Chevrolet Suburban Complaints (2022)

124 consumer complaints on file.

#11768042September 30, 2026
ENGINE
The fuel pump control module failed, causing the engine to stop.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766930September 25, 2026
ENGINE AND ENGINE COOLING
The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the engine failed after the message “Drive Carefully - Reduce Acceleration” was displayed and the vehicle then came to a sudden stop. The vehicle was unable to accelerate, and the engine seized. The contact replaced the battery, but the failure persisted. The vehicle was towed to an independent mechanic, and the vehicle was diagnosed with a blown engine. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 125,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11766657September 24, 2026
POWER TRAIN
Intermittant slow, jerking when shifting gears. In 4wd rear wheels locked up on right hand turn, sliding through intersection. No warning or failure lights. Needs inspection and repair.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765177September 18, 2026
POWER TRAIN
2022 Chevrolet Suburban, 3.0L Duramax diesel, 10-speed automatic, purchased March 2022, approx. 122,000 miles. In early August 2026 the transmission began shuddering at low speeds. Reported to the selling and servicing Chevrolet dealer on 08/11/2026 at 118,892 miles. No transmission diagnosis was performed; the dealer's written estimate recommended spark plugs on a diesel engine. The condition worsened. On 09/17/2026 the dealer verified the concern and documented a "very harsh shift which would continue until 5th gear" when accelerating, and found the transmission fluid "heavily contaminated with metal and clutch material." The dealer recommended transmission replacement at customer expense and stated GM Special Coverage N242454441 (transmission control valve wear, companion to Safety Recall 24V-797 / GM N242454440) does not apply because DTC P0747 is not set, although that bulletin lists harsh shifting as an effect of the worn control valve. The control valve body has not been inspected. GM's recall filing states this wear can cause harsh shifting and in rare cases momentary rear wheel lock-up. No warning lamps or messages appeared before the harsh shifting. No crash, fire or injury. The vehicle and transmission are at the dealer and available for inspection; a GM TAC/FSE inspection has been requested. Filing so NHTSA has a record of a 2022 Suburban diesel showing the recall symptom and being denied inspection on the basis of the P0747 code alone.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11765232September 18, 2026
ENGINE
While towing a light trailer (~3,000 lbs) through the mountains on an interstate, my 2022 Suburban with the 6.2 engine suddenly got hot and shut off. There were no symptoms of the engine having any issues, it had been running well the whole trip. The temperature gauge went from normal to very hot in a very short time. I was not able to get it to a pull-off area and was stranded partially in the right lane of the interstate with several collision close calls. This problem was later determined by the dealer to be the common crank bearing issue for this model engine.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761632September 2, 2026
ENGINE, ELECTRICAL SYSTEM, FUEL/PROPULSION SYSTEM
This problem isn’t just the 6.2L engine. My 22 Suburban has the 5.3L and had engine failure on the freeway going 70 mph in April 2026. Loud noises and loss of power. Towed to dealership and was confirmed that it was the same issues as the 6.2L. The dealership only replaced certain components (gears, rods, camshaft etc.) Parts replaced and vehicle returned a month later but still loss of power and bad idle. New dealership in May 2026, replaced same parts, said faulty parts were used at previous dealership. Vehicle repaired and returned in June2026, a day later new code for service transmission now code thrown and parking break not working. Returned to dealership and said it was a fuel pump module? failed. No vehicle for 3 months and lots of headaches. This recall needs to be extended to the 5.3L engine as well. Needs full replacement, not just repaired. My vehicle still doesn’t run great but Chevy will not honor anymore repairs.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761352September 1, 2026
ENGINE
The contact owns a 2022 Chevrolet Suburban. The contact received an unknown recall. The contact stated that the vehicle was taken to the dealer, and while parked at the dealer, it was determined that there were metal shavings in the oil and that the engine needed to be replaced. The vehicle was repaired, but a failure occurred 4,000 miles, two months later. The contact stated that while driving 55 MPH, the vehicle lost power and then stalled. The vehicle stopped in the middle of the highway and was inspected. The vehicle was then towed to a different dealer where it was diagnosed and determined that the engine had failed and needed to be replaced. The vehicle was not yet repaired. The vehicle was towed back to the dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 53,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11761177August 31, 2026
ENGINE
