Chevrolet Blazer Complaints (2021)

128 consumer complaints on file.

#11759058August 24, 2026
ENGINE
My 2021 Chevrolet Blazer RS equipped with the 3.6L LGX V6 experienced catastrophic engine failure at approximately 90,200 miles. The vehicle had no prior warning. The dealer diagnosed the timing chain / lift/ cam damage. I am requesting investigation into whether this represents a safety or durability defect affecting other vehicles
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758918August 23, 2026
FUEL/PROPULSION SYSTEM, ENGINE
Car will not crank, stalled while cranked, throws code P023F
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11758482August 21, 2026
ENGINE
While idling in my driveway, the engine started to shake and the check engine light came on. Got it diagnosed and was told by a private repair center that we had lost compression in cylinder 4 and that it was not worth the repair and we needed to replace the engine. Got it towed to the dealership, Bill Fox Chevrolet, for a 2nd opinion and they confirmed what the private shop had said. Because the vehicle was well maintained with regular preventative maintenance, it was deemed the failure was not the fault of the owner. GM extended a goodwill warranty to help cover the cost of the engine replacement (70% coverage. We were 1 month and 2,000 miles past our warranty). They never told us root cause, only that it would have cost more money to repair it than it would be to get a new engine. The Blazer had been running fine up to that point and was my wife's main mode of transportation. The Blazer only had 62,000 miles on it when the failure occured.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11753752July 30, 2026
AIR BAGS
The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at approximately 50 MPH, the vehicle struck a deer, causing severe damage to the vehicle's front end. The contact stated that smoke was coming from the center of the steering wheel; however, the vehicle's air bags had not deployed. The contact was transported to the local hospital and treated for chest injuries. The vehicle was towed to a local collision center. No further information was available. A Police report was filed at the scene. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet contacted. The failure mileage was 52,661.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#11751752July 21, 2026
POWER TRAIN
The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, and the transmission was slipping gears before the vehicle lost motive power. The contact stated that the vehicle failed to drive forward or move while in reverse. The check engine warning light was illuminated. The vehicle was towed to the residence. The contact, who was an independent mechanic, diagnosed the failure as a clutch solenoid failure. The contact stated that the transmission needed to be replaced. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The dealer was made aware of the failure but provided no assistance. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 100,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749371July 9, 2026
FUEL/PROPULSION SYSTEM
fuel pump control module failed at 26000. recall number N252516900. This is a recall that other 2021 blazers have ben part of. Over 300000 recalls so far. GM says my car isn't. Ridiculous. They dont want to acknowledge their fault. I need a formal statement that this module should be recalled for my car.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11749347July 9, 2026
FUEL/PROPULSION SYSTEM
XXX the car had gas, turned over, but would not start. I had it towed to a repair center who towed, did diagnostics and came up with the codes for a bad fuel pump control module. It was replaced and the car starts. There was no warning. Problem was confirmed by an independent service center. All documentation is available. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745926June 23, 2026
POWER TRAIN, ENGINE
The thermostat malfunctioned causing an error message regarding “steering assist is reduced”. When I parked and turned off, the engine fan continued to run. When car was restarted, the temp gauge inside was stuck at C. Took to dealership and they assessed. They repaired the thermostat under power train warranty, however there was a crack in the radiator (top) resulting in the need for a new radiator. This vehicle had 35,000 miles on it. Upon research online, it seems there are MANY people who have had this same issue and worse. It appears cars produced during COVID era are most affected. Chevy refused to warranty the issue. The dealership offered a small cost reduction (due to our loyalty). The thermostat and the radiator issues seem to be well known by Chevy, they just refuse to accept responsibility. Now we are out thousands of dollars on a basically “new” vehicle.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11745573June 22, 2026
LANE DEPARTURE: ASSIST, ELECTRICAL SYSTEM, ENGINE
The thermometer and thermometer sensor are glitching . The engine temp needle will not rise at all, the engine fan will run the whole time driving and then when it is turned off will run for 10 min . Right before this happens a notice shows the guided steering is being limited. I disconnected the battery and it reset , I drove and there were no issues , next time I started my car the engine temp needle stayed down and the van started again. This car has 36k miles on it. I just bought it 2 days before it started happening
