Ford C-Max Complaints

510 consumer complaints on file.

#10928499November 29, 2016
UNKNOWN OR OTHER
I AM APPALLED AT HOW FORD HAS TAKEN CARE OF THE RECALL ISSUE 16S30, ACCORDING TO THE LETTER I RECEIVED THE PART FOR THIS RECALL WILL NOT BE AVAILABLE UNTIL 2017 SECOND QUARTER? FIRST OF ALL THIS IS UNACCEPTABLE, CONSIDERING THIS IS NO FAULT OF MINE. WHAT REALLY UPSETS ME IS WHEN I TRIED TO OPEN THE HATCH TO LOAD MY GROCERIES, IT WOULDN'T OPEN, SO I LOADED THEM IN MY BACKSEAT. WELL WHEN I PULLED OUT, THE HATCH OPENED! WHAT CONCERNS ME IS WHAT IF THAT WOULD HAVE BEEN MY DOOR AND MY CHILD FELL OUT? I CALLED THE DEALERSHIP AS WELL AS FORD MOTOR AND NOTHING HAS BEEN RESOLVED! VERY POOR SERVICE FROM FORD
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10928128November 27, 2016
UNKNOWN OR OTHER, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
I RECEIVED A LETTER INFORMING ME OF THE RECALL ON THE DOOR LATCH, HOWEVER PARTS WILL NOT BE AVAILABLE UNTIL POSSIBLY THE 2ND QUARTER 2017. CONSIDERING MY LATCH ON THE BACK OPENS SOMETIMES, I AM CERTAINLY CONCERNED FOR MY DOORS OPENING WITH MY KIDS. HAVING TO WAIT IS UNACCEPTABLE. I SHOULD HAVE BEEN PROVIDED A LOANER CAR UNTIL MINE IS FIXED. I AM VERY10 DISSATISFIED WITH FORD MOTOR COMPANY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10926131November 15, 2016
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE DOOR LATCH FAILED AND THE DOOR WAS DIFFICULT TO OPEN AND CLOSE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). THE DEALER AND MANUFACTURER WERE CALLED ON MULTIPLE OCCASIONS AND STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE FAILURE MILEAGE WAS 26,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10924631November 7, 2016
STRUCTURE:BODY
THE REAR HATCH BECOMES UNLATCHED WHEN A BUMP IN THE ROAD, EVEN A SMALL RAISED ONE, IS DRIVEN OVER. I HAVE INFORMED THE LOCAL DEALER OF THIS. THE HATCH DOOR DOES NOT FULLY UNHINGE TO OPEN.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10916481October 17, 2016
ELECTRICAL SYSTEM
WE PURCHASED THIS CAR USED IN SEPTEMBER, 2016 AND IT HAD 33,000 MILES ON IT. ONE WEEK AFTER WE BOUGHT IT WE RETURNED TO THE CAR FROM DINNER AND FOUND IT WOULDN'T START. HAD IT JUMPED AND CONTINUED ON OUR WAY. ONE WEEK AGO WE WENT TO START THE CAR AFTER IT SAT IN THE DRIVEWAY OVERNIGHT AND THE SAME THING: BATTERY WAS DEAD. WE HAD IT JUMPED. THIS MORNING, AFTER SITTING IN THE DRIVEWAY OVERNIGHT, IT WOULDN'T START AGAIN, BATTERY DEAD. THIS IS THE THIRD TIME IN JUST OVER A MONTH OUR BATTERY HAS GONE DEAD. THIS SITE IS FULL OF REPORTS OF THIS HAPPENING, AND FORD DEALERS ARE UNABLE TO FIX THE PROBLEM. WHY HASN'T THIS CAR BEEN RECALLED? FORD NEEDS TO OFFER REPLACEMENT VEHICLES TO ANYONE UNFORTUNATE ENOUGH TO HAVE PURCHASED ONE OF THESE LEMONS.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10916154October 14, 2016