I am submitting a safety complaint regarding our 2022 Chevrolet Suburban equipped with the 6.2L L87 engine. The vehicle is subject to GM Product Safety Recall N252494000 / NHTSA Recall 25V-274. Our Suburban underwent GM's required recall inspection, including the Picoscope inspection. The engine passed the inspection and the engine oil type was changed in accordance with GM's recall procedure. Since passing that recall inspection, we have experienced the following issues: On XXX, at approximately 40,527 miles, while we were in [XXX], the vehicle displayed a reduced-acceleration warning and check-engine light and experienced significant acceleration problems and loss of reverse. We took the vehicle to Essenlohr Motors, a Chevrolet dealer in [XXX]. The dealer diagnosed a P0700 condition/control solenoid stuck off and repaired the transmission valve body under GM warranty. I understand this incident was diagnosed as a transmission issue, and I am including it as part of the vehicle's recent history rather than asserting that it was caused by the L87 engine defect. The dealer's repair order documents both the check-engine condition and our report of the reduced-acceleration warning. On XXX, after we had returned home to [XXX] from our trip to [XXX], the Suburban had 41,798 miles on it. We drove approximately 2 miles from home when a “Low Engine Oil–Add Oil” warning appeared. We immediately returned home and parked the vehicle. After allowing it to sit for approximately 15 minutes, we checked the engine oil and there was no oil registering on the dipstick. We saw no evidence of an external oil leak on the garage floor or underneath the vehicle. Rather than continuing to drive it, we had the Suburban towed to Wiers Chevrolet in [XXX]. The dealer confirmed that the engine was approx. two quarts low on oil and indicated that there was no apparent leaks. They performed an oil change and started a 6,000 mile oil consumption test. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760833August 31, 2026
ENGINE
The engine seized as we were driving 65mph on the highway on a family trip. Had no warning sings or any dashboard lights come on. The vehicle just put itself in neutral and we coasted down the road until we came to a complete stop. Had the recall done a year ago for it. The dealer confirmed now that it was a catastrophic engine failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760852August 31, 2026
POWER TRAIN
Just for information purposes, I have been an ASE certified Master automotive technician for 30 years. As I was accelerating onto the highway, my transmission downshifted hard, throwing everything forward. It then went into limp mode with “ses” light on. I was able to drive it home stuck in one gear. The next morning I tried to drive the truck. It had reverse but when trying to go forward, the transmission was stuck in between gears and fighting itself. I manually shifted into low gear and it seemed to clear up the binding. I drove the truck up and down my driveway which is about a half mile long. No more “ses” light but when I went to park it, there was no movement in reverse. As I researched the problem I found the recall information on the valve body. I called several dealerships to find a service writer that had experience with these transmission issues. The truck was towed to a dealership that knew about this recall. Their technician checked for codes but there were none. It seems these trucks reset or “lose” codes when the ignition is turned off. He checked the fluid and decided that the reverse clutch must be burned up. They quoted a transmission replacement at $6500. I asked if they had driven the truck forward at all to reset any trouble codes. The truck was “unsafe” to drive due to the random harsh downshift and erratic behavior. I went there(putting myself in danger) to drive the truck to reset any trouble codes. Within a mile the truck did the same thing. It stored a code P2732. I was informed that GM would not do anything for me unless there was a P747. After reasoning with the service manager and also GM, it was obvious I was out of luck. I had the truck towed home and removed the transmission pan. The fluid was clean and there was no debris. The problem is in the defective valve body from GM but since it didn’t have the code P0747 I’m stuck having to repair it myself. The truck has 126k miles still well within the extended service range.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760906August 31, 2026
ENGINE
The contact owns a 2022 Chevrolet Suburban. The contact stated that while driving at highway speeds, the vehicle shut off while displaying "Service Transmission Now Unable to Shift Soon" and "Engine Power is Reduced" warning messages. The vehicle was towed to a dealer where it was previously inspected under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, no repairs were performed. After remaining at the dealer for nearly eight weeks, the engine was replaced under warranty. A few weeks after the replacement, the same warning messages were displayed on the instrument panel upon startup. The contact attempted to drive the vehicle; however, the vehicle failed to exceed 20 MPH and was towed back to the dealer. While attempting to drive the vehicle into the service bay, the technician experienced severe hesitation and engine stalling. During diagnostic testing, a large amount of metal shavings was discovered in the oil filter, and the vehicle was diagnosed with the same engine failure as before. The vehicle was repaired; however, the contact refused to take possession of the vehicle due to safety concerns. The manufacturer was notified of the failure, and a case was filed. The failure mileage was 61,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760793August 30, 2026
ENGINE, ELECTRICAL SYSTEM
