Dodge · Model Report
Showing safety data for the 2003 model year only.
ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
The contact owns a 2003 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed and turning, the vehicle made an abnormal growling sound. The vehicle was taken to an independent mechanic, where it was diagnosed that the power steering fluid was leaking. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the vehicle had been repaired under NHTSA Campaign Number: 04V386000 (Steering) in 2004. The failure mileage was approximately 329,281.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2003 DODGE GRAND CARAVAN. WHILE DRIVING, THE STEERING WHEEL BECAME DIFFICULT TO TURN TO THE RIGHT. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CLOCKSPRING PIN WAS FRACTURED AND CAUSED THE FAILURE. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 367,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2003 DODGE GRAND CARAVAN. WHILE ACCELERATING FROM A STOP, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 238,000.
No injuries · No fire · No crash
THERE ARE TWO PROBLEMS THAT ARE VERY SERIOUS. FIRST, IN 2017 AS I WAS EXITING THE INTERSTATE, I DROVE THROUGH A PUDDLE. AS I ATTEMPTED TO TURN LEFT ONTO THE ROAD, MY STEERING WHEEL LOCKED AND IT WAS ONLY WITH EXTREME FORCE AND SLAMMING ON THE BRAKES THAT I KEPT FROM RUNNING THROUGH THE GUARDRAIL, AND DROPPING DOWN TO THE INTERSTATE BELOW. I WAS UNABLE TO MAKE THE TURN AND STOPPED ON THE OVERPASS UNTIL MY STEERING WHEEL UNLOCKED. YES, MY ENGINEER HUSBAND KEEPS UP WITH ALL OF OUR REGULAR MAINTENANCE, INCLUDING THE BELTS. NEXT, WITH AN UNUSUALLY HEAVY RAIN THIS PAST WEEK, MY BATTERY LIGHT CAME ON. AFTER PARKING FOR AN HOUR, MY STEERING WHEEL WOULD NOT TURN WHEN I ATTEMPTED GO AGAIN. I RESTARTED THE CAR FIVE TIMES BEFORE THE STEERING UNLOCKED. ALL WEEK, DURING THAT HEAVY RAIN, THE STEERING LOCKED REGULARLY. THESE PROBLEMS ARE ALL OVER THE WEB. WOMEN AND CHILDREN EVERYWHERE ARE IN DANGER OF DYING FROM SOMETHING THAT SHOULD HAVE BEEN RECALLED YEARS AGO. WHY IS THERE NO RECALL FOR THIS PROBLEM? IF YOU ARE REFUSING TO DO ANYTHING ABOUT THIS, THEN YOU ARE ELIGIBLE FOR BEING SUED ALONG WITH CHRYSLER, FOR ALLOWING THIS TO CONTINUE UNCORRECTED.
No injuries · No fire · No crash
THE PASSENGER SIDE SEAT BELT WARNING LIGHT TURNS ON EVEN WHEN THERE IS NO ONE IN THAT SEAT AND THE PASSENGER SIDE SEAT BELT RELEASES WHEN THERE IS SOMEONE IN THE SEAT! ADULTS AND OLDER CHILDREN HAVE PUT THE SEAT BELT IN PLACE BUT THE WARNING LIGHT STAYS ON. WHILE DRIVING OR SITTING STILL, THE SEAT BELT WILL RELEASE AT RANDOM, CAUSING THE PASSENGER TO HAVE TO CLICK IT INTO PLACE AGAIN. WHEN THE PASSENGER CLICKS THE SEAT BELT IN PLACE AND PULLS ON IT, IT EITHER STAYS IN POSITION OR RELEASES. IF IT STAYS IN POSITION, THEN WHILE DRIVING AND OR PARKED, THE SEAT BELT WILL SUDDENLY RELEASE. WHEN THE DRIVER HAD TO STEP HARDER ON THE BRAKE TO AVOID A DRIVER WHO STOPPED SUDDENLY, THE SEAT BELT RELEASED YET AT OTHER TIMES, THE SEAT BELT REMAINS IN PLACE. IT DOESN'T MATTER WHETHER OR NOT THE VAN IS IN GEAR OR PARKED, OR IF WE'RE STOPPED, MOVING, HIGHWAY DRIVING OR CITY DRIVING, THE SEAT BELT WILL RELEASE AT RANDOM TIMES. THIS HAD HAPPENED MULTIPLE TIMES SINCE WE BOUGHT THE VEHICLE, SOMETIMES MULTIPLE TIMES IN ONE TRIP. OTHER TIMES IT DOESN'T HAPPEN AT ALL. THE DATE GIVEN IS THE MOST RECENT TIME THAT IT RELEASED ON ITS OWN. I HAD BEEN PARKED AND THEN WAS BACKING OUT OF A PARKING SPACE WHEN MY DAUGHTER'S SEAT BELT (PASSENGER SIDE) RELEASED ON ITS OWN. I STOPPED AND PUT THE VAN IN PARK THEN HAD HER CLICK IN PLACE AGAIN. WE BOTH PULLED ON IT AND SINCE IT DIDN'T RELEASE, WE CONTINUED OUR TRIP, PRAYING THAT IT WOULDN'T DISCONNECT AGAIN WHILE WE WERE DRIVING.
No injuries · No fire · No crash