Chevrolet Aveo Complaints

1,322 consumer complaints on file.

#10263623March 30, 2009
ENGINE AND ENGINE COOLING:COOLING SYSTEM
NORMAL DRIVING OF VEHICLE PLASTIC THERMOSTAT HOUSING UNIT BROKE IN HALF AND EXPLODED COOLANT OVER THE ENGINE AND WINDSHIELD OF VEHICLE. CALLED THE DEALER AND WAS INFORMED THAT THEY KNOW THAT THE PART IS FAULTY AND WEARS OUT IN UNDER 40,000 MILES AND HAVE REDESIGNED THE PART USING POT METAL WHICH WILL NOW COST 89.99 TO REPLACE. THIS IS THE SECOND TIME WE HAVE HAD TO REPLACE THIS SAME PART ON THIS CAR IN THE THREE YEARS WE HAVE OWNED IT. SO THEY KNOW THE PART IS FAULTY AND THEN CHARGE FIVE TIME WHAT THE ORIGINAL PARTS REPLACEMENT COST WAS BECAUSE THEY KNOW YOU HAVE TO REPLACE IT THROUGH THEM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10262822March 23, 2009
ENGINE AND ENGINE COOLING:ENGINE
I OWN A 2005 CHEVY AVEO. HAVE OWNED SINCE 7-15-05. NO PROBLEMS EXCEPT FOR HEAD GASKET REPLACED WHILE STILL UNDER WARRANTY. ON 3/23/09, I WAS ON THE WAY TO WORK & WENT TO PASS A CAR. AS I PULLED BACK IN TO THE LANE & TOOK MY FOOT OFF THE GAS THE CARS SPEED STILL INCREASED. APPLIED BRAKES AND COULD STILL FEEL THE ENGINE PULLING AS IF I WERE STILL PRESSING THE GAS PEDAL. SLID IN TO NEUTRAL AND THE RPMS RACED TO 7. I FLIPPED BACK IN TO DRIVE & THE CAR KEPT SPEEDING UP. PUT BACK IN TO NEUTRAL & HIT THE GAS A COUPLE OF TIMES TO TRY & KICK IT DOWN & IT FINALLY WENT AFTER THE 3RD TIME FLIPPING IT BACK & FORTH BETWEEN NEUTRAL & DRIVE. SIDE NOTE: CAR WAS SITTING OUT ALL NIGHT IN WITH TEMP DROPPING TO TEENS WITH WINDCHILL. THIS IS THE SECOND INCIDENT. HOWEVER, THE FIRST TIME IT WAS NOT THIS EXTREME. I WAS AT APPROX 80-85 MPH BEFORE IT KICKED BACK DOWN THIS TIME. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10262862March 23, 2009
STRUCTURE, ENGINE AND ENGINE COOLING:COOLING SYSTEM, FUEL SYSTEM, GASOLINE, ELECTRICAL SYSTEM, POWER TRAIN, SUSPENSION
I TRADED IN A 2004 P.T.CRUISER TO GET A 2005 CHEVY AVEO AT THE TIME IT HAD 21000 MILES WHEN I GOT IT. MY WARRANTY WAS GOOD TILL 36000. I HAD LOTS OF ISSUES WITH A NOISE THAT STILL TO THIS DAY HAS NOT BEEN CORRECTED EVEN AFTER THREE ATTEMPTS UNDER MY CAR BY THE CHEVY SERVICE DEPT. I THEN HAD A COMPUTER RECALL OR SOMETHING THAT HAD TO BE REPLACED I ALSO HAD A GAS CAP THAT MALFUNCTIONED AND A CLOCK THAT HAD TO BE REPLACED. THOSE ARE THE NON LIFE THREATENING ISSUES. I HAD AN INCIDENT INSIDE OF THE ORIGINAL WARRANTY WHERE THE CAR THREW PARTS OUT OF THE ENGINE. IT WAS THE SERPENTINE BELT AND THE BRACKET THAT WAS METAL THAT IT WAS MOUNTED ON BROKE OUT OF THE ENGINE AS I WAS DRIVING IT. I AM CURRENTLY AT 55000 