Chevrolet HHR Complaints

3,575 consumer complaints on file.

#11773097October 22, 2026
STEERING, ELECTRICAL SYSTEM
While driving my car the power steering stopped working and I was unable to turn my steering wheel, the car wouldn't turn, almost ended up in a ditch.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11757032August 14, 2026
ELECTRICAL SYSTEM, ENGINE, UNKNOWN OR OTHER
Remedy for campaign 14V047000 was executed defectively, creating an unsafe mechanical failure that destroyed the powertrain. Failure occurred while or shortly before vehicle stalled in heavy traffic. Vehicle would not restart, but ignition switch stuck in start position while attempting restart, causing starter motor to crank continuously until the switch was turned to the off position. It is believed that starter motor was running while engine was running since last successful start about 3 minutes prior to stall, interfering with normal operation of the engine and eventually causing engine to jump timing and sustain catastrophic internal damage. Subsequent GM dealer service visit found that a burr on the new key provided with campaign 14V047000 repair caused ignition switch to bind in start position. Service staff buffed out burr on key which resolved switch binding, but vehicle refused to start. Borehole inspection of engine found damaged valves and pistons, leading to diagnosis of jumped timing. No other work other that diagnosis has been attempted at this point. Estimate to replace engine is $8600
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738005May 15, 2026
FUEL/PROPULSION SYSTEM
The fuel line rusted causing it to leak. We discovered it when we had some exhaust work done on the car. No one other then myself and the people that have done the exhaust work. There was no warning of the issue.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727264March 26, 2026
FUEL SYSTEM, GASOLINE
The contact owns a 2008 Chevrolet HHR. The contact stated that while the vehicle was parked and turned off, the contact was informed that the vehicle was leaking gasoline. The vehicle was inspected, and the contact was informed that fuel was leaking from the driver’s side rear wheel well area, near the muffler. While at the residence, the contact observed that fuel was still leaking from the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a rusted fuel line located near the driver’s side rear wheel well, and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer. The approximate failure mileage was 68,900. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11727282March 26, 2026
FUEL/PROPULSION SYSTEM
Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11720216February 24, 2026
ELECTRICAL SYSTEM, TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS, AIR BAGS
The contact owns a 2008 Chevrolet HHR. The contact stated that the key was stuck in the ignition switch and failed to release. Additionally, the TPMS warning light was illuminated. The vehicle was towed to the local dealer, who confirmed that the key was stuck and needed to be broken, and any damages would be at the owner's expense. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 14V171000 (Air Bags, Electrical System). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11706785December 23, 2025
AIR BAGS, ELECTRICAL SYSTEM
The contact owns a 2008 Chevrolet HHR. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 14V047000 (Air Bags, Electrical System); but the vehicle experienced a failure. The contact stated that the key could not be removed from the ignition switch while the key was in the "OFF" position. In addition, the battery was being drained. The contact stated that the battery was previously replaced several months ago. The contact stated that the key was stuck in the ignition switch. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 64,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11703297December 5, 2025
FUEL/PROPULSION SYSTEM
Car has developed a fuel leak once again in the rear of the vehicle. this is the second time a fuel leak has been noted. the first time the mechanic replaced a portion of the line that had corroded and was leaking fuel near the driver rear tire. now the leak is in another section of the original pipe near the fuel tank. this is poor quality and engineering.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11700657November 20, 2025
STEERING
Power steering went out while I was driving and it put me in danger and other drivers because it was hard to control the vehicle, the steering wheel was really tough to turn. The vehicle wasn't inspected by a professional because the problem just occurred.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11688527September 19, 2025
STEERING