POWER TRAIN
TL* THE CONTACT OWNS A 2014 FORD C-MAX HYBRID. AFTER PLACING THE VEHICLE IN PARK AND TURNING IT OFF, THE CONTACT WAS ALERTED THAT THE VEHICLE INDEPENDENTLY ROLLED BACKWARDS AND CRASHED INTO ANOTHER VEHICLE. THE CONTACT WAS NOT IN THE VEHICLE AT THE TIME OF THE CRASH. UPON ENTERING THE VEHICLE AND INSPECTING IT, THE CONTACT NOTICED THAT THE VEHICLE SHIFTED INTO REVERSE. THE FAILURE OCCURRED ON ONE SEPARATE OCCASION. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS ABLE TO BE DRIVEN AWAY FROM THE SCENE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,900.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10915510October 12, 2016
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2015 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE DOOR FAILED TO REMAIN SECURELY LOCKED AND OPENED TWICE WITHOUT WARNING. THE DEALER WAS NOTIFIED OF THE FAILURE TWO MONTHS AGO. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THERE WAS NO MANUFACTURER RECALL TO REPAIR THE VEHICLE. THE DEALER PROVIDED NO REPAIR SOLUTION. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES), BUT THE PARTS WERE NOT AVAILABLE. THE NOTICE INDICATED THAT THE PARTS MAY BECOME AVAILABLE IN THE SECOND QUARTER OF 2017. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10915546October 12, 2016
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2013 FORD C-MAX ENERGI. WHEN CHARGING THE VEHICLE, THE OUTLET LOCATED IN THE WALL MELTED AND THE SIDE OF THE CORD USED TO CHARGE THE VEHICLE, WHICH PLUGGED INTO THE WALL, ALSO MELTED. THE VEHICLE WAS UNABLE TO BE CHARGED. THE DEALER WAS INFORMED OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10908346September 21, 2016
STEERING
DRIVING ON I-40, ABOUT 150 MILES FROM MY DESTINATION ON JULY 31, 2016, THE "SERVICE POWER STEERING SOON" LIGHT CAME ON IN THE CAR. I FINISHED THE DRIVE HOME WITH NO PROBLEM AND TURNED THE CAR OFF TO UNLOAD IT. WHEN I RE-STARTED IT, THE CAR REPORTED A COMPLETE STEERING FAILURE, AND THE POWER STEERING ASSIST SIMPLY QUIT. I LOOKED ONLINE AND SAW THAT THIS HAS BEEN A CONSISTENT PROBLEM WITH THE FORD STEERING SYSTEM IN THE C-MAX AND OTHER MODELS. I ARRANGED TO HAVE THE ISSUE EXAMINED & REPAIRED AT MY LOCAL FORD DEALER. I DROVE THE CAR THERE, WITH EXTENSIVE EFFORT REQUIRED TO TURN THE WHEEL. THE DEALER DETERMINED THAT THE STEERING UNIT HAD FAILED, WITH APPROXIMATELY 35,000 MILES ON THE VEHICLE. MY COST WAS APPROXIMATELY $1880, AND I DO HAVE THE RECEIPT. FORD REFUSED TO ACKNOWLEDGE THIS AS A MANUFACTURER'S DEFECT AND I WAS FORCED TO PAY THE FULL AMOUNT. I BELIEVE THIS KNOWN DEFECT CREATES AN UNSAFE SITUATION. 