AND I HAVE THE POWER TRAIN ON IT. IN THE LAST MONTH I HAVE HAD THE CAR IN MY POSSESSION 1 WEEK THE REST IT'S BEEN IN THE SERVICE DEPT. A MONTH AGO THE PLASTIC AND YES THAT'S PLASTIC HOUSING FOR THE THERMOSTAT BLEW APART ON THE INTERSTATE CAUSING US TO HAVE TO DIAL 911 TO GET HELP BECAUSE WE WERE TRAPPED. TWO WEEKS AGO IT SPIT OUT THE TIMING BELT AND THE VALVES GOT BENT AND THE VALVE COVER WAS DAMAGED. WE DON'T KNOW WHAT PARTICLES ENDED UP IN THE ENGINE FOR NOW. I HAVE CONTACTED CHEVROLET ON ALL THESE ISSUES AND I ASKED THEM BEFORE MY WARRANTY WENT OUT AND RIGHT AFTER THE FIRST INCIDENT TO GIVE ME BACK THE MONEY FOR THE CAR. THEY CALLED ME TODAY AND SAID I DIDN'T HAVE A CASE BECAUSE THE WARRANTY WAS OUT I REMINDED THEM I HAD BEEN ASKING SINCE BEFORE AT THE FIRST INCIDENT WITH THE SERPENTINE AND BRACKET AND THEY SAID SORRY THE WARRANTY IS OUT. I REMINDED THEM I HAVE PICTURES OF THOSE PARTS AND CAN PROVE IT BUT THAT STILL WASN'T GOOD ENOUGH! I SPOKE TO HANNAH A DISTRICT SPECIALIST TODAY AND THAT IS WHO LIED TO HERSELF AND SAID THESE OCCURRENCES WERE AFTER THE WARRANTY. I HAVE PROOF CAN YOU PLEASE HELP BEFORE MY FAMILY DIES AND THEN WE HAVE DEPENDENTS WHO WILL OWN THE VERY COMPANY THE GOV'T IS TRYING TO BAIL OUT. I NEED YOU TO INTERVENE BEFORE I GO TO COURT OVER THIS. *TR
Crash:
No
Fire:
No
Injuries:
1
Deaths:
0
#10262618March 21, 2009
ENGINE AND ENGINE COOLING:COOLING SYSTEM
I WAS DRIVING DOWN THE ROAD AND SMELT BURNING FLUID AND THOUGHT IT WAS ANOTHER CAR ON THE ROAD. AFTER THE CAR WASN'T CLOSE TO ME ANYMORE I SMELT THE SAME ODOR. I LOOKED DOWN AT MY THERMOSTAT TO SEE MY CAR WAS IN THE RED, NO CHECK ENGINE LIGHT HAD COME ON OR ANYTHING. I PULLED OVER AND NOTICED IMMEDIATELY THAT MY THERMOSTAT HOUSING(WHICH IS PLASTIC AND A POOR DESIGN) HAD CRACKED IN HALF RIGHT ALONG THE SEAM.I HAVE READ THAT THIS PROBLEM HAS LEAD TO VERY EXPENSIVE REPAIRS DUE TO THE FACT THAT IT WARPS THE HEADS RIGHT AWAY AND IT CAN BE EASILY PREVENTED BY A BETTER QUALITY PART AND / OR DESIGN.THIS COULD HAVE BEEN A VERY DANGEROUS PROBLEM IF I HAD BEEN GOING DOWN A HILL, FAR FROM A PARKING SPOT, ON THE FREEWAY ETC. DO SOMETHING ABOUT IT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10260922March 6, 2009
ENGINE AND ENGINE COOLING
