Ford Bronco Complaints

938 consumer complaints on file.

#11709554January 7, 2026
ELECTRICAL SYSTEM
I am writing regarding my new Ford Bronco vehicle, VIN: [XXX] , purchased in November 2024, currently with 7,151.5 km. I recently received Ford’s official notice advising that the engine block heater in this vehicle may develop a coolant leak which could result in an electrical short circuit when the system is plugged in. This is a serious manufacturing and safety defect that existed at the time of sale. Due to the nature of this hazard, I am not operating the vehicle, as it has been placed it on storage insurance. The vehicle has not been driven since receiving Ford’s notice in order to mitigate risk and prevent potential damage or injury. Under Manitoba’s Consumer Protection Act and the Sale of Goods Act, a new vehicle must be of acceptable quality, safe, durable, and fit for its ordinary purpose. A vehicle delivered with an admitted safety defect fails to meet these legal requirements. Accordingly, I am formally exercising my right to rescind the sales contract and cancel the related financing agreement. I am kindly requesting a full buy-back, including refund of all payments made to date, payoff of the remaining loan balance by Ford or the dealer, and the cancellation of the financing agreement with no negative credit impact. I would appreciate a written response from you within five (5) business days so that we may proceed toward a timely and appropriate resolution. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709525January 7, 2026
STRUCTURE:BODY, VISIBILITY/WIPER
Chronic water leak from roofline obstructing vision and causing confusion while underway
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11709244January 6, 2026
ELECTRICAL SYSTEM
The contact owns a 2023 Ford Bronco. The contact stated while attempting to start the vehicle, there were several unknown warning lights illuminated. The contact exited the vehicle, raised the hood of the vehicle and became aware that rodents had chewed through the electrical wiring. The vehicle was not taken to the dealer or an independent mechanic to be inspected. The vehicle was not repaired. The manufacturer was notified not of the failure. The approximate failure mileage was 13,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708950January 5, 2026
UNKNOWN OR OTHER
Front camera only works about 1/4 of the time. Most of the time its just black.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11708904January 5, 2026
ELECTRICAL SYSTEM, BACK OVER PREVENTION: WARNINGS, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Concerns a safety-related defect involving the infotainment system in my 2022 Bronco, which is directly related to an active recall and has not been properly addressed by the manufacturer or dealership. Ford issued a recall concerning the infotainment system due to a safety concern. For over a quarter, Ford had no available fix. The entire time I had my Bronco, my infotainment system repeatedly malfunctioned, required frequent resets, & ultimately failed completely. When I contacted the dealership 10/23/25, the earliest service appt was 12/17/25. Upon arrival, I was informed that the infotainment system would need to be repaired before the recall software update could be applied. I explained that the failure itself was the reason for the recall. Despite this, I was required to pay a $196 diagnostic fee to determine if the failure was recall-related. After the eval, the dealership stated the failure was not Ford’s responsibility & provided an estimate of approximately $1,672.61 w/o tax to repair the system on a '22 vehicle. This determination contradicts the stated safety basis of the recall. I contacted my insurance provider to explore coverage. The claim was denied, w/the insurer stating the issue was not caused by an accident or break-in, but was consistent w/a vehicle defect. Despite this, I was still charged the diagnostic fee. Research indicates the recall involves an electrical defect, not only a software issue. A non-functioning infotainment system impacts access to safety alerts & vehicle information, which presents a legitimate safety risk. Ford & the dealership refused to repair the system under the recall, refund the diagnostic fee, or acknowledge the failure as recall-related. I'm continuing to operate a vehicle w/a known safety defect. I'm requesting NHTSA review if recall remedies are being improperly limited, if consumers are being charged for recall-related defects , and if manufacturer &dealership practices comply w/ fed safety requirements.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707925December 30, 2025
EXTERIOR LIGHTING
Description of Incident: > While driving in freezing drizzle/sleet conditions in northern Minnesota, the factory-installed LED headlights on my 2025 Ford Bronco became obscured by ice buildup within 15 minutes of driving. The Safety Issue: > the LED headlights do not produce sufficient heat to melt frozen precipitation. This resulted in a degradation of forward visibility during nighttime driving, creating a safety hazard. I was forced to pull over repeatedly on a high-speed roadway to manually scrape ice from the lenses. Request: > I am reporting this as a design defect for vehicles sold in northern climates. The lack of a heating element or de-icing mechanism in the standard LED equipment makes the vehicle unsafe for nighttime driving during freezing weather with high humidity conditions.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707821December 30, 2025
SERVICE BRAKES
Brake Light issue: Red Brake Light appears when driving over 40 MPH. To fix issue Tube Vacuum had to be replaced. Part# MB3Z 2420 This seems to be an on going issue with 2021 Broncos.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707156December 26, 2025
UNKNOWN OR OTHER
A serious safety recall advised in July of 2025 still has not been fixed.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11707002December 25, 2025
ELECTRICAL SYSTEM, SUSPENSION, FORWARD COLLISION AVOIDANCE: WARNINGS
My vehicle has both cracked and leaking rear shocks as well as issues with the rearview camera and infotainment system. I have gone through two Ford Dealerships to remedy this issue and was told parts are on back order. I attempted to remedy this issue when I first received notification that parts were available in August 2025. When I drive, I can feel the suspension is not providing support and continued use will cause other issues with the vehicle that may not be covered under warranty or the recall. My vehicle will also trigger the collision avoidance feature when there is physical trigger. This has caused my brakes to lock up in traffic.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706745December 23, 2025
SUSPENSION
The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle was bouncing. Additionally, the rear-end swayed while driving over a bump. The dealer was made aware of the failure but confirmed that parts were on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 40,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706454December 22, 2025
