Chevrolet Aveo Complaints

1,322 consumer complaints on file.

#10248522November 11, 2008
AIR BAGS
CONSUMER COMPLAINT: ODI CASE NUMBER: 10244499 COMPONENT: AIR BAGS:FRONTAL DETAILS: PASSENGER AIR BAG OFF -- INDICATOR IS LIT. WILL NOT ENGAGE PASSENGER SAFETY AIR BAG WHEN WIFE, WEIGHING 105 POUNDS IS IN SEAT. CHEVROLET DEALER CANNOT FIX. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10247309October 30, 2008
AIR BAGS
TL*THE CONTACT OWNS A 2004 CHEVROLET AVEO. WHILE DRIVING 25 MPH, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE HEAD ON. THE AIR BAGS FAILED TO DEPLOY. THE FIRE DEPARTMENT ARRIVED AND DEACTIVATED THE AIR BAG SWITCH, SO THAT THE AIR BAGS WOULD NOT DEPLOY WHILE REMOVING HER FROM THE VEHICLE. THE CONTACT SUSTAINED MAJOR INJURIES BY STRIKING THE STEERING WHEEL. THE VEHICLE WAS DESTROYED AND TOWED FROM THE SCENE. THE FAILURE AND CURRENT MILEAGES WERE 66,322.
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10246867October 27, 2008
UNKNOWN OR OTHER
ON MONDAY OCTOBER 20, 2008 I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT, THAT I BELIEVE WAS DIRECTLY RELATED TO FAULTY BRAKES. ON TWO PRIOR OCCASIONS, DIFFERENT LOCAL CHEVROLET DEALERSHIPS WERE CONTACTED. ON THE 2ND VISIT TO THE DEALERSHIP, THEY STATED THAT THE REAR BRAKES WERE NEVER "ADJUSTED" WHEN THIS VEHICLE WAS PURCHASED, AND MADE AN ADJUSTMENT. THEY STATED THAT THE FRONT BRAKES WERE "GLAZED" DUE TO THE PRESSURE ON THEM, AND NOT EQUAL PRESSURE ON ALL FOUR BRAKES. THEY STATED THEY CLEANED THE FRONT BRAKES THE BEST THEY COULD. THE BRAKES NEVER SEEMED TO BE COMPLETELY CORRECTED--MOST NOTICEABLE WHEN THE ENGINE WAS "COLD". THE PROBLEM WAS ERRATIC. PUMPING THE BRAKES PRIOR TO DRIVING BECAME A NECESSITY. THE ACCIDENT OCCURRED ON DRY ASPHALT, WHEN THE BRAKES DID NOT FUNCTION PROPERLY. THE 2008 CHEVROLET AVEO (APPX 5650 TOTAL MILES) COULD NOT MAKE A COMPLETE OR IMMEDIATE STOP WITH THESE BRAKES. A STOPPED PICKUP TRUCK WAS HIT IN THE REAR. NO INJURIES WERE REPORTED AT THE SCENE. BY NM LAW, A POLICE REPORT IS ONLY REQUIRED IF THERE IS A REPORTED INJURY. SINCE BOTH DRIVERS EXCHANGED INFORMATION, AND DECIDED TO LEAVE THE SCENE ON THEIR OWN, NO IMMEDIATE REPORTS WERE FILED UNTIL OCTOBER 24, 2008. ON OCTOBER 25, 2008 AN INDEPENDENT INSPECTION WAS COMPLETED BY JUST BRAKES, IN ALBUQUERQUE, NM. THE STATIC TEST FAILED THE FIRST TWO TIMES WHEN THE VEHICLE WAS COLD. A GOOD POSSIBILITY THAT THERE IS AN ERRATIC PROBLEM WITH THE VACUUM BOOSTER. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10246553October 23, 2008
ENGINE AND ENGINE COOLING