AFTER PULLING INTO A PARKING SPACE, MY 06 CHEVY AVEO'S ENGINE SHUT OFF AND I STARTED ROLLING BACKWARDS OUT OF MY PARKING SPACE. I HAD TO PRESS HARD ON MY BRAKES TO STOP ME FROM ROLLING. I HAD TO REMOVE MY KEY AND START MY ENGINE AGAIN. I WAS STILL IN DRIVE WHEN MY ENGINE DIED AND EVERYTHING IN MY CAR WAS STILL ON IE RADIO AND LIGHTS. THERE IS NO REASON THAT MY AUTOMATIC CAR SHOULD BE ROLLING BACKWARDS WHILE STILL IN DRIVE. TOOK IT TO THE DEALERSHIP AND THEY SAID MY COMP WAS RUNNING A THROTTLE BODY REPAIR. SINCE THAT WOULD BE THE THIRD THROTTLE BODY IN NINE MONTH, THE DEALER DECIDED TO CONTACT GM AND LOOK INTO IT. THROTTLE BODY CHECKED OUT FINE, AND GM TOLD DEALERSHIP TO RUN MORE DIAGNOSTICS AND PUT MILES ON MY CAR. AFTER A WHOLE WEEK, THE BEST THE DEALERSHIP COULD TELL ME WAS THAT THEY HAD NO IDEA WHAT WAS WRONG WITH MY CAR AND GM DIDN'T KNOW EITHER. THEY SAID IF IT WAS REPLICATED AGAIN, TO HAVE IT TOWED AND NOT TO TURN THE CAR BACK ON. AN 06 WITH ONLY 50,000 MILES ON IT SHOULD NOT HAVE THESE KINDS OF PROBLEMS. IN ONLY NINE MONTHS OF OWNING MY CAR I HAVE HAD TWO THROTTLE BODIES, A NEW HEAD, A NEW TIMING BELT, AND A NEW BRAKE LIGHT SWITCH. I WILL NEVER BUY THIS CAR AGAIN. NOW I HAVE TO WAIT UNTIL THIS CAR DIES AGAIN AND CAUSES ME TO GET INTO AN ACCIDENT BEFORE I CAN DO ANYTHING ABOUT IT. I AM EXTREMELY DISPLEASED WITH GM. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257687February 6, 2009
SUSPENSION:FRONT
SOMETIMES WHEN IT IS WINDY SPECIALLY ON THE BRIDGES OR HIGHWAY,OR WHEN A SEMI COMES FROM OPPOSITE DIRECTION, THE CAR WILL SORT OF JERK & GET A LOUD SQUEALING NOISE AND THE FORCE WILL MAKE THE CAR TO BE VERY UNSTABLE WHILE DRIVING LIKE IF THE CAR WOULD BE PULLED BY A GREAT FORCE, I TOLD THE DEALER ON NUMEROUS OCCASIONS ABOUT THE PROBLEM AND EVEN SHOWED THEM A VIDEO RECORDING I DID WHILE DRIVING THE VEHICLE AND THEY NEVER DID ANYTHING ABOUT IT. THIS VEHICLE HAS BECOME A GREAT RISK FOR ME AND MY FAMILY AND IM SCARED OF EVEN GOING ON TRIPS WITH THIS CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10257657February 5, 2009
AIR BAGS:FRONTAL
WE PURCHASED A NEW 2007 CHEVROLET AVEO FROM DEVOE CHEVROLET IN ALEXANDRIA, INDIANA, ON 4-12-2007. FROM THE BEGINNING, THE PASSENGER SIDE FRONT AIR BAG HAS ONLY WORKED INTERMITTENTLY. WE HAVE TAKEN THE CAR BACK TO DEVOE SEVERAL TIMES, BUT THEY COULD NEVER DUPLICATE THE PROBLEM, OR FIND ANYTHING WRONG. YET, THE PROBLEM STILL PERSISTED. THEY DID REPLACE THE SEAT, CHECKED THE SEAT WITH WEIGHTS, ETC., BUT IT DID NOT FIX THE PROBLEM. FINALLY, WHEN THE AIR BAG WAS NOT WORKING WITH ME (TERESA SHUMAN) SITTING IN THE PASSENGER SEAT, WE TOOK IT TO DEVOE, AND RUSTY (THE SERVICE DEPARTMENT MANAGER) SAW THAT THE AIR BAG WAS NOT WORKING WITH ME SITTING IN THE PASSENGER SEAT. THEY AGAIN TRIED TO CHECK THINGS OUT FOR ABOUT AN HOUR OR SO WHILE WE WERE THERE, BUT FOUND NOTHING WRONG. THEY DID FINALLY FIND AN OLDER BULLETIN FROM GM THAT SAID THE AIR BAG IN THE AVEO SOMETIMES DID NOT WORK FOR THE