1. FORD SHOULD BE HELD RESPONSIBLE TO FIX THIS DEFECT AS IT IS FAR MORE COMMON THAT ACCEPTABLE, AND 2. THEY SHOULD CHANGE WHAT HAPPENS TO A CAR WHEN THE PROBLEM IS DETECTED. HAD I NOT HAD A LOT OF STRENGTH, I COULD HAVE GOTTEN INTO AN ACCIDENT TRYING TO GET IT IN FOR REPAIR. THE SYSTEM WORKED JUST FINE FOR 150 MILES, SO THERE WAS NO REAL ISSUE STOPPING THE STEERING ASSIST...UNTIL I TURNED IT OFF AND THEN THE CAR DISABLED ITS STEERING. FORD SHOULD NOT BE ALLOWED TO LET THE CAR CONTINUE TO DRIVE AFTER THE CAR SELF-DISABLES ITS POWER STEERING. IT WAS ONLY SELF-DISABLED AFTER I SHUT IT OFF, SO IT WAS ACTUALLY STILL SAFELY DRIVEABLE, BUT THE CAR'S COMPUTER APPARENTLY DECIDED TO CREATE THE DANGEROUS SITUATION BY SHUTTING OFF THE EPAS SYSTEM COMPLETELY, YET LEAVE THE CAR DRIVABLE. PLEASE INVESTIGATE THIS FAILURE AND COMPEL FORD TO ADDRESS THE STEERING UNIT FAILURE ISSUE AND REIMBURSE THOSE OF US WHO HAVE BEEN FORCED TO PAY FOR THE REPAIR.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10906166September 13, 2016
ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY, ENGINE, LATCHES/LOCKS/LINKAGES:DOORS:LATCH
TL* THE CONTACT OWNS A 2014 FORD C-MAX ENERGI HYBRID. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE RODS AND PISTONS FRACTURED AND CAUSED THE ENGINE TO FAIL. AS A RESULT, THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. .....UPDATED 10/13/16 *BF THE CONSUMER STATED THE RADIATOR NEEDED TO BE REPLACED. THE DRIVER'S SIDE DOOR OPENED WHILE DRIVING. THE CONSUMER REQUESTED TO HAVE THE VEHICLE REPLACED OR REPURCHASED. UPDATED 09/20/2017*JS
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10904811September 8, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
THE 120 VOLT, 12 AMP CHARGE CORD THAT CAME WITH MY CAR (FORD PART NO. FM58-10B706AC) IS OVERHEATING CREATING A FIRE HAZARD. THE END OF THE CORD THAT PLUGS INTO THE WALL HAS MELTED AND THE PLUG HAS LEFT BURN MARKS ON THREE DIFFERENT ELECTRICAL OUTLETS ON MY HOUSE WHERE I PLUG THE CAR IN TO CHARGE. PHOTOS OF THE MELTED CORD AND OUTLET BURN MARKS ARE ATTACHED. THERE IS A DESIGN FLAW IN THAT THE CONTROL UNIT BUILT INTO THE CORD IS TOO HEAVY AND PULLS THE PRONGS FROM THE OUTLET AND IF A PRONG IS ONLY PARTIALLY PLUGGED INTO THE OUTLET IT DRAWS MORE CURRENT THAN THE CORD CAN HANDLE. FORD IS AWARE OF THE PROBLEM AND ADVISED (FORD EV HELP LINE 1-800-392-3673) THAT THE CORD SHOULD NOT BE LEFT HANGING IN MID-AIR AND NEEDS TO BE PROPPED UP WHEN PLUGGED IN. THOSE INSTRUCTIONS ARE NOT IN THE OWNERS MANUAL OR ON THE CORD, NOR WERE THEY COMMUNICATED TO CMAX ENERGI OWNERS. FORD ASSERTS THAT THE CORD IS NOT COVERED BY ITS EXTENDED 8-YEAR, 80,000 MILE WARRANTY FOR ELECTRICAL COMPONENTS FOR THE CMAX ENERGI, SO THIS PART IS NOW OUT OF WARRANTY. IT IS VERY EXPENSIVE (I WAS QUOTED $975 BY FORD TO REPLACE THE CORD). THUS IT IS HIGHLY LIKELY THAT OWNERS WILL DEFER REPLACING THE CORD AND KEEP USING IT, BECAUSE IT STILL WORKS EVEN THOUGH THE PLUG IS PARTIALLY MELTED. THIS CORD IS HIGHLY LIKELY TO RESULT IN FIRES AND MAY BE RESPONSIBLE FOR THE TWO CMAX ENERGI GARAGE FIRES IN FLORIDA I READ ABOUT IN THE PRESS LAST MONTH. I AM HAPPY TO PROVIDE MORE INFORMATION IF YOU WANT TO CONTACT ME.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10904820September 8, 2016