I DRIVE A 2005 CHEVY AVEO, YESTERDAY 10-22-08, WHILE I WAS DRIVING ON THE FREEWAY, MY ENGINE TEMP SHOT UP TO MAX. LUCKILY I WAS JUST COMING UP ON MY EXIT SO I GOT TO THE BOTTOM OF THE OFFRAMP AND PULLED OFF TO THE SIDE. SMOKE WAS POURING OUT THE HOOD OF MY CAR. IT TURNS OUT THE PLASTIC HOUSING THERMOSTAT HOUSING CRACKED IN HALF AND ALL THE COOLANT IN MY CAR POURED OUT. WHILE I WAS SITTING ON THE SIDE OF THE ROAD WAITING FOR THE TOW TRUCK MY ENGINE CONTINUED TO GET OVERHEATED. I REPLACED MY WATER PUMP HOUSING MYSELF CHEVY HAS AN UPDATED THERMOSTAT HOUSING MADE OF METAL NOW, BUT NOW I HAVE LARGE AMOUNTS OF AIR BLOWING THROUGH MY COOLANT RESERVOIR. MY HEAD GASKET IS BLOWN AND POSSIBLY THE HEAD IS WARPED. I WAS LOOKING ON LINE FOR INFO AND IT TURNS OUT THIS IS A VERY COMMON PROBLEM FOR MANY PEOPLE. NOW BECAUSE CHEVY DIDN'T RECALL A KNOWN PROBLEM THERE ARE HUNDREDS OF PEOPLE OUT THERE HAVING TO PAY $1,000+ TO HAVE MAJOR ENGINE WORK PERFORMED. NOT TO MENTION ALL THOSE PEOPLE STUCK ON THE SIDE OF THE ROAD WAITING FOR TOW TRUCKS. I DON'T KNOW IF THIS QUALIFIES AS SOMETHING YOUR ASSOCIATION DEALS WITH BUT I JUST THINK SOMEONE SHOULD BE NOTIFIED AND SOMETHING SHOULD BE DONE. THANK YOU FOR YOUR TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246551October 23, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THERMOSTAT HOUSING BROKE AT THE SEAL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246374October 22, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
WAS DRIVING ON THE EXPRESSWAY, WHEN THE THERMOSTAT HOUSING BROKE. THE CAR'S MILEAGE WAS 34, 500. CALLED DEALERSHIP SINCE THE WAS STILL UNDER WARRANTY AND THE DEALER TOLD ME THAT THE PART WAS NOT COVERED. I HAD TO PAY UPFRONT FOR THE PART AND HAD IT REPLACED. ALSO THE CAR NOW STARTS TO SHAKE AND THE HOLD LIGHT KEEPS FLASHING. THIS HAPPENS ABOUT TWICE A WEEK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246255October 21, 2008
LATCHES/LOCKS/LINKAGES
THE LOCK CYLINDER FELL INTO THE DRIVER SIDE DOOR. ALSO THE INSIDE LOCK PEG FELL IN TOO. NOW I CAN'T OPEN MY DOOR FROM THE INSIDE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10246276October 21, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
THERMOSTAT HOUSING BROKE IN HALF CAUSING OVERHEATING AND INTERNAL ENGINE DAMAGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10245857October 18, 2008
ENGINE AND ENGINE COOLING, AIR BAGS:FRONTAL, SERVICE BRAKES, ELECTRIC, POWER TRAIN:AUTOMATIC TRANSMISSION, TIRES
I BOUGHT MY AVEO NEW. AT ONLY 6,000 MILES THE MASTER CYLINDER FAILED AND 5,000 MILES LATER THE BRAKE BOOSTER FAILED AND I CRASHED--THE AIR BAGS DID NOT DEPLOY. GM WOULD FIXED THE BRAKE BOOSTER BUT NOT THE DAMAGE TO MY CAR! AT 13,000 MILES THE BRAKE DRUMS NEEDED TO BE RE-SURFACED, THE BRAKE ROTORS NEEDED TO BE CUT, AND I HAD TO GET NEW BRAKE PADS--AGAIN GM WOULD NOT FIX IT AND MADE ME PAY FOR IT. AT 16,000 MILES THE AIR BAG SENSOR FOR THE PASSENGER FAILED. AT 18,000 MILES THE GAS GAUGE FAILED AND THE SHIFTER GOT STUCK IN PARK, AND THE CRUISE CONTROL WOULD WORK ON AND OFF. AT 20,000 MILES THE ALL FOUR TIRES NEEDED TO BE REPLACED. AROUND THIS TIME, GAS MILEAGE DIPPED