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11742425June 6, 2026
ELECTRICAL SYSTEM
Lost coolant temp so replaced sensor with one from auto zone and worked for one then pegged to cold again fan runs 100% so went and bought another coolant temp sensor from Chevrolet installed that worked two pegged back to cold again fan 100% now going to pay $700.00 dollars to remove the two sensor wires for the harness all the two the Ecm heard with it being wrapped in the coil wires it gets electromagnetic static due to degradation of wires. Also Radiator started leaking after couple years but they want $3100.00 dollars for that.Was told extended warranty ran out three days before they discovered radiator leak.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11738765May 19, 2026
STEERING
The vehicle showed an error on the dash which stated "Action Required Steering Assist is Reduced Drive with Care" I tool the vehicle to the dealer I purchased it from McClusky Chevy at Kings Auto Mall in Mason Ohio. They informed me that the error code is C0460:58 and GM has a service bulletin 20-NA-215 which advises to replace the Steering Gear due to internal component interference. No one explained to me that this could cause catastrophic failure and lead to a crash before I left the dealership. They could not replace it as they said they do not have the part and it is on national backorder. Additionally they told me the repair would cost me $3,400. The vehicle has 42k miles on it and this repair is not under warranty as the warranty that would have covered it expired in March of 2026. I have taken the vehicle to a different GM dealer - Tom Gill GMC in Fairfield Ohio - they are waiting on the part and I have a case opened with GM regarding the costs. You would think that if there is a risk of a catastrophic failure which could cause harm to my self or someone else - the dealer would have an obligation to tell me so before i drive off. If not legally, certainly morally.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11737304May 12, 2026
SUSPENSION
Driving on straight road going speed limit. Heard a pop behind me like a tire pop. Car fish tailed uncontrollably and ended up crashing into a Ranch Fence on the right side of the road. 2 of my kids and myself had injuries. When we got off the vehicle witnesses and I saw A rear link broken which keeps the tires straight.
Crash:
Yes
Fire:
No
Injuries:
3
Deaths:
0
#11735127May 1, 2026
FUEL/PROPULSION SYSTEM, UNKNOWN OR OTHER
I am reaching out regarding an ongoing issue with my 2021 Chevrolet Blazer. The vehicle is experiencing a noticeable stutter or hesitation when shifting between second and third gear. In addition, there are instances where the vehicle accelerates unexpectedly or more aggressively than intended. This behavior is particularly concerning, as it presents a potential safety issue during normal driving conditions. These concerns have become increasingly noticeable, and I am concerned they may indicate a transmission or related mechanical problem that requires prompt inspection and resolution. Please advise if there are any known service bulletins, recalls, or warranty coverage related to these issues. For reference, the vehicle has been properly maintained and this behavior is not consistent with normal operation. Given that this is now the third major issue I’ve experienced with this vehicle, I am hoping this matter can be addressed without additional out-of-pocket expense. After additional research, I have learned that other owners have experienced the same issue. Others have stated the following: 1. Hesitation, stuttering, or jerking between gears Owners of 2020–2021 Blazers report hesitation and jerking during acceleration, sometimes described as gears “shifting in and out rapidly.” Forum users mention sluggish shifting or slipping feelings, especially at certain speeds. Others report hard or delayed shifts at low speeds (like 15–25 mph). 2. Shuddering / vibration (often tied to torque converter) There are repeated mentions of “shudder,” “surge,” or vibration during acceleration. Some cases were linked to: Contaminated transmission fluid Torque converter clutch (TCC) issues One owner said the problem felt like a bad torque converter and required service attention. 3. Unexpected acceleration / lunging Drivers across GM vehicles (including similar transmissions) report: “Jerking,” “bucking,” or “lunging” during acceleration Some describe needing to
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734510April 29, 2026
ENGINE, FUEL/PROPULSION SYSTEM, SERVICE BRAKES