PASSENGER IF SOMEONE LEANED BACK A LOT (I WASN'T), OR IF THEIR BOTTOM DIDN'T FIT THE SEAT CORRECTLY. DEVOE HAS NO IDEA WHAT TO DO AT THIS POINT. WE CALLED STEPHANIE (GM REP AT 1-866-790-5700, EXT 21936, CASE #71-692588437). STEPHANIE TOLD MY HUSBAND CRAIG THAT THERE WAS NOTHING THAT GM CAN DO TO FIX THE PROBLEM. THE CAR IS STILL UNDER WARRANTY. WE DO NOT FIND THIS ACCEPTABLE AT ALL!!!! AND, THE AIR BAG HAS NOT JUST MALFUNCTIONED WITH ME, BUT ALSO MALFUNCTIONED WITH SOME OF OUR FAMILY AND FRIENDS. WE WERE NOT TOLD, WHEN WE PURCHASED THE CAR, THAT THE AIR BAG WOULD MAYBE NOT WORK, OR WOULD ONLY WORK INTERMITTENTLY, IF A PERSON'S BOTTOM DID NOT FIT THE SEAT CORRECTLY. THE AIR BAG HAS MALFUNCTIONED FOR OVERWEIGHT, UNDER WEIGHT, AND NORMAL WEIGHT PEOPLE. THIS IS A MAJOR SAFETY ISSUE, ESPECIALLY IN A CAR AS SMALL AS THE AVEO!!! WE CANNOT BELIEVE THAT GM MORE OR LESS TOLD US TO LIVE WITH THIS PROBLEM. PLEASE HELP US . AND, IT'S IMPORTANT THAT PEOPLE WHO HAVE PURCHASED AN AVEO, OR ARE THINKING ABOUT PURCHASING AN AVEO, KNOW THAT THE PASSENGER FRONT AIR BAG MAY NOT WORK. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10255717January 20, 2009
AIR BAGS, SEAT BELTS
MY GRANDDAUGHTER WAS INVOLVED IN AN MVC IN FLORIDA. SHE WAS EXITING ON AN INTERSTATE RAMP AND FAILED TO LEAVE ROOM FOR ANOTHER STOPPED VEHICLE RESULTING IN A FRONT END/REAR END CRASH. THE AIR BAGS FAILED TO DEPLOY AND HER SEAT BELT DID NOT FULLY RESTRAIN HER, RESULTING A FRACTURED STERNUM (3 PLACES). SHE AS BEEN RECOVERING EVER SINCE AND NEITHER THE AUTO REPAIR SHOP NOR THE CHEVROLET DEALER HAS BEEN ABLE OR WILLING TO FIND OUT WHY THESE SYSTEMS FAILED. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10254936January 14, 2009
POWER TRAIN:AUTOMATIC TRANSMISSION
CHEVROLET AVEO 2004 THE AC AND THROTTLE VALVE LOCKED IN BELOW 0 WEATHER . *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10254672January 11, 2009
SUSPENSION, ENGINE AND ENGINE COOLING:COOLING SYSTEM, POWER TRAIN
PURCHASED NEW 2008 AVEO IN APRIL 2007 WHICH HAS EXCESSIVE VIBRATION. I TOOK INTO DEALERSHIP AND WAS ADVISED IT WAS DUE TO THE AC CAUSING EXTRA WORK FOR THE MOTOR. SINCE IT WAS SUMMER TIME I WENT ON MY WAY AND DEALT WITH THIS VIBRATION (WHICH ONLY HAPPENS WHILE IN DRIVE) IT IS NOW JANUARY AND NO AC IS BEING USED. I TOOK THE CAR BACK IN TO THE DEALERSHIP AND WAS TOLD YES THERE IS EXCESSIVE VIBRATION AND WE WILL LOOK INTO IT 4 HOURS LATER THEY CALLED TO LET ME KNOW THEY CANNOT FIND THE PROBLEM AND EVEN CONTACTED THE GM ADVISORS AND ARE ALL IN AGREEMENT WITH THIS ISSUE HOWEVER SINCE THERE IS NOT SERVICE BULLETIN OR RECALL REGARDING THIS