TO ABOUT 19-21MPG, BUT GM COULDN'T FIGURE OUT WHY. AT 30,000 MILES I HAD TO GET NEW ROTORS AND BRAKE PADS--AGAIN I HAD TO PAY FOR IT EVEN THOUGH THEY ARE WEARING OUT PREMATURELY. AT 35,000 MILES THE TRANSMISSION STARTED TO SHIFT HARD SO GM RECOMMENDED I CHANGE THE TRANSMISSION FLUID AT A COST $450 BECAUSE THE FLUID HAS A SPECIAL ADDITIVE THAT IS SHIPPED FROM KOREA! AT 44,000 MILES THE ENGINE DIED--MORE LIKE BLEW UP. GM SAID THAT IT IS MY FAULT FOR LETTING IT RUN TOO HOT, THOUGH I HAD NO WARNING FROM ANY GAUGES, LIGHTS, ECT... AGAIN I HAD TO FIX IT EVEN THOUGH I HAD THE 100,000 MILE WARRANTY. AT 48,000 MILES THE A/C NEEDED TO BE OVERHAULED--I HAD TO PAY FOR IT. AT 52,000 MILES I HIT A DEER AND AGAIN THE AIR BAGS DID NOT DEPLOY. THE INSURANCE COMPANY JUNKED IT. ABSOLUTELY WITHOUT A DOUBT IN MY MIND THE WORST CAR I HAVE EVER OWNED. GM SHOULD BE SUED FOR THIS CAR. THEY DO NOT HONOR THE WARRANTY AT ALL. THE SERVICE DEPARTMENTS TREATED ME WITH DISRESPECT. A COUPLE OF DEALERS REFUSED TO EVEN ACCEPT MY CAR FOR REPAIR. THE CAR IS VERY SCARY TO DRIVE AND NOT SAFE AT ALL. WITH ALL THE MONEY I SPENT FIXING THE CAR PLUS MY CAR PAYMENT EACH MONTH, I COULD HAVE EASILY PURCHASED A BMW INSTEAD. GM IS ABSOLUTELY THE WORST FOLKS TO DEAL WITH. NEVER AGAIN WILL I BUY OR SUPPORT ANYTHING FROM GM. *TR
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10245757October 17, 2008
ENGINE AND ENGINE COOLING
DRIVING ON THE FREEWAY UPHILL. NO WARNING LIGHTS, NO CHANGE IN TEMPERATURE. THERMOSTAT HOUSING BROKE IN HALF AT THE SEAM. THERMOSTAT IS ORIGINALLY FROM FACTORY, PERMANENTLY ENCASED IN A PLASTIC TYPE HOUSING. THIS IS ALL ONE (1) PIECE. CHEVY HAS SUPERSEDED THIS ITEM WITH A METAL TYPE HOUSING WITHIN THEIR RANKS/COMPUTERS, BECAUSE IT WAS A KNOWN ISSUE. THIS ITEM (PLASTIC THERMOSTAT HOUSING) KNOWINGLY SPLITS AS EARLY AS 30,000 MILES. FOR US IT WAS ABOUT 45,000 MILES. THIS WAS NEVER A RECALL ITEM NOR WAS ANY INFO EVER SENT OUT WARNING ABOUT IT. FAILURE OF THIS PART LEADS TO THE KNOWN LEAKING AND EXPELLING OF HAZARDOUS ANTI-FREEZE/COOLANT ON ROADS BUT ALSO LEADS TO THE UNREALIZED OVERHEATING OF ENGINE. THIS CAN LEAD TO UNNECESSARY ENGINE DAMAGE FROM SIMPLE OVERHEATING OF OIL TO THE EXTREME OF BLOWN HEAD GASKETS, BLOWN/BROKEN CYLINDER RINGS, WARPED ENGINE HEADS OR COMPLETE ENGINE SEIZURE. THIS FAILING PART WAS KNOWN EARLY ENOUGH THAT THE NEW PRODUCT HAD ALREADY BEEN MADE AND DISTRIBUTED TO DEALERSHIPS. WEB LOGS ARE FULL OF THIS PARTICULAR FAILURE, ON THIS VEHICLE. 3 DAYS AFTER REPAIR, THE CAR HAS A "SLOW START", AS LONG AS 15 MIN. THE DEALER KEPT IT 2 DAYS, REPLACED PLUGS & WIRES, CHARGED $400. 3 DAYS AFTER THIS (10/13/08), SAME EXACT PROBLEM, IN ADDITION HOLD LIGHT WILL STAY ON & CAR SHAKES AS IF NOT GETTING FUEL. I MUST TURN OFF THE ENGINE AND ATTEMPT TO RESTART. THE DEALER HAS INFORMED ME UNLESS THE ACTUAL PROBLEM IS OCCURRING THEY CANNOT DIAGNOSE. TODAY (10/16/08) AFTER A SLOW START, THE A/C WORKED FOR ABOUT 10 MIN THEN STARTED BLOWING HOT AIR. TURNED IT OFF FOR A COUPLE OF MINUTES AND IT PROCEEDED WITH COOL AIR. THIS HAPPENED TWICE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10245232October 13, 2008
