUT OF THE HEAD DUE TO THE LACK OF THREADING NEEDING TO KEEP IT IN PLACE. THE MECHANIC INFORMED HIM THAT THE FAILURE HAS OCCURRED THREE TIMES WITHIN THE LAST FIVE WEEKS. THERE ARE NO RECALLS AVAILABLE FOR THIS FAILURE. THE MECHANIC ALSO STATED THAT THIS COULD BE DUE TO A DESIGN FLAW. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 139,000 AND CURRENT MILEAGE WAS 140,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford E-350