I WILL HAVE TO JUST DEAL WITH IT AND WAIT AND SEE IF SOMETHING COMES UP WITH A FIX. I CANNOT BELIEVE I AM HAVING TO JUST DEAL WITH A BRAND NEW CAR WITH ISSUES...THIS CAR HAS BEEN TAKEN IN SEVERAL TIMES ALREADY..SHIFTER LOCKED UP AND WOULD NOT MOVE FROM PARK SO THEY REPLACED THAT...THEN CAR DIES ON HWY AND WAS TOWED INTO THE DEALERSHIP HAD TO FIX SOMETHING THAT HAD TO DO WITH THE THROTTLE, PAINT IN NOW PEELING AND ONLY HAS 11,000 MILES ANY HELP WOULD BE GREAT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10253712January 4, 2009
ENGINE AND ENGINE COOLING:COOLING SYSTEM
MY DAUGHTER WAS DRIVING OUR 2005 CHEVY AVEO WHEN SHE NOTICED SMOKE COMING FROM UNDER THE HOOD, SHE CONTACTED ME AND I CAME AND SAW ANTI-FREEZE ALL OVER ENGINE COMPARTMENT, IT IS WHEN I NOTICED THE THERMOSTAT HOUSING SPLIT AT SEAM. WE GOT THE CAR HOME USING 3.5 GALLONS OF ANTI-FREEZE AND SEVERAL STOPS TO LET ENGINE COOL. I HAVE READ HUNDREDS OF POSTINGS ON DIFFERENT WEBSITES WITH PEOPLE HAVING THE SAME PROBLEM. THIS PART IS TWO PLASTIC PARTS SEALED TOGETHER WITH THE THERMOSTAT BETWEEN THEM. I HAVE NOTICED THAT CHEVY KNEW OF THIS PROBLEM HAPPENING FROM 30K-50K MILEAGE ON THE VEHICLES AND THE NEW REPLACEMENT PART IS NOW METAL. ONCE I GET THE PART AND INSTALL IT I WILL HAVE TO PAY TO HAVE THE ENGINE CHECKED SINCE MOST OF THE COMPLAINTS ALSO MENTION THE HEAD WARPING DUE TO THE HEAT CAUSED BY THE THERMOSTAT HOUSING BREAKING. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10253372December 31, 2008
AIR BAGS:FRONTAL
"PASSENGER AIRBAG IS OFF" LIGHT COMES ON WHEN ADULT IS SEATED INDICATING AIRBAG IS DISABLED. HAVE HAD IT IN FOR SERVICE FOUR TIMES. HAVE BEEN TOLD WE WERE NOT SITTING IN THE SEAT PROPERLY. GM REPLACED SEAT AND SENSOR, BUT DID NOT CORRECT THE PROBLEM. LAST SERVICE DATE IS 12/24/2008. WAS TOLD THAT THE PROBLEM CANNOT BE FIXED. REPORTED AT 8297 MILES; CURRENT MILEAGE IS 53783. I WAS INFORMED THAT THE AIRBAG MAY NOT DEPLOY IN AN ACCIDENT INCREASING CHANCE OF INJURY. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10253044December 29, 2008
SERVICE BRAKES, HYDRAULIC
TL*THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHILE AT A GAS STATION, THE CONTACT NOTICED THAT THE FRONT DRIVER'S SIDE TIRE WAS COVERED IN BRAKE DUST. AFTER LEAVING THE GAS STATION, DRIVING APPROXIMATELY 70 MPH, ANOTHER VEHICLE SWITCHED LANES IN FRONT OF HIM. THE CONTACT APPLIED PRESSURE TO THE BRAKES AND THE FRONT END OF THE VEHICLE BEGAN SHAKING ROUGHLY. THE VEHICLE WAS DRIVEN TO HIS RESIDENCE. THE DEALER FROM WHERE THE VEHICLE WAS PURCHASED IS OUT OF BUSINESS. THE MANUFACTURER OFFERED TO CORRECT THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 14,733. UPDATED 03-06-09 *BF THE FRONT ROTORS WERE OUT OF ROUND. THE REAR BRAKES PULSATED AND VIBRATED. THE SECOND REPAIR, THE CONSUMER RECEIVED NEW BRAKE PADS AND BOOSTER. THE DRUMS AND SHOES WERE ALSO REPLACED. UPDATED 03/10/09. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10252521December 22, 2008