ELECTRICAL SYSTEM, ENGINE AND ENGINE COOLING, WHEELS
WE HAVE A 2004 AVEO AND NO LIGHT CAME ON AND AT 61,000 MILES MY CAR JUST QUIT RUNNING IN THE MIDDLE OF THE ROAD AND HAD TO BE TOWED TO THE DEALERSHIP THE TIMING BELT HAD BROKEN AND THE MOTOR WAS MESSED UP ALSO. I HAD TO PAY OVER $3,000 TO HAVE IT REPAIRED CAUSE A BELT BROKE. IT MESSED UP HALF OF THE MOTOR AND HAD TO BE REPLACED. THEN A MONTH LATER THE LIGHTS ON THE DASH QUIT WORKING AND THEY TOLD ME THAT THEY HAVE REPLACED THEM ALOT FOR THESE CARS AND THE WIRE HARNESS IS $1,200 DOLLARS AND I AM PAYING MORE FOR THE REPAIRS THEN I HAVE FOR THE CAR. THE CLOCK LIGHT HAS NEVER WORKED RIGHT SINCE WE GOT THE CAR. SO BE CAREFUL AND REPLACE YOUR TIMING BELT EARLY AND DON'T HAVE TO PAY ALL THAT MONEY LIKE WE HAD TO. I WISH I HAVE NEVER BOUGHT THE CAR NOW. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10245017October 9, 2008
POWER TRAIN:MANUAL TRANSMISSION
I HAVE A 2005 CHEVY AVEO THAT HAS REPEAT PROBLEMS WITH THE CLUTCH GETTING HOT AND SEIZING THE TRANSMISSION, I HAD THIS FIXED ONE IN JUNE OF THIS YEAR AND TODAY THE CLUTCH IS DOING THE SAME THING AGAIN, THIS TIME I ALMOST GOT IN 2 ACCIDENTS, COULDN'T SHIFT RIGHT AND WAS UNSAFE TO DRIVE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10244499October 6, 2008
AIR BAGS:FRONTAL
PASSENGER AIR BAG OFF -- INDICATOR IS LIT. WILL NOT ENGAGE PASSENGER SAFETY AIR BAG WHEN WIFE, WEIGHING 105 POUNDS IS IN SEAT. CHEVROLET DEALER CANNOT FIX. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10243261September 23, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
WE PURCHASED A PREOWNED CHEVROLET AVEO WITHIN APROX A YEAR (LOW MILEAGE STILL UNDER WARRANTY, ALSO PURCHASED EXTENDED WARRANTY & GAP INSURANCE), TAKEN VERY GOOD CARE OF IT, INCLUDING ROUTINE SERVICES AS NEEDED. SUDDENLY 3 WEEKS AGO WITHOUT ANY WARNING AT ALL THE ENGINE BLEW.. NO STEAM, NO GAGE WARNING, NO WARNING LIGHTS, NOTHING. SUDDENLY THE ENGINE LIGHT CAME ON & WITHIN LESS THAN 30 SECONDS ENGINE BLEW WHILE DRIVING WITH NO WARNING. WE HAD IT TOWED TO A MECHANIC WHO DETERMINED THAT THE THERMOSTAT HAD WENT BAD CAUSING THE ENGINE TO BLOW. WE DECIDED TO HAVE IT TOWED TO THE DEALERSHIP IN ORDER TO PROCESS OUR WARRANTY AND POSSIBLY TRADE IT IN.. THE SERVICE DEPT AT THE DEALERSHIP STATES THAT WITHOUT TAKING APART THE MOTOR ALL THEY CAN TRULY SAY IS THE CAR GOT HOT AND THE ENGINE BLEW. ONCE AGAIN, I STRESS- NO STEAM, NO RAISED TEMP IN GAUGES OR CHECK LIGHTS CAME ON. WE HAD NO WARNING OR NOTICE OF ANY PROBLEMS WITH THE CAR. AFTER 3 WEEKS THE CAR IS STILL SITTING