ELECTRICAL SYSTEM, LANE DEPARTURE: BLIND SPOT DETECTION, BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Location of wiring from the factory for Blind Spot Warning and Cross Traffic Alert systems is not protected. The wiring has frayed and broken due to the wiring being unprotected, loose and rubbing on the rear bumper, causing the systems to not function. This is a blatant design defect from the factory, causing two safety systems to fail. Reporting now as, to the best of my knowledge, the manufacturer has not issued a TSB or recall and dealerships have acknowledged the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706158December 19, 2025
EXTERIOR LIGHTING:HEADLIGHTS
The contact owns a 2024 Ford Bronco. The contact stated that while driving the vehicle at night, the headlights failed to provide adequate illumination and created a visibility hazard for the driver. While inspecting the vehicle, the contact discovered that there was condensation inside the front headlight assemblies, which caused the illumination from the headlights to be reduced. The contact indicated that the failure occurred while the temperature was below 50 degrees. The cause of the failures was not yet determined, and the vehicle was not repaired. The manufacturer and the local dealer were notified of the issue. The failure mileage was 3,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705997December 18, 2025
ENGINE, UNKNOWN OR OTHER
Ford has 3 safety recalls on 2021 ford bronco and they have no remedy to fix any of them yet. My car stalled out 3 times now because of the low pressure fuel pump failure recall. I was pulling out into traffic and it stalled out while a car was coming at me. The only solution Ford had was to put old parts in the car which I refused. I asked for a loaner vehicle and they said they don’t have any. Recall warning is going on 6 months. I am at a risk and other people are at a risk having my car on the road, tried lemon law and Ford denied me. Nobody feels safe in my car and someone is going to get seriously hurt if this happens at the wrong time.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11705690December 17, 2025
UNKNOWN OR OTHER
The vehicle was parked and not in operation when a fire occurred. There was no collision or impact. The fire originated in the vehicle and caused significant damage. Emergency services responded to extinguish the fire. The vehicle had been properly maintained and there were no aftermarket modifications. The cause of the fire is unknown at this
Crash:
No
Fire:
Yes
Injuries:
0
Deaths:
0
#11705547December 17, 2025
ENGINE
Check engine light stayed on, constant. Code run showed cylinder 4 misfire. Bronco still under warranty so took to dealership. Mechanic said coolant was inside cylinder so he requested recommended remedy from Ford and would probably be engine replacement.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703800December 8, 2025
ELECTRICAL SYSTEM, STEERING, VEHICLE SPEED CONTROL
Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, an 18-wheeler in the lane beside me was merging to his right. The sudden loss of my IPC screen meant I could not see my speedometer, warning indicators, safety messages, or any visibility cues needed to safely judge traffic speed and spacing. This created an immediate hazardous situation and made it extremely difficult to manage both my own speed and the surrounding traffic patterns. As I recognized the danger, I attempted to brake and avoid a collision. During this moment, my steering wheel began to shake slightly—possibly due to the lane-keeping or lane-safety system responding. Despite my efforts to correct and avoid impact, the 18-wheeler collided with my vehicle. At the time of the crash, I had no visibility of any dashboard warnings, alerts, vehicle speed, or safety notifications due to the IPC failure. My insurance representative has inspected my vehicle and deemed it a total loss.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11703666December 8, 2025
EXTERIOR LIGHTING
While driving on the interstate in light snow and mostly clear and semi dry roads, ice accumulates on both the head lights and the foglights to a degree that they no longer project enough light to see far enough ahead at even moderate speeds. When I pulled over to inspect them, the surface was coated with a mix of ice and dirt rendering them useless. Ambient temperatures were between 24 and 30 degrees. It seems that the LED lights lack enough heat to protect from ice accumulation and a heat element of some type should have been included given the placement of the lights being somewhat recessed and that allows for accumulation. Obviously in pre-dawn darkness this produced an unsafe operation of a vehicle at highway speeds due to not being able to see the road far enough in advance. As far as I know it has not been addressed or noticed by Ford since there is no information about this in their manual. I have seen aftermarket products that heat the light surface and prevent the accumulation of ice - Ford should retrofit something to prevent the accumulation of ice on light surfaces.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702675December 3, 2025
EXTERIOR LIGHTING
Driving in sub-freezing temperatures with snow/rain falling and slush on the road, the headlights iced over with thick slush and ice and reduced visibility to dangerous levels requiring me to pull off the road and chip off the ice putting myself in a dangerous situation being on the side of the road during a storm.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702446December 2, 2025
EXTERIOR LIGHTING
While driving in snowy conditions the headlights become covered with snow to the point of not illuminating enough to see. Which then makes trying to find a spot to pull over safely to wipe them becomes extremely dangerous. The snow covered lights happens quickly. Creating hazardous driving conditions. The data provided is the most recent. This happens every winter since purchasing this vehicle. I was not familiar with notifying your agency until recently.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11702389December 2, 2025
EXTERIOR LIGHTING
On November 30th, 2025 I drove southbound from Milwaukee to Chicago, leaving at approximately 5:30 a.m., on I-41. There was a winter storm warning in effect. Approximately every twenty miles I needed to stop and deice my headlights as light output had diminished to almost zero, resulting in extremely dangerous visibility. I have experienced similar problems in Manitoba and western Minnesota. In these areas, there is often more than fifteen miles before you can exit the highway or find a safe place to pull over. It is not possible to get this problem diagnosed by a dealer. However, it is a common complaint among Bronco (and Jeep) owners. The combination of an upright grill and the low heat output of LED lighting quickly render headlights useless in snowy or icing conditions. No warnings appear; light output simply quickly drops to almost nothing.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Ford Bronco