AIR BAGS:FRONTAL
TL*THE CONTACT OWNS A 2008 CHEVROLET AVEO. WHEN THE VEHICLE WAS PURCHASED IN JUNE OF 2008, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE AIR BAG INDICATOR REMAINED ILLUMINATED. HE TOOK THE VEHICLE TO THE DEALER FOUR TIMES AND THEY STATED THAT THE FAILURE WAS DUE TO THE AIR BAG SYSTEM BEING UNHOOKED. THE DEALER HOOKED THE SYSTEM BACK, BUT THE FRONT DRIVER AND PASSENGER AIR BAG INDICATORS CURRENTLY REMAIN ILLUMINATED. HE TOOK THE PASSENGER WITH HIM TO THE DEALER, BUT THEY WERE UNABLE TO RETRIEVE A DIAGNOSTIC CODE FOR THE FAILURE. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE ; HOWEVER, THEY WILL ORDER THE AIR BAG SEAT SENSOR. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 3,000 AND CURRENT MILEAGE WAS 6,500.
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10252384December 21, 2008
ENGINE AND ENGINE COOLING
2004 CHEVROLET AVEO BROKE TIMING BELT AT 53,470 MILES. ALWAYS SERVICED ON TIME. NO WARNING LIGHTS. ALSO, HAVE HAD ELECTRICAL PROBLEMS WITH CAR SINCE BUYING. DASHBOARD CLOCK RESETS CONSTANTLY. ODOMETER READING FAILS. THIS IS A DANGEROUS CAR. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251580December 12, 2008
SUSPENSION:FRONT
TL*THE CONTACT OWNS A 2005 CHEVROLET AVEO. AFTER THE VEHICLE WAS TAKEN IN FOR SERVICE, IT BEGAN MAKING A LOT OF NOISE. THE CONTACT RETURNED THE VEHICLE TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE. HOWEVER, THEY DISCOVERED A SCREW GLUED TO THE FRONT SUSPENSION. THE CONTACT TOOK THE VEHICLE TO ANOTHER REPAIR SHOP AND THEY STATED THAT THERE WAS A WEAK STRUT MOUNT IN THE FRONT SUSPENSION. THE CONTACT CONTINUED TO TAKE THE VEHICLE BACK AND FORTH TO THE DEALER BECAUSE THE BOLT COULD HAVE LOOSENED AND CAUSED A CRASH. THE DEALER FINALLY INSPECTED THE VEHICLE AND REORDERED THE PARTS FOR THE REPAIR. THE FAILURE MILEAGE WAS 41,000. UPDATED 1/6/09 *CN THE CONSUMER WAS TOLD A MAIN CONNECTION POINT BOLT ON THE CROSSMEMBER WAS STRIPPED AND VERY LOOSE. UPDATED 01/14/09. *JB
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10251249December 9, 2008
ENGINE AND ENGINE COOLING:COOLING SYSTEM