UNUSABLE AT THE DEALERSHIP SERVICE DEPT UNTIL WE DECIDE WHAT WE ARE GOING TO DO, AS WE WAIT ON HAVING MORE DIAGNOSTIC WORK DONE TO FILE WITH THE WARRANTY. WE DECIDED TO DO SOME RESEARCH ON THE CAR AND FOUND HUNDREDS OF COMPLAINTS IDENTICAL WORD FOR WORD ON WHAT HAPPENED TO US- ALL STEMMING FROM THERMOSTAT AND ENGINES RANDOMLY BLOWING UP WITHOUT WARRANTY. WE HAVE PRINTED ALL OF THESE OUT TO PRESENT TO CHEVROLET & OUR DEALERSHIP WHERE OUR CAR CURRENTLY SITS UNUSABLE. WE HAVE ALREADY CONTACTED CHEVROLET, & OUR WARRANTY COMPANY IN HOPES TO FIND A RESOLUTION AND WE WISH/HOPE A RECALL WILL BE ISSUED FOR THE MANY CASES LIKE OURS. I AM WILLING TO PROVIDE ANY PROOF IF NEEDED. THIS CAR HAS MANY COMPLAINTS AND COMMONLY THIS COMPLAINT REGARDING SUDDEN ENGINE BLOWING UP.. THE PART THAT HAS US UPSET IS THAT THE MANUFACTURER AND DEALERSHIPS SEEMINGLY AREN'T TAKING RESPONSIBILITY FOR THIS AND MANY PEOPLE ARE LOSING MONEY AND POSSIBLY SAFETY IN THEIR CARS BECAUSE OF THIS ISSUE. PLEASE HELP US. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242432September 16, 2008
VISIBILITY
CRACK DEVELOPED IN THE UPPER LEFT OF WINDSHIELD WAS NOT CAUSED BY A STONE OR ANYTHING ELSE. DEALERSHIP IS SAYING IT WAS CAUSED BY THE WINDSHIELD WIPER. IT STARTED BEYOND THE WIPER RANGE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242093September 14, 2008
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
TIMING BELT BROKE PREMATURELY AT 54541 MILES. GM OWNERS MANUAL SAYS TO CHANGE IT AT 60000 MILES. CAR WAS WORKED ON BY GM UNDER THERE SPECIAL BULLETIN FOR THIS PROBLEM. HOWEVER THE CAR HAD TO BE RETURNED TO THE DEALER, THIS TIME IT 56870 MILES ON IT WHEN THE SES LIGHT CAME ON I TOOK THE CAR TO AAMACO ON SATURDAY BECAUSE THE DEALERSHIP WAS CLOSED SOME OF THE CODES WERE MY TRANSMISSION I WAS TOLD IT WASN'T GOING IN 4TH GEAR AND BURNED MY TRANSMISSION FLUID. SO I HAD MY TRANSMISSION SERVICED AT MY EXPENSE BY THE DEALERSHIP. THE DEALERSHIP TOLD ME THAT GM HAD THE PART #'S LISTED WRONG AND THEY HAD INSTALLED THE WRONG PARTS WHEN THEY HAD WORKED ON THE CAR THE FIRST TIME. SO NOW THEY PUT IN NEW PARTS AND THE CAR STILL DOESN'T RUN RIGHT. THEY TELL ME I NEED NEW PLUGS AND WIRES AND THAT THE COST WOULD BE 300.00. I TOLD THEM NO WAY I WAS GIVEN THEM 300.00 FOR 4 PLUGS AND 4 WIRES. SO THEY ENDED UP CHANGING THE PLUGS FOR 32.00 AND I CHANGED THE WIRES MYSELF. AT 56987 MILES CAR GOES BACK TO DEALER THIRD TIME, SES LIGHT ON, CAUSE : INTAKE MANIFOLD TUNING SOLENOID DISCONNECTED AND TIMING BELT TO TIGHT. AT 57012 MILES A C/S SES LIGHT ON, CAUSE; LOW EFFICIENCY THE DEALER REPLACED THE CATALYTIC CONVERTER DUE TO THE TIMING BELT. CAR HAS NEVER RUN RIGHT AFTER THESE ATTEMPTS OF REPAIRS AND NOW SEPT. 2008 SES LIGHT COMES ON AGAIN THE HAS 66200 MILES ON IT. TOOK IT TO THE DEALER AND THEY TOLD ME I NEEDED NEW WIRES AND PLUGS AGAIN AND THAT THEY COULD NOT DO ANYTHING IF I DID NOT LET THEM CHANGE THEM. THIS IS JUST ANOTHER CASE OF GM NOT STANDING BEHIND THERE PRODUCTS THAT FAIL. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10242105September 14, 2008
