BMW · Model Report
Showing safety data for the 2004 model year only.
BMW of North America, LLC (BMW) is recalling certain model year 2000-2003 525i Sedan, 530i Sedan, 540i Sedan, 2001-2003 525i Sports Wagon and 540i Sports Wagon vehicles, and 2000-2004 X5 SAV 3.0i, X5 SAV 4.4i, and X5 SAV 4.6is vehicles. This recall affects certain vehicles where the original steering wheel has been replaced with the optional sports steering wheel. The sports steering wheel has a frontal air bag inflator that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
ON CERTAIN PASSENGER VEHICLES WITH 3.0 L ENGINES AND MANUAL TRANSMISSIONS, IF THE VEHICLE IS IN FIRST GEAR, AND MOVING SLOWLY, WITH THE ACCELERATOR PEDAL HELD IN A CONSTANT POSITION OF LOW ENGINE SPEED AND WITH THE CLUTCH PEDAL HELD IN A PARTIALLY DEPRESSED POSITION, ENGINE SPEED MAY INCREASE.
ON CERTAIN SPORT UTILITY VEHICLES, THE IN-TANK FUEL LINE MAY HAVE BEEN ATTACHED INCORRECTLY.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 8 AND 12 CYLINDER ENGINES, THE DIGITAL ENGINE MANAGEMENT CONTROL (EMC) UNITS WERE NOT PRODUCED ACCORDING TO SPECIFICATIONS.
ON CERTAIN SPORT UTILITY VEHICLES, THE BOLTS THAT HOLD THE FRONT DIFFERENTIAL, THE RIGHT OUTPUT SHAFT HOUSING FLANGE AT THE ENGINE, AND THE RIGHT-HAND ENGINE SUPPORT MAY BE INSUFFICIENTLY TIGHTENED.
No start no crank sos light battery drain
No injuries · No fire · No crash
Vehicle rpm’s rev wildly in park and neutral. When driving vehicle speeds up on its own and rpm’s climbs out of control. When stopped at a light or in traffic, car leaps forward against the break .
No injuries · No fire · No crash
MY STEERING IS WAY TO TIGHT. AND ITS HARD TO MOVE THEVCAR.
No injuries · No fire · No crash
FRONT PASSENGER SEAT BELT DOESN'T WORK PROPERLY. *TR
No injuries · No fire · No crash
TL* THE CONTACT OWNS A 2004 BMW X5. WHILE DRIVING 55 MPH ON THE FREEWAY, THE VEHICLE JERKED SEVERELY. SUDDENLY, THE ENGINE POWERED DOWN IN THE MIDDLE OF TRAFFIC. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER SAFELY ONTO THE SHOULDER. A MESSAGE INDICATING "FAIL SAFE" APPEARED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE WAS LATER TAKEN TO RAY CATENA BMW (543 TARRYTOWN RD, WHITE PLAINS, NY 10607, (914) 761-5555) WHERE IT WAS DIAGNOSED THAT A NEW ENGINE AND VALVE PUMP NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 120,000.
No injuries · No fire · No crash