IN THE BEGINNING I HAD NO PROBLEMS WITH THE CAR WHATSOEVER. THEN THE THERMOSTAT HOUSING BLEW APART CAUSING THE ENGINE TO OVERHEAT AND BLOWING THE HEAD GASKET. NEITHER CHEVY OR MY EXTENDED WARRANTY COMPANY (TOYOTA) WOULD COVER THE REPAIR. I HAD TO SPEND OVER ONE HUNDRED DOLLARS ON JUST THE THERMOSTAT HOUSING AND OVER THREE HUNDRED TO GET THE PROBLEM DIAGNOSED. THE CAR STILL SITS IN MY DRIVEWAY BROKEN. I HAD TO SPEND ANOTHER FOUR HUNDRED AND FIFTY DOLLARS TO GET THE HEAD REPAIRED AND TO BUY THE NEW GASKETS. JUST GOT THE CAR BACK TOGETHER AND STILL DOESN'T RUN RIGHT. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0
#10249559November 22, 2008
AIR BAGS:FRONTAL
I WAS IN A SEMI V CAR ACCIDENT WEDNESDAY NOVEMBER 19TH, ON A 4 LANE MAJOR HIGHWAY (I-294). I WAS DRIVING A 2004 CHEVY AVEO. I WAS CUT OFF BY THE SEMI AND MY CAR WAS HIT, SPUN OUT OF CONTROL THROUGH 3 LANES OF TRAFFIC AND HIT THE CENTER MEDIAN OF THE HIGHWAY. THE CAR IS TOTALED. THE ENTIRE ENGINE BLOCK WAS SMASHEDINWARD. MY AIRBAG DIDN'T DEPLOY. I'M ANGRY. THIS CAR HAS HAD NOTHING BUT DEFECT AFTER DEFECT, BUT I PAID FOR A SAFETY FEATURE THAT WAS FAULTY. I WALKED AWAY FROM THIS ACCIDENT, BY THE GRACE OF GOD, AND NOW AM SUFFERING HORRIFIC PAIN THAT IS DIRECTLY INFLUENCED BY MY AIRBAG NOT DEPLOYING. I HAVE NO RECOURSE TO TAKE AGAINST CHEVY. I WANT DOCUMENTATION OF THIS MAJOR FAILURE. I'M LUCKY I DIDN'T DIE. THE SEMI WAS TICKETED IN THE ACCIDENT. *TR
Crash:
Yes
Fire:
No
Injuries:
1
Deaths:
0
#10249405November 20, 2008
VEHICLE SPEED CONTROL
TL*THE CONTACT OWNS A 2006 CHEVROLET AVEO. WHILE ATTEMPTING TO PARK AT APPROXIMATELY 5 MPH WITH THE BRAKE PEDAL DEPRESSED, THE ENGINE BEGAN TO REV. THE VEHICLE JUMPED A CURB AND SCRAPED A BUILDING WITH THE DRIVER'S SIDE FENDER BEFORE IDLING NORMALLY AGAIN. THERE WERE NO INJURIES, BUT A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 27,000. UPDATED 12-15-08 *BF UPDATED 12/17/08. *JB
Crash:
Yes
Fire:
No
Injuries:
0
Deaths:
0
#10248634November 12, 2008
ENGINE AND ENGINE COOLING
MY CAR IS A 2004, CHEVY AVEO, WITH 23,100 MILES. THE TEMPERATURE GAGE SHOWED THE ENGINE TO BE OVERHEATING ON MY WAY TO WORK ON OCTOBER 29, 2008. THERE WERE NO WARNING LIGHTS, ONLY A RAMBLING ENGINE SOUND AND A BURNING TYPE OF SMELL. THE RESERVOIR TANK WAS HALF EMPTY AND THERE WAS VISIBLE SIGNS OF LEAKAGE AROUND THE THERMOSTAT HOUSING. THE REPLACEMENT OF THE THERMOSTAT HOUSING REMEDIED THE FAILURE. HOWEVER, THE THERMOSTAT HOUSING FROM THE FACTORY IS ORIGINALLY ENCASED IN PLASTIC HOUSING, BUT THE CHEVY DEALER RETAILS THE PART WITH METAL HOUSING. THE METAL HOUSING INDICATES CHEVY'S AWARENESS, YET THERE IS NO EXISTENCE OF COVERAGE ON THE WARRANTY OR ANY ISSUING OF RECALL OF THE PART. *TR
Crash:
No
Fire:
No
Injuries:
0
Deaths:
0

← Back to Chevrolet Aveo