SUSPENSION
MY AVEO IS 2005 AND MY REAR DRIVER SIDE SHOCK HAD THE TOP BOLT HOLDING THE SHOCK TO THE CAR SNAP. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10241118September 5, 2008
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
PURCHASED ON 6/14/08 WITH 272 MILES, ABOUT 2 WKS LATER, TIRE PRESSURE LIGHT COMES ON AND STAYS ON, CHECK TIRES THEY ARE OK, CALL DEALER, WAS TOLD TO BRING IT IN, TOOK ON 7/17/08 TO DEALER, SERVICE DEPT CHECK AND FOUNT THE SENSOR OPEN, REPAIR SHEET SAYS THEY REPLACED SENSOR 5.890 AND ORDERED MODULE. WAITED FOR THEM TO CALL ME, I CALLED ON 8/13/08 THEY HAD THE PART IN FOR WKS BUT HAD NOT CALLED, TOOK BACK IN ON 8/20/08 AND REPAIR SHEET STATES THE THEY FOUND THE TIRE SENSOR MODULE OPEN AGAIN AND REPLACED THE TIRE SENSOR MODULE 5.890. ALL WORK WAS DONE UNDER WARRANTY, BUT THIS HAS NOT FIXED THE PROBLEM. NOW THE SENSOR LIGHT DOESN'T STAY ON ALL THE TIMES, BUT IF YOU HAVE TO SIT IN TRAFFIC AND IDLE THAN THE LIGHT COMES ON AND STAYS ON UNTIL YOU TURN THE CAR OFF AND RESTART IT. ALSO, THE SALESMAN SAID IT WOULD GET 38 MPG AND I'M LUCKY TO GET 27-29 MPG. AFTER THE NEXT VISIT TO THE DEALER FOR THIS SENSOR AND I WILL CONTACT THE STATE OF NC ABOUT THIS CAR BEING A LEMON. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10240594September 2, 2008
ENGINE AND ENGINE COOLING, EQUIPMENT:MECHANICAL
2005 CHEVY AVEO. THERMOSTAT IS ORIGINALLY, FROM FACTORY, PERMANENTLY ENCASED IN A PLASTIC TYPE HOUSING. THIS IS ALL ONE (1) PIECE. CHEVY HAS SUPERSEDED THIS ITEM WITH A METAL TYPE HOUSING WITHIN THEIR RANKS/COMPUTERS, BECAUSE IT WAS A KNOWN ISSUE. THIS ITEM (PLASTIC THERMOSTAT HOUSING) KNOWINGLY SPLITS AS EARLY AS 30,000 MILES. FOR US IT WAS ABOUT 46,000 MILES. THIS WAS NEVER A RECALL ITEM NOR WAS ANY INFORMATION EVER SENT OUT WARNING ABOUT IT. FAILURE OF THIS PART LEADS TO THE KNOWN LEAKING AND EXPELLING OF HAZARDOUS ANTI-FREEZE/COOLANT ON ROADS BUT ALSO LEADS TO THE UNREALIZED OVERHEATING OF ENGINE. THIS CAN LEAD TO UNNECESSARY ENGINE DAMAGE FROM SIMPLE OVERHEATING OF OIL TO THE EXTREME OF BLOWN HEAD GASKETS, BLOWN/BROKEN CYLINDER RINGS, WARPED ENGINE HEADS OR COMPLETE ENGINE SEIZURE. CHEVY RETAILS THE NEW METAL PART FROM $82.00 - $95.00. THIS FAILING PART WAS KNOWN EARLY ENOUGH THAT THE NEW PRODUCT HAD ALREADY BEEN MADE AND DISTRIBUTED TO DEALERSHIPS. WEB LOGS ARE FULL OF THIS PARTICULAR FAILURE, ON THIS VEHICLE. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10240657September 2, 2008
SUSPENSION:FRONT
EVERY FEW THOUSAND MILES I HAVE TO GET MY CAR REALIGNED. THIS PROBLEM IS COSTING ME IN FEES AND NEW TIRES. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Aveo