Operating vehicle normally until one day I heard a rattling noise from the engine compartment. Car had limited speed and i had to pull over to check what the issue was and the car wont start. No check engine lights, no warning. Tried turning car on but only the car starter keeps rolling. Tried jumping and it doesnt start and had to have it towed to the dealership. Car is under 55,000miles and dealer diagnosis indicates there are metal particles in the new oil after replacing oil and a loose bearing. States i will need a new engine, which is on back order and GM will only cover $44/day until repair is complete. All maintenance and oil change invervals were kept up to date. Other days when I start the car, the main HUD with the speedometer does not turn on. Pitch black... I can drive but not know what my speed is. I had to disconnect battery and reconnect to clear the issue. It has happened several times.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11760269August 28, 2026
ENGINE
Had the recall service done , where they change the oil weight, to the 6.2 L engine and just a few months later the engine died while driving on the highway . It just stopped running. The car is only 3.5 years old and the engine died. They took it apart and said it was a non effected part that failed but i find that crazy. No warning just complete shut down. I was luck and only going about 30 MPH on the highway due to heavy traffic. But then needed to sit on the highway for hours weighting for a tow. The kicker is the car would not go into neutral and made everything so much harder.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11759270August 24, 2026
ENGINE
operating vehicle as usual, in drive, when engine spontaneously turned off. Alerted by system to "push button to start again" and put me in neutral. Extremely dangerous while the vehicle was in motion. This is the exact same thing I read about in a 2025 recall of 2021-2024 model year Suburbans and other vehicles. Mine is a 2022 Suburban.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758864August 23, 2026
UNKNOWN OR OTHER
Found that SOS nor OnStar buttons were not working. Dealership checked telematics control module was failing. Service bulletins were issued for wide spread failures, however no recall notices were issued. The module failure will also prevent notifications in the event of a traffic crash. Estimated repair cost $900. A true safety issue that should require a recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758091August 19, 2026
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle, the instrument panel displayed a blank screen. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed, and it was determined that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 95,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758065August 19, 2026
ELECTRICAL SYSTEM
The telematics control module in this vehicle failed. A dealer diagnostic scan on 03/09/2026 at 67,839 miles documented the following active and history codes: U0198 Lost Communication with Telematics Module, reported independently by the Radio, Body Control Module, and Instrument Panel Cluster Control Module; U0499 Invalid Data Received from Telematics Module, reported by the Engine Control Module; U1962 Unable to Authenticate Serial Data Message; B1A1F Ethernet Bus 4 (+) Circuit Open with a Low Voltage/High Temperature symptom; and P00FF Body Control Module Requested MIL Illumination, listed as Current. As a result, the check engine light is commanded on. All OnStar functions are inoperative, including Automatic Crash Response and Emergency SOS, which are safety systems. The OnStar button has no illumination at all. Remote functions and vehicle connectivity are dead. No warning message or notification of a module fault was ever displayed in the vehicle. The infotainment system reports “Your Software is Up-to-Date” and the Device Registration screen reports “Registered.” The last over-the-air software update this vehicle received was in August 2023
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757705August 18, 2026
UNKNOWN OR OTHER
2022 chevy suburban diesel. Severe paint chipping and rust around windshield and top of truck. Midnight blue is the color and chevy is not covering the his defect of it destroying my truck right now complete rust and chunks of paint chipping away on the windshield it is so noticeable how bad this is chipping. And whole top of truck and front paneling show same signs everywhere of bubbling ready to chip away soon. The corrosion on truck that should not occur On a 4 year anniversary or truck from chevy a 2022! I’ve been asking for this for months as 9,500 for a paint job quote for something that it shouldn’t need to be done a paint job with rust. Chevy needs to step up and fix this. I’m a mother to 7 daughters and we need this vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11754534August 3, 2026
ENGINE
The contact owns a 2022 Chevrolet Suburban. The contact stated that while attempting to start the vehicle with the Push-To-Start button, the engine failed to turn over. The check engine warning light was illuminated. The contact's husband was notified of DTC: P129F, which was diagnosed by the OnStar App. The vehicle was towed to a local dealer where it was diagnosed with a defective fuel control module. The vehicle was scheduled to be repaired out-of-pocket. Upon further investigation, the contact associated the failure with General Motors Emissions Recall: N252516900; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 39,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749284July 9, 2026
ENGINE
Driving down XXX going back home was driving normal when suv shut off on freeway with no warning what so ever i was 12 hours away from home almost crashed into bridge side wall was stranded on side of freeway with my whole family n my new born baby in the heat motor locked up per dealer 74k miles had to pay tow truck n a rental to get back home INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Suburban