HYBRID PROPULSION SYSTEM: INVERTER, EQUIPMENT:ELECTRICAL
THE FORD EV CHARGE CORD (FORD PART NO. FM58-10B706AC) THAT CAME WITH MY 2013 CMAX ENERGI DRAWS TOO MUCH CURRENT AND IS A FIRE HAZARD. I JUST FILED A VEHICLE COMPLAINT (NO. 10904811) WITH PHOTOGRAPHS OF THE MELTED CORD AND BURN MARKS ON MY OUTLETS, DESCRIBING THE HAZARD IN DETAIL. IT IS LIKELY THAT THIS CORD OR A SIMILARLY DESIGNED CORD IS USED WITH THE FORD FOCUS ENERGI AND FORD FUSION ENERGI SO THIS HAZARD SHOULD BE INVESTIGATED AS AN EQUIPMENT DEFECT AND NOT JUST A VEHICLE DEFECT.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10899097August 29, 2016
ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM, POWER TRAIN
WHILE DRIVING ON AN INTERSTATE AT NIGHT AT 70MPH THE CAR TURNED OFF ITS PROPULSION SYSTEM WITHOUT WARNING. A RED WARNING INDICATOR CAME ON STAYING STOP SAFELY NOW. MY WIFE WAS ABLE TO PULL TO THE SIDE OF THE INTERSTATE. SHE TURNED THE CAR OFF AND IT RESTARTED. THE NEXT DAY SHE DROVE IT TO THE SUPERMARKET. ON THE 2 MILE DRIVE HOME IT STOPPED MULTIPLE TIMES WHILE THE CAR WAS IN MOTION JUST LIKE IT HAD ON THE INTERSTATE. THIS SEEMS VERY SIMILAR TO THE PROBLEMS THAT LED TO A RECALL ON THE FORD FOCUS ELECTRIC, WHICH WAS MADE IN THE SAME PLANT AT THE SAME TIME IN 2013: HTTP://INSIDEEVS.COM/FORD-FOCUS-ELECTRIC-SHUTDOWN-PROBLEMS-WHILE-DRIVING-GET-OFFICIAL-AS-NHSTA-INVESTIGATES/.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10899144August 29, 2016
STEERING
POWER STEERING FAILED WHILE DRIVING ON A 70MPH HIGHWAY. NO WARNING OR INDICATION. THE STEERING JUST CUT OUT. I WAS TRAVELLING WITH MY 2 YEAR OLD SON IN THE BACK WHEN I BASICALLY LOST ALL CONTROL OVER THE CAR. IT WAS NEAR IMPOSSIBLE TO NAVIGATE TO THE SIDE OF THE ROAD. I HAD TO STOP THE VEHICLE IN THE MIDDLE OF A BUSY HIGHWAY. A GENTLEMAN HAD TO STOP AND HELP ME GET THE CAR TO THE SHOULDER. THE CAR IS THREE YEARS OLD AND WE WERE TOLD THE POWER STEERING IS SHOT. WE WILL HAVE TO HAVE IT REPLACED AND IT WILL COST $1,700.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10895980August 15, 2016
POWER TRAIN
REVERSE GEAR SETTING ACTUALLY PUT THE CAR IN DRIVE AFTER STARTING THE PARKED CAR ND ATTEMPTING TO BACK OUT OFPARKING SPACE. I TRIED TURNING OFF ENGINE, AND THE SAME THING OCCURRED, THE CAR CONTINUED TO CREEP FORWARD UNTIL THE CAR MADE CONTACT WITH THE PARKING SPACE SIGN. THIS IS NOT A SMALL ISSUE AS 1) IT PROBABLY OCCURRED PREVIOUSLY WITH THE SAME MODEL IN THE SAME FLEET AND LEASER CHARGED ME UPWARD OF FIVE HUNDRED DOLLARS TO FIX VOSMETIC DAMAGE CAUSED WHILE PARALLEL PARKING AND 2) THUS