Power steering lights up and I am unable to turn the steering wheel. When I shut the motor down and start back up, the steering starts working again. This has been doing this for about 4 years now. I took it to White Allen Chevrolet when it first started happening and they told me that they drove it around and that it did not happen while they test drove the car. It happens intermittingly. I never know when it is going to happen. When it first started, it only happened about once every six months or so. Now it is happening every time I am in the car. Sometimes when I pull out onto a street and into traffic the power steering light comes on and I have to find a spot to get off the street so that I can turn the motor off and restart the engine. Today 09/18/2025, it cut off 3 times. I am checking to see if there is a recall on this model for the power steering. I have found out that it does not use power steering fluid but that it has a motor under the steering wheel that controls the power steering.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678710August 6, 2025
STEERING
My power steering keeps going out. It randomly makes it hard to turn which could cause a crash. It's common in other hhr models, mine has not been inspected personally yet. It has a chime and then the console says "power steering". There were no signs before it started. It goes away when you restart the car but will come back randomly. I was advised by an auto repair place to replace the battery, but it didn't help.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678399August 5, 2025
STEERING
Power steering motor went out. Went to the dealer to get special coverage 14119 ( I was aware of the issue ). Dealership refused to do work for free as stated in service bulletin. Called GM Corporate and they also said work would would not be done for free. 14119 specifically stated that power steering motor would be changed and I quote " at no cost to the customer " unquote. They want $175 just to look at my vehicle. When does the " at no cost to the customer " come in, apparently we seem to have forgotten that. I would like some legal clarification to this from the nhtsa.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11678011August 2, 2025
SUSPENSION, ENGINE, STRUCTURE:BODY
The door few open because the door latch broke off
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11673723July 15, 2025
AIR BAGS, ELECTRICAL SYSTEM
The contact owns a 2009 Chevrolet HHR. The contact stated that while starting the vehicle, there was an abnormal clicking sound coming from the vehicle. In addition, the contact stated that the passenger’s side air bag warning light illuminated and occasionally flashed on and off. The vehicle was taken to the dealer but was not diagnosed or repaired due to the cost. The contact had previously received notification of NHTSA Campaign Number: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) and the vehicle was repaired; however, the failure persisted. The manufacturer was not made aware of the failure. The failure mileage was approximately 199,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11668600June 23, 2025
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The contact owns a 2011 Chevrolet HHR. The contact stated that while approaching the locked vehicle, the contact noticed that the rear driver's side door had failed to latch securely and was open. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 42,495.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11663581May 29, 2025
STEERING, UNKNOWN OR OTHER
While replacing 3 motor mounts, engine oil pan,transmission oil pan, also CV axles, wheel bearings needed replaced. When i got my car back the power steering wasn't working. My mechanic said there was a recall for my year, make and model for the power steering assist. I haven't gotten this fixed yet due to lack of funds . I am filling this out to see if is recalled.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11659516May 7, 2025
FUEL/PROPULSION SYSTEM
The fuel line on the left back side of the car (back drivers side) was leaking fuel when it was in parking or sitting and idling. Noted fuel smell when car started up and was idling, car was taken to independent mechanic, fuel line was broke in 2 places. It was broke close by the wheel are and the other spot was back by the exhaust
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11652486April 3, 2025
VISIBILITY:GLASS, SIDE/REAR
The contact owns a 2008 Chevrolet HHR. The contact stated while warming up the vehicle, the rear window exploded without warning or impact. There was smoke coming from the front of the vehicle. There was an abnormal burning odor detected. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000. The VIN was not available.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11641227February 6, 2025
VEHICLE SPEED CONTROL
vehicle ecm keeps reporting an error code p2138 that refers to a correlation issue between sensors on the throttle/pedal system, causing the vehicle to enter into reduced power and eventually disables engine. Problem persists even after replacing pedal component. Apparently water enters the compartment where the part is located and corrodes wiring between the ecm and the pedal system. GM is apparently aware but so far has done nothing. Problem is especially hazardous because engine power is reduced during acceleration and happens without warning. Vehicle could be in high density traffic and then suddenly experiences lack of power or total disability, and driver must try to navigate to the side of the road--not always possible or safe to do.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11631633December 19, 2024
FUEL/PROPULSION SYSTEM
Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet HHR