Chevrolet HHR Complaints (2006)

1,006 consumer complaints on file.

#11678011August 2, 2025
SUSPENSION, ENGINE, STRUCTURE:BODY
The door few open because the door latch broke off
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663581May 29, 2025
STEERING, UNKNOWN OR OTHER
While replacing 3 motor mounts, engine oil pan,transmission oil pan, also CV axles, wheel bearings needed replaced. When i got my car back the power steering wasn't working. My mechanic said there was a recall for my year, make and model for the power steering assist. I haven't gotten this fixed yet due to lack of funds . I am filling this out to see if is recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11629295December 6, 2024
STEERING
The contact owns a 2006 Chevrolet HHR. The contact stated while driving at an undisclosed speed, the steering wheel seized, with the power steering warning light illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was restarted; however, the failure recurred. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 240,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11614139September 12, 2024
STEERING
The (EPS) system in my 2006 Chevy HHR has experienced multiple malfunctions. The power steering suddenly cuts out without warning while driving at both low and high speeds, making it extremely difficult to steer, especially when attempting to turn or change lanes. This failure happens intermittently, and the EPS motor is suspected to be the root cause. I have replaced fuses and relays, but the issue persists. This system is available for inspection upon request. This malfunction poses a severe risk to my safety and the safety of others. When the power steering fails, it becomes nearly impossible to turn the vehicle, which is especially hazardous during routine maneuvers such as lane changes or turns at intersections. The sudden loss of steering capability, especially at higher speeds, has left me vulnerable to potential collisions. Given the unpredictability of the issue, it could easily lead to a fatal accident if it occurs while navigating tight curves or avoiding road hazards. The problem has been confirmed by a certified mechanic, who validated that the power steering system is malfunctioning and recognized the danger it poses. The mechanic advised that this issue is prevalent in vehicles of this make and model & suggested filing a formal complaint to prompt further investigation by the manufacturer. To date, the veh has been thoroughly examined by an independent service center. They confirmed the malfunction of the EPS system but were unable to fully resolve the issue through standard repairs like fuse or relay replacements. A "Power Steering" message illuminates on the dashboard. A few seconds later, the power steering system fails completely, leaving the vehicle almost impossible to control. These warnings have been intermittent, but their frequency has increased over time. The first occurrence was about a year ago, Given the ongoing danger and prevalence of this issue among other 2006 Chevy HHR owners, I am requesting that GM initiate a formal recall.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11595986June 23, 2024
STEERING
Power steering cuts off and very hard to steer until you turn off vehicle and turn back on but then will go out again while driving .This is very un safe when my wife is driving Kids to school.I have read that 2009-2011 has same issue and have been recalled why isn’t this one if it’s same problem .
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11579304March 25, 2024
STEERING
The contact owns a 2006 Chevrolet HHR. The contact stated that the vehicle was parked with the key locked inside. The locksmith assisted the contact with entering the vehicle. The contact stated that it was difficult to pull out of the parking space due to a loss of power steering functionality. The vehicle was driven to a local mechanic but was not repaired due to the cost. The manufacturer was not made aware of the failure. The approximate failure mileage was 146,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11578872March 22, 2024
FUEL/PROPULSION SYSTEM
Fuel line is leaking under the car. I could smell gas when I would get out of my car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11562300December 28, 2023
ELECTRICAL SYSTEM, STEERING
while driving the car after a few miles, the door locks start going up and down, the power steering light comes on and is hard to steer, the check engine light comes on, the speedometer stops working and the tach malfunctions. the car surges while moving foward. if you shut the car off it will reset itself. once you start the car again it starts to malfunction again. one gararge owner did some tests but didn't fix the problem
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11558570December 5, 2023
STEERING
The power steering went out. Very hard and unsafe to drive.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11542647September 5, 2023
FUEL/PROPULSION SYSTEM
Gas line leaking under left rear tire