Went to park car in a park to drop daughter off and it sputtered out and stalled out of nowhere with no warning. I had received a lamp warning very sporadically prior to this and on occasion that stated 'reduced steering assist drive with care' this resulted in heavy steering for that drive until car was shut off and then it would go away and be fine again, fixed the car through Knudtsen Chevy due to a recall about a month before on the issue with the engine being turned off and it thinking it was still hot and still running the fan (even though the car was not running). Knudtsen fixed that issue. Low battery voltage light did not come on however battery was older so had battery installed at park to ensure the issue was not due to the battery. The oil was fresh and showed no issues, changed 2 weeks before fresh oil no issues found during service. When tried to restart the car it would think it would try to start and then sputter out and not stay in idle. Les Schwab left and called a mobile mechanic to bring the computer. Computer was hooked up and it would try to start, however, it would not know it was already running and try to start again on it's own...the codes that came up were the PO101 code came up for Mass Air Flow issue...and then the codes would go in a wild sequence of fail.....mechanic checked for loose connections around air filter, took air filter out and it was clean no issues, checked pipe no visible issues. We walked away and walked around the park to give it some time to sit and then we tried it again and it tried and sputtered out and died again would not stay idling. Then all of a sudden we heard it try to start itself without us trying to start it and it clanked. We hauled it to Knudtsen for a diagnosis. They stated "the motor will not turn this way or that way and it is seized or locked up". This is a 2021 with only 89,000 miles it should have a longer life than this. Please investigate and is there anything we can do to fix it?
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11734437April 28, 2026
ENGINE
Both camshaft carriers failed due to a manufacturing defect. According to NHTSA bulletins 21-NA-240 and PIP5755, the oil leak from the cam carrier is caused by improper sealant application during manufacturing. Although the dealer addressed the issue, it was clearly not a problem that arose from normal use. The leak had the potential to worsen and lead to a fire hazard. Chevy of Montebello confirmed the issue and repaired the vehicle for over $7,500. There were no warning signs, as the leak was difficult to detect on the driveway. The low-oil warning light came on the day before we took the vehicle to the dealer.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11733441April 23, 2026
POWER TRAIN
The transmission (powertrain) developed a delay when shifting into reverse, followed by harsh engagement. The condition worsened over time and resulted in a complete loss of reverse. The vehicle will not move when shifted into reverse. This creates a safety risk when parking, backing out of spaces, or maneuvering in traffic, as the driver cannot safely control vehicle movement. The issue occurred at approximately 89,000 miles under normal driving conditions. No warning lights were present prior to failure. The problem was reported to a dealership and diagnosed as a transmission failure. The condition is reproducible and ongoing. I was also informed that multiple vehicles of the same model were experiencing similar transmission issues at the same time. The failure limits safe operation of the vehicle and increases risk in situations where reverse movement is required.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11732946April 22, 2026
PARKING BRAKE
The contact owns a 2021 Chevrolet Blazer. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle with several unknown warning lights illuminated. The contact stated that the electronic parking brake independently activated. Additionally, the failure had occurred while the vehicle was parked. The failure was persistent. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 31,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11731606April 16, 2026
ENGINE
The vehicle had an oil leak from both the left and right camshaft carriers. The dealer confirmed the issue and carried out the necessary repairs. Because the leak was not easily detectable, it could have led to engine failure while driving. There were no warning indicators; only small oil droplets were found on the ground.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11730609April 12, 2026
ELECTRICAL SYSTEM, ENGINE, POWER TRAIN
Once I turn the vehicle off, there is a loud sound coming from the engine area that sounds like a fan. Then the first incident of the fan ongoing after the vehicle was powered off, a battery light was on the internal driver dashboard and stayed on. The battery was recently replaced during 2026 so the battery should not be anywhere near dead, dying, or needing to be checked
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#11726942March 25, 2026
ELECTRICAL SYSTEM
The contact owns a 2021 Chevrolet Blazer. The contact stated that while attempting to start the vehicle, several unknown warning lights illuminated, and other lights inside the vehicle flashed on and off. The contact stated that the failure also occurred while driving at various speeds. A dealer was contacted. The vehicle was taken to several dealers for diagnostic tests; however, the diagnostic result was unknown. The manufacturer was notified of the failure and informed the contact that there would be a callback about the cause of the failure; however, there has been no callback yet. The approximate failure mileage was 50,000.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Blazer