Dodge · Model Report
Showing safety data for the 1998 model year only.
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO THE FUEL PUMP MODULE.
ON CERTAIN MINIVANS, THE DRIVER'S AIR BAG MAY BECOME DISABLED DUE TO A FAILURE OF THE CLOCKSPRING, WHICH IS LOCATED IN THE HUB OF THE STEERING WHEEL.
ON CERTAIN MINI VANS, THE CLOCKSPRING ASSEMBLY MAY HAVE BEEN WOUND INCORRECTLY DURING THE VEHICLE ASSEMBLY PROCESS.
VEHICLE DESCRIPTION: MINI VANS BUILT WITH 3.3L AND 3.8L ENGINES HAVE FUEL RAILS WITH NITROLE RUBBER O-RING SEALS THAT CAN DEGRADE OVER TIME. FUEL LEAKAGE FROM THE UNDERHOOD FUEL INJECTION FUEL RAIL COULD RESULT, INCREASING THE LIKELIHOOD OF A VEHICLE FIRE.
The contact owns a 1998 Dodge Grand Caravan. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of power steering assist and then stalled. Additionally, the odometer failed to display the correct mileage and the speedometer failed to display the correct speed of the vehicle while the engine revved. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 152,000.
No injuries · No fire · No crash
THE DRIVER'S HORN DOES NOT WORK AND HASN'T SINCE IT WAS TAKEN IN TO REPLACE THE CLOCK SPRING ASSEMBLY. THIS WAS DONE AS PER A RECALL ISSUED BY NHTSA AND DAIMLERCHRYSTLER CORPORATION RELATING TO DRIVER'S AIRBAG BY THE ORIGINAL OWNER. HE ALSO DID NOT HAVE THE ORIGINAL PAPERWORK ON THE VAN. I AM THE SECOND OWNER AND WHEN I DISCOVERED THE HORN DID NOT WORK. AFTER RESEARCHING AND SUBSCRIBING TO THE THE NHTSA RECALL ALERTS I DETERMINED THAT THIS MAY HAVE BEEN CAUSED BY THE CLOCK SPRING REPLACEMENT. I WAS ALSO TOLD THAT THE REPLACEMENT CLOCK SPRING COULD HAVE BEEN DEFECTIVE AS WELL, BECAUSE IT WAS DONE SO SOON AFTER THE RECALL WAS ISSUED. I TOOK IT TO A LOCAL DEALERSHIP WHERE I LIVE AND THEY CONFIRMED THAT THERE HAD BEEN A RECALL ISSUED AND THEY WERE SORRY, BUT THEY COULDN'T REPLACE IT AGAIN. THEY SUGGESTED THAT I TAKE IT BACK TO THE DEALERSHIP WHERE IT WAS PURCHASED. I EXPLAINED TO THEM THAT I WAS NOT THE ORIGINAL OWNER AND DIDN'T KNOW WHERE IT WAS PURCHASED FROM ORIGINALLY. EVEN WHEN I TOLD THEM THAT I WOULD PAY THE COST OF THE REPAIR, THEY WERE NOT INTERESTED. I TOOK IT TO A LOCAL MECHANIC AND HE DIDN'T WANT TO TOUCH IT BECAUSE THERE WAS SO MUCH INVOLVED IN THE STEERING COLUMN THAT COULD GO WRONG AND HE DIDN'T HAVE THE EXPERTISE TO DO IT. THE VEHICLE IS NOT SAFE AND HASN'T BEEN SINCE BEFORE AND AFTER I PURCHASED IT. MY CONCERN IS IF THE HORN DOESN'T WORK'THEN HOW CAN I BE SURE THE AIRBAG DOES. I'M STILL DRIVING THIS VEHICLE BECAUSE I CAN'T SELL IT TO SOMEONE ELSE IN THIS CONDITION. IS THERE NO RECOURSE IF THE VEHICLE AS NOT REPAIRED AS PER THE NHTSA'S RECALL? THIS VEHICLE ONLY HAS 91054 MILES ON IT AS OF THIS DATE.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WHILE OPERATING THE VEHICLE, A KNOCKING NOISE WAS HEARD COMING FROM THE ENGINE AND THE VEHICLE HESITATED WHEN ACCELERATING. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS DUE TO LOW OIL PRESSURE CAUSED BY FAULTY ENGINE CONNECTING RODS. THE VEHICLE WAS NOT REPAIRED. SWANTYS DODGE (2494 SOUTH HWY 95, BULLHEAD CITY, AZ) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 261,000.
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 1998 DODGE GRAND CARAVAN. WHILE DRIVING 60 MPH, ALL THE WARNING INDICATORS ILLUMINATED AND THE HORN, SPEEDOMETER, FUEL GAUGE, AND CRUISE CONTROL FAILED TO FUNCTION. THE CONTACT CALLED STEW HANSEN DODGE RAM CHRYSLER JEEP AT (515) 331-2900 (LOCATED AT 12103 HICKMAN RD, URBANDALE, IA 50323) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.
No injuries · No fire · No crash
SERVICE BRAKE FAILURE WHILE DRIVING, DIAGNOSED BY REPAIR SHOP AS A RUPTURED BRAKE LINE. INSPECTION OF OTHER BRAKE LINES SHOWED HEAVY CORROSION. VEHICLE WAS IN MOTION (STRAIGHT LINE) ON A CITY STREET AND RETAINED MINIMAL BRAKING. I WAS ABLE TO STOP AT A STOP LIGHT (NO COLLISION) AND 'LIMP' TO THE REPAIR SHOP. REPAIRS CONSISTED OF REPLACING THE HYDRAULIC BRAKE LINES.
No injuries · No fire · No crash