COULD CAUSE BODILY INJURY HAD THE PARKING SPACE NOT BEEN BLOCKED IN FRONT. THESE CARS ARE PART OF A MEMBERSHIP BASED RENTAL FLEET, AND SHOULD BE HIGHLY MAINTAINED. AFTER CONTACTING THE EMERGENCY NUMBER OF THE FLEET LEASER, I WAS A FEW MINUTES LATER ABLE TO REENTER AND START THE CAR, AND THE REVERSE GEAR OPERATED PROPERLY. THE LEASER HAS PREVIOUSLY RAISED MY INSURANCE RATE BASED ON SMALL AMOUNTS OF DAMAGE TO A FLEET VEHICLE INCURRED WHILE PARKING. MY GUESS IS THAT THEY KNOW OF TE PROBLEM AND HAVE CHOSEN TO BLAME THE DRIVERS RATHER THAN THE MANUFACTURERS OR MAINTENANCE ENGINEERS.
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10894712August 10, 2016
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2014 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE VEHICLE WAS PLUGGED IN AND RECHARGING IN THE GARAGE. TWO HOURS LATER, AN EXTENSIVE FIRE ERUPTED FROM THE CHARGE CORD. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES. THE DEALER TESTED THE VEHICLE AND STATED THAT THE CHARGE CORD OVERHEATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND SENT A TECHNICIAN, BUT WAS NOT ABLE TO DETERMINE THE SPECIFIC CAUSE OF THE FAILURE. THE VEHICLE WAS INSPECTED BY A DEALER AND THE INSURANCE ADJUSTER. THE COSMETIC DAMAGES WERE REPAIRED, BUT THE CONTACT WAS UNABLE TO DETERMINE IF THE FAILURE WOULD RECUR. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#10884517July 13, 2016
ELECTRICAL SYSTEM, ENGINE
TL* THE CONTACT OWNS A 2013 FORD C-MAX. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE BATTERY WAS REPLACED, BUT THE FAILURE RECURRED THREE WEEKS LATER. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC; HOWEVER; THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10876018June 22, 2016
ELECTRICAL SYSTEM
THE CHARGE HOUSING CAP FELL OFF. DEALER SAYS IT AFFECTS THE CHARGING CAPACITY $500 CHEAP CRAP!!!! IT DID NOT EVEN LAST 2-YEARS!!!! HOW CAN U ABUSE IT WHEN ALL U DO IS PUSH A BUTTON!! NEVER MORE... A FORD!!!
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10875607June 21, 2016
ELECTRICAL SYSTEM
WE GET A "FAULT IN CHARGING" ERROR MESSAGE WHEN WE TRY TO CHARGE THE VEHICLE
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10871820June 1, 2016
VISIBILITY
TL* THE CONTACT OWNS A 2015 FORD C-MAX ENERGI. THE CONTACT STATED THAT THE VEHICLE WAS PARKED DURING NINETY DEGREE TEMPERATURE WEATHER WHEN IT WAS NOTICED THAT THE MOON ROOF CRACKED EXTENSIVELY. THE DEALER WAS NOTIFIED AND AT THE DEALER'S REQUEST, THE VEHICLE WAS TAKEN TO THE DEALER'S LOCATION FOR EXAMINATION. THE DEALER INFORMED THE CONTACT THAT THE CRACKS APPEARED TO BE AN IMPACT DAMAGED, STATING THAT SOMETHING MIGHT HAVE HIT THE ROOF AND THAT THE MANUFACTURER WOULD NOT BE RESPONSIBLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 4,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford C-Max