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11534867July 27, 2023
ELECTRICAL SYSTEM, LATCHES/LOCKS/LINKAGES, POWER TRAIN
The contact owns a 2006 Chevrolet HHR. The contact stated that while driving at various speeds, the vehicle lost motive power and would not properly accelerate. Additionally, the front passenger’s side door would not open while using the interior door latch. The contact stated while using the cigarette lighter, the vehicle shut off, and smoke filled the cabin of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 92,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11491694October 31, 2022
FUEL/PROPULSION SYSTEM
Rear Section of the rear fuel line started to rott out and started leaking. The sction is where there is insulation on the line, adjacent to the Left rear tire. The rest of the line is good with no corrosion or rust. When the car is running and stopped a puddle forms under the car that is gasoline. I noticed it about a week ago , I smelled gas and thought the engine was the source, but later determined it was the fuel line as I could see the leak. It is by the rear plastic fuel line holder / support. The vehicle is always parked on a concrete driveway or paved street. Never on grass or dirt.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11445931January 3, 2022
SERVICE BRAKES, EXTERIOR LIGHTING
Brake light tail light and rear blinker housing keeps melting leaving us with no working lights what so ever. Costly and dangerous
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11426119July 23, 2021
STEERING:ELECTRIC POWER ASSIST SYSTEM
The contact owns a 2006 Chevrolet HHR. The contact stated that the power steering warning light was illuminated, and the steering wheel was difficult to maneuver. The contact stated that the failure recurred while driving at various speeds and while idling. The contact stated that the failure occurred at least once every hour. The contact learned that the electronic power steering gear needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 46,973.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11425858July 21, 2021
STEERING
While driving in town lost the power steering on a turn making it difficult to steer and control the car. Self explanatory for keeping control of the car. Not sure what the problem is for sure the motor or other components. There was a vehicle safety recall but I was not notified that my vehicle may have been included. Problem still exists. No inspections as no accident occurred. Got a chime when unit failure immediately when it got disabled. No warning or message before or prior to failure.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11424558July 13, 2021
FUEL/PROPULSION SYSTEM
Fuel line rotting. Dripping gas towards rear of car. When I did my research this is very common with the Chevy cars. Like the HHR cavaliers and cobalts. Using a cheap metal then wrapping it in a heat shield that cause moisture to stay trapped causing the lines to rot.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11423614July 6, 2021
SERVICE BRAKES, HYDRAULIC
The contact owns a 2006 Chevrolet HHR. The contact stated while starting the vehicle, the low unknown fluid warning light was illuminated. The contact checked the fluid levels and the fluid levels were at full. After a couple of days the contact restarted the vehicle and the warning light was off. The contact was concerned that there might be an issue with brake fluid not flowing through the brake lines as designed which could cause the brakes to not work properly. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 160,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11383320December 14, 2020
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS 2006 CHEVROLET HHR. THE CONTACT STATED THAT THERE WAS AN ODOR OF FUEL WHILE THE VEHICLE WAS PARKED. THE CONTACT NOTICED A PUDDLE OF FUEL AT THE FRONT OF THE DRIVER'S SIDE UNDERNEATH THE VEHICLE. THE CONTACT ALSO NOTICED THAT THE VEHICLE WAS LEAKING FUEL WHERE THE HEAT SHIELD INSULATION RETURN AND BRAKE LINE WERE LOCATED. THE CONTACT STATED THAT FUEL LINE WAS CORRODED WITH SEVERAL HOLES. THE CONTACT CALLED REEDMAN TOLL AUTO GROUP (1700 LINCOLN HWY #101, LANGHORNE, PA 19047) AND INFORMED THE DEALER OF THE FAILURE AND WAS ADVISED TO SCHEDULE AN APPOINTMENT. THE CONTACT CALLED THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 128,586.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11378646December 9, 2020
EXTERIOR LIGHTING:BRAKE LIGHTS
TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE BRAKE WARNING LIGHT ILLUMINATED CONTINUOUSLY WHILE IT WAS 27 DEGREE FAHRENHEIT. THE CONTACT MENTIONED THAT THERE WERE MULTIPLE COMPLAINTS DUE TO COLD WEATHER AND THAT THE BRAKE LIGHT MAY REMAIN ILLUMINATED. IN ADDITION, THE CONTACT NOTICED THAT THERE WAS AN UNKNOWN TECHNICAL SERVICE BULLETIN FOR THE ISSUE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11373108November 5, 2020
FUEL/PROPULSION SYSTEM
FUEL LINE LEAK NEAR REAR TIRE. FOUND PRESSURE LINE ROTTED INSIDE OF HEAT PROTECTION WRAP.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR